Volt VFL-4602-BBZ User manual

VOLT®Low Voltage Landscape Lighting
VOLT®Integrated LED Gentle & Big Splash
VFL-4601-BBZ & VFL-4602-BBZ
INSTALLATION INSTRUCTIONS
Specications and product details subject to change without notice.
© Copyrigwht 2019, VOLT® Lighting, Lutz FL USA 33549 • All rights
reserved. [email protected] • 813.978.3700
- 1 -
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)

VOLT®Integrated LED Gentle & Big Splash
VFL-4601-BBZ & VFL-4602-BBZ
Important: Please Read Before Installation
INSTALLATION INSTRUCTIONS
!
www.voltlighting.com [email protected] • 813.978.3700
Package Contents
A. (1) Fixture Body
Product Dimensions
3.25”
2.5”
1.5”
2.5”
- 2 - - 3 -
B. (1) Stake
This xture is intended for installation in accordance with local codes
and the National Electric Code (NEC). Failure to adhere to these codes
and instructions may result in serious injury, property damage and void
the warranty.
These instructions do not intend to cover all variations in installation,
operation maintenance or mounting situations.
1. Make sure that the power is turned OFF before installing or servicing
this xture.
2. Warning: this xture is not intended to be installed within 10 feet [3
meters] of a pool, spa or fountain.
3. This xture is intended to be used only with a power supply
(transformer) rated maximum of 300 watts (25 AMPS) at 15 volts.
4. Underground Low Energy Cable must not be buried over 6” (15.2 cm) in
order to connect to the main low voltage cable.
5. Wiring connections must be made with wire connectors that are suitable
for outdoor use.
6. Position the wire connector so that it is located within 6 inches (15.2
cm) from a building structure, a luminaire, or tting.
Important Safety Instructions
!
LIGHTED LAMP IS HOT!
WARNING – TO REDUCE THE RISK OF FIRE OR INJURY TO PERSONS.
1. Turn o/unplug and allow to cool before reducing lamp.
2. Lamp gets HOT quickly!
3. Do not touch the hot lens, guard or cowl.
4. Keep lamp away from materials that may burn.
5. Do not touch lamp at any time.
6. Use a soft cloth.
7. Oil from skin may damage lamp.
8. Do not operate the xture with a damaged or missing lens or shield.
Install Stake
1
Board
Stake
Soil
Ground
Determine your desired location for
mounting the xture. Hammer the
stake into the ground until ange
of stake is ush to grade. To avoid
damage to the stake, place a board on
top of the stake while hammering.
NOTE: If the ground is hard and the
stake is dicult to install, make a
crosscut in the ground using a at
shovel.

INSTALLATION INSTRUCTIONS
[email protected] • 813.978.3700
Adjust Fixture Body
4
Use the included Allen wrench to
unlock the set screw and adjust
the xture body to your desired
direction. Tighten the set screw
once your desired angle is achieved.
Fixture
Body
Allen
Wrench
Set Screw
Adjust
www.voltlighting.com
- 4 - - 5 -
Clear away an area on the ground
at the wireway slot on top of
the stake. Lay the luminaire
pigtail into the wireway slot and
thread the xture onto the stake.
Tighten using the lock nut to
secure it to the base.
Install Fixture Body to Stake
2
Fixture Body
Pigtail
Wireway Slot
Stake
Wire Connections
3
Strip both leads from the luminaire pigtail. Using two wire connectors
(sold seperately), connect the leads from the luminaire to the main
supply cable leads.
Pigtail
Main Supply Cable
Wire Connectors
Remove Glare Guard with Lens
Replace Lens
1
2
Loosen the thumb screws, then
remove the glare guard and the lens
from the xture body.
Remove the lens from the rubber
gasket, then replace it with the lens
you would like to use.
Fixture
Body
Glare
Guard
Glare
Guard
Thumb Screw
Gasket and
Lens
Replace Lens
VOLT®Integrated LED Gentle & Big Splash
VFL-4601-BBZ & VFL-4602-BBZ

www.voltlighting.com
- 6 -
[email protected] • 813.978.3700
- 7 -
INSTALLATION INSTRUCTIONS
Place the glare guard and the
gasketed lens back onto the
xture body and secure with
the thumb screws previously
removed. Hand tighten until snug.
Install Glare Guard with Lens
3
Fixture
Body
Glare
Guard
Thumb Screws
VOLT®Integrated LED Gentle & Big Splash
VFL-4601-BBZ & VFL-4602-BBZ

is-VFL-4601-4602-BBZ-ver2.pdf
Specications and product details subject to change without notice.
© Copyright 2019, VOLT® Lighting, Lutz FL USA 33549 • All rights
reserved. [email protected] • 813.978.3700
www.voltlighting.com
- 8 -
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)