Zoeller AquaNot Fit 508 User manual

SECTION: 2.65.013
FM3124
0320
Supersedes
0918
TECHNICAL DATA SHEET
MODEL 508 12-VOLT BACKUP
Submersible Sump Pump System
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
© Copyright 2020 Zoeller®Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
CONTROLLER
The Aquanot®Fit 508 with Z Control®technology is a premium high
performance, self-testing internet-connected battery backup pump
system.
PUMP
• 12 volt, highly efcient, non-corrodible pump construction.
Supplied with 9' (2.7 m) leads.
• Legs allow free-standing installation
• Quick disconnect discharge
• Aluminum seal pocket and cooling plate
• Integrated check valve
CONTROLLER
The Aquanot®Fit DC Controller keeps the battery charged. The
controller has many built-in features such as:
• Monitors the switches,runs the pump
• Performs Self-testing diagnostics
• Communicates with the Z Control®Cloud; receives
commands from user through Cloud such as "Silence",
"Reset", "Test", and many conguration changes
• 7 amp
BUTTONS
• Alarm Silence/Reset - press to silence alarms. Press and hold
for three seconds to reset alarms.
• Test - Press to initiate pump test
SWITCHES
• Reliable, vertical oat switch for adjustable operation.
• High water reed sensor provides high water signal and
redundant pump run.
BATTERY CASE
The included battery case will accommodate maximum battery
dimensions of 13" (330 mm) L x 7-1/2" (191 mm) W x 9-1/2" (241
mm) H and ts all group size 27, 29 and 31 batteries. Made from
non-corrodible polyethylene. To use multiple batteries, order extra
battery case with hookup wire (P/N 007861).
FITTINGS
An integrated DC pump discharge check valve, additional thread-in
AC pump check valve, tee, and adapter are included.
• Connection fault
• Power outage/restored
• Pump activation
ALERTS
• Pump cycled
• High water
• Battery fault
• Switch fault
• Pump fault
Aquanot®Deep-cycle Battery (purchase separately)
P/N 10-1450 - AGM (shown)
P/N 10-0761 - Wet
Aquanot®Fit 508 system
Patent No. D740329
AQUANOT® FIT
Solid Flashing Off
System
Ready No Faults (Green) AC off with no faults (Green) --
Battery
Charged (Green)
Low Battery (Red) No AC Power
Charging (Yellow)
Bad Battery (Red)
DC pump Pump Ran
(Yellow)
Pump Running
(Yellow) --
Pump Fault (Red)
Float
Status High Water (Red) Float Fault (Red) --
Z Control Connected Searching
Broadcasting
SSID or
Dormant

TOTAL DYNAMIC HEAD FLOW
PER MINUTE @ 12.1 VOLTS
© Copyright 2019 Zoeller®Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | zoellerpumps.com
Shipping weight: 17 lbs. (7.7 kg)
NOTE: Not recommended for installation with over 20' (6 m) Total Dynamic
Head.
Performance chart based upon actual performance achieved with a 12 volt
deep-cycle battery. Some manufacturers publish performance data based upon
D.C. Pump testing according to Marine Industry standards which can reflect a
performance of 40% - 80% higher than actual battery powered performance.
See FM3120 (Aquanot®Fit 508) Installation Instructions.
Minimum pit size recommendation: 18" (46 cm) diameter X 22" (56 cm)
deep. Minimum battery requirements: deep-cycle, size 27, 175 minute
reserve capacity.
152944
WARRANTY
3 years from date of purchase. Battery warranty is 3 years.
BATTERY LIFE
The estimated life of a fully charged (175 minute reserve capacity)
battery when the pump is operating continuously is approximately
5.5 hours. However, most backup system pump operation is
intermittent.The system willprovide protection for extendedperiods
of time dependent upon stop-start requirements and multiple
battery arrangements.
PERFORMANCE DATA
Pump performance is based on the use of a fully charged 12 volt,
(200-minute reserve capacity) deep-cycle battery with no deciency
and less than two years old.
AQUANOT®BATTERY
• Size 31 “Wet” P/N 10-0761 (69 lbs. [31 kg]) (shipped via
truckline only) 200 minute reserve capacity
• Size 27 “AGM” P/N 10-1450 (66 lbs. [30 kg]) 175-minute
reserve capacity
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0 30
20
1.5
Meters
39
Gal.
76
114
148
Liters
20 6.1 6 23
FLOW PER MINUTE
LITERS 0 80
5
25
15
10
GALLONS
TOTAL DYNAMIC HEAD
0
2
4
6
10 20 30
160
40 50
FEET
METERS
20
8
PUMP PERFORMANCE CURVE
MODEL 508 @ 12.1 VOLTS
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0 30
20
1.5
Meters
39
Gal.
76
114
148
Liters
20 6.1 6 23
FLOW PER MINUTE
LITERS 0 80
5
25
15
10
GALLONS
TOTAL DYNAMIC HEAD
0
2
4
6
10 20 30
160
40 50
FEET
METERS
20
8
PUMP PERFORMANCE CURVE
MODEL 508 @ 12.1 VOLTS
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be
followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
CAUTION
SK3182
OUTLET
PRIMARY PUMP
1" MIN.
IMPORTANT: OFF LEVEL
OF FLOAT ASSEMBLY
MUST BE HIGHER THAN
DC BACKUP PUMP INTAKE
DC PUMP INSTALLED IN LINE WITH SUBMERSIBLE PUMP
BATTERY BOX
AQUANOT®FIT CONTROLLER
OUTLET
CONTROLLER
HIGH WATER
REED SENSOR