Aaeon SBC-657B User manual

SBC-657B / HSB-657I
VIA C3EdenCPU
Half-Size CPU Card
With LCD, Ethernet, PC/104 &
CompactFlash, USB
SBC-657 Rev.B / HSB-657I Rev.A Manual 1
st Ed.
Nov. 2003

Half-Size CPU Card SBC-657B / HSB-657I
i
Copyright Notice
This document is copyrighted, 2003. All rights are reserved. The
original manufacturer reserves the right to make improvements to
the products described in this manual at any time without notice.
No part of this manual may be reproduced, copied, translated, or
transmitted in any form or by any means without the prior written
permission of the original manufacturer. Information provided in
this manual is intended to be accurate and reliable. However, the
original manufacturer assumes no responsibility for its use, or for
any infringements upon the rights of third parties that may result
from its use.
The material inthis document is for product information only and
is subject to change without notice. While reasonable efforts have
been made in the preparation of this document to assure its
accuracy, AAEON assumes no liabilities resulting from errors or
omissions in this document, or from the use of the information
contained herein.
AAEON reserves the right to make changes in the product design
without notice to its users.

Half-Size CPU Card SBC-657B / HSB-657I
ii
Acknowledgments
All other products’name or trademarks are properties of their respective
owners.
lAward is a trademark of Award Software International, Inc.
lCompactFlash™is a trademark of the Compact Flash Association.
lMicrosoft Windows®is a registered trademark of Microsoft Corp.
lIBM, PC/AT, PS/2, and VGA are trademarks of International Business
Machines Corporation.

Half-Size CPU Card SBC-657B / HSB-657I
iii
Packing List
Before you begin installing your card, please make sure that the
following materials have been shipped:
•1 SBC-657B & HSB-657I Half-Size CPU Card
•1 Quick Installation Guide
•1 CD-ROM for manual (in PDF format) anddrivers
•1Short copper and support
•1Jumper Cap
•1Cable Accessory
If any of these itemsshould bemissing or damaged, please contact
your distributoror sales representative immediately.

Half-Size CPU Card SBC-657B / HSB-657I
iv
Contents
Chapter 1 General Information
1.1Introduction..................................................................................1-2
1.2Features .........................................................................................1-3
1.3Specifications ................................................................................1-4
Chapter 2 Quick Installation Guide
2.1 Safety Precautions........................................................................2-2
2.2 Location of Connectors and Jumpers........................................2-3
2.3Mechanical Drawing.....................................................................2-7
2.4List of Jumpers .............................................................................2-11
2.5 List of Connectors........................................................................2-12
2.6Setting Jumpers.............................................................................2-13
2.7COM2 Ring signal select (JP1)....................................................2-14
2.8Clear CMOS (JP2)........................................................................2-14
2.9 RS-232/422/485 Setting (JP4)....................................................2-14
2.10 RS-232/422/485 Setting (JP5)..................................................2-15
2.11 LCD Shift Clock Select (JP6)....................................................2-15
2.12 LCD Voltage Setting (JP7)........................................................2-15
2.13 Power Connector (ATX Power) (PWR1)................................2-16
2.14 FAN Connector (CN1)..............................................................2-16
2.15 Keyboard and Mouse Connector (CN2) .................................2-17
2.16 Parallel Port Connector (CN3) .................................................2-17
2.17 Floppy Connector (CN4) ..........................................................2-18

Half-Size CPU Card SBC-657B / HSB-657I
v
2.18 IR Connector (CN5)..................................................................2-18
2.19 Front Panel Connector (CN6)..................................................2-19
2.20 Optional PME Connector (CN7).............................................2-19
2.21 IDE Hard Drive Connector (CN8)..........................................2-20
2.22 USB Connectors (CN9/CN11)................................................2-21
2.23 CompactFlashDisk Connector (CN10)..............................2-22
2.24 10/100Base-T RJ-45 Ethernet Connector (CN12) ................2-23
2.25 COM1/3/4 RS-232 Serial Port Connector (CN13/CN21/CN22)
..............................................................................................................2-24
2.26 COM2 RS-232/422/485 Serial Port Connector (CN14).......2-24
2.27 VGA Display Connector (CN15).............................................2-25
2.28 TTL_LCD Connector (CN16/CN17).....................................2-25
2.29 Channel 1 LVDS Connector (CN18).......................................2-27
2.30 Channel 2 LVDS Connector (CN19).......................................2-27
2.31 Backplane ATX Power Connecotr (CN24).............................2-28
2.32 Internal Mouse Connector (CN25)..........................................2-28
2.33 Internal Keyboard Connector (CN26).....................................2-28
Chapter 3 Award BIOS Setup
3.1 System test and initialization.......................................................3-2
3.2 Award BIOS setup.......................................................................3-3
3.3 Standard CMOS Features ............................................................3-6
3.4 Advanced BIOS Features ............................................................3-7
3.5 Advanced Chipset Features.........................................................3-8
3.6 Integrated Peripherals..................................................................3-9
3.7 Power Management Setup...........................................................3-10

Half-Size CPU Card SBC-657B / HSB-657I
vi
3.8 PnP/PCI Configurations.............................................................3-11
3.9 PC Health Status...........................................................................3-12
3.10 Frequency/Voltage Control......................................................3-13
3.11 Load Fail-Safe Defaults.............................................................3-14
3.12 Load Optimized Defaults..........................................................3-14
3.13 Set Supervisor/User Password .................................................3-14
3.14 Save & Exit setup.......................................................................3-15
3.15 Exit Without Saving...................................................................3-15
Chapter 4 Driver Installation
4.1 Installation 1..................................................................................4-3
4.2 Installation 2..................................................................................4-4
Appendix A Programming the WatchDog Timer
Programming......................................................................................A-2

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 1 General Information 1-1
General
Information
Chapter
1

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 1 General Information
1
-
2
1.1 Introduction
Half-size CPU Card, SBC-657B / HSB-657I, is powered by VIA
C3series microprocessor with a maximum of 800MHz high
process speed. Featured with CoolStreamarchitecture, it
performs as a strengthened single board computer with low
power consumption while no CPU fan required.
Onboard VIA ProSavagePN133 chipset integrates various
functions, including excellent display presentation ability.
Featured with AGP 4X, the throughput can reach as high as
1.07GB per second. LCD interface is both provided by TTL and
LVDS up to 36 bit. Also, supporting CRT and LCD to display at
the same time offers wider media applications.
One RJ-45 Ethernet connector comes with a maximum data
transfer rate of 100MB per second. The 7.3” x 4.8” computer
board is connected to the infinite LAN world. Four serial ports
are designed particularly for industry standard applications and
offering various devices connection ability. And, four USB ports
provide Plug-and-Play pleasant uses.
Implementing 16-bit Industry Standard Architecture (ISA)
interface makes it easy to apply onto a wide range of industry
fields. Industrial standard Type II CompactFlashslot performs
as a mobile memory device with utilization freedom. PC/104
socket is reserved for further function expansion interface.
Overall, this powerful CPU card is a high-end computer board
for implementation.

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 1 General Information
1
-
3
1.2Features
•Supports VIA C3Processor up to 800MHz
•Integrated AGP 4X 2D/3D graphic accelerator
•36-bit TTL/LVDS TFT LCD
•10/100Mbps Fast Ethernet
•Supports Type II CompacFlashMemory
•PC/104 expansion interface
•ISA interface

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 1 General Information
1
-
4
1.3 Specifications
System
lCPU: VIA Eden300/400/667/733/800MHz
processor
lMemory:144-pin SDRAM SODIMM Socket
x 1, max. 512MB
lChipset: VIA VT8606 + VT82C686B
lBIOS:Award 256KB FLASH ROM
lSSD: One Type II CompactFlash Slot
lWatchdog timer: Generate a system reset
lEthernet: RTL 8139D, 10/100Base-T RJ-45
Ethernet connector x 1
lExpansion Interface: ISA interface, PC/104 socket
lBattery: Lithium battery
lPower supply voltage: +5V, +12V, 5VSB, ATX
lOperating temperature: 32 to 140 °F (0 to 60°C)
lBoard size: 7.3" (L) x 4.8" (W)
(185 mm x 122 mm)
lGross Weight: 0.66lb (0.3kg)
Display
lChipset VIA VT8606
lMemory size: Shared system memory up to 32MB
lResolution: up to 1280 x 1024@ 24bpp colors

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 1 General Information
1
-
5
for CRT
lLCD Interface: 18/36-bit TTL/LVDS TFT/DSTN
LCD
lSupports CRT and LCD simultaneous display
I/O
lMIO: EIDE (UDMA100) x 1, FDD x 1,
RS-232/422/485 x 1, RS-232 x 3,
LPT x 1, VGA x 1,
Keyboard/Mouse Connector x 1
lIrDA: One IrDA Tx/Rx header
lUSB: Two 5x2 pin headers support 4 USB
1.1 ports

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick InstallationGuide
Quick
Installation
Guide
Chapter
2
Part No.2007657020 Printed in Taiwan November 2003
Notice:
The Quick Installation Guide is derived from
Chapter 2 of
user manual. For other chapters and
further installation
instructions, please refer to the user manual CD-ROM
that
came with the product.

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
2
2.1 Safety Precautions
Always completely disconnect the power cord from
your board whenever you are working on it. Do not
make connections while the power is on, because a
sudden rush of power can damage sensitive
electronic components.
Always ground yourself to remove any static charge
before touching the board. Modern electronic
devices are very sensitive to static electric charges.
Use a grounding wrist strap at all times. Place all
electronic components on a static-dissipative surface
or in astatic-shielded bag when they are not in the
chassis

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
3
2.2Location of Connectors and Jumpers
Locating connectors and jumpers (component side)
SBC-657B

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
4
Locating connectors (solder side)
SBC-657B

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
5
Locating connectors and jumpers (component side)
HSB-657I

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
6
Locating connectors (solder side)
HSB-657I

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
7
2.3 Mechanical Drawing
Mechanical drawing (component side)
SBC-657B

Half-Size CPU Card SBC-657B / HSB-657I
Chapter 2 Quick Installation Guide
2
-
8
Mechanical drawing (solder side)
SBC-657B