AFL Hyperscale U Series User manual

6RU
Front-Access
V-Panel (FVP)
Installation Guide
Series

2© AFL Hyperscale. All rights reserved Series
Safety Precautions
Laser Precautions
Warning: The laser light used to transmit information over optical ber cables can cause severe eye
damage. Because this light is invisible, it will not cause the iris of the eye to contract involuntarily as when
viewing a bright visible light, and no pain is felt as the retina is burned.
Never look into the end of a ber or connector which may have a laser coupled to it. Should accidental
eye exposure to laser light be suspected, arrange for an eye examination immediately.
General Precautions
Personnel must be thoroughly familiarized with all applicable Occupational Health and Safety (OH&S)
regulations, local regulations, and your company safety practices and policies.
Warning: To reduce the chance of accidental injury:
Before work begins, all personnel must be thoroughly familiar with the operation of all equipment
and procedures to be used during the installation.
Before use, all equipment, especially safety gear, must be inspected and tested for proper operation.
Replace and repair as necessary.
U-Series 6RU Front-Access V-Panel (FVP)
Before installing or adjusting this product, please read these instructions carefully.
Please keep this guide for future reference.

3
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Component Overview
02
04
04
05
01
02
06
03

4© AFL Hyperscale. All rights reserved Series
(12) Ø10mm OD Fiber
Braid Tube (1m)
(13) Port Labels
(1-864)
(19) ) 6RU Rear Door +
Panel Slide Latches
(15) Velcro
(21) 6RU LHS Door
Mount
(14) Electrical Tape
(20) 6RU RHS Door
Mount
(16) Hose Clip
(22) 6U Front Door
Assembly
(17) M6 x 10 Screw
(23) Breakout Bracket
Assembly
(18) Front Labels
(24) Cable Entrance Cover
with 2 pcs Brush Strip
(11) Cable Ties
MODULE1 MODULE2 MODULE3 MODULE4 MODULE5 MODULE6 MODULE7 MODULE8 MODULE9 MODULE10 MODULE11 MODULE 12
A
1 13 25 37 49 61 73 85 97 109 121 133 145 157 169 181 193 205 217 229 241 253 265 277
2 14 26 38 50 62 74 86 98 110 122 134 146 158 170 182 194 206 218 230 242 254 266 278
3 15 27 39 51 63 75 87 99 111 123 135 147 159 171 183 195 207 219 231 243 255 267 279
4 16 28 40 52 64 76 88 100 112 124 136 148 160 172 184 196 208 220 232 244 256 268 280
5 17 29 41 53 65 77 89 101 113 125 137 149 161 173 185 197 209 221 233 245 257 269 281
6 18 30 42 54 66 78 90 102 114 126 138 150 162 174 186 198 210 222 234 246 258 270 282
7 19 31 43 55 67 79 91 103 115 127 139 151 163 175 187 199 211 223 235 247 259 271 283
8 20 32 44 56 68 80 92 104 116 128 140 152 164 176 188 200 212 224 236 248 260 272 284
9 21 33 45 57 69 81 93 105 117 129 141 153 165 177 189 201 213 225 237 249 261 273 285
10 22 34 46 58 70 82 94 106 118 130 142 154 166 178 190 202 214 226 238 250 262 274 286
11 23 35 47 59 71 83 95 107 119 131 143 155 167 179 191 203 215 227 239 251 263 275 287
12 24 36 48 60 72 84 96 108 120 132 144 156 168 180 192 204 216 228 240 252 264 276 288
B
289 301 313 325 337 349 361 373 385 397 409 421 433 445 457 469 481 493 505 517 529 541 553 565
290 302 314 326 338 350 362 374 386 398 410 422 434 446 458 470 482 494 506 518 530 542 554 566
291 303 315 327 339 351 363 375 387 399 411 423 435 447 459 471 483 495 507 519 531 543 555 567
292 304 316 328 340 352 364 376 388 400 412 424 436 448 460 472 484 496 508 520 532 544 556 568
293 305 317 329 341 353 365 377 389 401 413 425 437 449 461 473 485 497 509 521 533 545 557 569
294 306 318 330 342 354 366 378 390 402 414 426 438 450 462 474 486 498 510 522 534 546 558 570
295 307 319 331 343 355 367 379 391 403 415 427 439 451 463 475 487 499 511 523 535 547 559 571
296 308 320 332 344 356 368 380 392 404 416 428 440 452 464 476 488 500 512 524 536 548 560 572
297 309 321 333 345 357 369 381 393 405 417 429 441 453 465 477 489 501 513 525 537 549 561 573
298 310 322 334 346 358 370 382 394 406 418 430 442 454 466 478 490 502 514 526 538 550 562 574
299 311 323 335 347 359 371 383 395 407 419 431 443 455 467 479 491 503 515 527 539 551 563 575
300 312 324 336 348 360 372 384 396 408 420 432 444 456 468 480 492 504 516 528 540 552 564 576
C
577 589 601 613 625 637 649 661 673 685 697 709 721 733 745 757 769 781 793 805 817 829 841 853
578 590 602 614 626 638 650 662 674 686 698 710 722 734 746 758 770 782 794 806 818 830 842 854
579 591 603 615 627 639 651 663 675 687 699 711 723 735 747 759 771 783 795 807 819 831 843 855
580 592 604 616 628 640 652 664 676 688 700 712 724 736 748 760 772 784 796 808 820 832 844 856
581 593 605 617 629 641 653 665 677 689 701 713 725 737 749 761 773 785 797 809 821 833 845 857
582 594 606 618 630 642 654 666 678 690 702 714 726 738 750 762 774 786 798 810 822 834 846 858
583 595 607 619 631 643 655 667 679 691 703 715 727 739 751 763 775 787 799 811 823 835 847 859
584 596 608 620 632 644 656 668 680 692 704 716 728 740 752 764 776 788 800 812 824 836 848 860
585 597 609 621 633 645 657 669 681 693 705 717 729 741 753 765 777 789 801 813 825 837 849 861
586 598 610 622 634 646 658 670 682 694 706 718 730 742 754 766 778 790 802 814 826 838 850 862
587 599 611 623 635 647 659 671 683 695 707 719 731 743 755 767 779 791 803 815 827 839 851 863
588 600 612 624 636 648 660 672 684 696 708 720 732 744 756 768 780 792 804 816 828 840 852 864
TOPLEFT 1- 864
BOTTOMRIGHT
In the Box
(07) M6 Cage Nut
+ Screws
(10) Nylon Braid
(08) 12f Ribbon Splice
Protector
(09) 24f 200μm SpiderWeb
Ribbon®(SWR®)
LC Pigtail (Pre-Installed)
Item
Number Item Description Qty
01 U-Series 6RU Front-Access
V-Panel Chassis 1
02 288f Modular Drawer 3
03 6RU Shipping Bracket 2
04 U-Series Patch Adapter Plate 36
05 288f Ribbon Mass Splice Tray 6
06 25mm PVC Blind Blanking
Grommet (Black) 6
07 M6 Cage Nuts & Screws 8
08 12f Ribbon Splice Protector 72
09 24f 200μm SpiderWeb Ribbon
(SWR) LC Pigtail (Pre-Installed) 36
10 Nylon Braid (5m x 3pcs) 15m
11 Cable Ties 10
12 Ø10mm OD Fiber Braid Tube
(1m) 1
13 Port Labels (1-864) 8
14 Electrical Tape (18m x 1pcs) 18m
15 Velcro (1m x 2pcs) 2m
16 Hose Clip 2
17 M6 x 10mm Screw 4
18 Front Labels (for optional label
installation see page 16) 6
19
6RU Rear Door + Panel Slide
Latches (1.5mm Sheet, Cutout
15.4 x 17.9mm)
1
20 6RU RHS Door Mount 1
21 6RU LHS Door Mount 1
22 6RU Front Door Assembly 1
23 Breakout Bracket Assembly 1
24 Cable Entrance Cover with 2 pcs
Brush Strips 1

5
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Cross-Head and
Flat-Head Screwdriver
Scissors
Socket Wrench /
Spanner-13mm
Measuring Tape
What You Will Need Related Products
FVP Pre-Terminated
Replacement Cassette 250 μm WTC with SWR®
One-Click®Cleaner
D-LC, Duplex LC
U-Series 3456f & 6912f
Breakout Box

6© AFL Hyperscale. All rights reserved Series
Using a at-head screwdriver, lift up cover tabs.
1
Repeat for all cover tabs (QTY x 8) and lift off cover.
2
Panel Mounting

7
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Remove the shipping bracket xing
bolts (QTY x 4) using socket wrench and
screwdriver.
3Using handles, lift panel out of shipping crate.
Weight: approx. 25kg - TAKE CARE WHEN
LIFTING.
4
Using socket wrench or spanner, remove
shipping bracket bolts (QTY X 6 per side).
5Starting from top to bottom, slide out and de-
latch rail, and set aside to splice one at a time.
6
Activate black lever to detach slide rail
Panel Mounting

8© AFL Hyperscale. All rights reserved Series
6U
1U
1U
1U
1U
1U
Insert cage nuts in positions shown on both
left- and right-hand-side of rack.
7Partially tighten cage nut screws in positions
shown using screwdriver.
8
Insert 6RU panel into 19” rack and tighten
all cage nut screws.
9Remove rear door. 10
1U
Panel Mounting

9
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Slide hose clamps over cable and strip cable
jacket 4m according to manufacturer’s
guidelines.
11 Cut 2.5m/8” approx. length of nylon braid, slide
braid onto ber braid tube, then tape braid at
both ends of tubing to secure.
12
Separate out and tape up 144f ber bundle
ends as per splicing schedule and feed into
ber braid tube.
13 Slide ber braid tube up to jacket strip point
and remove tape, allowing braid to feed onto
ber.
14
4m/13”
approx.
Braid
Tube
Tape
Cable Installation

10 © AFL Hyperscale. All rights reserved Series
Remove tape from the tube, feed nylon
braid onto ber towards cable, and remove
tube from ber.
15
Attach cable to clamp with hose clips and
place braid tails into slots.
17 Position and screw cable breakout unit onto
side of panel.
18
Repeat steps 12-15, ensuring all ber has
braided sleeve, and tape braid sleeve at cable
jacket end.
16
Tape
25mm/1”
approx.
Hose
Clamps
Cable
Braid
Cable Installation

11
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Cut
Grommet
Cable
Braid
Cut grommets halfway through. Route cable
braid tails though grommet in 2 x 144f bundles
and slot grommets into panel (do not pull tight,
leave natural slack curve).
19 Feed all cable braid tails through to front of
panel and cable tie braids to T-slots. DO NOT
OVER-TIGHTEN.
20
Fit cable cover.
21 Fit rear door. 22
Screw
Positions
Cable
Tie
Cable Cover
Cable Installation

12 © AFL Hyperscale. All rights reserved Series
Remove bottom drawer cover.
23
Cassette to splice tray ber map: cassettes 1-6 into Splice Tray 1 (BOTTOM), cassettes 7-12 into Splice Tray 2
(TOP).
24
Splice Tray 2
(Top)
Splice Tray 1
(Bottom)
Cassette/
Pigtail Tail
Number
Splice Tray 2
(Top Tray)
Splice Tray 1
(Bottom Tray)
Cable Installation

13
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Splice Tray 2 (TOP): Tie off cable braid to splice tray. Starting with internal pigtail #7 (RED), splice to cable
ber (GREEN), place splice protector into YELLOW holder. Coil ber in suggested route shown.
26
Splice Tray 1 (BOTTOM): Tie off cable braid to splice tray. Starting with internal pigtail #1 (RED), splice to cable
ber (GREEN), place splice protector into YELLOW holder. Coil ber in suggested route shown.
25
Internal SWR®Pigtail
Fiber Slack Loop
(Pre-Installed)
Internal SWR Pigtail
Fiber Slack Loop
(Pre-Installed)
Tail
Identication
Labels
Cable Fiber
Slack Loop
Splice Tray 1
(Bottom Tray)
Splice Tray 2
(Top Tray)
Cable Braid
Cable
Tie-Off Point
Cassette
Identication
Labels
Cable Installation
Cable Fiber
Slack Loop
Cable Braid
Cable
Tie-Off Point
Tail
Identication
Labels
Cassette
Identication
Labels

14 © AFL Hyperscale. All rights reserved Series
Re-t drawer cover, ensuring cable braid tail
passes though cut-out (use cut-out on right-
hand-side for alternate side cable entry).
27
Ensuring drawer runners are retracted, slide
spliced drawer into bottom runner position of
6RU housing - an audible click sounds when
runners are engaged.
28
Push drawer back into panel so that it is fully
retracted.
30
Ensure drawer runners
are retracted
Push/Pull Handle
Slide drawer back out to fully extended, gently
pull braid tail to straighten, and make slack
coil, securing with Velcro as shown.
29
Cable Installation

15
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Repeat steps 25-30 for middle and top
drawers.
31 Slide door mount bracket behind screw heads
and tighten. Repeat for other side.
32
Attach front door to mounts with spring
plungers. Door pivots and latches closed with
swell latches. Stick relevant port label to rear of
door.
33
Labels
Cable Installation

16 © AFL Hyperscale. All rights reserved Series
Braided tail routing example for splicing cable /
conduit between two panels.
Cable Tie
Point
Braid Tails
Panel Dimensions
Braided tail routing example for bottom feed cable
routing - t cable cover as shown.
Cable
Braid
Screw
Positions
Additional Steps
Braid can route through
aperture cover

17
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
6RU V-Panel Front Label Application Guide
The complete V-Panel with labels applied should look as shown above.
Application of front labels to the central tabs
Left Labels
All labels centrally
aligned to tabs they
are applied to
All labels centrally
aligned between
the screws
Right Labels

18 © AFL Hyperscale. All rights reserved Series
Notes

19
U-Series 6RU Front-Access V-Panel (FVP)
© AFL Hyperscale. All rights reserved
Series
Notes

Thank you for choosing AFL Hyperscale
AFLHS6RUFVP270820
www.aflhyperscale.com
AFL Hyperscale reserves the right to make changes in this Installation Guide at any time without notice