Aiwa WD-X500M User manual

SERVICE MANUAL
DATA
BASIC TAPE MECHANISM : CDS-801AW1
BASIC CD MECHANISM : CDC02AW2
STEREO CAR
CD CASSETTE RECEIVER
WD-X500M
S/M Code No. 09-015-356-6N1
YU(ST)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-2-
SPECIFICATIONS
• Design and specifications are subject to change without notice.
RADIO SECTION
(FM)
Frequency Range: 87.5 MHz – 108 MHz (100-kHz steps) * or
87.5 MHz – 108 MHz (50-kHz steps) *
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz – 15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB
(AM)
Frequency Range: 530 kHz – 1,710 kHz (10-kHz steps) *or
531 kHz – 1,602 kHz (9-kHz steps) *
Usable Sensitivity: 30 µV (30 dB)
9 k 10 k
* Set the frequency increment for your area using the switch on the
front of the unit. (The switch is factory-set to the 10 k position)
TAPE SECTION
Tape Speed: 4.8 cm/sec. (17/8ips)
S/N Ratio: 50 dB
Frequency Response: 40 Hz – 14,000 Hz
Stereo Separation: 40 dB
CD SECTION
Frequency Response: 17 Hz – 20 kHz + 0/–3 dB
Dynamic Range: More than 80 dB
Channel Separation: More than 65 dB
S/N Ratio: More than 85 dB
Wow/Flutter: Unmeasurable
AUDIO SECTION
Max. Power Output: 45 W x 4 channels
AUX IN input
Input sensitivity (load impedance)
AUX IN: 300 mV (10 kΩ)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance: 4Ω
Tone Control: Bass ± 10 dB at 100 Hz
Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance):
2.2 V (10 kΩ)
Installation size: 178 (W) x 100 (H) x 158 (D) mm
(71/8 (W) x 4 (H) x 61/4 (D) inches)
STEERING-WHEEL REMOTE CONTROL
Dimensions: approx. 67 (W) x 26 (H) x 27 (D) mm
(23/4(W) x 11/16 (H) x 11/8(D) inches)
(excluding holder)
Weight: approx. 38 g (1.33 oz)
(including holder, battery)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-3-
REF. NO PART NO. KANRI DESCRIPTION
NO.
ACCESSORIES LIST
1 8B-KL1-901-010 IB,YU(3L) 500M
2 8B-KL1-902-010 IB,INST,YU,YL (3L,P)500M
3 8B-KL1-007-010 CASE,DFP 2DIN
4 87-B10-141-010 NUT,5 TYPE-2
5 87-B10-143-010 UT1+5-15 W/O SLOT
6 87-B10-144-010 W,5.2-10-0.5
7 87-B10-145-010 W-SPR,5.3-8.5-1.5
8 87-B10-216-010 U+2.6-4.0 ZINC BLK (BH M2.6)
9 8B-KL1-220-010 S-SCREW,5*8TH+TAPPING
10 8Z-KT1-616-010 CONN ASSY,16P B52
11 8Z-KC1-250-010 S-SCREW,HEXAGON
12 87-B10-143-010 UT1+5-15 W/O SLOT
13 8Z-KC1-235-010 HLDR,REAR MTG
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-4-
CAUTIONS WHEN SERVICING
1. Disassembly Procedure
1) Remove the COVER BOTTOM.
2) Remove the screws (pointed by the arrows), and then remove the
DECK MECHANISM.
See Fig. 1.
3) Remove the COVER TOP.
4) Remove the screws (pointed by the arrows), and then remove the
CD MECHANISM.
See Fig. 2.
2. Service Position
Check the operation in the stable status (using a plate, etc.).
See Fig. 3.
3. Test Mode
1. Starting CD Test
1) Use solder to short-circuit the TEST lands.
See Fig. 4.
2) Connect the ACC/BACKUP wire of connector assembly to the posi-
tive (+) terminal of power supply unit, and the ground wire, to the
negative (-) terminal.
3) Adjust the voltage of power supply unit to 14.5 V, and then turn the
power on.
The test mode will start, and all LCD segments will light.
See Fig. 5.
2. Releasing CD Test Mode
1) Turn the power supply unit off.
2) Disconnect each wire of connector assembly.
3) Remove the solder from the TEST lands on the Main C.B.
Fig-1
Fig-2
Fig-3
Fig-4
Fig-5
IC401
IC901
SOLDER BRIDGE
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-5-
RNDM 6
REP1
5
INT
3
REP 4
Mode Operation key Display Details
Operation
SLED
PU moves to outer tracks.
PU moves to inner tracks.
Sled servo
Mechanism operation check
STOP All segments light
All segments light
Standby status
Tracking servo OFF
Track no. and play
time displayed.
TRAVERSE Play pause status
PLAY
Focus servo
Tracking servo
CLV servo
Sled servo
Normal play.
Same as in search mode
if TOC READ is not possible.
TOC READING
Track no., play time displayed.
Level displayed.
SEARCH Continuous focus search
PU lens repeats full-swing.
(Note 1)
Check APC circuit.
Measure laser current.
Check focus error waveform.
LOAD/
UNLOAD CHUCKING
All segments light
START All segments light Test mode starts
All servo OFF
Laser ON
VCC ON
All servo OFF
Laser ON/OFF
3. Description of CD Test Mode Functions
• Check the search mode without inserting a disc.
• Press the REPEAT button to release each mode.
Note 1:
If focus search is continuously operated for 10 minutes or more, the driver IC will generate heat, the protection circuit will operate, and
the CD player may not operate. In this case, turn power off, radiate heat for approx. 10 minutes, and then restart the player.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-6-
ELECTRICAL MAIN PARTS LIST - 1/3
REF. NO PART NO. KANRI DESCRIPTION
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
IC
87-A21-538-010 IC,KIA2025P
87-002-394-010 IC,LB1641
87-A21-936-040 C-IC,LC75421M
87-A21-937-040 C-IC,BA3834F
87-A21-562-010 IC,LA4743B
87-A21-935-030 C-IC,LC75884W
87-A90-951-010 RCR UNIT,SBX1971-52
8B-KL1-622-030 C-IC,UPD178078GF-550-3BA
88-KT1-606-080 IC,PST994D
TRANSISTOR
87-A30-468-040 C-TR,KRC102S-RTK
87-A30-061-080 C-TR,KTA1504GR
87-A30-060-080 C-TR,KTC3875GR
87-A30-295-080 TR,KRA226M
87-A30-473-080 TR,KRC102M-AT
87-A30-487-080 TR,KRC111M-AT
87-A30-472-040 C-TR,KRA226S-RTK
87-A30-469-040 C-TR,KRC111S-RTK
87-A30-279-040 C-TR,DTC314TK
87-A30-467-040 C-TR,KRA111S-RTK
87-A30-299-080 TR,2SB1326
89-418-580-080 TR,2SD1858TV2
87-A30-302-040 C-TR,2SD1758-F5
89-420-120-010 TR,2SD2012
DIODE
87-A40-250-040 C-DIODE,DAN217
87-A40-350-080 ZENER,MTZJ4.7C
87-020-465-080 DIODE,1SS133
87-A40-817-040 C-ZENER,STZ6.8N
87-A40-504-040 C-DIODE,KDS184
87-001-783-080 DIODE,1N4002
87-A40-650-080 ZENER,MTZJ6.8A
87-070-334-080 ZENER,MTZJ10B
87-A40-798-010 DIODE,1N5402 (3A/200V)
87-A40-505-040 C-DIODE,KDS181
87-A40-509-080 ZENER,MTZJ6.8C
87-017-932-080 ZENER,MTZJ6.2B
87-070-136-080 ZENER,MTZJ5.1B
87-A40-620-080 ZENER,MTZJ6.2A
87-A40-624-080 ZENER,MTZJ10A
MAIN C.B
C0101 87-012-274-080 C-CAP,U 1000P-50 K B
C0102 87-012-286-080 C-CAP,U 0.01-25 K B
C0104 87-012-282-080 C-CAP,U 4700P-50 K B
C0105 87-010-498-040 CAP,E 10-16 M 5L SRE
C0106 87-012-195-080 C-CAP,U 100P-50 J CH
C0107 87-010-498-040 CAP,E 10-16 M 5L SRE
C0108 87-010-555-040 CAP,E 100-10 M 5L SRE
C0109 87-012-281-080 C-CAP,U 3900P-50 K B GRM
C0110 87-012-286-080 C-CAP,U 0.01-25 K B
C0111 87-A10-248-080 C-CAP,U 0.1-16 K BR
C0112 87-012-286-080 C-CAP,U 0.01-25 K B
C0113 87-012-286-080 C-CAP,U 0.01-25 K B
C0114 87-010-759-080 C-CAP,U 0.1-25 Z F
C0115 87-012-286-080 C-CAP,U 0.01-25 K B
C0116 87-010-495-040 CAP,E 2.2-50 M 5L SRE
C0117 87-010-787-080 C-CAP,U 0.022-25 K B
C0121 87-A11-228-080 C-CAP,U 0.027-25 K B
C0122 87-A11-228-080 C-CAP,U 0.027-25 K B
C0123 87-A10-047-080 C-CAP,U 1-10 Z F
C0124 87-A10-047-080 C-CAP,U 1-10 Z F
C0301 87-010-805-080 C-CAP,S 1-16 Z F
C0302 87-010-805-080 C-CAP,S 1-16 Z F
C0303 87-010-787-080 C-CAP,U 0.022-25 K B
C0304 87-010-787-080 C-CAP,U 0.022-25 K B
C0305 87-A10-504-080 C-CAP,U 0.047-16 K B
C0401 87-010-498-040 CAP,E 10-16 M 5L SRE
C0402 87-010-498-040 CAP,E 10-16 M 5L SRE
C0403 87-012-276-080 C-CAP,U 1500P-50 K B
C0404 87-012-276-080 C-CAP,U 1500P-50 K B
C0405 87-A11-062-080 C-CAP,S 2.2-16 Z F
C0406 87-A11-062-080 C-CAP,S 2.2-16 Z F
C0407 87-010-786-080 C-CAP,U 0.018-25 K B GRM
C0408 87-010-786-080 C-CAP,U 0.018-25 K B GRM
C0409 87-A10-781-080 C-CAP,U 0.15-10 K B
C0410 87-A10-781-080 C-CAP,U 0.15-10 K B
C0411 87-A10-781-080 C-CAP,U 0.15-10 K B
C0412 87-A10-781-080 C-CAP,U 0.15-10 K B
C0413 87-A10-047-080 C-CAP,U 1-10 Z F
C0414 87-A10-047-080 C-CAP,U 1-10 Z F
C0415 87-010-552-040 CAP,E 22-16 M 5L SRE
C0416 87-010-555-040 CAP,E 100-10 M 5L SRE
C0417 87-010-498-040 CAP,E 10-16 M 5L SRE
C0418 87-010-498-040 CAP,E 10-16 M 5L SRE
C0419 87-010-498-040 CAP,E 10-16 M 5L SRE
C0420 87-010-498-040 CAP,E 10-16 M 5L SRE
C0421 87-A10-353-080 C-CAP,U 0.22-10 K B
C0422 87-A10-353-080 C-CAP,U 0.22-10 K B
C0423 87-A10-047-080 C-CAP,U 1-10 Z F
C0424 87-A10-047-080 C-CAP,U 1-10 Z F
C0425 87-A10-047-080 C-CAP,U 1-10 Z F
C0426 87-A10-047-080 C-CAP,U 1-10 Z F
C0431 87-012-270-080 C-CAP,U 470P-50 K B
C0432 87-012-270-080 C-CAP,U 470P-50 K B
C0433 87-012-270-080 C-CAP,U 470P-50 K B
C0434 87-012-270-080 C-CAP,U 470P-50 K B
C0441 87-A10-260-080 C-CAP,U 0.1-16 K B
C0442 87-A10-260-080 C-CAP,U 0.1-16 K B
C0443 87-A10-260-080 C-CAP,U 0.1-16 K B
C0444 87-010-805-080 C-CAP,S 1-16 Z F
C0445 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0446 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0447 87-A10-260-080 C-CAP,U 0.1-16 K B
C0491 87-A11-127-080 CAP,TC U 3900P-50 K B
C0492 87-010-498-040 CAP,E 10-16 M 5L SRE
C0501 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0502 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0503 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0504 87-012-358-080 C-CAP,S 0.47-10 Z F CM/CB
C0505 87-012-271-080 C-CAP,U 560P-50 K B
C0506 87-012-271-080 C-CAP,U 560P-50 K B
C0507 87-012-271-080 C-CAP,U 560P-50 K B
C0508 87-012-271-080 C-CAP,U 560P-50 K B
C0511 87-010-553-040 CAP,E 47-16 M 5L SRE
C0512 87-010-805-080 C-CAP,S 1-16 Z F
C0514 87-012-368-080 C-CAP,S 0.1-50 Z F
C0515 87-012-368-080 C-CAP,S 0.1-50 Z F
C0516 8A-KC7-623-000 CAP,E 2200-16 125 BT
C0571 87-012-368-080 C-CAP,S 0.1-50 Z F
C0572 87-012-368-080 C-CAP,S 0.1-50 Z F
C0573 87-012-368-080 C-CAP,S 0.1-50 Z F
C0574 87-012-368-080 C-CAP,S 0.1-50 Z F
C0591 87-012-278-080 C-CAP,U 2200P-50 K B
C0592 87-010-074-040 CAP,E 4.7-35 M 5L SRE
C0593 87-012-368-080 C-CAP,S 0.1-50 Z F
C0601 87-012-278-080 C-CAP,U 2200P-50 K B
C0603 87-012-278-080 C-CAP,U 2200P-50 K B
C0608 87-010-787-080 C-CAP,U 0.022-25 K B
C0609 87-010-555-040 CAP,E 100-10 M 5L SRE
C0610 87-010-787-080 C-CAP,U 0.022-25 K B
C0611 87-010-555-040 CAP,E 100-10 M 5L SRE
C0612 87-010-759-080 C-CAP,U 0.1-25 Z F
C0615 87-010-498-040 CAP,E 10-16 M 5L SRE
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-7-
ELECTRICAL MAIN PARTS LIST - 2/3
REF. NO PART NO. KANRI DESCRIPTION
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
C0616 87-010-498-040 CAP,E 10-16 M 5L SRE
C0617 87-010-759-080 C-CAP,U 0.1-25 Z F
C0618 87-010-553-040 CAP,E 47-16 M 5L SRE
C0621 87-010-759-080 C-CAP,U 0.1-25 Z F
C0622 87-010-553-040 CAP,E 47-16 M 5L SRE
C0791 87-A10-047-080 C-CAP,U 1-10 Z F
C0792 87-A10-047-080 C-CAP,U 1-10 Z F
C0793 87-012-282-080 C-CAP,U 4700P-50 K B
C0794 87-012-282-080 C-CAP,U 4700P-50 K B
C0821 87-A10-047-080 C-CAP,U 1-10 Z F
C0822 87-A10-047-080 C-CAP,U 1-10 Z F
C0901 87-012-182-080 C-CAP,U 27P-50 J CH
C0902 87-012-182-080 C-CAP,U 27P-50 J CH
C0903 87-010-759-080 C-CAP,U 0.1-25 Z F
C0904 87-010-759-080 C-CAP,U 0.1-25 Z F
C0905 87-010-759-080 C-CAP,U 0.1-25 Z F
C0907 87-012-195-080 C-CAP,U 100P-50 J CH
C0908 87-012-195-080 C-CAP,U 100P-50 J CH
C0909 87-010-759-080 C-CAP,U 0.1-25 Z F
C0910 87-012-274-080 C-CAP,U 1000P-50 K B
C0911 87-018-123-080 CAP,TC U 220P-50 K B UP050
C0912 87-012-199-080 C-CAP,U 220P-50 J CH
C0915 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM
C0981 87-018-209-080 CAP,TC U 0.1-50 Z F UP050
C0985 87-010-759-080 C-CAP,U 0.1-25 Z F
CN0601 8Z-KT1-611-010 CONN,16P CAM-B51
CN0891 87-A61-219-010 CONN,20P H 52089-2020
CN0971 88-KTA-603-010 CONN,15P CAM-B68
CNA0202 8B-KL1-617-010 CONN ASSY,5P DECK AUDIO
CNA0222 8B-KL1-616-010 CONN ASSY,12P DECK CONT
!!
!!
!F0601 8Z-KC1-621-010 FUSE,15A 32V
J0101 8Z-KT1-614-010 ANT,AW-002
J0301 8A-KC7-620-010 JACK,DIN 13 P SKDS1302
J0401 87-A61-224-010 JACK,PIN 4P XR-401
L0101 87-003-143-080 COIL,4.7UH K LAL02
L0104 8Z-KT1-619-010 COIL,68MH K7-D
L0401 87-003-143-080 COIL,4.7UH K LAL02
L0601 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE
L0791 87-003-102-080 COIL,10UH J LAL02
L0901 87-003-149-080 COIL,47UH J LAL02
LED0901 87-027-262-010 LED,TLR124 RED
SW0901 87-A91-070-010 SW,TACT SKHHLV
SW0904 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TU0101 8B-KCF-621-010 TU UNIT, FAE347-A22
X0901 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49
FRONT C.B
C0701 87-010-805-080 C-CAP,S 1-16 Z F
C0702 87-A10-504-080 C-CAP,U 0.047-16 K B
C0703 87-A10-504-080 C-CAP,U 0.047-16 K B
C0704 87-012-272-080 C-CAP,U 680P-50 K B GRM
C0705 87-010-805-080 C-CAP,S 1-16 Z F
C0706 87-A10-260-080 C-CAP,U 0.1-16 K B
C0711 87-A10-260-080 C-CAP,U 0.1-16 K B
C0721 87-010-787-080 C-CAP,U 0.022-25 K B
C0722 87-010-787-080 C-CAP,U 0.022-25 K B
C0771 87-010-805-080 C-CAP,S 1-16 Z F
CON0701 88-KTA-602-010 C-CONN,15P CAM-B67
CON0702 8B-KL1-618-010 F-CABLE,3P 60MM (AUX)
LCD0701 8B-KL1-626-010 LCD,BKL-1
LED0731 87-A41-100-040 LED,SEL6410E GRN
LED0732 87-A41-100-040 LED,SEL6410E GRN
LED0733 87-A41-100-040 LED,SEL6410E GRN
LED0734 87-A41-059-080 LED,SEL6427EP GRN
LED0735 87-A41-059-080 LED,SEL6427EP GRN
LED0736 87-A41-100-040 LED,SEL6410E GRN
LED0737 87-A41-100-040 LED,SEL6410E GRN
LED0738 87-A41-100-040 LED,SEL6410E GRN
LED0739 87-A41-100-040 LED,SEL6410E GRN
LED0740 87-A41-100-040 LED,SEL6410E GRN
LED0741 87-A41-064-010 LED,BR2222S RED
LED0742 87-A41-064-010 LED,BR2222S RED
LED0743 87-A41-063-010 LED,EBR3368S RED
LED0751 87-A92-042-090 LED,KM2520MBC30 BLU
LED0752 87-A92-042-090 LED,KM2520MBC30 BLU
LED0753 87-A40-814-080 LED,SEL2E10C BLU
LED0761 87-A41-064-010 LED,BR2222S RED
LED0762 87-A41-064-010 LED,BR2222S RED
PL0701 8B-KCF-631-010 LAMP,9V-65MA
PL0702 8B-KCF-631-010 LAMP,9V-65MA
PL0703 8B-KCF-631-010 LAMP,9V-65MA
PL0704 8B-KCF-631-010 LAMP,9V-65MA
SW0701 87-A91-987-080 SW,TACT SKQCAB
SW0702 87-A91-987-080 SW,TACT SKQCAB
SW0703 87-A91-987-080 SW,TACT SKQCAB
SW0704 87-A91-987-080 SW,TACT SKQCAB
SW0705 87-A91-987-080 SW,TACT SKQCAB
SW0706 87-A91-987-080 SW,TACT SKQCAB
SW0707 87-A91-987-080 SW,TACT SKQCAB
SW0708 87-A91-987-080 SW,TACT SKQCAB
SW0709 87-A91-987-080 SW,TACT SKQCAB
SW0710 87-A91-987-080 SW,TACT SKQCAB
SW0711 87-A91-987-080 SW,TACT SKQCAB
SW0712 87-A91-987-080 SW,TACT SKQCAB
SW0713 87-A91-987-080 SW,TACT SKQCAB
SW0714 87-A91-987-080 SW,TACT SKQCAB
SW0716 87-A91-987-080 SW,TACT SKQCAB
SW0717 87-A91-987-080 SW,TACT SKQCAB
SW0718 87-A91-987-080 SW,TACT SKQCAB
SW0721 87-A91-986-010 SW,RTRY EC12E24504-15MM
PRE C.B
C0201 87-012-272-080 C-CAP,U 680P-50 K B GRM
C0202 87-012-272-080 C-CAP,U 680P-50 K B GRM
C0203 87-012-272-080 C-CAP,U 680P-50 K B GRM
C0204 87-012-272-080 C-CAP,U 680P-50 K B GRM
C0205 87-010-263-040 CAP,E 100-10 M 11L SME
C0206 87-010-263-040 CAP,E 100-10 M 11L SME
C0207 87-012-286-080 C-CAP,U 0.01-25 K B
C0208 87-012-286-080 C-CAP,U 0.01-25 K B
C0211 87-010-401-040 CAP,E 1-50 M 11L SME
C0212 87-010-401-040 CAP,E 1-50 M 11L SME
C0213 87-012-271-080 C-CAP,U 560P-50 K B
C0214 87-012-271-080 C-CAP,U 560P-50 K B
C0215 87-010-263-040 CAP,E 100-10 M 11L SME
C0216 87-010-404-040 CAP,E 4.7-50 M 11L SME
C0218 87-010-378-040 CAP,E 10-16 M 11L SME
C0219 87-012-266-080 C-CAP,U 220P-50 K B GRM
C0223 87-010-404-040 CAP,E 4.7-50 M 11L SME
C0224 87-010-380-040 CAP,E 47-16 M 11L SME
C0225 87-010-380-040 CAP,E 47-16 M 11L SME
C0226 87-012-141-080 C-CAP,S 0.22-16 Z F C2012
C0227 87-012-141-080 C-CAP,S 0.22-16 Z F C2012
C0228 87-012-141-080 C-CAP,S 0.22-16 Z F C2012
C0229 87-012-286-080 C-CAP,U 0.01-25 K B
C0230 87-012-274-080 C-CAP,U 1000P-50 K B
C0291 87-012-266-080 C-CAP,U 220P-50 K B GRM
C0292 87-012-266-080 C-CAP,U 220P-50 K B GRM
C0293 87-012-266-080 C-CAP,U 220P-50 K B GRM
C0294 87-012-266-080 C-CAP,U 220P-50 K B GRM
CON0201 87-A60-670-010 CONN,6P H 2MM JMT
CON0202 87-A60-622-010 CONN,5P V 2MM JMT
CON0221 87-099-203-010 CONN,10P H BLK 6216
CON0222 87-A60-629-010 CONN,12P V 2MM JMT
L0201 87-005-902-080 C-COIL,S 4.7UH K LK2125
L0202 87-005-902-080 C-COIL,S 4.7UH K LK2125
L0203 87-005-902-080 C-COIL,S 4.7UH K LK2125
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-8-
88
A
Resistor Code
Chip Resistor Part Coding
Figure
Value of resistor
Chip resistor
Wattage Type Tolerance
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
CJ
CJ
CJ
Form
LW t
1.6 0.8 0.45
2 1.25 0.45
3.2 1.6
108
118
128
: A
: A
CHIP RESISTOR PART CODE
0.55
Resistor Code
Dimensions (mm)
Symbol
1/16W 1005 5% CJ
1.0 0.5 0.35 104
Lt
W
• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.
ELECTRICAL MAIN PARTS LIST - 3/3
L0204 87-005-902-080 C-COIL,S 4.7UH K LK2125
L0210 87-003-143-080 COIL,4.7UH K LAL02
AUX C.B
J0701 85-HRL-623-010 JACK,3.5 BLK ST BLK
REF. NO PART NO. KANRI DESCRIPTION
NO.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-9-
TRANSISTOR ILLUSTRATION
BE
C
DTC314TK
KRA111S
KRA226S
KRC102S
KRC111S
KTA1504GR
KTC3875GR
E
C
C
B
2SD1758
E C B
KRA226M
KRC102M
KRC111M
E C B
2SB1326
2SD1858
B C E
2SD2012
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

-10-
BLOCK DIAGRAM - 1/1
J101
ANTENNA
JACK
BAND
SW
LOC/DX
CONT
Q102,
103
Q105,
106 Q101
TUN-L
TUN-R
BAND
CONT.
EO0
LOC/DX
2
16 17 9,12 6,14 3,4
TU101
IC201
IC221
J301
CDC-02A
CN891 CNA222 CNA223
CON222
CNA202 CON202
MAIN C.B
PRE C.B
FRONT C.B
LCD701
LCD DISPLAY
SW701~718
IC701 IC771
JOG DIAL J701
AUX IN
REMOTE
CONTROL
SENSOR
CON701
CN971
AUX L AUXR
TA-L
TA-R
CD-L
CD-R
IC901
IC401
IC441
Q401,402 Q403~406
MUTE
SW
Q491,492
IC501
D981,982,
R981,982,
C981
IC985
Q607
Q301,302
Q601,602
Q611
Q612~615
Q621
CON601
1~4,
9~12
7
16
J401
L
RFRONT
L
RREAR
AF MUTE
DSSA CONT
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com