Allen-Bradley 1757-ABRIO User manual

ProcessRemoteI/O

(RIO)

Communication

Interface Module

1757-ABRIO

User Manual

Allen-Bradley HMIs

Important User Information

Because of the variety of uses for the products described in this

publication, those responsible for the application and use of these

products must satisfy themselves that all necessary steps have been

taken to assure that each application and use meets all performance

and safety requirements, including any applicable laws, regulations,

codes and standards. In no event will Allen-Bradley be responsible or

liable for indirect or consequential damage resulting from the use or

application of these products.

Any illustrations, charts, sample programs, and layout examples

shown in this publication are intended solely for purposes of

example. Since there are many variables and requirements associated

with any particular installation, Allen-Bradley does not assume

responsibility or liability (to include intellectual property liability) for

actual use based upon the examples shown in this publication.

Allen-Bradley publication SGI-1.1, Safety Guidelines for the

Application, Installation and Maintenance of Solid-State Control

(available from your local Allen-Bradley office), describes some

important differences between solid-state equipment and

electromechanical devices that should be taken into consideration

when applying products such as those described in this publication.

Reproduction of the contents of this copyrighted publication, in whole

or part, without written permission of Rockwell Automation, is

prohibited.

Throughout this publication, notes may be used to make you aware of

safety considerations. The following annotations and their

accompanying statements help you to identify a potential hazard,

avoid a potential hazard, and recognize the consequences of a

potential hazard:

WARNING

Identifiesinformationaboutpracticesorcircumstances

thatcancauseanexplosioninahazardousenvironment,

which may lead to personal injury or death, property

damage, or economic loss.

ATTENTION

Identifiesinformationaboutpracticesorcircumstances

thatcanleadtopersonalinjuryordeath,propertydamage,

or economic loss.

IMPORTANT Identifies information that is critical for successful

application and understanding of the product.

Rockwell Automation

Support

Before you contact Rockwell Automation for technical assistance, we

suggest you please review the troubleshooting information contained

in this publication first.

If the problem persists, call your local Rockwell Automation

representative or contact Rockwell Automation in one of the

following ways:

Your Questions or Comments on this Manual

If you find a problem with this manual, please notify us of it on the

enclosed How Are We Doing? form.

Phone United

States/Canada 1.440.646.5800

Outside United

States/Canada You can access the phone number for your

country via the Internet:

1. Go to http://www.ab.com

2. Click on Product Support

(http://support.automation.rockwell.com)

3. Under Support Centers, click on Contact

Information

Internet ⇒1. Go to http://www.ab.com

2. Click on Product Support

(http://support.automation.rockwell.com)

Allen-Bradley HMIs

Notes:

iPublication 1757-UM007A-EN-P - April 2002

Table of Contents

Important User Information. . . . . . . . . . . . . . . . . . . . . . . . . . ii

Rockwell Automation Support . . . . . . . . . . . . . . . . . . . . . . . iii

Your Questions or Comments on this Manual . . . . . . . . . iii

Preface

Who Should Use this Manual. . . . . . . . . . . . . . . . . . . . . . . P-1

Purpose of this Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . P-1

Conventions and Related Terms. . . . . . . . . . . . . . . . . . . . . P-1

Related Documentation. . . . . . . . . . . . . . . . . . . . . . . . . . . P-1

Chapter 1

Overview

1757-ABRIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1

Mapping and Accessing RIO Data . . . . . . . . . . . . . . . . . . . 1-2

RSLinx Requirements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3

Installing AbRioCfg . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3

Quick Start . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5

Chapter 2

Configuring the 1757-ABRIO

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1

Autoconfiguring I/O Racks . . . . . . . . . . . . . . . . . . . . . . . . 2-1

Adding Block Transfer Modules. . . . . . . . . . . . . . . . . . . . . 2-4

Addressing Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-5

Configuring Block Transfer Modules . . . . . . . . . . . . . . . . . 2-6

Scaling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-6

Input Scaling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-7

Output Scaling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-7

Creating Tags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8

Numeric Read and Numeric Write . . . . . . . . . . . . . 2-8

Flag Read and Flag Write . . . . . . . . . . . . . . . . . . . . 2-8

Text Read . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8

Creating a Tag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-9

Mapping Data to Tags. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-10

Discrete I/O . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-10

Block Transfers . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-10

I/O . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-10

Deleting Mapped Data . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

Downloading the Configuration. . . . . . . . . . . . . . . . . . . . . 2-11

Uploading a Configuration . . . . . . . . . . . . . . . . . . . . . . . . 2-11

Allen-Bradley HMIs

Publication 1757-UM007A-EN-P - April 2002

Table of Contents ii

Chapter 3

Accessing Data on the

1757-ABRIO

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

Modes of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

CONFIG Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

INACTIVE Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

ACTIVE Mode (Run) . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2

FORCED ACTIVE Mode . . . . . . . . . . . . . . . . . . . . . . . . 3-2

ProcessLogix Accessing Data from the ABRIO . . . . . . . . . . 3-3

ControlLogix Accessing Data from the ABRIO . . . . . . . . . . 3-6

First: Create Tags For All Messages

and All Storage Areas . . . . . . . . . . . . . . . . . . . . . . 3-6

Second: Create Message Commands to

Read and Write All RIO Data . . . . . . . . . . . . . . . . 3-7

Identifying the Path . . . . . . . . . . . . . . . . . . . . . . . . 3-11

Accessing Data from OPC/DDE . . . . . . . . . . . . . . . . . . . . . 3-12

Configuring a Topic in RSLinx . . . . . . . . . . . . . . . . . . . 3-12

Accessing the Data. . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13

Troubleshooting ABRIO Communications . . . . . . . . . . . . . 3-13

Chapter 4

Monitoring the 1757-ABRIO

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

Monitoring Discrete I/O . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

Monitoring the Data Value of Tags. . . . . . . . . . . . . . . . . . . 4-2

Monitoring the Status of a Block Transfer. . . . . . . . . . . . . . 4-3

Monitoring the Scanner Log. . . . . . . . . . . . . . . . . . . . . . . . 4-4

Monitoring Diagnostic Counters. . . . . . . . . . . . . . . . . . . . . 4-5

Active Rack List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5

Global Diagnostic Counters . . . . . . . . . . . . . . . . . . . . . 4-5

Fatal Errors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6

Publication 1757-UM007A-EN-P - April 2002

Table of Contents iii

Chapter 5

Supported 1771 Modules

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1

1771-IFE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-2

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5

1771-OFE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-6

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8

1771-IR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-9

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-11

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-11

1771-IXE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-12

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14

1771-IL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-15

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17

1771-NOC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-18

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-18

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20

1771-NOV. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-21

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23

1771-NIV . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-24

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-24

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-26

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-26

1771-NR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-27

Module Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 5-28

I/O Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-29

Diagnostic Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-30

1770-HT1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-31

Rack Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-32

Configuring the 1770-HT1 . . . . . . . . . . . . . . . . . . . . . . 5-32

Configuring the Hart Network . . . . . . . . . . . . . . . . 5-32

Hart Command status. . . . . . . . . . . . . . . . . . . . . . . . . . 5-37

Allen-Bradley HMIs

Publication 1757-UM007A-EN-P - April 2002

Table of Contents iv

Chapter 6

Updating the 1757-ABRIO

Firmware

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1

NTools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1

ControlFlash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2

Appendix A

Troubleshooting

LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-1

RIO LED - Network Status . . . . . . . . . . . . . . . . . . . . . . A-1

SYS LED - ControlBus Status. . . . . . . . . . . . . . . . . . . . . A-1

OK LED - Module Health . . . . . . . . . . . . . . . . . . . . . . . A-2

4-Character Display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-2

Using the Configuration Program for Troubleshooting . . . . A-3

Common Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-3

Autoconfiguration fails or does not find racks . . . . . . . . A-3

Data is not updating . . . . . . . . . . . . . . . . . . . . . . . . . . A-4

Rack is offline or isn’t updating . . . . . . . . . . . . . . . . . . A-4

Menu items are grayed out. . . . . . . . . . . . . . . . . . . . . . A-4

Using RSLogix 5000 to Diagnose Problems. . . . . . . . . . . . . A-4

General Tab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-5

Connection Tab. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-5

Module Info Tab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-6

Backplane Tab. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-6

Appendix B

Operational Comparison Between

the 1757-ABRIO and PLC-5

Normal Operational Messages . . . . . . . . . . . . . . . . . . . . . . B-1

Exception Handling Messages . . . . . . . . . . . . . . . . . . . . . . B-4

Appendix C

Specifications

1Publication 1757-UM007A-EN-P - April 2002

Preface

Who Should Use this

Manual

We assume you have a good understanding of 1771 RIO (Remote I/O)

as well as the host processor system (ProcessLogix or ControlLogix).

Purpose of this Manual

This manual describes how to understand, configure and troubleshoot

your 1757-ABRIO RIO module.

For installation information, refer to the Process Remote I/O (RIO)

Communication Interface Module, publication 1757-IN916A-EN-P.

Conventions and Related

Terms

Popular Control Unit manuals by other brands

Festo

Festo Compact Performance CP-FB6-E Brief description

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Quick installation guide

JS Automation

JS Automation MPC3034A user manual

JAUDT

JAUDT SW GII 6406 Series Translation of the original operating instructions

Spektrum

Spektrum Air Module System manual

BOC Edwards

BOC Edwards Q Series instruction manual

KHADAS

KHADAS BT Magic quick start

Etherma

Etherma eNEXHO-IL Assembly and operating instructions

PMFoundations

PMFoundations Attenuverter Assembly guide

GEA

GEA VARIVENT Operating instruction

Walther Systemtechnik

Walther Systemtechnik VMS-05 Assembly instructions

Altronix

Altronix LINQ8PD Installation and programming manual

Eaton

Eaton Powerware Series user guide

WAGO

WAGO 750-407/040-000 manual

Sony

Sony CCU-590 Operation manual

Graco

Graco 25D614 instructions

Task Force Tips

Task Force Tips YE-RF-900 Instructions for installation, safe operation and maintenance

Shini

Shini SPV-U Series manual