ATD Tools ATD-7437A User manual

ATD7437A_rev_0519Made in China to ATD Tools, Inc. Specifications
Visit us at www.atdtools.com
ATD-7437A
1-1/2 Ton Heavy-Duty Hydraulic
Floor Style Transmission Jack
Owner’s Manual
Features:
7KHDGMXVWDEOHKHDGFDQEHWLOWHGIRUZDUGEDFNZDUGDQG
VLGHWRVLGHIRURSWLPXPDOLJQPHQWRIWUDQVPLVVLRQEROWSDWWHUQVDQGSLQV
/RDGUHVWUDLQLQJFKDLQIRUVDIHUDLVLQJDQGORZHULQJRIORDG
VZLYHOFDVWHUVDOORZHDV\PRYHPHQWDQGSRVLWLRQLQJRIWUDQVPLVVLRQMDFN
5XJJHGVWHHOZKHHOVDQGIXOOVZLYHOEDOOEHDULQJFDVWHUV
8VHUIULHQGO\URWDWLQJSXPSLQJVRFNHWIRUPD[LPXPPXOWLGLUHFWLRQDORSHUDWLRQ
0HHWVRUH[FHHGV$60(3$6(VWDQGDUGV
Specifications:
&DSDFLW\7RQV
0LQLPXP+HLJKW´
0D[LPXP+HLJKW´
+DQGOH/HQJWK´
6DGGOH%DVH´[´
([SDQGHG6DGGOH$UHD´[´
6KLSSLQJ:HLJKWOEV


BEFORE USE
1. Inspect MDFN EHIRUH each use. Do not use if EHQW
EURNHn or FUDFNHG components are noted. (QVXUH
thatcasters movefreel\. &KHFN forandtighten an\
loose DVVHPEOLHs.
. Verif\that the product and the application are
compatLEOH.
3. 5HPRYH oil filler SOXJVFUHZ prior to initial use to
confirmoil levelis atorMXVW DERYH theinnerF\OLQGHr
as seen from the reservoir, fill as needed and
reinstall oil filler SOXJVFUew.
Save these instructions
For \RXU safet\,read, understand,and followtheinformationprovided withandon thisMDFN The ownerandoperator of
this equipment should have an understanding of this MDFN and safe operating procedures EHIRUH attempting to use. The
owner and operator should EH aware that use and repair of this product PD\ require special VNLOOV and NQRZOHGJH
Instructions and VDIHW\ information should EH FRQYH\HG in the operator's native language EHIRUH use of this MDFN is
authorized. MaNe certain that the operator thoroughl\understands the inherent dangers associated with the use and
misuse of the product. If DQ\ GRXEt H[LVWV as to the safe and proper use of this MDFN remove from service immediatel\.
Inspect before each use. Do not use if EURNHQ EHQW FUDFNHG or damaged parts are noted. $Q\ MDFN that appears
damaged in DQ\ wa\, or operates DEQRUPDOO\ should EH removed from service immediatel\. If the MDFN has EHHQ or
suspected to have EHHQ VXEMHFWHG to a shocNload D load dropped suddenl\, XQH[SHFWHGO\ upon LW LPPHGLDWHO\
discontinue use until MDFN has EHHQ FKHFNHG E\DIDFWRU\ authorized service center.It is recommended that an
annualinspectionEH done E\ qualifiedpersonnel. /DEHOV and operator'smanuals are DYDLODEOH frommanufacturer.
PRODUCT DESCRIPTION
ATDTools+\GUDXOLF Transmission -DFNV aredesigned toEH usedas anaid inthe removaland installationof automotive
and light WUXFN transmissions, transfer cases and WUDQVD[OHV 7KH\ are intended for use under an overhead lift or in a
garage pit. This MDFNPHHWVRUH[FHHGV$60(3$6(VWDQGDUGV.
SAFETY INSTRUCTIONS
SPECIFICATIONS
Stud\, understand, and follow all printed materials
providedwithonthisproductEHforeuse.
Do not H[FHHG rated capacit\.
8VH RQO\ on hard, level surfaces FDSDEOH of supporting
rated FDSDFLW\ loads.
8VH of this MDFN is limited to the removal, installation
andtransportationof transmissions,transfer cases
and WUDQVD[OHV Do not use a transmission MDFN to tilt
orsupport avehicle.
(QVXUH thecenterJUDYLW\ ofloadiscenteredonthesaddle.
For \RXU safet\, do not H[FHHG  tilt angle of the
saddle DVVHPEO\ in all directions.
$GHTXDWHO\ supportthevehicle EHfore startingrepairs.
8VH RQO\ chains and slings provided.
If loaded MDFN must EH moved, PDNH sure that the load
is secured, stDEOH and in lowest position.
This is a lifting and lowering device onl\.
Transferload LPPHGLDWHO\ toappropriatesupport
devicefor serviceor repair.
6KRFN loads PD\ cause the sudden loss of load DQG or
cause the MDFN to tip or flip over violentl\,EHQG or EUHDN.
No alterations shall EH made on this product
Failure to heed these PDUNLQJV PD\ result in personal
LQMXU\ andorpropert\damage.
!WARNING
CAUTION!5HDG carefXOO\ EHfore XQSDFNLQJ product
Model
ATD-7437A OEV ´ ´ ´[´ ´[´ ´ OEV
&DSDFLW\ Minimum
+HLJKW
0D[LPXP
+HLJKW 6DGGOH%DVH ([SDQGHG6DGGOH Area +DQGOH
/HQJWK :HLJKW

3
ASSEMBLY
/LWWOH DVVHPEO\ is required. 5HIHU to thefigures in the
manual for details in understanding the DVVHPEO\DQG
the components of \RXU product.
t,QVWDOOEUDFNHWVSDUWDQGSDUWLQWRVDGGOH
SODWHSDUWZLWKWKHEROWVSDUWZDVKHUV
SDUWDQGZLQJQXWVSDUW
$WWDFKWKHFKDLQVSDUWWRWKHEUDFNHWVSDUW
6HFXUHWREUDFNHWVZLWKWKHEROWVSDUWZDVKHUV
SDUWORFNZDVKHUVSDUWDQGQXWVSDUW
t$VVHPEOHWKHFKDLQKRRNVSDUWKRRNVWRWKH
DGDSWHUEROWVSDUWZLWKWKHZLQJQXWVSDUW
t6HFXUHWKHDGDSWHUEROWVSDUWWRWKHWZRUHPDLQLQJ
EUDFNHWVSDUWXVLQJWKHZDVKHUVSDUWDQG
QXWVSDUW
OPERATION
Raise saddle:
1. /RFDte and close release valve E\ turning NnoE
FORFNZLVe firml\, then pump the pump handle until
the load is contacted.
 Followvehicle manufacturer’srecommended proce-
dures for removing the load as outlined in vehicle
service manual or repair JXLGH3RVLWLRQWKHWUDQVPLVVLRQ
on the saddle plate, resting against the angle plates.
3. Secure load with provided chains. (QVXUHWKHORDG¶V
center of JUDYLW\ is centered on the saddle and load
is VWDEOe EHIRUe moving MDFN.
Lower saddle:
Caution! %H sure all tools and personnel are clear
EHIRUH loweringload.'\QDPLF VKRFN loads arecreated
E\ TXLFNO\ opening and closing the release valve as the
loadisEHLQJ lowered. Theresulting overload ma\
cause K\GUDXOLF V\Vtem failure.
1. Slowl\, JHQWO\ turn the release valve NQRE
FRXQWHUFORFNZLVH never more than 1/2 full turn
until the load is completHO\ lowered.
.Immediatel\transferthe load toan appropriate
repair IL[WXUH
Toavoid crushingandrelated
LQMXULHV
1(9(5 ZRUN on,underor
aroundaload supportedonl\
E\ a MDFN ,PPHGLDWHO\
transfer the load to an
appropriateZRUN station.
!WARNING
MAINTENANCE
Important8VH RQO\ agood gradeK\GUDXOLF MDFN oil.Avoid
PL[LQJ differentW\pes offluidandNEVER use EUDNefluid,
turELne oil, transmission fluid, motor oil or gl\Ferin.
Improper fluid can cause premature failure of the MDFN
andthe potentialforsudden andimmediate lossof load.
:H recommend0RELO '7( 13M orequivalent.
Adding oil
1. :ith saddle fXOO\ lowered, set MDFN in its upright,
levelposition. 5HPRYH oilfiller SOXJ screw.
.7KHRLOOHYHOVKRXOGEHZLWKLQ´RIWKHILOOHU
plug hole.
Changing oil
ForEHVW performanceand longestlife,replace the
complete fluid VXSSO\ at least once per \Har.
1. :ith saddle fXOO\ lowered, set MDFN in its upright,
levelposition.5HPRYH the oil fillerSOXJ screw.
./D\ the MDFN on its side and drain the fluid into a
VXLWDEOH container.
Note: Dispose of K\GUDXOLF fluid in accordance with
localregulations.
3. Set MDFN in its level upright position.
4. Fill with oil until MXVtEHORZ the rim of oil filler hole.
5. 5HLQVtall oil filler plugscrew.
Lubrication
A periodic coating of light OXEULFDting oil to pivot points,
D[OHV and hinges will help to prevent rust and assure
thatwheels,casters andpump DVVHPEOLHV move freel\.
Cleaning
3HULRGLFDOO\ FKHFN the ram for signs of rust or
corrosion. Clean as needed and wipe with an oil\
cloth.
Note: NeverusesandpaperorDErasive materialon
thesesurfaces!
Storage
:KHQ not in use, store the MDFN with pump piston and
saddle in lowest position.
IMPORTANT: 7KHXVHRIDOFRKROK\GUDXOLFEUDNHIOXLG
or detergent motor oil could damage the seals and result
LQMDFNIDLOXUH

4
TROUBLESHOOTING
Symptom Possible Cause Corrective Action
1. 5elease valve is open 1. Close release valve
. /owno oil in reservoir . Fill with oil and Eleed s\stem
3. Air-locNed s\stem 3. %leed s\stem
4. /oad is aEove capacit\of MacN4. 8se correct equipment
. 3acNing worn out or defective . Install seal Nit
JacNlifts onl\partiall\1. Too much or not enough oil 1. ChecNoil level
JacNadvances slowl\1. 3ump not worNing correctl\1. Install seal Nit, or replace power
unit
1. C\linder pacNing is leaNing 1. Install seal Nit
. Valve not worNing correctl\
suction, deliver\, release, or E\pass
. Inspect valves. Clean and repair
seat surfaces
3. Air-locNed s\stem 3. %leed s\stem
JacNleaNs oil 1. :orn or damaged seals 1. Install seal Nit
JacNwill not retract 1. 5elease valve is closed 1. Open or clean release valve
JacNdoes not lift
JacNlifts load, Eut doesn't
hold

5
REPLACEMENT PARTS
Not all components of this MDFN are replacement items, EXW are illustrated as a convenient reference for location
and position in the DVVHPEO\ sequence. :KHQ ordering parts, please give the model QXPEHU and parts description.
Call \RXUGLVWULEXWRU for current pricing.
+DQGOH$VVHPEO\
3RZHU8QLW$VVHPEO\
%UDFNHW$VVHPEO\
%UDFNHW$VVHPEO\
&DVWHU$VVHPEO\


ITEM# ORDERING PART# PART DESCRIPTION QTY ITEM# ORDERING PART# PART DESCRIPTION QTY
1:+((/ ASSY. 4 1-15 CO33(5 :AS+(5 1
:AS+(5  1-1VA/V(1
3N8T1-17 ST((/ %A// 
435T7437A-04 F5AM(11-1O-5ING 
535T7437A-05 %O/T1-19 5(/(AS(VA/V(1
35T7437A-0S+AFT 1 1-03IN 1
735T7437A-07 :AS+(5 11-15(/(AS(KNO%1
35T7437A-05OD /INK 1- %O/T1
935T7437A-09 :AS+(5  1-3ST((/ %A// 1
10 35T7437A-10 SADD/( S(AT 1 1-4%A// S(AT 1
11 35T7437A-11 S+AFT 1 1-5S35ING 1
135T7437A-1:AS+(5 41- SC5(: 1
13 35T7437A-13 %5ACK(T11-7S(A/ING :AS+(5 1
14 35T7437A-14 N8T1- SC5(: 1
15 35T7437A-15 S+AFT 1 1-9S35ING 1
135T7437A-13IN 1-30 ST((/ %A// 1
17 35T7437A-17 %O/T 7 1-31 S35ING 1
135T7437A-1+AND :+((/  1-3CO33(5 :AS+(5 1
19 35T7437A-19 ADJ8STM(NT 5OD 1-33 SC5(: 1
035T7437A-0N8T 3 1-34 CO33(5 :AS+(5 1
135T7437A-1S+AFT 1 1-35 :AS+(5 3
 35T7437A- 5(TAINING 5ING 1-3%5ACK(T1
335T7437A-3N8T1-37 3IN 1
435T7437A-4%(A5ING 4 1-3Y-5ING 1
535T7437A-5N
8T1-39 O-5ING 1
 35T7437A- S+AFT 1 1-40 CY/IND(5 38M31
735T7437A-7S+AFT 1 1-41 38M3CY/IND(5 1
 35T7437A- G5(AS(FITTING 1 1-4:I3(5 5ING 1
935T7437A-9/IFT A5M 1 1-43 /INK 3/AT(
30 35T7437A-30 3IN 1-44 3IN 
31 35T7437A-31 S+AFT 1-45 +AND/( 1
335T7437A-35OD /INK 1-4+AND/( S/((V(1
33 35T7437A-33 :AS+(5  3-1 %O/T
34 35T7437A-34 5OD /INK 1 3-:AS+(5 
35 35T7437A-35 3IN 1 3-3 :AS+(5 
335T7437A-33IN 3-4 C+AIN 
1-1 SNA35ING 1 3-5 N8T
1-:AS+(5  3-%O/T4
1-3 O-5ING 1 3-7 %5ACK(T
1-4 3ISTON 5OD 1 3-%5ACK(T1
1-5 3ISTON 5ING 1 3-9 :AS+(5 4
1-S(A/ING :AS+(5 13-10 N8T4
1-7 O-5ING 1 3-11 N8T
1-:AS+(5 13-1:AS+(5 
1-9 :AS+(5 13-13 %5ACK(T
1-10 %ODY 1 3-14 N8T
1-11 OI/FI//(5 3/8G13-15%O/T
1-1:AS+(5  3-1+OOK 
1-13 %O/T3-17 35T7437A-317 %O/T
1-14 %O/T13-135T7437A-31%OA5D1
NA35T7437A-SK S(A/KIT 1
1-3, 1-6, 1-7, 1-11, 1-15, 1-18, 1-27, 1-32, 1-34, 1-38 (x2), 1-39 (x2)
%racNet AssemEl\
* - Seal Kit Includes:
%racNet 1 AssemEl\Power Unit Assembly
+andle
Ass
\
35T7437A-01
35T7437A-37
35T7437A-37
35T7437A-45
35T7437A-31-37
35T7437A-3-31
3ower 8nit AssemEl\
Caster
Ass
\

7
DATE MAINTENANCE PERFORMED
PREVENTATIVE MAINTENANCE RECORD LOG


WARRANTY
1 YEAR LIMITED WARRANTY
THIS WARRANTY AND CONFIRMED RECEIPT(S) SHOULD BE RETAINED BY THE CUSTOMER AT ALL TIMES
385&+$6(')520 _______________________________________
'$7(385&+$6(' ________________________________________
,192,&(5(&(,37180%(5BBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBB
<RXU$7'$LVZDUUDQWHGIRUDSHULRGRIPRQWKVIURPWKHRULJLQDOSXUFKDVHGDWH
)RUDSHULRGRIRQH\HDUIURP\RXUSXUFKDVHGDWH$7'7RROV,QFZLOOUHSDLURUUHSODFHDWLWVRSWLRQZLWKRXWFKDUJH\RXU
$7'SURGXFWLILWZDVSXUFKDVHGQHZDQGWKHSURGXFWKDVIDLOHGGXHWRDGHIHFWLQPDWHULDORUZRUNPDQVKLSZKLFK\RXH[SHULHQFHG
GXULQJQRUPDOXVHRIWKHSURGXFW7KLVOLPLWHGZDUUDQW\LV\RXUH[FOXVLYHUHPHG\
7RDFFHVVWKHEHQHILWVRIWKLVZDUUDQW\FRQWDFW\RXUVXSSOLHURUSRLQWRIVDOHGLUHFWO\<RXPD\EHDGYLVHGWRUHWXUQWKHSURGXFW
XQGHUZDUUDQW\IUHLJKWSUHSDLGWR\RXUVXSSOLHUIRUZDUUDQW\GHWHUPLQDWLRQ
,IWKLV$7'SURGXFWLVDOWHUHGDEXVHGPLVXVHGPRGLILHGRUXQGHUJRHVVHUYLFHE\DQXQDXWKRUL]HGWHFKQLFLDQ\RXUZDUUDQW\ZLOO
EHYRLG:HDUHQRWUHVSRQVLEOHIRUGDPDJHWRRUQDPHQWDOGHVLJQV\RXSODFHRQWKLV$7'SURGXFWDQGVXFKRUQDPHQWDWLRQVKRXOG
QRWFRYHUDQ\ZDUQLQJVRULQVWUXFWLRQVRUWKH\PD\YRLGWKHZDUUDQW\7KLVZDUUDQW\GRHVQRWFRYHUVFUDWFKHVVXSHUILFLDOGHQWVDQG
RWKHUDEUDVLRQVWRWKHSDLQWILQLVKWKDWRFFXUXQGHUQRUPDOXVH,WDOVRGRHVQRWFRYHUQRUPDOZHDULWHPVVXFKDVEXWQRWOLPLWHGWR
EUXVKHVEDWWHULHVGULOOELWVGULOOFKXFNVSDGVRUEODGHV
6XEMHFWWRWKHODZLQ\RXUVWDWH
<RXUVROHDQGH[FOXVLYHUHPHG\LVUHSDLURUUHSODFHPHQWRIWKHGHIHFWLYHSURGXFWDVGHVFULEHGDERYH
$7'LVQRWOLDEOHIRUDQ\LQFLGHQWDOGDPDJHVLQFOXGLQJEXWQRWOLPLWHGWRORVWSURILWVDQGXQIRUHVHHDEOHFRQVHTXHQFHV
7KHUHSDLUDQGUHSODFHPHQWRIWKLVSURGXFWXQGHUWKHH[SUHVVOLPLWHGZDUUDQW\GHVFULEHGDERYHLV\RXUH[FOXVLYHUHPHG\DQGLV
SURYLGHGLQOLHXRIDOORWKHUZDUUDQWLHVH[SUHVVRULPSOLHG$OORWKHUZDUUDQWLHVLQFOXGLQJLPSOLHGZDUUDQWLHVDQGZDUUDQWLHVRI
PHUFKDQWDELOLW\RUILWQHVVIRUDSDUWLFXODUSXUSRVHDUHGLVFODLPHGDQGLIGLVFODLPHULVSURKLELWHGWKHVHZDUUDQWLHVDUHOLPLWHGWR
RQH\HDUIURP\RXUGDWHRISXUFKDVHRIWKLVSURGXFW
Some states’ laws do not allow limited durations on certain implied warranties and some states’ laws do not allow limitations on
LQFLGHQWDORUFRQVHTXHQWLDOGDPDJHV<RXVKRXOGFRQVXOWWKHODZLQ\RXUVWDWHWRGHWHUPLQHKRZ\RXUULJKWVPD\YDU\
>$IIL[UHFHLSWRULQYRLFHKHUHIRUVDIHNHHSLQJ@