Black Box AVX-DVI-TP-100M User manual

Order toll-free in the U.S.: Call 877-877-BBOX (outside U.S.
call 724-746-5500) • FREE technical support 24 hours a day, 7 days
a week: Call 724-746-5500 or fax [phone] • Mailing address:
Black Box Corporation, 1000 Park Drive, Lawrence, PA 15055-1018
Web site: www.blackbox.com • E-mail: [e-mail]
Customer
Support
Information
BL A C K B O X®
Extends your PC DVI transmission distance up to
330 feet (100 m).
Includes two compact units: transmitter and receiver.
Extended Range DVI-D Extender with Audio and RS-232
AVX-DVI-TP-100M

724-746-5500 | blackbox.com
Page 2
Trademarks Used in this Manual
Trademarks Used in this Manual
Black Box and the Double Diamond logo are registered trademarks
of BB Technologies, Inc.
UL is a registered trademark of Underwriters Laboratories.
Any other trademarks mentioned in this manual are acknowledged
to be the property of the trademark owners.

724-746-5500 | blackbox.com Page 3
FCC and IC RFI Statements/NOM Statement
FEDERAL COMMUNICATIONS COMMISSION AND INDUSTRY
CANADA RADIO FREQUENCY INTERFERENCE STATEMENTS
This equipment generates, uses, and can radiate radio-frequency energy,
and if not installed and used properly, that is, in strict accordance with the
manufacturer’s instructions, may cause interference to radio communication.
It has been tested and found to comply with the limits for a Class A computing
device in accordance with the specifications in Subpart B of Part 15 of FCC rules,
which are designed to provide reasonable protection against such interference
when the equipment is operated in a commercial environment. Operation of this
equipment in a residential area is likely to cause interference, in which case the
user at his own expense will be required to take whatever measures may be nec-
essary to correct the interference.
Changes or modifications not expressly approved by the party responsible
for compliance could void the user’s authority to operate the equipment.
This digital apparatus does not exceed the Class A limits for radio noise
emission from digital apparatus set out in the Radio Interference Regulation
of Industry Canada.
Le présent appareil numérique n’émet pas de bruits radioélectriques dépassant
les limites applicables aux appareils numériques de classe A prescrites dans le
Règlement sur le brouillage radioélectrique publié par Industrie Canada.
Normas Oficiales Mexicanas (NOM)
Electrical Safety Statement
INSTRUCCIONES DE SEGURIDAD
1. Todas las instrucciones de seguridad y operación deberán ser leídas antes
de que el aparato eléctrico sea operado.
2. Las instrucciones de seguridad y operación deberán ser guardadas para
referencia futura.
3. Todas las advertencias en el aparato eléctrico y en sus instrucciones de
operación deben ser respetadas.
4. Todas las instrucciones de operación y uso deben ser seguidas.

724-746-5500 | blackbox.com
Page 4
NOM Statement
5. El aparato eléctrico no deberá ser usado cerca del agua—por ejemplo,
cerca de la tina de baño, lavabo, sótano mojado o cerca de una alberca,
etc.
6. El aparato eléctrico debe ser usado únicamente con carritos o pedestales
que sean recomendados por el fabricante.
7. El aparato eléctrico debe ser montado a la pared o al techo sólo como sea
recomendado por el fabricante.
8. Servicio—El usuario no debe intentar dar servicio al equipo eléctrico más
allá a lo descrito en las instrucciones de operación. Todo otro servicio
deberá ser referido a personal de servicio calificado.
9. El aparato eléctrico debe ser situado de tal manera que su posición no
interfiera su uso. La colocación del aparato eléctrico sobre una cama, sofá,
alfombra o superficie similar puede bloquea la ventilación, no se debe
colocar en libreros o gabinetes que impidan el flujo de aire por los orificios
de ventilación.
10. El equipo eléctrico deber ser situado fuera del alcance de fuentes de calor
como radiadores, registros de calor, estufas u otros aparatos (incluyendo
amplificadores) que producen calor.
11. El aparato eléctrico deberá ser connectado a una fuente de poder sólo
del tipo descrito en el instructivo de operación, o como se indique en el
aparato.
12. Precaución debe ser tomada de tal manera que la tierra fisica y la
polarización del equipo no sea eliminada.
13. Los cables de la fuente de poder deben ser guiados de tal manera que no
sean pisados ni pellizcados por objetos colocados sobre o contra ellos,
poniendo particular atención a los contactos y receptáculos donde salen
del aparato.
14. El equipo eléctrico debe ser limpiado únicamente de acuerdo a las
recomendaciones del fabricante.
15. En caso de existir, una antena externa deberá ser localizada lejos de las
lineas de energia.
16. El cable de corriente deberá ser desconectado del cuando el equipo no
sea usado por un largo periodo de tiempo.
17. Cuidado debe ser tomado de tal manera que objectos liquidos no sean
derramados sobre la cubierta u orificios de ventilación.

724-746-5500 | blackbox.com Page 5
NOM Statement
18. Servicio por personal calificado deberá ser provisto cuando:
A: El cable de poder o el contacto ha sido dañado; u
B: Objectos han caído o líquido ha sido derramado dentro del aparato; o
C: El aparato ha sido expuesto a la lluvia; o
D: El aparato parece no operar normalmente o muestra un cambio en su
desempeño; o
E: El aparato ha sido tirado o su cubierta ha sido dañada.

724-746-5500 | blackbox.com
Page 6
Safety Instructions
Safety Instructions
The Extended Range DVI-D Extender has been tested for conformance to safety
regulations and requirements, and has been certified for international use.
However, like all electronic equipment, the extender should be used with care.
Please read and follow the safety instructions to protect yourself from possible
injury and to minimize the risk of damage to the unit.
• Follow all instructions and warnings marked on this unit.
• Do not attempt to service this unit yourself, except where explained in this
manual.
• Provide proper ventilation and air circulation and do not use near water.
• Keep objects that might damage the device away from it and be sure to place
this unit on a stable surface.
• Use only the power adapter and power cords and connection cables designed
for this unit.
• Do not use liquid or aerosol cleaners to clean this unit. Always unplug the
power to the device before cleaning.

724-746-5500 | blackbox.com Page 7
Table of Contents
Table of Contents
1. Specifications ................................................................................................8
2. Overview ..............................................................................................10
2.1 Introduction......................................................................................10
2.2 Features ............................................................................................10
2.3 What’s Included................................................................................10
2.4 Hardware Description....................................................................... 11
2.4.1 Transmitter............................................................................ 11
2.4.2 Receiver.................................................................................13
3. Hardware Installation .................................................................................15
4. Cable ..............................................................................................16
Appendix. Troubeshooting...............................................................................17
A.1 Contacting Black Box........................................................................17
A.2 Shipping and Packaging ...................................................................17

724-746-5500 | blackbox.com
Page 8
Chapter 1: Specifications
1. Specifications
Audio Support — Stereo 2-channel analog audio
Approvals — Converter Unit: FCC, CE, RoHS, WEEE
Power Supply: UL®, FCC
Compliance — HDMI, DVI 1.1, HDCP
Computer Interface — DVI-D
ESD Protection — Human body model: ±19 kV (air-gap discharge) and ±12 kV
(contact discharge);
Core chipset: ±8 kV
Equalization — Automatic
Heat Dissipation — 3.41 BTU/hr.
Input DDC Signal — 5 volts p-p, TTL
Input TMDS Signal — 1.2 volts p-p
Input TMDS Signal — 1.2 volts p-p
Maximum Distance between TX and RX — 328 ft. (100 m) using
CAT5e/CAT6/CAT7 cable
Operating System Support — All known operating systems, all known
hardware that supports/follows the HDMI/DVI spec
Rackmount Kits — Wallmount brackets and hardware included
RS-232 Support — Transmitter: Acts as DCE device;
Receiver: Acts as DTE device;
RX and TX: additional control signals not supported
Video Bandwidth — 340 MHz (10.2 Gbps)
Video Support — 480p/720p/1080p60/1920x1200 @ 60 Hz/
1600 x 1200 @60 Hz
Connectors — Transmitter: (1) DVI F input, (1) 3.5-mm audio input, (1) 2.5-mm
barrel connector for power, (1) RJ-45 8P8C output, (1) RS-232 DB9 F for
serial extension;
Receiver: (1) DVI F output, (1) 3.5-mm audio output, (1) 2.5-mm barrel
connector for power, (1) RJ-45 8P8C input, (1) RS-232 DB9 M for serial
extension
Indicators — (2) LEDs on both the transmitter and receiver: Power, Link
Temperature Tolerance — Operating: 32 to 104° F (0 to 40° C)
Operating Humidity — 90%, noncondensing

724-746-5500 | blackbox.com Page 9
Chapter 1: Specifications
Power — Source: Desktop power supply; Power supply cord length: 4 ft.
(12.8 m);
For both the transmitter and receiver: AC input: 100–240 VAC, 50–60 Hz,
0.8 A,
Consumption: 20 W;
Output: 5 VDC, 4 A
Size — Each unit: 1.3"H x 4.1"W x 3"D (3.2 x 10.5 x 7.6 cm)
Weight — Each unit: 0.9 lb. (0.4 kg)

724-746-5500 | blackbox.com
Page 10
Chapter 2: Overview
2. Overview
2.1 Introduction
The Extended Range DVI-D Extender extends your PC DVI transmission distance
up to 330 ft. (100 m) at up to 1920 x 1200 or 1080p resolution. With the
extender, users can transmit high quality digital video from PC applications over
one inexpensive CAT5e/6/7 LAN cable to a remote monitor or projector, instead
of using short and expensive DVI cables. You can disconnect the monitor, place
it in a remote location, and reconnect it without rebooting the operating sys-
tem. The XR DVI Extender also supports serial port RS-232 (TXD and RXD)
control.
The extender includes two compact units: a transmitter and a receiver. The
transmitter unit connects to your PC DVI output and serial port, such as COM1,
and the receiver unit connects to a monitor with serial control (such as touch
panels). While successfully connected, the two LED lights on the RJ-45 connec-
tor will blink.
2.2 Features
• Complies with DVI 1.0 standard.
• Supports EDID and HDCP bypass.
• Extends the transmission length from the sources up to 330 ft. (100 m) at
1920 x 1200 or 1080p resolutions.
• Features auto equalization.
• Supports HDTV resolutions and VESA standards.
• Supports serial port RS-232 (TXD and RXD) control.
• Direct plug-in at TX and wall-mounting with screws at RX.
2.3 What’s Included
Your package should contain the following items. If anything is missing or
damaged, contact Black Box Technical Support at 724-746-5500 or
[e-mail].
• (1) DVI Transmitter with built-in wallmount brackets
• (1) DVI Receiver with built-in wallmount brackets
• (2) 5-VDC, 4-A power supplies with power cords
• (4) screws
• This user manual

724-746-5500 | blackbox.com Page 11
Chapter 2: Overview
2.4 Hardware Description
2.4.1 Transmitter
Figures 2-1 and 2-2 show the front and back panels of the Transmitter. Table 2-1
describes its components.
1 2 3 4
Figure 2-1. Transmitter’s front panel.
5 6 7
Figure 2-2. Transmitter’s back panel.

724-746-5500 | blackbox.com
Page 12
Chapter 2: Overview
Table 2-1. Transmitter’s components.
Number Component Description
1Barrel connector Links to 5-VDC power supply.
2Power LED Lights when the unit is receiving power.
3 DVI-D input Connect to a DVI source with a DVI
female-to-male cable.
4 Audio input Connect to audio input.
5RS-232 input Connect to a PC’s serial port with a DB9
female-to-male cable.
6RJ-45 connector Plug a CAT5/5e/6 cable in that needs to
be linked to the receiver.
7Link LED Data is being transmitted.

724-746-5500 | blackbox.com Page 13
Chapter 2: Overview
2.4.2 Receiver
FIgures 2-3 and 2-4 show the front and back panels of the receiver unit. Table
2-2 describes its components.
8 9 10 11
Figure 2-3. Receiver’s front panel.
12 13 14
Figure 2-4. Receiver’s back panel.

724-746-5500 | blackbox.com
Page 14
Chapter 2: Overview
Table 2-2. Receiver’s components.
Number Component Description
8Barrel connector Links to 5-VDC power supply.
9Power LED Lights when the unit is receiving power.
10 DVI-D output Connect to a DVI display with a DVI
male-to-male cable.
11 Audio output Connect to audio output.
12 RS-232 output Connect to an RS-232 enabled device or
touch panel with serial port control.
13 RJ-45 connector Plug a CAT5/5e/6 cable in that needs to
be linked to the transmitter.
14 Link LED Data is being received.

724-746-5500 | blackbox.com Page 15
Chapter 3: Hardware Installation
3. Hardware Installation
1. Connect the transmitter to your DVI source (PC).
2. Connect the transmitter to your serial controlled device.
3. Connect the receiver to the remote DVI monitor.
4. Connect the receiver to the serial control device or monitor.
5. Make sure your CAT5/5e/6 cable is tightly connected and not loose.
6. High quality PC video displays on the screen.
PC
DVI cable
CAT5/5e/6
cable
DVI cable
Flat panel
display
XR Extender
Transmitter
(AVX-DVI-TP-100M)
XR Extender
Receiver
(AVX-DVI-TP-100M)
Audio
cable
Speakers
Audio
cable
Figure 3-1. Connection diagram.

724-746-5500 | blackbox.com
Page 16
Chapter 4: Cable
4. Cable
1. The transmission length is largely affected by the type of LAN cables, the type
of HDMI sources, and the type of HDMI display. The testing result shows solid
LAN cables (usually bulk cable (100 ft. [300 m]) can transmit a lot longer sig-
nals than stranded LAN cables (usually in patch cord form). Shielded STP
cables are better suited than unshielded UTP cables. For long extension users,
choose solid core LAN cables.
2. We recommend using EIA/TIA-568-B termination (T568B) for LAN cables for
better performance.
3. To reduce the interference among the unshielded twisted pairs of wires in
LAN cable, you can use shielded LAN cables to improve EMI problems, which
are worse in long transmissions.

724-746-5500 | blackbox.com Page 17
Appendix: Troubleshooting
Appendix. Troubleshooting
A.1 Contacting Black Box
If you determine that your extender is malfunctioning, do not attempt to alter or
repair the unit. It contains no user-serviceable parts. Contact Black Box Technical
Support at 724-746-5500 or [e-mail].
Before you do, make a record of the history of the problem. We will be able to
provide more efficient and accurate assistance if you have a complete
description, including:
• the nature and duration of the problem.
• when the problem occurs.
• the components involved in the problem.
• any particular application that, when used, appears to create the problem or
make it worse.
A.2 Shipping and Packaging
If you need to transport or ship your extender:
• Package it carefully. We recommend that you use the original container.
• If you are returning the unit, make sure you include everything you received
with it. Before you ship for return or repair, contact Black Box to get a Return
Authorization (RA) number.

724-746-5500 | blackbox.com
Page 18
NOTES

724-746-5500 | blackbox.com Page 19
NOTES

Chapter
724-746-5500 | blackbox.com
About Black Box
Black Box provides an extensive range of networking and infrastructure
products. You’ll find everything from cabinets and racks and power and surge
protection products to media converters and Ethernet switches all supported
by free, live 24/7 Tech support available in 30 seconds or less.
© Copyright 2012. Black Box Corporation. All rights reserved.
BL A C K B O X®
Great tech support is just 30 seconds away
at 724-746-5500 or blackbox.com.
Black Box Tech Support: FREE! Live. 24/7.
Tech support the
way it should be.
AVX-DVI-TP-100M, version 2