Club Car TURF 2 XRT User manual

2001
Owner’s
Manual
Turf 2 XRT
Gasoline
Vehicles
Europe

2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 1
NOTICE
The Transportation and Utility Vehicle Limited Warranty appears on the last pages of this manual. No other
warranties, express or implied, are contained herein.
Club Car is not liable for errors in this manual or for incidental or consequential damages that result from the
use of the material in this manual.
This manual contains proprietary information that is protected by copyright. All rights are reserved.No part of
this manual may be photocopied, reproduced, or translated to another language without the written consent
of Club Car, Inc.
The information contained in this document is subject to change without notice.
Club Car reserves the right to make design changes to vehicles without obligation to make these changes on
units previously sold.
These vehicles do not conform to Federal Motor Vehicle Safety Standards for automobiles or to FMVSS 500
for low-speed vehicles, and are not equipped for operation on public streets, roads, or highways.
P.O. Box 204658
Augusta, Georgia 30917-4658 USA
Telephone: [phone]
www.clubcar.com
©2000 Club Car, Inc.
Club Car and ArmorFlex are
registered trademarks of Club Car, Inc.
This manual effective December 1, 2000

2 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual

2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 3
FOREWORD
Thank you for choosing Club Car.You have chosen the finest utility vehicle on the market; the vehicle most
widely recognized as the industry leader in vehicle efficiency and long-lasting value. Please protect your
investment and ensure that your Club Car vehicle provides years of reliable, superior performance by reading
and following the maintenance instructions in this manual.
Your comfort and safety are important to us, so we urge you to read and follow the step-by-step operating
instructions and safety procedures in this manual. These instructions must be followed in order to avoid the
risk of severe personal injury. If you rent or loan your vehicle to others, we recommend that you ask them to
read this manual before they operate the vehicle.
Club Car products are backed by a customer support system designed to offer you fast, courteous service. In
the event that your Club Car vehicle needs repairs or service, we recommend that your local authorized Club
Car representative perform them. For the name and address of the Club Car representative nearest you, logon
to our web site at www.clubcar.com or call 1-800-ClubCar (258-2227) or 1-706-863-3000.If you would prefer to
write to us, direct your letter to: Club Car, Attention: Marketing Services, P.O. Box 204658, Augusta, Georgia
30917-4658, USA.Your local authorized Club Car representative can also provide technical advice, parts, and
service manuals.
We hope you will consider this owner’s manual a permanent part of your Club Car vehicle. If you sell the
vehicle, please include the manual so that the next owner will have the important operating, safety, and main-
tenance information it contains.

4 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
Safety signs like you see above may at first seem shocking, but their impact is mild
compared with the reality of severe personal injury.
Your safety and satisfaction are of the utmost importance to Club Car. That is why
before operating the vehicle, we urge you to review the information in this manual.
Understand and become familiar with the DANGER, WARNING and CAUTION state-
ments and procedures it contains, along with the safety decals that are affixed to
your vehicle.
Take time to understand the language of safety. It is a language that can save your life.
!WARNING
Rotating Parts
Practice Safety

2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 5
TABLE OF CONTENTS
General Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Vehicle Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Accessories. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Model Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety Details . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Vehicle Feature Identification. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Controls and Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Pre-Operation and Daily Safety Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Driving Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Bed Latch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Prop Rod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Loading and Unloading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Towing with the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Transporting on a Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Periodic Service Schedule. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Periodic Lubrication Schedule. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Fueling Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Cleaning the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Subsequent Owner Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Rear Fender Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Wheel and Tire Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Warranties . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

General Information
6 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
GENERAL INFORMATION
The Turf 2 XRT is a utility vehicle especially designed for off-road transportation of cargo and passengers. Its
construction allows for operation on extremely rough terrain on inclines not exceeding 20%. The vehicle is
not intended for use on public streets, roads, or highways or for operation in flammable or explosive atmo-
spheres.The following table provides a complete listing of vehicle specifications and capacities.
Throughout this manual, important vehicle information and features are highlighted.We urge the owner/oper-
ator to read and understand this manual.
VEHICLE SPECIFICATIONS
SPECIFICATIONS
Turf 2 XRT
POWER SOURCE
Engine: 4-cycle OHV, 351 cc, 11 hp rated, single-cylinder, air-cooled, with pressure lubrication system •
Fuel system: Side-draft carburetor with float bowl, fixed jets, fuel filters, and impulse fuel pump •
Governor: Automatic ground-speed sensing, internally geared in unitized transaxle •
Ignition: Transistor electronic ignition with electronic RPM limiter •
Unitized transaxle: Fully synchronized forward and reverse with neutral (11.8:1 forward, 17.1:1 reverse) •
Electrical system: 12 volt, 500 cca at –17.8 °C (0 °F), 650 at 0 °C (32 °F).105-minute reserve capacity and 35-amp
charging capacity
•
Torque converter: Automatic, variable-speed, dry type •
STEERING/SUSPENSION/BRAKES
Steering: Self-adjusting rack and pinion •
Suspension: Front and rear multi-leaf springs with dual hydraulic shocks •
Brakes: Mechanical brake cable system to manually adjusted drum brakes on each wheel with
separate hand-operated park brake;self-adjusting multi-latch ratchet and pawl •
BODY CHASSIS
Frame/Chassis: Twin I-Beam welded aluminum •
Side and rear body: All aluminum •
Front body: ArmorFlex
®
•
Front body finish: Matched paint finish over molded-in color •
Tires: Heavy Duty All-Terrain: tubeless, 6-ply rated
Turf: tubeless, 4-ply rated 22 x 11.00 x 10 in. 23 x 10.50 x 12 in.
DIMENSIONS/WEIGHT
Overall length 305 cm (120.4 in.)
Overall width 130 cm (51.3 in.)
Overall height (at steering wheel) 129 cm (51.1 in.)
Overall height (at light bar) 191 cm (75.3 in.)
Wheelbase 199 cm (78.5 in.)
Ground clearance (under differential) 16 cm (6.4 in.)
Front wheel tread 92 cm (36.5 in.)
Rear wheel tread 104 cm (41.3 in.)
Weight ( standard vehicle with all-terrain tires;dry) 413.6 kg (910 lb.)
Forward speed 24-27 km/h (15-17 mph)
Governed RPM 2900 ± 30
Curb clearance circle (diameter) 660 cm (21 ft.-8 in.)
Turning radius (per SAE J 695) 330 cm (130 in.)
Load bed height 75 cm (29.8 in.)
Load bed size (box bed inside dimensions) 124 x 126 x 28 cm (48.8 x 49.8 x 10.9 in.)
(15.3 cubic feet)

Accessories
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 7
ACCESSORIES
There is a complete line of accessory equipment available from Club Car and our dealers. Care should be
taken that these accessories are properly installed by trained technicians, and that they are used in the man-
ner for which they were designed. See following WARNING.
∆ WARNING
•Custom cab assemblies, canopy tops, weatherproof enclosures, and windshields will NOT
protect occupants from flying objects.
•If the vehicle is equipped with an electric powered or hydraulic bed lift, remove the bed before
servicing the bed lift system.
ACCESSORY EQUIPMENT
• Light bar with 2 halogen work lights
• Nerf bars
• Turf tires
• White canopy top
• Windshield: one-piece or fold-down, tinted high-impact modified acrylic (requires canopy top)
• Cab
• Comfort cab heater
• 3-Sided enclosure: white or gray (requires canopy top)
• Electric lift or hydraulic dump
DIMENSIONS/WEIGHT, CONTINUED
Floorboard height 40 cm (16.0 in.)
Maximum vehicle capacity (passengers, cargo load, and gross trailer weight – level surface only) 409 kg (900 lb.)
Maximum payload capacity (cargo load and gross trailer weight – level surface only) 227 kg (500 lb.)
Maximum vehicle gross weight (fully loaded, accessories included) 861 kg (1900 lb.)
Standard seating capacity 2
Seat height (at seat bottom) 71 cm (28.0 in.)
CLIMATIC EXTREMES
Operating temperature range –20 to 40 °C (4 to 104 °F)
LIQUID CAPACITIES
Engine crankcase without filter .95 L (32 oz.)
Engine crankcase with filter 1.12 L (38 oz.)
Unitized transaxle: 80-90 WT. API Class GL-3 or 80-90 WT. AGMA Class EP Gear Lube .8 L (27 oz.)
Gasoline tank (unleaded gasoline only) 26.5 L (7 gal.)
TIRE PRESSURE
All-terrain tread .96-1.24 Bars (14-18 psi)
Turf tread 1.24-1.38 Bars (18-20 psi)
SPECIFICATIONS
Turf 2 XRT

Vehicle Feature Identification
8 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
• Glove box with lock
• Pintle hitch
• Aluminum tool box
• Bed mat
• Exhaust spark arrestor
• Taillights
• Turn signals
MODEL IDENTIFICATION
The serial number of each Club Car vehicle is printed on a bar code decal (1) mounted on the frame directly
above the accelerator pedal (Example: XG0101-123456) (Figure 1, Page 8) . There is also a second serial
number decal mounted on the front body frame behind the center dash panel.The center dash panel must
be removed to view this decal. See following NOTE.
NOTE: Always have the vehicle serial number at hand when ordering parts or making inquiries.
SAFETY SYMBOLS
∆
Safety alert
Reverse (Forward/Reverse handle)
Forward (Forward/Reverse handle)
Neutral (Forward/Reverse handle)
Horn
Light switch
Front of vehicle (illustration reference only)
Figure 1 Serial Number Decal
Club
GO
GO
SERIAL NUMBER
XG0101-123456
P O BOX 204658
AUGUSTA GA 30917
Club Car R
This vehicle is covered by one or more of the
following U.S. Patents as applicable: D271008
D292899, 4343503, 4539162, 4637270, 4821827
4826467, 5042519, 5083736 and other
patents pendings.
1

Safety Details
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 9
SAFETY DETAILS
∆ WARNING
•This owner’s manual should be read completely before attempting to drive or service the
vehicle. Failure to follow the instructions in this manual could result in property damage,
severe personal injury, or death.
It is important to note that some vital statements throughout this manual and on the decals affixed to the
vehicle are preceded by the words DANGER, WARNING, CAUTION, or NOTE. For your protection, we rec-
ommend that you take special notice of these safety precautions. Safety precautions are essential and must
be followed.
If any of the operation or warning decals on the vehicle become damaged, have been removed, or cannot be
easily read, they should be replaced immediately to avoid possible property damage, personal injury, or
death. Contact your Club Car dealer.
∆ DANGER
• A DANGER indicates an immediate hazard that will result in severe personal injury or death.
∆ WARNING
•AWARNING indicates an immediate hazard that could result in severe personal injury or death.
∆ CAUTION
• A CAUTION indicates hazards or unsafe practices that could result in minor personal injury or
product or property damage
.
The safety precautions listed must be followed whenever the vehicle is being operated, repaired, or serviced.
Vehicle feature identification information is also included on pages 16 and 17.
The following pages contain DANGER/WARNING/CAUTION statements for operation and maintenance for
this vehicle. Other warnings for specific procedures appear throughout this manual and on the vehicle.
Descriptions of vehicle features and operating instructions follow these warning statements.
DRIVING INSTRUCTIONWARNINGS
The following warnings should be observed when driving the vehicle. See page 23 for complete driving
instructions.
∆ DANGER
• Do not operate vehicle in enclosed area without proper ventilation. The engine produces
carbon monoxide, which is an odorless, deadly poison.
• A utility vehicle will not provide protection from lightning, flying objects, or other storm-
related hazards. If caught in a storm while driving a utility vehicle, exit the vehicle and seek
shelter in accordance with applicable safety guidelines for your location.

Driving Instruction Warnings
10 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
∆ WARNING
•Only licensed drivers should be allowed to drive this vehicle.
•Before allowing the vehicle to be driven, make sure the driver is familiar with all controls and
operating procedures.
•No one under the age of 16 years should be allowed to drive the vehicle.
•No more than two people should be on the vehicle at one time.
•Do not leave children unattended on vehicle.
•Do not allow riders in the cargo bed.
•The vehicle is not specially equipped for handicapped persons:
- Be sure all passengers are capable of securing themselves in a moving Club Car vehicle
before allowing them to ride in one.
- Be sure all persons can properly operate the vehicle prior to allowing them to drive the vehicle.
•For night use, the vehicle must be equipped with headlights, taillights, and reflectors.
•To avoid being struck, do not stand in front of or behind the vehicle.
•Operate the vehicle from the driver seat only.
•To prevent falls from the vehicle, remain seated and hold on to armrest at all times. Driver
should keep both hands on the steering wheel when the vehicle is in motion.
•To prevent the possibility of serious injury, keep entire body inside the vehicle.
•To stop the vehicle, release the accelerator pedal, then depress the brake pedal firmly. To
avoid unintentionally starting or rolling the vehicle, or when leaving the vehicle:
- Set the park brake.
- Place the Forward/Reverse handle in NEUTRAL.
- Turn the key switch to OFF and remove the key.
•Stop the vehicle before shifting the Forward/Reverse handle. Failure to do so may result in
injury to inattentive passengers and (or) damage to the vehicle.
•To prevent overturning the vehicle, drive slowly around turns.
•To prevent overturning the vehicle, drive slowly straight up and down slopes, never across
them. Avoid driving the vehicle on slopes exceeding 20% incline.
•To avoid possible injury to inattentive passengers and (or) damage to the vehicle, avoid
sudden starts, sudden stops, and abrupt turns.
•To avoid the possibility of losing control of or overturning the vehicle, reduce speed for
adverse driving conditions such as wet grass or rough terrain.
•Do not use the vehicle on public roads. It is neither designed nor intended for street use and
should not be licensed for use on public roads.
•The vehicle should be driven by trained drivers in specified areas only.
•Do not drive while under the influence of alcohol, drugs, or medications.

Loading and Unloading Warnings
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 11
•Use brakes to reduce speed when coasting downhill.
•Improper use of the vehicle or failure to properly maintain it could result in decreased vehicle
performance or severe personal injury.
•Never attempt jumps.
LOADING AND UNLOADINGWARNINGS
The following warnings should be observed when loading and unloading the vehicle. See page 26 for com-
plete loading and unloading instructions.
∆ WARNING
•Follow all procedures listed in this manual for loading and unloading the vehicle.
•Firmly engage the park brake before loading the vehicle.
•Do not allow riders in the cargo bed.
•Do not exceed the maximum vehicle capacity. Rated capacity is for level surfaces only.
•Overloading can affect vehicle handling or cause component failure, resulting in loss of
control of vehicle and possible severe personal injury.
•Reduce vehicle load and speed when driving up or down slopes or on uneven terrain.
•Reduce speed and avoid sudden stops when backing up. Failure to do so may cause the
vehicle to overturn or flip over backwards.
•Do not load the tailgate. The tailgate should be in the upright position and latched securely
while the vehicle is in motion.
•To avoid shifting the vehicle load and possibly overturning the vehicle, avoid sudden starts,
sudden stops, and abrupt turns. The cargo’s center of gravity may affect the handling,
steering, and braking of the vehicle.
•To prevent cargo from shifting and possibly injuring a passenger or affecting the vehicle’s
handling, cargo should be evenly spread over the floor of the cargo bed as far forward as
possible and well secured.
•Avoid stopping on a hill when loaded. If you must stop on a hill, avoid sudden starts, or rolling
backwards and stopping suddenly. Failure to heed this warning may cause vehicle to
overturn, possibly resulting in severe personal injury.
•Exercise caution when operating in high winds; vehicle can become unstable under certain
loading conditions.
•Avoid top-heavy loads.The center of gravity of a load should never exceed 38 cm (15 inches)
above the bottom of the cargo bed.
•Always unload cargo bed before raising vehicle with a lift, hoist, or jack.

Towing Warnings
12 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
TOWING WARNINGS
The following warnings should be observed when towing the vehicle. See page 26 for complete towing
instructions.
∆ WARNING
•Never tow a vehicle or trailer on public streets or highways.
•Normal vehicle operating speed should be reduced when towing.
•Extreme caution should be used when towing.
•Do not exceed the maximum vehicle capacity. Rated capacity is for level surfaces only.
•Do not allow riders in the vehicle or trailer being towed.
•Avoid sudden starts, sudden stops, and tight turns when towing.
•Avoid stopping on a hill when towing. If you must stop on a hill, avoid sudden starts, or rolling
backwards and stopping suddenly. Failure to heed this warning could cause vehicle to
overturn, possibly resulting in severe personal injury.
TRANSPORTING ON ATRAILER WARNINGS
The following warnings should be observed when transporting the vehicle on a trailer. See page 26 for com-
plete transportation instructions.
∆ WARNING
•Turn fuel shut-off valve to closed (OFF) position (Figure 13, Page 27).
•Do not allow riders in the trailer being towed.
•Avoid sudden starts, sudden stops, and tight turns when transporting a vehicle on a trailer.
•For use on public roads, the trailer must meet all governmental requirements such as
taillights, brake lights, etc.
•Reduce normal driving speed when transporting a vehicle on a trailer.
•Never tow a Club Car vehicle behind a passenger vehicle or truck on a public road unless it is
on an approved trailer.
•The vehicle to be transported should be tied securely to the trailer, with the park brake firmly
engaged, the Forward/Reverse handle in NEUTRAL, and the key switch OFF.
•Because of the added length of the trailer, use caution when making turns.
•Never transport the vehicle on a trailer with a load in the vehicle cargo bed.
•Remove the vehicle windshield before transporting on a trailer.

Storage Warnings
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 13
STORAGEWARNINGS
The following warnings should be observed when preparing a vehicle for storage. See page 26 for complete
instructions for vehicle storage.
∆ DANGER
• Never attempt to drain gasoline when the engine is hot or while it is running.
• Be sure to clean up any spilled gasoline before operating the vehicle.
• Store gasoline in an approved gasoline container only. Store in a well-ventilated area away
from sparks, open flames, heaters, or heat sources.
• Keep gasoline out of the reach of children.
• Do not siphon gasoline from the vehicle.
∆ WARNING
•Turn the key switch OFF, remove the key, and leave the Forward/Reverse handle in the
NEUTRAL position during storage. This is to prevent unintentionally starting the vehicle or a
fire hazard.
•Turn fuel shut-off valve to closed (OFF) position (Figure 13, Page 27).
•Do not attempt to charge a frozen battery or a battery with a bulged case. Discard the battery.
Frozen batteries can explode.
∆ CAUTION
•Batteries in a low state of charge will freeze at low temperatures.
BATTERY WARNINGS
The following warnings should be observed when working with batteries. See page 28 for complete
instructions on handling batteries.
∆ DANGER
• Battery – Explosive gases! Do not smoke! Keep sparks and flames away from vehicle and
service area.
• Tools, wires, and metal objects can cause sparks when shorted across a battery.
• Follow all instructions carefully when working with batteries.
• Charge battery in a well-ventilated area only.
DANGER CONTINUED ON NEXT PAGE...

Maintenance Warnings
14 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
DANGER, Continued:
• Poison! Contains acid! Causes severe burns – avoid contact with skin, eyes, or clothing.
Antidotes:
- External: Flush with water for 15 minutes. Call a physician immediately.
- Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
- Eyes: Flush with water for 15 minutes. Call a physician immediately.
∆ WARNING
•Do not jump start the vehicle. To charge the battery, use an automotive-type 12-volt charger
rated at 10 amps or less.
•Wear safety glasses or approved eye protection when servicing the vehicle. Wear a full face
shield and rubber gloves when working with batteries.
•Use insulated tools when working around battery or electrical connections.
•Frame ground –Do not allow tools or other metal objects to contact frame when
disconnecting battery or other electrical wiring. Never allow a positive wire to touch the
vehicle frame, engine, or other metal component.
MAINTENANCEWARNINGS
The following warnings should be observed when preforming maintenance. See page 29 for complete
instructions for vehicle maintenance.
∆ DANGER
• Gasoline vapors – Battery vapors – Flammable! Explosive! Do not smoke. Keep sparks and
flames away from the vehicle and service area. Service only in well-ventilated areas.
∆ WARNING
•Only trained technicians should repair or service the vehicle. Anyone doing even simple
repairs or service should have knowledge and experience in electrical and mechanical repair.
•Follow the procedures exactly as stated in this manual, and heed all DANGER,WARNING, and
CAUTION statements in this manual as well as those affixed to the vehicle.
•Do not modify or change the vehicle in any way that might affect its stability or handling, or
increase maximum vehicle speed beyond factory specifications. Property damage, personal
injury, or death could result.
•Do not tamper with the governor. Doing so will void the warranty, as well as damage the
engine and other components, and could result in property damage, personal injury, or death
due to unsafe speeds.

Maintenance Warnings
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 15
•Do not wear loose clothing or jewelry, such as rings, watches, chains, etc., when servicing the
vehicle.
•When servicing the vehicle:
- Place the Forward/Reverse handle in NEUTRAL.
- Turn the key switch to OFF and remove the key.
- Chock the wheels.
- Disconnect the battery cables as shown (1), negative cable (–) first (Figure 2, Page 15).
- Disconnect the spark plug wire from the spark plug.
•Moving parts –do not attempt to service vehicle while the engine is running.
•Do not work on vehicle powertrain or under the cargo bed when it is loaded.
•Turn fuel shut-off valve to closed (OFF) position (Figure 13, Page 27).
•Hot! Do not attempt to service hot engine or exhaust system. Attempting to do so could cause
severe burns.
•If any problems are found during scheduled inspection or service, do not operate the vehicle
until repairs are made. Failure to make necessary repairs could result in fire, property
damage, severe personal injury, or death.
•Do not remove prop rod or close bed until all persons are clear of the bed area. Lower the bed
gently, keeping entire body clear. Do not drop the bed. Failure to follow these instructions
could result in severe personal injury.
•A hydraulic bed lift system is under pressure. Wear a face shield and use extreme caution
when servicing it.
Figure 2 Battery Cable Removal
1

Vehicle Feature Identification
16 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
TURF 2 XRT
•Vehicle rated capacity - 900 lbs. on level surface only.
Weight to include passengers, cargo bed load, and
gross trailer weight. See Owner's Manual.
•Maximum cargo load - 500 lbs. Weight to include cargo
bed load and gross trailer weight.
•Maximum trailer hitch tongue weight - 150 lbs.
•Cargo should be evenly spread over the floor of the
cargo bed as far forward as possible and secured.
•For vehicle stability, when fully loaded, drive slowly
and avoid stopping on or backing down steep hills.
•Avoid top heavy loads. See Owner's Manual.
•When driving on uneven terrain or down steep hills,
reduce speed and load.
VEHICLE
LOADING
Read Owner's Manual
and warnings on dash. CCI 102006701
WARNING
L
A
T
C
H
0
P
E
N
Crush area.
Can cause severe injury.
Stay clear when closing bed.
CCI 101543701
WARNING
UNDER
16 YOUNG DRIVERS INCREASE CHANCE OF DEATH
CCI 102075801
•Young drivers may not be able to control vehicle. •No drivers younger than 16 years old.
WARNING
STAY CLEAR
CRUSH AREA
CCI 101609401
Riding in cargo bed
can cause severe injury
or death.
Do not ride in cargo bed.
WARNING
CCI 101553901
OFF ON START
•Before using vehicle, read operating instructions.
•Remain seated and hold on to seat handle while moving.
•Do not start vehicle until all occupants are seated.
•Two (2) persons per seat maximum.
•Operate from driver side only and not on public roads.
•Keep entire body inside vehicle while moving.
•Drive slowly in turns and straight up and down slopes.
•Do not leave children unattended on vehicle.
•Never operate under the influence of alcohol or drugs.
•Use brakes to reduce speed when coasting downhill.
•Never stand in front of or behind vehicle. CCI 1019606-01
WARNING
ROLLOVER OR FALLING OFF MAY CAUSE DEATH.
H
O
R
N
CCI 102243201
•Read owner's manual and safety warnings located on dash panel prior to driving.
•Study and understand controls.
TO START ENGINE
•Place shift lever in –Neutral position.
•Depress brake pedal.
•Turn key switch to “START”position and release.
TO OPERATE VEHICLE
•Make sure wheels are turned in desired direction.
•Be sure nothing is in your path.
•While vehicle is stopped, select vehicle direction by
placing shift lever or switch in desired position.
–Forward –Neutral –Reverse (Buzzer will sound)
•Park brake will release when accelerator pedal is pushed.
•Slowly push accelerator pedal to increase speed.
•Accelerator pedal must be released to shift vehicle to neutral.
TO STOP VEHICLE
•Release accelerator pedal and push brake pedal.
•After stopping, firmly push park brake until it locks.
•Turn key to “OFF”position, remove key and place shift
lever in straight up neutral position when not in use.
OPERATING INSTRUCTIONS
1
2
3
4
5
6
8
9
10
11
12
13
16
15
17 14
7

Vehicle Feature Identification
2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual 17
TURF 2 XRT
TURF 2 XRT IDENTIFICATION KEY
(1) Serial number (10) Bed latch warning decal (18) Forward/Reverse handle
(2) Fuel/Hour gauge (11) Underage warning decal (19) Fuel shut-off valve
(3) Oil warning light (12) Accelerator pedal (20) Gasoline warning decal (on frame)
(4) Driver/Passenger warning decal (13) Brake pedal (21) Rotating parts and hot manifold decal (on
starter/generator and engine)
(5) Key switch (14) Park brake pedal (22) Trailer hitch decal
(6) Operating instructions decal (15) Horn (23) Bed latch
(7) Park brake handle (16) Vehicle loading decal (24) Frame ground and governor warning decal
(on frame)
(8) Crush area decal (17) Directional arrow on tire (25) Choke
(9) Bed load warning decal
KEEP CLEAR
Rotating parts
HOT
manifold & muffler
CAN CAUSE SEVERE INJURY
CCI 101960501
WARNING
• GASOLINE EXPLOSION / FIRE.
• CAN CAUSE SEVERE INJURY OR DEATH.
• NO SMOKING, SPARKS, OR OPEN FLAME.
• STOP ENGINE, ALLOW TO COOL BEFORE REFUELING.
• TURN FUEL VALVE ( ) ON DURING OPERATION.
( ) OFF DURING STORAGE OR TRANSPORT.
CCI 101547601
WARNING
CCI 101915201
Negative frame ground. Can cause severe injury.
Do not contact positive (+) battery post or cable to frame.
Disconnect negative battery lead first.
Excessive speed.
Can cause severe injury or death.
Do not tamper with engine governor adjustment.
WARNING
WARNING
MAXIMUM TONGUE
WEIGHT - 150 lbs.
CCI 1011553
NOTICE
18
19
21
22
23
24
20
25

Controls and Indicators
18 2001 Turf 2 XRT Gasoline Vehicle Owner’s Manual
CONTROLS AND INDICATORS
Read DANGER andWARNING on page 14.
KEY SWITCH
The key switch is mounted on the dash to the right of the steering column (Figure 3, Page 18). It has three
positions, OFF, ON, and START, which are clearly labeled. To start the vehicle, place the Forward/Reverse
handle in the NEUTRAL position and turn the key past the ON position to the START position and hold until
the engine is running smoothly. Release the key and it will return to the ON position and the engine should
idle.The engine will continue to idle until the key is turned to the OFF position. See following WARNING,
CAUTION, and NOTE.
∆ WARNING
•Moving parts! Keep clear of the engine compartment while the engine is running.
∆ CAUTION
•Do not “rev” the engine for long periods of time while the Forward/Reverse handle is in the NEUTRAL
position. Failure to heed this caution could result in damage to the unitized transaxle.
•Do not shift the Forward/Reverse handle while the accelerator pedal is pressed.Shift the handle only
when the vehicle is at a complete stop. Failure to heed this caution could result in damage to the
unitized transaxle.
NOTE: The key can be removed only when the key switch is in the OFF position.
FORWARD/REVERSE CONTROL
The Forward/Reverse handle is located on the seat support panel (Figure 4, Page 18).The handle has three
distinct positions: (FORWARD), (NEUTRAL), and (REVERSE). Rotate the handle to the FOR-
WARD position, towards the driver, to operate the vehicle in the forward direction. Rotate the handle to the
Figure 3 Key Switch Figure 4 Forward/Reverse Handle
•Beforeusingvehicle, readoperatinginstructions.
•Remain seatedandhold ontoseathandle while moving.
•Donotstartvehicle until all occupantsareseated.
•Two(2) personsperseatmaximum.
•Operate fromdriversideonly andnotonpublic roads.
•Keepentirebodyinsidevehicle while moving.
•Driveslowly in turnsandstraight upanddownslopes.
•Donotleavechildrenunattendedonvehicle.
•Neveroperateundertheinfluenceof alcohol ordrugs.
•Usebrakestoreducespeedwhencoastingdownhill.
•Neverstandin frontoforbehindvehicle.
CCI 1019606-01
WARNING
ROLLOVER OR FALLING OFF MAY CAUSE DEATH.
OFF ON START