Cretors Nacho Alto User manual

176 MITTEL DRIVE, WOOD DALE, IL 60191
Model Nacho Alto
Warmer and Display Cabinets Manual
120 Volt, Single Phase, 60 Hz (-A)
230 Volt, Single Phase, 50 Hz (-E)
READ and UNDERSTAND these operating and safety
instructions before operating this Cretors machine

NACHO ALTO 6 13
2
TABLE OF CONTENTS
I. Safety Alert Symbol...............................................................................................3
II. Safety First ..............................................................................................................3
III. Introduction............................................................................................................3
IV. Purpose of Manual ................................................................................................4
V. Product Identification...........................................................................................4
VI. Principles of Display Cabinet Operation ...........................................................4
VII. Control Switch .......................................................................................................4
VIII. Installation Instructions........................................................................................4
IX. Operating Instructions..........................................................................................5
X. Sanitation Instructions..........................................................................................5
XI. Service Instructions ...............................................................................................6
Troubleshooting.....................................................................................................6

NACHO ALTO 6 13
3
I. SAFETY ALERT SYMBOL
The symbol shown is used to call your attention to instructions concerning your personal safety
and the safety of others. Watch for this symbol. It points out important safety precautions. It
means ATTENTION! Become Alert! Your personal safety is involved! Read the message that
follows and be alert to the risk of personal injury or death.
II. SAFETY FIRST
The information in this manual is essential for the safe installation and
operation of your Cretors machine. The manual must be read and
understood before installing, and operating the equipment, or equivalent
training must be provided.
The employer shall instruct each employee in the recognition and avoidance
of unsafe conditions, as well as, the regulations applicable to his work
environment and to control or eliminate any hazards or other exposure to
illness or injury. Ref.: 29 CFR 1926.20 (b)(4)(a)(2)
It is understood that safety rules within individual companies vary. If a conflict
exists between the safety procedures contained in this manual and the rules of a
using company, the more stringent rule should take precedence.
III. INTRODUCTION
This manual is filled with time-saving and money-saving information regarding your Cretors
machine. There is nothing more important than the safety aids and warnings that are throughout
this document. The Safety Alert Symbol is used to identify topics of primary safety concern
wherever they appear.
If, after reviewing this manual, anything is unclear or technical problems are encountered, contact
the distributor from whom you purchased your machine for assistance. If there are any additional
questions, feel free to contact our Customer Service Department at the address and/or phone
number listed on the last page of this manual. Always have the model and serial number of your
machine available to assist in obtaining the correct information.

NACHO ALTO 6 13
4
IV. PURPOSE OF MANUAL
This instruction manual is intended to familiarize owners with the operation and safety
procedures associated with your Cretors machine.
It is important that this manual be kept available to operating personnel.
V. PRODUCT IDENTIFICATION
CRETORS POPCORN AND NACHO DISPLAY CABINET
MODEL
NAAON-X/NAECN-X –WARMER/DISPLAY CABINET
Electrical:
120 Volt, 60 Cycle, 555 Watts
230 Volt, 50 Cycle, 555 Watts
VI. PRINCIPLES OF DISPLAY CABINET OPERATION
Theory and Observations of Display Cabinet Operation
The Display/Warmer Cabinets hold nacho chips, popcorn, or other snacks to maximize the sell
ability of snacks. Load and un-load product through the large door on the unit’s front. The
unit features a corrosion-resistant design and tempered glass for easy cleaning; the surface will
not scratch or discolor. The unit’s doors are easily-removable, for cleaning. Rubber feet
prevent skidding on counter top surfaces. The cabinet is provided with forced hot air to keep
product warm and lighted cabinet and sign for enhanced merchandizing.
VII. CONTROL SWITCH
MAIN POWER SWITCH -Controls light and cabinet heat.
VIII. INSTALLATION INSTRUCTIONS
1. Location
Choose a location for your Cretors Display/Warming Cabinet to maximize the ease of
operation and maintenance procedures. Check your local building and fire codes for
location restrictions.
2. Power Supply
Check the nameplate to determine the required power supply.

NACHO ALTO 6 13
5
Connect your cabinet only to the correct power source.
Make certain the main power switch on the cabinet is in the 'OFF' position when
plugging into power source.
3. Install the racks
Install the clips in all four corners at the same height, as desired. The unit is provided with
six (6) racks and twenty-four (24) clips which can be installed to accommodate different size
packaging and for optimal merchandizing. Rack supports snap into place.
IX. OPERATING INSTRUCTIONS
Do not attempt to operate your Cretors Display Cabinet until you have read and
understood this manual. Failure to do so may result in serious injury or death.
Do not attempt to operate your Cretors machine unless the installation instructions
have been strictly adhered to. Failure to do so may result in serious injury or death.
Operate your display cabinet only if it is in sanitary condition (SANITATION
INSTRUCTIONS). Failure to do so may result in illness to your customers.
1. Turn on rocker switch to turn on light, blower and heat.
2. Load unit with product. Do not overfill the cabinet.
3. Dispense product through the front door. If machine is ordered as pass thru, the unit
can be loaded and unloaded from either side.
X. SANITATION INSTRUCTIONS
Be certain the machine is turned off and the power is unplugged before sanitizing this
machine, unless a specific cleaning procedure requires power to the machine. Failure
to do so could result in serious injury or death.
Do not clean heated surfaces until they have been given sufficient time to cool.
Failure to do so may result in serious burns or scalds.
Do not immerse the cabinet in water. This will damage the electrical components, and
may cause short circuits, resulting in an electrical shock hazard if power is applied.

NACHO ALTO 6 13
6
1. After unit has been allowed to cool and has been unplugged, remove any excess
product remaining in the bottom.
2. Clean all surfaces with a non-abrasive food safe cleaner.
This appliance should not be cleaned with a water jet.
XI. SERVICE INSTRUCTIONS
Only a qualified person should perform the following diagnostic checks, and, if
necessary, corresponding adjustments and repairs. Many of the following procedures
may present an electrical shock hazard and can cause serious injury or death.
Perform work only on de-energized circuits. Failure to do so may lead to electrical
shock resulting in personal injury or death.
A. Parts
When ordering parts, refer to the recommend spare parts list included with this manual or
wiring diagram. Always supply the serial number and model number of your machine.
B. Check Unit Periodically
Periodically check electrical switch and cord for signs of wear. Check all screws and rivets
for tightness.
C. To Access Electrical Components
To access all electrical components, unplug power cord from outlet, and then lay unit on its
side and remove the four screws from the bottom cover, exposing heating element, switch,
and wiring. THIS UNIT IS NOT FUSED.
D. Troubleshooting
PROBLEM
POSSIBLE CAUSE
ACTION
Unit will not heat.
Machine unplugged or not
switched on.
Plug unit in. Turn on power.
Loose connection to heat
element or failure.
Blower unplugged or blocked
Thermostat failed
Repair connection or replace
element
Check for any blockage and
clear
Replace thermostat

NACHO ALTO 6 13
7
This manual is filled with timesaving and money-saving information regarding your Cretors
Display Cabinet. There is nothing, however, more important than the safety aids and warnings
found throughout this document.
If you have any questions, feel free to contact our Customer Service Department at 800-840-6166.
Additional copies of this manual can be obtained from Customer Service.
Cretors warranties this machine to be free of defects in parts, materials, and workmanship for one
year. Please complete and return the registration card to activate your warranty. If you have
questions concerning the warranty, please contact Customer Service at 800-840-6166.
CUSTOMER SERVICE HOURS:
Our office hours are 8:30 a.m. to 5 p.m. (U.S. Central Time) Monday through Friday. An answering
machine is in use all other times.
SHIPPING POLICY:
We make every effort to ship approved orders on the requested ship date. If a delay in shipment is
necessary, you will be notified. Pallet quantities vary by product. Please inquire when placing
order. Most of our products are shippable by UPS.
DAMAGE OR SHORTAGE POLICY:
We recommend that you do not sign the delivery receipt until after inspecting the product(s).
Claims can be filed if a shortage is observed, but only when it has been noted on the delivery
receipt.
C. CRETORS AND COMPANY
3243 N. CALIFORNIA AVENUE
CHICAGO, IL 60618
PHONE [phone], FAX [phone]
WEB SITE: http://www.cretors.com Email: po[email protected]om
Cretors joins the information age! Check out our links http://www.twitter.com
http://www.facebook.com/pages/Chicago-IL/C-Cretors-Co/90143449620

NACHO ALTO 6 13
8
RECOMMEND SPARE PARTS LIST
PART DESCRIPTION
PART NUMBER
DOOR HINGE
16938-LH or -RH
LIGHT STRIP
18410-ASSY
DOOR
16924-L or -R
KNOB
1292
MAGNET
19122
FAN
16996-A/ -E
HEAT ELEMENT
16997-A/ -E
RACK SUPPORT CLIPS
16807
RACKS
16904
C. CRETORS AND COMPANY
176 MITTEL DRIVE
WOOD DALE, IL 60191
PHONE [phone], FAX [phone]
WEB SITE: http://www.flo-thru.com Email: [email protected]
Email: [e-mail]