Daedong KIOTI PX9530 User manual

Congratulations, and welcome to the fabulous world of PX9530 / PX1053 / PX1153 / PX1303 ownership, where serious
work is made fun again!
This versatile tractor is a culmination of the entire tractor and diesel knowledge gained by the Daedong IND. Co., LTD
over the years since 1947 and has been designed with the nest materials and under rigid quality control standards set
forth by the KIOTI Engineering Department.
Knowledge of tractor operation is essential for many years of dependable service and reliability. To help new owner's
familiarize themselves with the KIOTI PX9530 / PX1053 / PX1153 / PX1303, it is the policy of KIOTI tractor to provide
an owner's manual which includes helpful information about tractor safety, operation and maintenance. If the informa-
tion you seek is not found in this manual, your KIOTI tractor dealer will be happy to help you.
Please feel free to contact DAEDONG IND. CO.,LTD / DAEDONG-USA, INC. with your questions/concerns.
FOREWORD
Make sure to read this manual carefully and keep it handy for future reference.
When leasing or transferring this tractor, deliver this manual together with the tractor.
The specications in this manual are subject to change without notice.
< NOTE >
TG120-수출향-US-00.indd 1 2017-10-20 오후 5:57:23

This manual was compiled in compliance with the ISO 3600, standards and the instructions contained here comply with
the requirements of the Machinery Directive 2010/52/EU in force in the European Community. For tractors sold or used
outside the European Community, local laws will prevail.
Main protections on the tractors discussed in this manual.
ISO 3600 EU STANDARDS
DESCRIPTION NON CABIN CABIN
1. ROPS (Protection against overturning) Yes Yes
2. FOPS (Protection against objects falling from above) No Yes
3. OPS (Protection against penetration of objects from sides)
protection against hazardous chemicals
No
(CategoryⅠ)
No
(CategoryⅠ)
TG120-수출향-US-00.indd 2 2017-10-20 오후 5:57:23

1
2
3
4
5
6
7
8
9
10
SAFETY PRECAUTIONS ........................................
IDENTIFICATION & INTRODUCTION OF WARRANTY ......
SPECIFICATIONS....................................................
DESCRIPTION OF OPERATING SYSTEM .............
OPERATION ............................................................
3- POINT HITCH .....................................................
MAINTENANCE .......................................................
STORAGE AND DISPOSAL....................................
TROUBLESHOOTING .............................................
INDEX.......................................................................
3-POINT HITCH IMPLEMENT AND
LOADER OPERATION
SECTION
TABLE OF CONTENTS
TG120-수출향-US-00.indd 3 2017-10-20 오후 5:57:23

TABLE OF CONTENTS
SAFETY PRECAUTIONS ....................................1-1
PRECAUTIONS BEFORE OPERATION .................. 1-2
GENERAL PRECAUTIONS............................................. 1-2
PRECAUTIONS DURING OPERATION................... 1-5
WHEN STARTING THE ENGINE.................................... 1-5
WHEN DRIVING THE TRACTOR ................................... 1-8
WHEN PARKING THE TRACTOR .................................. 1-9
WHEN OPERATING THE PTO ....................................... 1-9
WHEN USING THE 3-POINT HITCH ............................ 1-10
SAFETY PRECAUTIONS DURING SERVICING ... 1-10
SAFETY PRECAUTIONS WHEN USING THE
LOADER .............................................................. 1-14
SAFETY DECAL MAINTENANCE ......................... 1-17
DECAL MOUNTING LOCATION ................................... 1-17
DECALS ........................................................................ 1-18
CAUTIONS FOR DECAL MAINTENANCE ................... 1-22
IDENTIFICATION & INTRODUCTION OF
WARRANTY ......................................................2-1
INTRODUCTION....................................................... 2-2
WARRANTY, PRE-DELIVERY INSPECTIONS AND
INSTALLATION ............................................................ 2-3
WARRANTY CLAIM ........................................................ 2-4
SPARE PARTS WARNING.............................................. 2-5
IF YOU MOVE ................................................................. 2-5
POST-WARRANTY SERVICE......................................... 2-5
SAFETY........................................................................... 2-6
VEHICLE IDENTIFICATION NUMBER..................... 2-6
TRACTOR SERIAL NUMBER ......................................... 2-6
ENGINE SERIAL NUMBER............................................. 2-6
TRANSMISSION SERIAL NUMBER ............................... 2-7
ESSENTIAL REPLACEMENT PART ....................... 2-8
OILS AND FLUIDS .......................................................... 2-8
FILTERS .......................................................................... 2-9
BELTS AND RUBBER PARTS....................................... 2-10
OTHER COMPONENTS ............................................... 2-10
SPECIFICATIONS................................................3-1
GENERAL SPECIFICATIONS .................................. 3-2
EXTERNAL DIMENSIONS .............................................. 3-2
GENERAL SPECIFICATIONS......................................... 3-3
TG120-수출향-US-00.indd 4 2017-10-20 오후 5:57:23

TABLE OF CONTENTS
HEAD LIGHT HIGH BEAM LAMP ................................. 4-15
TURN SIGNAL LAMP.................................................... 4-15
GLOW PLUG LAMP ...................................................... 4-15
PARKING BRAKE LAMP............................................... 4-16
PTO LAMP..................................................................... 4-16
4WD LAMP.................................................................... 4-16
QUICK-TURN LAMP ..................................................... 4-17
BRAKE(ONE SIDE) LAMP ............................................ 4-17
CRUISE PTO LAMP...................................................... 4-18
FORCED DeSOx WARNING LAMP.............................. 4-18
DeSOx ACTIVE LAMP................................................... 4-19
DeSOx INHIBIT LAMP................................................... 4-20
EMISSION WARNING LAMP ........................................ 4-20
LOW UREA LEVEL WARNING LAMP........................... 4-21
WATER-IN-FUEL WARNING LAMP .............................. 4-21
LOW FUEL LEVEL WARNING LAMP ........................... 4-22
OPERATING THE CONTROLS .............................. 4-23
SHUTTLE SHIFT LEVER .............................................. 4-25
MAIN SHIFT LEVER...................................................... 4-26
RANGE GEAR SHIFT LEVER....................................... 4-27
PTO CHANGE LEVER .................................................. 4-28
TRAVELING SPEED............................................... 3-11
MANUAL.........................................................................3-11
POWER SHUTTLE........................................................ 3-12
IMPLEMENT LIMITATIONS.................................... 3-14
STANDARD SIZE BY IMPLEMENT............................... 3-14
DESCRIPTION OF OPERATING SYSTEM .........4-1
EXTERIOR VIEW...................................................... 4-3
SWITCH .................................................................... 4-4
MOUNTING LOCATION .................................................. 4-4
KEY SWITCH .................................................................. 4-5
COMBINATION SWITCH ................................................ 4-6
HAZARD LAMP SWITCH ................................................ 4-8
INSTRUMENT PANEL ............................................ 4-11
TACHOMETER / HOURMETER ................................... 4-12
ECO PTO....................................................................... 4-12
FUEL GAUGE................................................................ 4-12
ENGINE COOLANT TEMPERATURE GAUGE............. 4-13
ENGINE OIL PRESSURE WARNING LAMP ................ 4-14
BATTERY CHARGING LAMP ....................................... 4-14
TG120-수출향-US-00.indd 5 2017-10-20 오후 5:57:24

PTO SELECTION LEVER ............................................. 4-29
CLUTCH PEDAL ........................................................... 4-29
BRAKE PEDAL.............................................................. 4-30
STEERING WHEEL ADJUSTMENT.............................. 4-31
PARKING BRAKE LEVER............................................. 4-31
FOOT THROTTLE......................................................... 4-32
HAND THROTTLE LEVER............................................ 4-32
PTO SWITCH ................................................................ 4-33
CALIBRATION SWITCH................................................ 4-34
CLUTCH REACTION SPEED SETTING BUTTON
(POWER SHUTTLE).................................................. 4-34
DIFFERENTIAL LOCK PEDAL (REAR) ........................ 4-34
SEAT ADJUSTMENT..................................................... 4-35
POSITION CONTROL LEVER ...................................... 4-37
DRAFT CONTROL LEVER............................................ 4-38
JOYSTICK LEVER ........................................................ 4-38
DOUBLE ACTING LEVER............................................. 4-39
EXTERNAL LIFT LEVER............................................... 4-40
CABIN SYSTEM ..................................................... 4-41
INTERIOR DEVICES..................................................... 4-41
EXTERIOR DEVICES.................................................... 4-42
ENTRANCE................................................................... 4-42
UNLOCKING THE DOOR ............................................. 4-43
REAR WINDOW............................................................ 4-43
WORKING LIGHT.......................................................... 4-44
WIPER........................................................................... 4-44
PTO CRUISE................................................................. 4-45
DeSOx SWITCH............................................................ 4-46
MODE SELECTION SWITCH ....................................... 4-48
CD PLAYER................................................................... 4-49
BLUETOOTH PLAYER/RADIO ..................................... 4-49
DEFOGGER SWITCH................................................... 4-49
ANTENNA...................................................................... 4-50
ROOM LAMP................................................................. 4-50
ACCESSORY ................................................................ 4-51
SUN VISOR (IF EQUIPPED)......................................... 4-52
SUNROOF..................................................................... 4-52
EMERGENCY HAMMER(ONLY EU MODEL)............... 4-53
HEATER AND AIR CONDITIONER ............................... 4-53
OPERATING METHODS............................................... 4-54
SYSTEM CONFIGURATION ......................................... 4-58
7-PIN POWER OUTPUT SOCKET ............................... 4-59
TIRES, WHEELS AND BALLAST .......................... 4-59
TABLE OF CONTENTS
TG120-수출향-US-00.indd 6 2017-10-20 오후 5:57:24

GENERAL TIRE INFORMATION................................... 4-59
INFLATION PRESSURE ............................................... 4-61
TREAD........................................................................... 4-62
WHEEL TORQUE AND DIRECTION............................. 4-66
ADDITIONAL WEIGHT(IF EQUIPPED)......................... 4-67
MASS(ES) AND TIRE(S) ............................................... 4-71
OPERATION ........................................................5-1
RE-OPERATION CHECK ......................................... 5-2
OPERATING THE ENGINE ...................................... 5-3
STARTING THE ENGINE................................................ 5-3
STOPPING THE ENGINE ............................................... 5-7
WARMING UP ................................................................. 5-8
JUMP STARTING ............................................................ 5-9
OPERATING THE TRACTOR................................. 5-10
HOW TO DRIVE ............................................................ 5-10
PARKING....................................................................... 5-13
TURNING ...................................................................... 5-15
DRIVING ON SLOPE .................................................... 5-15
THE CAUTIONS WHEN COMING IN AND OUT OF
WORK FIELD............................................................. 5-15
PRECAUTIONS WHILE DRIVING ON THE ROAD ...... 5-16
LOADING INTO AND UNLOADING OUT OF THE
TRUCK....................................................................... 5-17
PRECAUTIONS WHEN USING POWER STEERING .. 5-17
3-POINT HITCH CONTROL SYSTEM .......................... 5-19
REMOTE HYDRAULIC ................................................. 5-22
CONNECTING AND DISCONNECTING IMPLEMENT.... 5-24
3-POINT HITCH IMPLEMENT AND LOADER
OPERATION......................................................6-1
REMOVAL AND INSTALLATION OF 3-POINT
HITCH IMPLEMENT (WITH PTO SHAFT) ............ 6-2
OPERATION FOR 3-POINT HITCH IMPLEMENTS . 6-5
ADJUSTMENT OF LIFT ROD ......................................... 6-5
ADJUSTMENT OF TOP LINK ......................................... 6-6
PRECAUTION FOR INSTALLING HOW TO USE
TOP LINK HOLES........................................................ 6-6
ADJUSTMENT OF STABILIZER ..................................... 6-7
DISMOUNTING THE IMPLEMENT................................. 6-7
DRAFT HITCH AND TRAILER ........................................ 6-8
PTO & PTO SHIELD GUARD.......................................... 6-9
CONVERTIBLE PTO SHAFT [6 & 21-SPLINE] (IF
EQUIPPED)......................................................................6-10
TABLE OF CONTENTS
TG120-수출향-US-00.indd 7 2017-10-20 오후 5:57:24

TABLE OF CONTENTS
PRECAUTIONS WHEN USING THE PTO.....................6-11
INSTALLING PTO SHAFT............................................. 6-12
HYDRAULIC BRAKE VALVE (IF EQUIPPED) .............. 6-13
HANDLING LOADER ............................................. 6-15
FIXATION POINTS FOR FRONT END LOADER ......... 6-16
DRIVING ON SLOPE .................................................... 6-17
JOYSTICK LEVER ........................................................ 6-18
JOYSTICK VALVE ......................................................... 6-20
MAINTENANCE...................................................7-1
MAINTENANCE CHECK LIST ................................. 7-3
DAILY CHECK ITEM ....................................................... 7-3
MAINTENANCE SCHEDULE CHART............................. 7-4
LUBRICANTS ........................................................... 7-7
MAINTENANCE CODE ............................................ 7-8
HOW TO OPEN THE HOOD(A) ...................................... 7-8
CHECKING AND ADDING FUEL(C) ............................... 7-8
CHECKING TRANSMISSION FLUID LEVEL(D)............. 7-9
CHECKING ENGINE OIL LEVEL(E) ............................. 7-10
CHECKING COOLANT LEVEL(F)..................................7-11
CLEANING GRILL, RADIATOR SCREEN(G) ............... 7-12
CHECKING BRAKE PEDALS(H) .................................. 7-12
CHECKING GAUGES, METER AND EASY
CHECKER(I) .............................................................. 7-13
CHECKING HEAD LIGHT, HAZARD LIGHT ETC.(J).... 7-13
CHECKING SEAT BELT AND CABIN(K)....................... 7-13
CHANGING ENGINE OIL AND REPLACING FILTER(L)..7-13
CHECKING AND REPLENISHING UREA TANK (AT)... 7-15
REPLACING TRANSMISSION FLUID AND FILTER(M) .. 7-16
CHANGING FRONT AXLE CASE OIL(N) ..................... 7-18
ADJUSTING BRAKE PEDAL(O) ................................... 7-18
BLEEDING BRAKE FLUID LINE................................... 7-20
LUBRICATING GREASE LOCATIONS(P) .................... 7-21
CHECKING WHEEL BOLT / NUT TORQUE(Q) ............ 7-22
REPLACING FUEL FILTER(S)...................................... 7-23
REPLACING AIR CLEANER PRIMARY ELEMENT(T) .... 7-24
CHECKING FUEL LINES(U) ......................................... 7-25
ADJUSTING FAN BELT TENSION(V)........................... 7-26
BATTERY(W)................................................................. 7-26
CHECKING INTAKE AIR LINE(X) ................................. 7-29
ADJUSTING TOE-IN(Y) ................................................ 7-29
CHECKING RADIATOR HOSE AND CLAMP(Z)........... 7-30
TG120-수출향-US-00.indd 8 2017-10-20 오후 5:57:24

POWER STEERING LINE(AA)...................................... 7-31
AIR CONDITIONER BELT TENSION(AB)..................... 7-31
CLEANING AIR CONDITIONER CONDENSER(AC) .... 7-32
ADJUSTING FRONT AXLE PIVOT(AD)........................ 7-32
ADJUSTING ENGINE VALVE CLEARANCE(AE) ......... 7-33
REPLACING AIR CLEANER FILTER(AF) ..................... 7-33
CHECKING AIR CONDITIONER HOSE(AG) ................ 7-34
CHECKING CAB CUSHION RUBBER(AH) .................. 7-34
REPLACING AIR FILTER(AI) ....................................... 7-34
CHECK AND CLEAN CAB AIR INTAKE FILTER(AU) ... 7-35
FLUSH COOLING SYSTEM AND CHANGING
COOLANT(AJ) ........................................................... 7-37
ANTIFREEZE ................................................................ 7-39
DRAINING WATER FROM CLUTCH HOUSING(AL).... 7-39
CHECKING AND REPLACING WIPER(AM) ................. 7-40
REPLACING FUSE(AN)................................................ 7-42
REPLACING CABIN FUSE(AO).................................... 7-44
SLOW BLOW FUSE(AP)............................................... 7-44
REPLACING BULB(AQ)................................................ 7-45
STORAGE AND DISPOSAL................................8-1
TRACTOR STORAGE .............................................. 8-2
DAILY STORAGE ............................................................ 8-2
LONG-TERM STORAGE................................................. 8-2
USING TRACTOR AFTER STORAGE..................... 8-3
USAGE AND DISPOSAL.......................................... 8-4
TROUBLESHOOTING.........................................9-1
ENGINE TROUBLESHOOTING ............................... 9-2
TRACTOR TROUBLESHOOTING ........................... 9-4
INDEX.................................................................10-1
TABLE OF CONTENTS
TG120-수출향-US-00.indd 9 2017-10-20 오후 5:57:24

This manual includes information titled as WARNING, CAUTION, IMPORTANT and NOTE. These titles indicate the fol-
lowing:
SAFETY AND VEHICLE DAMAGE WARNING
WARNING
This indicates that a condition may result in harm, serious injury or death to you or other
persons if the warning is not heeded. Follow the advice provided with the warning.
CAUTION
This indicates that a condition may result in damage to your vehicle or its equipment if the
caution is not heeded. Follow the advice provided with the caution.
IMPORTANT
This mark indicates emphasis on notable characteristics of working procedures, and infor-
mation about technology for easier operation.
NOTE
This indicates that interesting or helpful information is being provided.
TG120-수출향-US-00.indd 10 2017-10-20 오후 5:57:25