Dormakaba ED50 User manual

ED50/ED100/ED250
Swing Door Operators
Installation in Overhead Concealed Header
Door Installation, Setup,
Troubleshooting and Maintenance
Instructions
DL4617-003 – 09-2021
| EN |

2ED50/ED100/ED250 09-2021DL4617-003
dormakaba ED50/ED100/ED250 OHC Header
Setup and Troubleshooting Instructions
Table of Contents
Table of contents 
 General information 
. General information 
 ED//ED OHC product
description 
 ED//ED OHC door configurations 
. OHC single door configurations 
. OHC pair door and double egress door
configurations 
 Technical data 
. ED//ED technical data 
. Operating specifications 
 Safety information 
 ED/ED/ED User interface 
. Overview 
.  button keypad and display 
. Operator status LEDs 
. Mode switch and Exit Only switch panel 
. ED/ED/ED automatic and
manual modes 
. Low and full energy doors 
 System accessories 
. System accessory electrical connections 
. System accessories 
 Terminal board connections 
 ED/ED/ED door signage 
. Full energy operator 
. Low energy operator 
. Door signage, full energy single swing
doors (ANSI/BHMA A.) 
. Door signage, low energy single swing
doors (ANSI/BHMA A.) 
. Door signage, full energy pair swing doors
(ANSI/BHMA A.) 
. Door signage, low energy pair swing doors
(ANSI/BHMA A.) 
. Door signage, full energy double egress
swing doors (ANSI/BHMA A.) 
. Safety label, automatic swing doors 
. Safety label, low energy swing doors 
Table of contents
 Parameters 
. ED/ED/ED OHC – viewing and
changing parameters 
. Configuration parameters 
. Driving parameters 
 System setup for single door installation 
. Set operator spring tension 
. Set braking circuit plug position 
. ED/ED/ED OHC power on 
. Set installation type parameter AS 
. Set door width parameter Tb 
. Set OHC reveal depth parameter rd =  
. Set door type parameter dL 
. Perform partial learning cycle to rotate
arm to door installation position 
 Single door installation 
. Customer supplied single door -
installation 
. Prepare top of door for overhead arm 
. Prepare door for bottom door pivot and
install pivot 
. Install floor pivot shaft bearing 
. Hang door 
. Perform learning cycle 
 Set power fail closing speed 
. Set power fail closing speed 
 Pair door installation 
. Customer supplied doors - pair door
installation 
. Perform learning cycle for each door 
. Set power fail closing speed 
 Pair door parameters, Sync cable 
. Set ED operator parameters for pair door
operation 
. Connect Sync cable between
ED/ED/ED operators 
 Connect accessory wiring 
. Connect accessory wiring, single door 
. Connect accessory wiring, double doors 
 Install door signage, header cover 
. Install door signage 
. Install header cover 

3
ED50/ED100/ED250 09-2021DL4617-003
dormakaba ED50/ED100/ED250 OHC Header
Setup and Troubleshooting Instructions
Table of Contents
 ANSI/BHMA standards 
. Power operated pedestrian doors
(ANSI/BHMA .) 
. Low energy power operated doors
(ANSI/BHMA A.) 
 Upgrade cards 
. Upgrade cards 
. Container module 
. Installing upgrade cards 
 Maintenance 
. ED/ED/ED environment and
cleaning 
. Overhead arm and bottom door pivot 
. ED brake maintenance 
Appendix A - Driving parameters 
A. Driving parameters – detail 
Appendix B - Troubleshooting 
B. Information and error codes 
B. Red LED status codes 
B. Troubleshooting chart, "ln" codes 
B. Troubleshooting chart, "E" codes 
Appendix C - dormakaba handheld 
C. dormakaba handheld terminal 
C. New dormakaba handheld; language
change to English 
C. dormakaba handheld; firmware update 

4ED50/ED100/ED250 09-2021DL4617-003
dormakaba ED50/ED100/ED250 OHC Header
Setup and Troubleshooting Instructions
Chapter 1
.. Door Installation, Setup, Maintenance and
Troubleshooting Instructions.
This manual provides Setup, Maintenance and
Troubleshooting instructions for ED/ED/ED
overhead concealed (OHC) header door
configurations.
.. OHC header Installation Instructions.
Reference ED/ED/ED OHC Installation
Instructions DL-.
.. ED/ED/ED OHC header Installation.
NOTICE
Exterior door use.
To insure proper suitability for exterior door
use, the following topics must be addressed in
the context of the door application setting.
• Site-specific use factors such as high wind
conditions and/or building pressure.
• Door width, height, weight, and usage
patterns.
• Observable prevailing conditions at the
opening under which the operator is
expected to perform. In some instances, this
may require increased force settings to
counteract these conditions.
• Door mounted presence sensors.
When attempting to overcome these forces,
it is strongly suggested that door mounted
presence sensors be employed to enhance
pedestrian safety through the opening.
.. Manual storage.
This document must be kept in a secure place, and
accessible for reference as required.
If the door system should be transferred to another
facility, insure that this document is transferred as well.
.. dormakaba.us website.
Manuals are available for review, download, and printing
on the dormakaba.us website.
.. Dimensions
Unless otherwise specified, all dimensions are given in
both inches (“) and [mm].
 General information
. General information
.. Symbols used in these instructions.
WARNING
This symbol warns of hazards which could result
in personal injury or threat to health.
CAUTION
This symbol warns of a potentially unsafe
procedure or situation.
NOTICE
Draws attention to important information
presented in this document.
TIPS AND RECOMMENDATIONS
Clarifies instructions or other information
presented in this document.
Fig. 2.1 ED50/ED100/ED250 OHC with overhead arm

5
ED50/ED100/ED250 09-2021DL4617-003
dormakaba ED50/ED100/ED250 OHC Header
Setup and Troubleshooting Instructions
Chapter 2
 ED//ED OHC product
description
Fig. 2.2 ED100/ED250 OHC operator
Fig. 2.5 Overhead arm
TIPS AND RECOMMENDATIONS
Insure ED50/ED100/ED250 OHC header
installation is qualified for use at the respective
smoke or fire-rated door.
NOTICE
Door jambs, door(s) and installation by
customer.
. Intended use.
ED/ED/ED are electromechanical operators
used exclusively for opening and closing interior or
exterior swing doors. Reference Para. ...
. Packaging
ED/ED/ED operators are packaged in a
header for overhead concealed (OHC) installation.
For pair swing doors, two ED/ED/ED
operators are packaged in a single header.
. ED/ED/ED operators.
.. ED
• Supplied only as a low energy operator.
(ANSI/BHMA A.).
.. ED
• Supplied as a low energy operator.
(ANSI/BHMA A.).
• Configured as a full energy operator (ANSI/BHMA
A.) using parameter adjustment.
.. ED
• Supplied as a low energy operator.
(ANSI/BHMA A.).
• Configured as a full energy operator (ANSI/BHMA
A.) using parameter adjustment.
. ED/ED/ED separate modules (Fig. .).
.. Single door header; modules supplied:
• Low voltage wiring connection module.
• Main power module.
.. Pair door header; modules supplied:
• Two low voltage wiring connection modules.
• Two main power modules. Fig. 2.4 Wiring module Main power module
NOTICE
Door weights and ED operator low energy
requirements.
•  to  pounds: It is recommended the
ED operator(s) be configured for low energy.
•  to  pounds: The ED operators must
be configured for low energy.
. Maximum door weights*.
*Maximum door weight is based on prevailing conditions
at the door opening.
Door width ED
maximum door
weight
ED
maximum
door weight
ED
maximum
door weight
Inches mm Pounds - kg Pounds - kg Pounds - kg
 .      
 .      
       
       
Fig. 2.3 ED50 OHC operator