EAGLE CLAW Shappell DX4000 User manual

IMPORTANT SAFETY INFORMATION
CO
WARNING: KEEP ALL FLAME AND HEAT SOURCES AWAY FROM
THIS TENT FABRIC. This tent meets the flammability requirements of
CPAI-84. The fabric may burn if left in continuous contact with any flame source.
The application of any foreign substance to the tent fabric may render the flame
resistant properties ineffective.
CARBON MONOXIDE POISONING HAZARD: This shelter is nearly air tight
and must be ventilated if using an oxygen consuming heat source. An extra zipper
pull at the top of each door provides ventilation and can also be used to form a
window for viewing. DO NOT PACK SNOW AROUND SHELTER or in any
way prevent fresh air from entering shelter. Failure to ventilate shelter could
create a serious health hazard or death.
Towing of shelter with a motorized vehicle is not recommended.
PREVENT DAMAGE TO HINGE JOINT: Always set shelter on a level flat
surface.
MAINTENANCE: After each use, set up shelter until fabric is completely dry.
Never leave shelter folded closed with a wet cover.
NOTICE: It is normal for fabric to have some pinholes. This does not affect
water repellency.
READ SETUP & TAKEDOWN INSTRUCTIONS BEFORE USING SHELTER
PORTABLE
ICE FISHING SHELTER
REPLACEMENT PARTS
To order parts, please give Part No., Description and Qty needed.
EAGLE CLAW FISHING TACKLE
ATTN: Shappell Parts Dept.
4245 E. 46th Ave., Denver, CO 80216
[phone]
MODEL DX4000 (58” x 92” Floor)
Part# Description
10214 Fabric Cover
10419 Frame Assembly
10406 Floor Pole (only)
10409 Roof Tube (plain end)
10410 Roof Tube (formed end)
10413 Elastic Frame Cord
10401 Carpeting
10423 Roof Bow
SK4000 Skis
10328 Window 9” x 16”
10354 Window 9” x 30”
Accessories
IA2 Ice Anchor
LOT #: ____________
NOTE: Small holes, tears and cuts in cover can be repaired with
black duct tape applied to coated side of fabric.
CONSUMER WARRANTY
Eagle Claw Shappell® warrants its products against defects in material and
workmanship for one (1) YEAR from date of purchase. We will provide FREE
repair or replacement, in whole or in part, at our option, for any product, found in
our opinion to be defective. If return is required, freight must be prepaid. This
warranty does not cover freight damage, ordinary wear and tear, abuse, misuse
or altered product.
WINDOWS ARE NOT GUARANTEED AT TEMPERATURES BELOW
–15 DEGREES FAHRENHEIT.
For warranty claim, send letter indicating product and explanation of defect plus
dated proof of purchase to Eagle Claw Fishing Tackle, ATTN: Warranty Dept.,
4245 E. 46th Ave., Denver, CO 80216.
REV 0816
10423 10409
10410
10214
10419
10406
10401

Fig. 7
Fig. 9
Fig. 8
Fig. 10
Fig. 11
Hold Down Frame
Fig. 2
Fig. 1
SET UP INSTRUCTIONS
1) Open floor on a flat, level surface, with a door end facing the
wind. Damage to Hinge Joint may occur if Floor is not evenly
supported.
2) Assemble Roof Tube sections.
4) Fig. 2, Raise second U Frame,
again keeping Frame about 24”
away from Corners of Fabric Top.
Assemble Frame and push into
Corners of Fabric Top and adjust
Seam in Fabric to follow Curve of
the Frame. Clip end of Roof Tube
Assembly to U Frame and slide
next to inside edge of nuts as
shown in Fig. 3 & 4. Clip second
Roof Tube Assembly into place
next to Nuts. With both Roof
Tubes next to inside edge of
Nuts...Install Roof Bows, Fig. 4.
3) Fig. 1, Raise one U Shaped Frame. Keep Frame about 24” away
from Corners of Fabric Top and Slip ends of U Frame over Crimped
ends of Floor Poles...Shock Cord will pull Frame together. Push As-
sembled Frame into Corners of Fabric Top and adjust Seam in Fab-
ric so that it follows the Curve of the Frame. Snap end of a Roof
Tube Assembly to U Frame and Support Frame as shown in Fig. 2.
TAKE DOWN INSTRUCTIONS
1) Fig. 5, Remove Roof Tubes from one U Frame and use one
Roof Tube to Support other U Frame as shown. Pull U Frame
away from Fabric Corners, then pull apart and Fold Frame to Floor
while keeping Fabric away from Frame. Do Not Wrap Fabric
Around Frame. NOTE: U Frame should lay inside of the Floor
Poles, not on top of them. Repeat for other U Frame, Fig 6.
Fig. 5
Fig. 6
2) Fold Tent as shown in Fig. 7,8,9,10 and11.
Fig. 4
Roof Bows
Fig. 3
Pull shock cord into
slot in fish door to
hold door open.