Elkay 4592 FTN Series User manual

97215C (Rev. SIE - 1/11)
4592_FTN 4593_ FTN LK4593_FTN
PAGE1
Owners Manual
Wall Mount Stone Fountains
IMPORTANT
ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON
Toassureyouinstallthismodeleasilyandcorrectly,
PLEASEREADTHESESIMPLEINSTRUCTIONSBEFORESTARTINGTHE
INSTALLATION.CHECKYOURINSTALLATIONFORCOMPLIANCEWITH
PLUMBING,ELECTRICALANDOTHERAPPLICABLECODES.Afterinstallation,
leavetheseinstructionsinsidethefountainforfuturereference.
IMPORTANT! INSTALLER PLEASE NOTE.
THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS,
ETC. TO WATER LINES ISACOMMON PROCEDURE. THIS GROUNDING MAY BE IN THE
BUILDINGORMAYOCCURAWAYFROM THEBUILDING.THISGROUNDINGCAN CAUSE
ELECTRICALFEEDBACK INTOAFOUNTAIN, CREATINGAN ELECTROLYSIS WHICH
CAUSESAMETALLIC TASTE OR AN INCREASE IN THE METALCONTENT OF THE WATER.
THISCONDITIONISAVOIDABLE BYUSINGTHEPROPERMATERIALSASINDICATED.ANY
DRAIN FITTINGS PROVIDED BYTHE INSTALLER SHOULD BE MADE OF PLASTIC TO
ELECTRICALLYISOLATETHEFOUNTAINFROMTHEBUILDINGPLUMBING SYSTEM.
FIG. 1
TUBE IS
SECURED
IN POSITION
SIMPLY PUSH IN
TUBE TO ATTACH PUSH IN COLLET TO RELEASE TUBE
PUSHING TUBE IN BEFORE
PULLING IT OUT HELPS TO
RELEASE TUBE
FIG. 2
OPERATIONOFQUICKCONNECT FITTINGS
Installer
NOTE: WATER FLOW
DIRECTION
BUILDINGWATERINLET
SERVICESTOP
(NOT FURNISHED)
1/4"O.D.TUBE
WATER INLET
TOCOOLER
3/8"O.D.UNPLATED
COPPERTUBE CONNECT
COLDWATERSUPPLY
WWW.RESTROOMDIRECT.COM 704 • 937 • 2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

97215C (Rev. SIE - 1/11)
4592_FTN 4593_FTN LK4593_FTN
PAGE2
4592 ROUGH-IN
GENERALINSTRUCTIONS
1. Water supply 3/8" O.D. unplated copper tube. Waste 1-1/4" O.D. Contractor to supply waste trap and
service stop valve in accordance with local code.
2.Connecting linestobe madeofunplated copperandshould bethoroughlyflushed toremoveall foreign
matter before being connected to fountain. This fountain is manufactured in such a manner that it does
not in anyway cause taste, odor, color, or sediment problems.
3.Connect fountaintobuilding supplyline with ashut-off valve andinstall a3/8"unplated copperwaterline
between the valve and the fountain. Remove any burrs from outside of water line and insert into inlet side
of the strainer (see Fig.1) to a positive stop - approximately 3/4". (see Fig.2) DO NOT SOLDER TUBES
INSERTED INTO THE STRAINERAS DAMAGE TO THE O-RINGS MAY RESULT.
4. These products are designed to operate on 20 psig to 105 psig supply line pressure. If inlet pressure is
above 105 psig, a pressure regulator must be installed in the supply line. Any damage caused by reason
of connecting this product to supply line pressures lower than 20 psig or higher than 105 psig is not
covered by warranty.
LEGEND:
A=RECOMENDEDWATERSUPPLYLOCATION, 3/8" O.D. UNPLATED COPPERTUBECONNECTSTUB 1-1/2" (38mm)OUTFROM
WALL SHUT OFF VALVE BY OTHERS.
B=RECOMMENDEDLOCATIONFORWASTEOUTLET,1-3/4" O.D. (44mm) DRAIN.
C=(4) 5/16" (8mm)DIA. MOUNTING HOLES.
INSTALLATION INSTRUCTIONS
1. This fountain is to be mounted on a smooth, flat, finished wall surface with adequate support structure.
NOTE: Wall mounting structure must be capable of supporting 300 lb. load on fountain.
2. Establish rim height that fountain is to be mounted at.
3.Referto rough-inforplumbing.
4.Locate andinstall trap.(trap not furnished)
5.Installshut-offvalveonbuilding water supply. (valvenotfurnished)
6. Locate and install fountain using 3/8" minimum lag screws or bolts. (screws or bolts not furnished)
7.Connect watersupplyand fountaindrain.
8. Turn on water supply and check all connections for leaks.
WWW.RESTROOMDIRECT.COM 704 • 937 • 2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

97215C (Rev. SIE - 1/11)
4592_FTN 4593_ FTN LK4593_FTN
PAGE3
4593 ROUGH-IN
FIG. 3
ACORNNUT
WASHER
CLOSETSCREW
ORTHREADEDROD
(DEPENDINGONWALL TYPE
ANDANCHORUSED)
SUGGESTED CONFIGURATION FOR EXPOSED MOUNTING BOLTS
LEGEND:
A=RECOMENDEDWATERSUPPLYLOCATION, 3/8" O.D. UNPLATEDCOPPERTUBECONNECTSTUB 1-1/2" (38mm)OUTFROM
WALL SHUT OFF VALVE BY OTHERS.
B=RECOMMENDEDLOCATIONFORWASTEOUTLET,1-3/4" O.D. (44mm) DRAIN.
C=(4) 5/16" (8mm)DIA. MOUNTING HOLES.
WWW.RESTROOMDIRECT.COM 704 • 937 • 2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115

97215C (Rev. SIE - 1/11)
4592_FTN 4593_FTN LK4593_FTN
PAGE4
100147140560
100322740560
101570540560
15005C
15013C
170705042830
40048C
40089C
400942308640
98287C
40169C
50986C
55996C
56092C
56121C
600985551640
61313C
66346C
70683C
75588C
75589C
TROUBLE SHOOTING AND MAINTENANCE
Orifice Assy: Mineral deposits on orifice can cause water flow to spurt or not regulate. Mineral deposits may be removed from
the orifice with a small round file not over 1/8" diameter or small diameter wire.
CAUTION: DO NOT file or cut orifice material.
Stream Regulator: If orifice is clean, regulate flow as in “Stream Height" instructions above. If replacement is necessary,
see parts list for correct regulator part number.
Actuation of Quick Connect Water Fittings: Cooler is provided with lead-free connectors which utilize an o-ring water seal.
To remove tubing from the fitting, relieve water pressure, push in on the gray collar while pulling on the tubing. (See Fig.2)
To insert tubing, push tube straight into fitting until it reaches a positive stop, approximately 3/4".
FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620
PRINTEDINU.S.A.
10
716
48
11
FIG. 4
ITEMIZED PARTS LIST
ITEM
NO. PART NO. DESCRIPTION
1
2
3
4
5
6
7
8
9-A
9-B
10
11
12
13
14
15
16
17
18
19
20
Drain Gasket
Bubbler Gasket
Drain Gasket
RegulatorRetaining Nut
Bubbler Tube Assy.
Basin
Button
Nut - Cover
Bubbler
Bubbler Assembly
Hex Nut 1-5/16"-20UN
Regulator Holder
In-Line Strainer
Poly Tubing (Cut To Length)
Drain Elbow
Drain Plug Assy.
Regulator
DrainTube
Union - 1/4
Slip Joint Nut 1-1/4
Gasket
FIG. 5
STREAM HEIGHTADJUSTMENT: Stream height isfactorysetat
35 PSI. If supply pressure varies greatly from this, remove
items 7 and 8 (see Fig.4) and adjust screw on item 16.
Clockwise adjustment will raise stream and counterclockwise
adjustment will lower stream. For best adjustment, stream
should hit basin approx. 6-1/2" from bubbler.
2
9A
15
6
3
2
12
192014
518
13
13
1
17
See
Fig. 4
4593 SHOWN
9B
WWW.RESTROOMDIRECT.COM 704 • 937 • 2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115