Elkay EFP01-G-A Instruction Manual
ELKAY Pre-Filtration Sediment Filter EFP01-G-A
Please read all instructions, specications, and precautions before installing and using
your water lter system.
Page 1 1000003998 (Rev A - 05/2017)
PARTS LIST
• Filter Assembly
• G1 Brass Nut (2)
• G3/4 Brass Connector (2)
• Rubber Washer (2)
• 12.5mm I.D. PVC Drain Tube (300mm)
• 150mm Cable Tie
• 29.5mm ID PE Drain Tube (1.2m)
• Hose Clamp
• 3V Lithium Battery
• Manual
SPECIFICATIONS
Rated operating pressure 0.1-0.4Mpa
50L/min at 0.2MPa
Rated ambient
temperature 4-40°C
Rated operating
temperature 5-38°C
Ambient Humidity 90% Max
Cable Tie
P.E. Drain
Tube
Battery
Hose
Clamp
Brass Nut Brass
Connector
Rubber
Washer
PVC Drain
Tube
Page 21000003998 (Rev A - 05/2017)
Notice
•
•
•
•
•
Caution
Caution
140mm
318mm
264mm
95mm
Page 3 1000003998 (Rev A - 05/2017)
Note:
Before Installation
Ball
Valve
Water
Meter
Floor
Drain
Floor
X>220mm
pipe center and upper
barrier)
X>65mm
X=180±5mm
inlet/outlet)
X<1200mm
inlet/outlet center
X>350mm
Page 41000003998 (Rev A - 05/2017)
Installation
1.
Note:
Ball
Valve 1
Water
Meter
Floor
Drain
Floor
Pre-Filter
PVC Drain Tube
PE Drain Tube
Ball
Valve 2
Ball
Valve 4
Ball
Valve 3
Page 5 1000003998 (Rev A - 05/2017)
2.
the tube through the anti-siphon opening using the provided cable tie. Pull the cable tie tight
PVC Drain
Tube
Center
Boss
Cable Tie
Opening
3.
Rubber
Washer
Brass
Connector
Brass Nut
PTFE tape
Page 61000003998 (Rev A - 05/2017)
4.
5.
nose plyers or another tool can be used to turn the brass connector using the internal ridges.
Note:
be about 140mm.
Internal
Ridge
Inlet Outlet
140mm
Page 7 1000003998 (Rev A - 05/2017)
6.
Note:
are over tightened.
OutIn
Page 81000003998 (Rev A - 05/2017)
Rotate the sump and tighten the nut.
Note: The decorative cover direction can be changed
Connecting Nut
Page 9 1000003998 (Rev A - 05/2017)
Clamp In
This Groove
Drain
Connector
Opening
8.
•
•
cause damage.
•
•
Page 101000003998 (Rev A - 05/2017)
Battery Installation
1.
2.
Note:
Copper Clip
Mount the copper
clip side
The battery should be
installed in place. The
clamp points at both sides
should press on the battery
Ball
Valve 1
Water
Meter
Ball
Valve 4
Ball
Valve 3
The overall installation
P.E. drain tube should be
anti-siphon opening to
prevent splashing.
tube should be put in
Ball
Valve 2
Page 11 1000003998 (Rev A - 05/2017)
Electronics Operation
•
•
•
maximum).
•
•
A)
Note:
B)
increase the value.
C)
the value.
D)
user is saved.
Note:
Page 121000003998 (Rev A - 05/2017)
Backwashing
1.
2.
3.
4.
Page 13 1000003998 (Rev A - 05/2017)
Care and Maintenence
1.
2. Pull up on the upper cover to remove it.
3.
remove the body.
4.
Note:
element.
5.
Note:
Note:
6.
upper retainer.
Note:
7.
Filter Body
Connecting
Nut
Retainer
Filter
Element
Page 141000003998 (Rev A - 05/2017)
Troubleshooting
Problem Possible
Cause
output
source is
element is
valves is not
pressure.
element is
The thread connection is not
Wrap the thread connection
The brass nut(s) are not
tight. Tighten the nut(s).
damaged at the inlet/outlet
connector.
The nut is not tight. Tighten the connecting nut.
The o-ring is aged or
damaged.
replace it.
The rubber seal is aged or
damaged.
replace it.
Drain connector is not tight. Tighten the drain connector.
The rubber seal is aged or
damaged.
replace it.
The PE drain tube is
Re-install PE drain tube or
Page 15 1000003998 (Rev A - 05/2017)
Warranty
1
2
2
3
4
5
Dim display
screen
No battery. Install battery.
The battery
has run out. Replace battery.
Positive and
negative poles
reversed.
Re-install battery.
Poor outlet
particles)
Bypass valve
is open. Close ball valve 3.
Pores in
stainless steel
mud into the
personnel.
Page 161000003998 (Rev A - 05/2017)
EFP01-G-A
.
.
. .
. .
.
.
.
)
(
.
.3
.
.
16 (05/2017 -) 1000003998
IntlCare@ 630-575-4755
1
2
2
3
4
5
.
.
.
.
.
.42 1
.
.
.
.
.
.
.1
PTFE
.
.PTFE
.2
.
./
.
.3
. .
. O
O
.
.4 .
.5
. .
.
.
15 (05/2017 -) 1000003998
.
1..
2..
3..
4..
. :
5. .
. .
. :
:
.
6. .( )
.
. :
.
7.
.
14 (05/2017 -) 1000003998
. .
1.. . 180
2.. .
3.. . 180
4.. . ""
“”
.
“”
.( )
13 (05/2017 -) 1000003998
Table of contents
Languages:
Other Elkay Water Filtration System manuals
Popular Water Filtration System manuals by other brands
Hydrotech Water
Hydrotech Water 765AIO Installation and operation manual
Doulton
Doulton HIS installation instructions
INAZUMA
INAZUMA ITF-30 septem Installation and operating instructions
Canature
Canature 475 Pro Series Installation & operation manual
VEVOR
VEVOR CPF-2500 instruction manual
Wisy
Wisy Optima installation instructions