EVBIKE EVBAT36V7A User manual

Baery for electric bicycle drive
EVBAT36V7A
INSTALLATION AND OPERATING INSTRUCTIONS

www.EVBIKE.cz
Thank you for purchasing EVBIKE baery set. We believe that you will be fully saffied with its use.
Before installing and first use, read carefully the instrucons!
If you have found in the manual the fact, that could prevent you the use of the product, please return it before
installing in the undamaged original packaging back. For the current warranty condions and the possibility
of returning, please contact your dealer who will advise you how to proceed.
SPECIFICATIONS
Nominal Voltage: 36V
Cell material: Lithium (Li-ion)
Normal Capacity: 7 Ah*
Charging Volatge: 42 V
Charging Current: 2A
Cover Material: slina hliníku
Dimensions (L x W x H): 31 x 9 x 9 cm**
Hmotnost baterie: 2,6 kg
Hmotnost nosiče: 0,5 kg
*Minimum guaranteed capacity. Cells, however, have normally higher capacity of up to 8.2 Ah. **Without holder
Dovozce: Global World Logisc Ltd.,EU-VAT ID: CZ682998344

www.EVBIKE.cz
BATTERY INSTALLATION BATTERY ON THE BIKE FRAME
Importer: Global World Logisc Ltd.,EU-VAT ID: CZ682998344
To connect the baery to the controller you must loosen screws of two-piece cover (A and B, Fig. 2) on the boom
of the baery holder, connect the connectors and ghten them sufficiently (Fig. 3, 4). Screw connector cover back.
All screws must be ghtened sufficiently to avoid the transient resistance effect when discharging (C, D, Fig. 3).
This effect can cause the baery deep discharge, short circuit or damage to the material due to excessive
temperatures. Screws ghten with adequate force to prevent damage of the baery terminals.
Baery holder is mounted into the holes on the bike frame designed for mounng bole cage (Fig. 1).
Finally, insert the baery into the holder and lock key. Please pay aenon to the right and gently fing the
baery into the holder - ensures long life of the latch mechanism.
●
●
●
●
34
12
A
B
C
D

www.EVBIKE.cz
PUTTING INTO OPERATION
The baery is put into operaon by switching the green buon located on the boom right of the baery
holder (fig. 2).
PROPER CHARGING
Lithium cells which contain EVBIKE baeries can be recharged at any level of charge or discharge - these
baeries have no memory effect. We recommend always aer the ride, to recharge the baery so you can
immediately enjoy full power and a long driving range. Aer recharge always unplug the baery from
the charger. Charge the baery only at room temperature (25 ° C). Charging at temperatures below freezing
and vice versa charging the baery exposed to excessive sunlight is prohibited.
Current state of charging is indicated by LED color lights on charger.
• RED – charging in progress.
• GREEN – charging finished (charger is now disconnected from baery).
The charging me is 3-6 hours depending on baery condion.
PROPER DISCHARGING
Recharge the baery to full capacity aer the the first disconnecon of protecve controller. Never try to
reuse the baery aer protecve disconnecon! Deep discharge of some cells and their unrepairable damage
may happen! Such baery usage may also cause unbalance of baery cells voltage and decrease their
capacity. In extreme cases, the baery can not be recharged again. This kind of damage can be easily
diagnosed and will result in avoiding your warranty.
BALANCE CHARGING
Inside the baery is an electronic baery protecon - balance circuit (compensates the voltage of the cells to
the same value). When using the baery cells voltage is always soly unblanced and we recommend aer
about 8-10 charging cycles to leave the baery on the charger even aer charging is completed. The baery is
sll charged by a small maintenance current flow and balance circuit equals the voltage of cells to the same
level. Therefore double the charge me compared to standard me. Do not perform balance charging every
me you recharging the baery. It may shorten service life of the baery cells. We recommend balance
charging especialy before first ride and always, if you suppose that the baery has not its standard power!
Importer: Global World Logisc Ltd.,EU-VAT ID: CZ682998344

www.EVBIKE.cz
Importer: Global World Logisc Ltd.,EU-VAT ID: CZ682998344
END USER INSTRUCTIONS
Baeries and cells can be used only by person, instructed to use Lithium baeries and cells. This nstrucon is
done by last reseller. When the baeries are sold and shipped, instrucon is done via enclosed manual, more
details to be found at reseller website.
WARNINGS FOR BATTERY USE POSSIBLE DANGERS
•
•
•
Danger of shortcut and fire
Charged or uncharged cells contains a high amount of electric power, it may cause a electric sparks when
contacts are in shortcut. Baeries are not flammable, but fire may be created from sparks or high
temperature connectors (temperature caused by shortcut).
Danger of injury caused by DC current
When connecng more cells or baeries to serie, the danger of injury increases. Never touch the electric
wires or other componnents that are powered.
Danger of chemical material
Lithium cells and baeries does not contain any causcs or acids. Sll materials that are affecng human
body are inside. We recommend you to use following guidelines when manipulang with Lithium cells.
a)
b)
c)
Eye protecon: use eyewear to prevent intrusion of any chemicals in eye.
Skin protecon: use protecon clothing and gloves. Prevent contact of chemicals with your skin.
Inhale protecon: Manipulate with cells or baeries only in venlated areas.
STORAGE
If you do not use the bike for more than 1 hour, always disconnect the baery using its power switch. If you
do not use the bike for more than 24 hours, always remove the baery, recharge it and store in a safe dry
place at room temperature. Beware of short-circuit the baery terminals (contacts) when storing and
handling. For long-term storage, such as off-season, it is also necessary check baery every 14 days (using
LEDs) and aer 1 month recharge the baery to its full capacity. If you do not perform this maintenance
deep discharge of the baery cells will occur. This irreparable baery damage is not covered by warranty.

www.EVBIKE.cz
WARNINGS
• Protect against unqualified manipulaon, protect against kids.
• Protect against water or other liquids.
• Use the baeries with control or constant managment of Baery protecon/control system.
• Protect the cells and baeries against overcharge and deep discharge.
• Don’t brake baery case, don’t manipulate with damaged baeries.
Baery and cell recyclaon – legal obligaon informaons
a) Of the manner of re-collecon; for this purpose, the seller publishes actual list of affordable way to take
back and separated collect. Including at least name of the place and address.
Place to take back and separated collecon: i4wifia.s., Průmyslová 11, Praha 10, 102 19
b) About possible negave effects of materials used in baeries or accumulators to environment and human
health.
Baeries and cells contain chemical materials that have negave effect on environment and human health.
c) About meaning of graphical symbol for separated colleon or take back and about meaning of markings
Importer: Global World Logisc Ltd.,EU-VAT ID: CZ682998344
THIS IS GRAPHICAL SYMBOL FOR SEPARATED COLLECT OR TAKE BACK.
DO NOT PUT BATTERIES TO MUNICIPAL WASTE BUT HANDLE THEM IN PLACE
FOR SEPARATED COLLECT OR TAKE BACK.
Global World Logisc Ltd.,EU-VAT ID: CZ682998344, as legal enty authorized by manufacturer for EU,
hereby declares, that the device is in compliance with basic requirements and further relevant provisions
of direcve LOW VOLTAGE DIRECTIVE 2006/95/EC which sets technical requirements for electric devices
of low voltage. This declaraon is issued on documents provided by Manufacturer.