FieldServer ProtoNode FPC-N64 User manual

1
ProtoNode FPC-N64 GATEWAY for Interfacing Hunter
Commercial TRAK Fans Quick Start
Port R1 - RS-485 To Modbus RTU Fans
Port R2 - RS-485 Field Protocol to Local Network
Power Input 9-30VDC
ETH1 – Ethernet Field Protocol to Local Network
ETH2 – Ethernet to Modbus TCP/IP Fans

120V/240V
AC Power
FAN #
1
HMI/FAN
CONTROLLER
Modbus Splitter
CAT 5E
FAN #
2
FAN #
3
C OM 4
C OM 1
C OM 2 C OM 3
C OM 4
C OM 1
C OM 2 C OM 3
CAT 5E
CAT 5E
CAT 5E
Modbus Splitter
C OM 4
C OM 1
C OM 2 C OM 3
Modbus Splitter
CAT 5E
CAT 5E
CAT 5E
Modbus
Address 1
Modbus
Address 2
Modbus
Address 3
1
2
4 5
7 8
BMS
CAT 5E
Modbus RTU –
BACnet Gateway
Figure 1 – Sample 3-

2
•Whether the system is 1--Fan, each Modbus RTU fan interfaces with the ProtoNode
  of the
 from the fan
shows a 3-
 

CAT 5E
124
5
7
8
Modbus RTU –
BACnet Gateway
To Modbus
Splitter
Figure 2 – 

 
1.  -over-


Modbus
RTU Fan
Pins

Pinout
FieldServer
ProtoNode
Pin Label
Pin

 Blue-Solid,
Blue-Stripe+ L

GND -
Stripe, Brown-Solid- N -
Figure 3 – 
 - Strip pin 4 (Blue--of the ethernet cable 
terminal 
 - Strip pin 7 (Brown--of the ethernet cable and connect to -N
terminal - Ground 

3
2. 
Modbus
RTU Fan
Pins

Pinout
FieldServer
ProtoNode
Pin Label
Pin

Transmit
Pin 1
-Stripe
TX+
RS-
Receive
Pin 2
-Solid
RX-
RS--
 Shield GND RS-
Figure 4 – RS-
 - -
Gateway for RS-
 - -- R1 terminal of the
Gateway for RS-- 
 -  -R1 terminal of the Gateway for RS-
3. 
 - 
 as shown in

CAT5E
124
5
7
8
Modbus RTU –
BACnet Gateway
FAN#1
C OM4
C OM1
C OM2 C OM3
Modbus Splitter
CAT5E
Modbus
Address 1
120V/240V
AC Power
– 

4
Figure 6 –  
4. local 
 
ETH1(LAN) to Local PC PC
Figure 7 – 
 
192.168.1.24, Subnet Mask is 255.255.255.0 

““
“““Internet Protocol Version 4
192.168.1.59, Subnet mask
255.255.255.0


5. 
Open a web browser and connect to the FieldServer’s default IP Address: 192.168.1.24
Username
use Default Password listed on the 
6. 
 

6
 
  


7

Fan 
 


 
main page
  Te st

 To start 
 
 Select speed 1-10 
 



 
 
 Select brightness level 1- 


 

10
 

