Fujitsu M4097D - Fb 50PPM SCSI A3 Dupl 100Sht Adf Manual

M4097D Image Scanner
Operator's Guide
P3PC-E482-05EN

i
For Safe Operation
Treatment of This Manual
READ ALL OF THIS MANUAL CAREFULLY BEFORE USING THIS PRODUCT,
IF NOT USED CORRECTLY, UNEXPECTED INJURY MAY BE CAUSED TO
USERS OR BYSTANDERS.
While all efforts have been made to ensure the accuracy of all information in this
manual, PFU assumes no liability to any party for any damage caused by errors or
omissions or by statements of any kind in this manual, its updates or supplements,
whether such errors are omissions or statements resulting from negligence,
accidents, or any other cause. PFU further assumes no liability arising from the
application or use of any product or system described herein; nor any liability for
incidental or consequential damages arising from the use of this manual. PFU
disclaims all warranties regarding the information contained herein, whether
expressed, implied, or statutory.
PFU reserves the right to make changes to any products herein, to improve
reliability, function, or design, without further notice and without obligation.
EMC and Safety
FCC declaration: This equipment has been tested and found to comply with the
limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits
are designed to provide reasonable protection against harmful interference in a
residential installation. This equipment generates, uses, and can radiate radio
frequency energy and, if not installed and used in accordance with the instruction
manual, may cause harmful interference to radio communications. However, there
is no guarantee that interference will not occur in a particular installation. If this
equipment does cause harmful interference to radio or television reception, which
can be determined by turning the equipment off and on, the user is encouraged to
try to correct the interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the
receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.

ii
FCC warning: Changes or modifications not expressly approved by the party
responsible for compliance could void the user's authority to operate the equip-
ment.
NOTICE
• The use of a non-shielded interface cable with the referenced device is prohibited.
The length of the parallel interface cable must be 3 meters (10 feet) or less. The
length of the serial interface cable must be 15 meters (50 feet) or less.
• The length of the power cord must be 3 meters (10 feet) or less.
This Class B digital apparatus complies with Canadian ICES-003.
Cet appareil numérique de la classe B est conformme à la norme NMB-003 du
Canada.
As an ENERGYSTAR®Partner, PFU Limited has determined that this scanner meets
ENERGYSTAR®guidelines for energy efficiency. ENERGYSTAR®is a U. S. registered
mark.

iii
Warning on Use Requiring Extremely High Safety Levels
This Product is designed, developed and manufactured as contemplated for
general use, including without limitation, general office use, personal use and
household use, but is not designed, developed and manufactured as contemplated
for use accompanying fatal risks or dangers that, unless extremely high safety is
secured, could lead directly to death, personal injury, severe physical damage or
other loss (hereinafter “High Safety Required Use”), including without limitation,
nuclear power core control, airplane control, air traffic control, mass transport
operation control, life support, weapon launching control. You shall not use this
Product without securing the sufficient safety required for the High Safety Required
Use. If you wish to use this Product for High Safety Required Use, please consult
with our sale person in charge before such use.
Warning on Reproduction
Reproducing bills, coins, government securities and passports, licenses issued by
public author or civilian organizations, official documents and private paper is illegal
and brought to justice.
About Copyright
Literary works like books, paintings, wood-block prints, maps, drawings and
photographs should not be reproduced other than the personal or domestic use or
the use within other limit without the rightful person’s permission.
Trademark Acknowledgment
PFU is a registered trademark of PFU Limited.
• Microsoft, Windows and Windows NT are registered trademarks of Microsoft
Corporation America in the United States and any other countries. In this manual,
the Microsoft Windows 98®Operating System is referred to as Windows 98, the
Microsoft®Windows ME®Operating System is referred to as Windows ME, and
the Microsoft®Windows 2000®Operating System is referred to as Windows 2000.
the Microsoft®Windows XP®Operating System is referred to as Windows XP.
• Adobe and the Adobe logo as well as Acrobat and the Acrobat Logo are
trademarks of Adobe Systems Incorporated.

iv
• The contents of this manual may be revised without prior notice.
• We are unaccountable for any damages or passive damages from the use of
this equipment or this manual and any compensation of third party.
• The details of warranty is described in the warranty document pre-packaged.
• The minimum holding period of spare parts of this equipment is five years
from the effective date of discontinuance.
All Rights Reserved, Copyright © PFU LIMITED 2001-2003
Conventions for Alert Messages
This manual uses alert messages to prevent users and bystanders from being
injured or from suffering damage to their property. An alert message consists of an
alert signal and alert statements. The alert signals and their meanings are as
follows.
WARNING
WARNING indicates that personal injury like pinching of fingers or hands may result
if you do not follow a procedure correctly.
CAUTION
CAUTION indicates that damage to the scanner may result if you do not follow a
procedure correctly.
Official PFU part names are indicated with an initial capital letter, as in the part name
“Pick roller”.
NOTICE
A NOTICE provides “how-to” tips or suggestions to help you perform a procedure
correctly.
• ISIS is a registered trademark of Pixel Translations, A Division of Actionpoint Inc.
• All other brand names and product names of this manual are trademarks or
registered trade marks.
• Reproducing in whole or in part of this manual against the Copyright law.

v
PFU Offices
Please send your comments on this manual or on PFU products to the following
addresses:
PFU LIMITED
Imaging Products Division
Solid Square East Tower, 580
Horikawa-cho, Saiwai-ku,
Kawasaki-shi, Kanagawa 212-8563, Japan
Phone: [phone]
Fax: [phone]
Website: http://imagescanner.fujitsu.com/
E-mail: [email protected]
Corporate headquarters
Nu 98-2 Unoke, Unoke-machi, kahoku-gun,
Ishikawa 929-1192, Japan
Phone: [phone]
Fax: [phone]
North America
FUJITSU COMPUTER PRODUCTS OF
AMERICA, INC.
2904 Orchard Parkway, San Jose,
CA 95134-2009, U.S.A.
Phone: [phone]
Technical Assistance Center: (1-800)626-4686
Fax: [phone]
Website: http://www.fcpa.com/
E-mail: [email protected]
FUJITSU CANADA, INC.
2800 Matheson Boulevard East,
Mississauga, Ontario L4W 4X5, Canada
Phone: [phone]
Fax: [phone]
Website: http://www.fujitsu.ca/
E-mail: [email protected] (for sales
questions)
[email protected] (for technical
questions)
Europa
FUJITSU EUROPE LTD.
Hayes Park Central, Hayes End Road, Hayes
Middlesex UB4 8FE, England
Phone: [phone]
Fax: [phone]
Website: http://www.fujitsueurope.com/home/
E-mail: [email protected]
FUJITSU DEUTSCHLAND GMBH.
Frankfurter Ring 211,
80807 München 40, Germany
Phone: [phone]
Fax: [phone]
Website: http://de.fujitsu.com/
E-mail: [email protected]
FUJITSU ITALIA S.p.A.
Via Nazario Sauro, 38
20099 Sesto San Giovanni (Milan), Italy
Phone: [phone]
Fax: [phone]
Website: http://www.fujitsueurope.com/
FUJITSU ICL ESPAÑA, S.A.
Camino Cerro de los Gamos, 1 28224,
Pozuelo de Alarcon, Madrid, Spain
Phone: [phone]
Fax: [phone]
Website: http://www.fujitsueurope.com/
E-mail: [email protected]
Australia
FUJITSU AUSTRALIA LTD.
2 Julius Avenue
North Ryde, N.S.W 2113 Australia
Phone: [phone]
Fax: [phone]
Website: http://au.fujitsu.com/

vi
Asia
FUJITSU ASIA
20 Science Park Road, #03-01,
Tele Teck Park Singapore Science Park II,
Singapore 117674
Phone: [phone]
Fax: [phone]
Website: http://sg.fujitsu.com/
E-mail: [email protected]
FUJITSU TAIWAN LTD.
19th Fl., No39, 1 Sec. Chung-Hwa Rd.,
Taipei, Taiwan
Phone: [phone]
Fax: [phone]
Website: http://tw.fujitsu.com/
FUJITSU HONG KONG LTD.
10/F., Lincoln House, 979 King’s Road,
Taikoo Place, Island East, Hong Kong
Phone: [phone]
Fax: [phone]
Website: http://hk.fujitsu.com/
E-mail: [email protected]
FUJITSU SYSTEMS BUSINESS (THAILAND)
LTD.
12th Fl., Olympia Thai Tower,
444 Rachadapisek Road, Samsennok,
Huay kwang, Bangkok 10320, Thailand
Phone: [phone]
Fax: [phone]
Website: http://th.fujitsu.com/
FUJITSU KOREA LTD.
Susong Tower Building, 83-1
Susong-Dong, Jongno-gU, Seoul,
Koria
Phone: [phone]
Fax: [phone]
Website: http://kr.fujitsu.com/
E-mail: [email protected]
FUJITSU MALAYSIA SDN, BHD.
7th FL, Wisma Damansara, Jalan Semantan
50490 kuara Lumpur, Malaysia
Phone: [phone]
Fax: [phone]
Website: http://my.fujitsu.com/
FUJITSU PHILIPPINES, INC
2nd Fl., United Life Building, Pasay Road,
Legaspi Village Makati, Metro Manila,
Philippines
Phone: [phone]
Fax: [phone]

vii
Preface
Thank you very much for your purchase of the M4097D Image Scanner.
The M4097D is a very fast and highly functional image scanner developed for
volume filing, using charge-coupled device (CCD) image sensors. This scanner
features duplex scanning and high quality image processing with an automatic
document feeder (ADF).
As this manual explains the basic handling of the scanner, read it carefully to use
the scanner properly.
Edition Date published Revised contents
01 February, 2000 First edition
02 February, 2000 Second edition
03 May, 2000 Third edition
04 October, 2002 Manual code changed
Manual code: P3PC-E482-05EN

viii

ix
ix
CONTENTS
❑❑
❑❑
❑CHAPTER 1 COMPONENTS
Checking the Components ............................................... 1-1
Units and Assemblies ...................................................... 1-2
Operator Panel ................................................................ 1-5
❑❑
❑❑
❑CHAPTER 2 INSTALLATION AND CONNECTIONS
Precautions ...................................................................... 2-1
Inspection ........................................................................ 2-2
Repositioning the Shipping Lock ...................................... 2-4
Cable Connections .......................................................... 2-5
Mounting the Stacker ....................................................... 2-7
Setting the SCSI ID and the SCSI Terminator .................. 2-8
❑❑
❑❑
❑CHAPTER 3 OPERATING INSTRUCTION
Turning the Power On ...................................................... 3-1
Waking up the Scanner from the Low Power Mode.......... 3-2
Manual Feed Mode Setting .............................................. 3-3
Loading Documents on the ADF ...................................... 3-4
Loading Documents on the Flatbed ............................... 3-10
Loading Documents Larger than the Document Bed ..... 3-11
Reading a Page from a Thick Book ................................ 3-12
❑❑
❑❑
❑CHAPTER 4 ADF DOCUMENT SPECIFICATION
Document Size ................................................................ 4-1
Document Quality ............................................................ 4-2
ADF Document Feeder Capacity ..................................... 4-4
Areas not to be Perforated ............................................... 4-5
Grounding Color Areas .................................................... 4-6
Double Feed Detection Condition .................................... 4-7
Job Separation Sheet ...................................................... 4-8
❑❑
❑❑
❑CHAPTER 5 SCANNER SPECIFICATIONS
Basic Product Specification ............................................. 5-1
Installation Specification .................................................. 5-2
Dimensions ...................................................................... 5-3