Furniture of America CM-BK458Q User manual

EASY
The Assembly Rating is a 5-point system that
shows the degree of effort needed in
assembling a specific product (with 1 being
easy and 5 being difficult). For some
products, two persons are recommended.
Allen Wrench (Included)
Assembly Instructions
Tools Required for Assembly:
Rev.14-12-22
Page 1 of 8
DIFFICULT
ASSEMBLY RATING
CM-BK458Q
2 PERSONS RECOMMENDED
Phillips Screwdriver (Not Included)

Page 2 of 8

#4 x 1 pc
Upper Rt. End G/Rail
Parts List
#1 x 1 pc
Lower Lt. End G/Rail
#3 x 1 pc
Upper Lt. End G/Rail
#7 x 2 pcs
Guardrail Support
Before you begin, please read Page 2
for “Assembly and Care Advice” AND
Page 10 for “Safety Warnings”.
And remember, do not tighten until
each step is completed or instructed.
MD
Page 3 of 8
#9 x 1 pc
Left Ladder Rail
#6 x 4 pcs
Guardrail
#10 x 5 pc
Ladder Rung
#2 x 1 pc
Lower Rt. End G/Rail
#5 x 4 pcs
Side Rail
#8 x 1 pc
Right Ladder Rail
#11 x 1 pc
Support Rail
#14 x 1 set
Queen Slat Kit
#13 x 1 set
Twin Slat Kit (13 pcs)
#12 x 4 pcs
Support Leg

#D x 8 pcs
Screw 6.3x75mm
Hardware List
#A x 16 pcs
Bolt 1/4”x3-1/8”
#C x 1 pc
Z Allen Wrench
#I x 6 pcs
Screw 4x40mm
Page 4 of 8
#F x 4 pcs
Wood Pin
#B x 16 pcs
Side Rail Nut
#E x 16 pcs
Screw 6.3x50mm
#H x 15 pcs
Screw 4x30mm
Due to the size and/or weight of this product, it
is highly recommended that the assembly
should be done near the area of its intended
location. Make sure you have enough space to
move around during the assembly. ALWAYS
have at least two people to help with
transporting and assembling the product to
avoid any potential injury and/or damage.
#G x 16 pcs
Wood Dowel
Note: Right and left are
determined by facing the front
of the ladder or the front of the
bunk bed in its upright
position.
#J x 8 pc
Screw 4x20mm

Page 5 of 8
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#A x 8 pcs
#B x 8 pcs
#A x 8 pcs
#B x 8 pcs
#D x 8 pcs
#G x 16 pcs
#H x 6 pcs

Page 6 of 8
Turn right (clockwise) to tighten
#F x 4 pcs
#J x 8 pcs
#E x 10 pcs

Page 7 of 8
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#E x 6 pcs
#I x 6 pcs
#H x 15 pcs
ASSEMBLY IS COMPLETED
Safety is ALWAYS the main
priority. Please take the time to
inspect the assembly and FULLY
tighten all bolts/screws.
Read and follow the information on
the WARNINGS shown on the end
structure of the upper bunk and on
the carton. Do not remove warning
label from the bed. Keep these
instructions for future reference.

Page 8 of 8
Safety Warnings for Bunk Beds
1. Read and follow the information on the WARNINGS shown on the end
structure of the upper bunk and on the carton.
2. Do not remove warning label from the bed.
3. Keep these instructions for future reference.
4. Use only mattress which is 74” - 75” long and 37½” - 38½” wide with no
more than 6” thickness for the twin-size upper bunk. Use only mattress
which is 80” - 81” long and 60” - 61” wide with no more than 6” thickness for
the queen-size lower bunk.
5. Surface of mattress must be at least 5 inches (127 mm) BELOW the upper
edge of guardrails.
6. The MAXIMUM weight capacity for the upper bunk is not to exceed 150 lbs.
7. Do not allow persons under 6 years of age to use the upper bunk.
8. Periodically check and ensure that the guardrails, ladder, handle and other
components are in their proper position, free from damage, and that all
connectors are tightened and secured.
9. For safety reasons, especially on the upper bunk bed, DO NOT allow rough
playing or jumping on the bed and do not allow playing or hiding under the
bed.
10. Always use the ladder for entering and leaving the upper bunk.
11. Do not use substitute parts. Contact the manufacturer or dealer for
replacement parts.
12. Use of a nightlight may provide added safety precaution for a person using
the upper bunk.
13. Always use the guardrails on both long sides of the upper bunk. If the bunk
bed will be placed next to the wall, the guardrail that runs the full length of
the bed should be placed against the wall to prevent entrapment between
the bed and the wall.
14. The use of water or sleep flotation mattresses is prohibited.
15. No more than one person is allowed on the upper bunk at all times.
WARNING:
STRANGULATION HAZARD
Never attach or hang objects to any part of the bunk bed
that are not designed for use with the bed. Objects such as
hanger, hook, belt, bag, rope, string, etc. should not be used
on or around the bunk bed.