Furniture of America CM-BK607T User manual

EASY
The Assembly Rating is a 5-point system that
shows the degree of effort needed in
assembling a specific product (with 1 being
easy and 5 being difficult). For some
products, two persons are recommended.
Allen Wrench (Included)
Assembly Instructions
Tools Required for Assembly:
Rev.14-10-20
Page 1 of 10
DIFFICULT
ASSEMBLY RATING
CM-BK607T
2 PERSONS RECOMMENDED
Phillips Screwdriver (Not Included)

Page 2 of 10

#4 x 2 pcs
Front Side Rail
Parts List
#1 x 1 pc
Top Right End G/Rail
#3 x 2 pcs
Lower End Guardrail
#7 x 2 pcs
Front Guardrail
Before you begin, please read Page
2 for “Assembly and CareAdvice”
AND Page 10 for “Safety Warnings”.
And remember, do not tighten until
each step is completed or instructed.
MD
Page 3 of 10
#9 x 1 pc
Left Ladder Rail
#6 x 2 pcs
Rear Guardrail
#10 x 1 pc
Right Ladder Rail
#2 x 1 pc
Top Left End G/Rail
#5 x 2 pcs
Rear Side Rail
#8 x 2 sets
Slat (13 pcs)
#11 x 4 pcs
Ladder Rung
Note: Right and left are determined
by facing the front of the ladder of the
bunk bed in its upright position.

#D x 6 pcs
Screw M6x60mm
Hardware List
#A x 16 pcs
Bolt 1/4”x3-1/2”
#C x 8 pcs
Screw M6x40mm
#G x 4 pcs
Stud
Page 4 of 10
#F x 20 pcs
Wood Screw
#B x 6 pcs
Bolt 1/4”x1-1/2”
#E x 1 pc
Allen Wrench
#H x 16 pcs
Side Rail Bracket
Due to the size and/or weight of this product, it
is highly recommended that the assembly
should be done near the area of its intended
location. Make sure you have enough space to
move around during the assembly. ALWAYS
have at least two people to help with
transporting and assembling the product to
avoid any potential injury and/or damage.

Page 5 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#A x 8 pcs
#H x 8 pcs
#A x 8 pcs
#G x 4 pcs
#H x 8 pcs

Page 6 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#D x 4 pcs
#F x 8 pcs

Page 7 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#C x 8 pcs
#B x 6 pcs
#D x 2 pcs

Page 8 of 10
Turn right (clockwise) to tighten
#F x 6 pcs
#F x 6 pcs
Turn right (clockwise) to tighten

Page 9 of 10
Read and follow the information on the
WARNINGS shown on the end structure of
the upper bunk and on the carton. Do not
remove warning labels from the bed. Keep
the instructions for future reference.
Safety is ALWAYS the main priority. Before using the bunk
bed and for extra safety measures, please take the time to
inspect the assembly again and make sure ALL parts are
assembled correctly, ALL bolts/screws are FULLY
tightened and the bunk bed is stable and secure.
Must use Bunkie mattresses or Bunkie
boards (sold separately).
ASSEMBLY IS COMPLETED

Safety Warnings for Bunk Beds
1. Read and follow the information on the WARNINGS shown on the end
structure of the upper bunk and on the carton.
2. Do not remove warning label from the bed.
3. Keep these instructions for future reference.
4. IMPORTANT: Must use Bunkie mattress or Bunkie board. The proper
sizes for the UPPER/LOWER TWIN-SIZE Bunkie mattress or Bunkie board
should be 74” - 75” long and 37½” - 38½” wide with no more than 6”
thickness and for the UPPER/LOWER FULL-SIZE should be 74” - 75” long
and 53” - 54” wide with no more than 6” thickness.
5. Surface of mattress must be at least 5 inches (127 mm) BELOW the upper
edge of guardrails.
6. The MAXIMUM weight capacity for the upper bunk is not to exceed 150 lbs.
7. Do not allow children under 6 years of age to use the upper bunk.
8. Periodically check and ensure that the guardrails, ladder, handle and other
components are in their proper position, free from damage, and that all
connectors are tightened and secured.
9. DO NOT allow horseplay, rough playing or jumping on the beds and do not
allow playing or hiding under the beds.
10. Always use the ladder for entering or leaving the upper bunk.
11. Do not use substitute parts. Contact the manufacturer or dealer for
replacement parts.
12. Use of a nightlight may provide added safety precaution for a person using
the upper bunk.
13. Always use the guardrails on both sides of the upper bunk.
14. If the bunk bed will be placed next to a wall, the guardrail that runs the full
length of the bed should be placed against the wall to prevent entrapment
between the bed and the wall.
15. The use of water or sleep flotation mattresses is prohibited.
16. No more than one person is allowed on the upper bunk at all times.
WARNING:
STRANGULATION HAZARD
Never attach or hang objects to any part of the bunk bed
that are not designed for use with the bed. Objects such as
hanger, hook, belt, bag, rope, string, etc. should not be used
on or around the bunk bed.
Page 10 of 10