Gasmate FH209 User manual

1
FOR YOUR SAFETY
If you smell gas:
1. Shut off the gas to the appliance.
2. Extinguishanyopename.
3. If odour continues, immediately call
your gas supplier.
Donotstoreorusegasolineorotherammablevapour
andliquidsinthevicinityofthisoranyotherappliance.
WARNING:
Improperinstallation,adjustment,alteration,serviceor
maintenance can cause injury or property damage.
Readtheinstructionsthoroughlybeforeinstallingor
servicingthisequipment.
FOR OUTDOOR USE ONLY
PROPANE GAS
• The ideal solution for extending the season of outdoor
entertaining
• Maximum output 38MJ/h
• Adjustableheatoutput
• Operates for approximately 9 hours on a properly
lled9Kgpropanecylinder
• Includesasafety‘tip-over’switchthathaltssupplyof
gastotheunitshoulditbeaccidentallyknockedover
• Flame safeguard system for enhanced safety
• Durableandweatherresistant
• Completewithhoseandregulator
• For outdoor use only
• GascertiedtoAustralianstandards
03223 07/15
Important:Theinstallerorsellermustleavetheseinstructionswiththeconsumer.
Retain these instructions for future use

2
INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS
Priortoassemblingyourappliance,thefollowing
mustbereviewed.Compliancewiththefollowing
should result in satisfactory heater operation. This
instructionmanualshouldberetainedforfuture
reference.Theinstallationmustconformwith
localcodesorauthorityhavingjurisdiction.
1. The appliance is intended for heating
residential and non-residential outdoor spaces.
Theinstallationmustconformwithlocalcodes
or,intheabsenceoflocalcodes,withthe
Australian Standard AS 5601.
2. Adequate clearance around air openings
intothecombustionchamber,clearances
fromcombustiblematerials,provisionsfor
accessibilityandforcombustionandventilating
airsupplymustbemaintainedatalltimes
whentheapplianceisoperating.
3. Properclearancefromcombustiblematerials
mustbemaintainedatalltimes.Theminimum
clearancesareasfollows:
Minimum Clearance from Combustibles
Side 650 mm Rear 650 mm
Ceiling 800 mm
 Combustiblematerialsareconsideredtobe
wood,compressedpaper,plantbres,plastic,
plexiglasorothermaterialscapableofbeing
ignitedandburned.
 Suchmaterialsshallbeconsideredcombustible
eventhoughameproofed,re-retardant
treated or plastered. Additional clearance may
berequiredforglass,paintedsurfacesand
othermaterialswhichmaybedamagedby
radiantorconvectionheat.
4.Heatersmustbeplacedonaleveland
adequatefootingandbereadilyaccessible.
5. The gas manifold supply pressure must
beregulatedat2.75kPautilisinganAGA
approvedregulator(suppliedwithheater).
6.Theappliancemustbeinspectedbeforeeach
use,andatleastannuallybyaqualied
serviceperson.
a. Theapplianceareamustbekeptclearandfree
ofcombustiblematerials,gasolineandother
ammablevapoursandliquids.
b. Gasoricesandburnermustbekeptclear
ofdirtandcobwebs.Flowofcombustion
andventilationairthroughtheperforated
portionsoftheheatermustnotbeobstructed.
Cleaningwithasoftbrushbeforeuseandat
leasteverysixmonthsisrecommended.
c.Allgasconnectionsshouldbecheckedfor
leaksutilisingasoapsolution.NEVER use a
ameforthispurpose.
For any queries or assistance call
Customer Service
Australia Only
1300 174 876
Hours of operation:
Monday to Friday 8.30am - 5.30pm EST
Do not return to place of purchase.
Thisappliancemustonlybeusedinawell
ventilatedarea.
1. Thisapplianceshallnotbeinstalledor
usedindoors,inbuildings,garagesor
any other enclosed area.
2. DO NOT place articles on or against this
appliance.
3. DO NOTuseorstoreammable
materials near this appliance.
4. Childrenandadultsshouldbealerted
to the hazards of high surface
temperatures,burnsandclothing
ignition.
5. Childrenshouldbecarefullysupervised
whentheyareintheareaofthe
appliance.
6. NEVER hang anything including clothes
orotherammableitemsonthe
appliance.
7. DO NOT operate this appliance unless it
isfullyassembledwithburnerguardin
place.
8. DO NOT SPRAY AEROSOLS IN THE
VICINITY OF THIS APPLIANCE
WHILE IT IS IN OPERATION.
9. Installationandrepairshouldbedoneby
aqualiedserviceperson.Theappliance
mustbeinspectedbeforeuseandat
leastannuallybyaqualiedservice
person.Morefrequentcleaningmaybe
requiredasnecessary.Itisimperative
thatcontrolcompartment,burnersand
circulating air passages of the heater
andlightbekeptclean.
IMPORTANT SAFETY RULES

3
Screwthecouplingnutofregulatorintothe
cylindervalveoutlet.
(Cylindernotincluded)
POL CYLINDER CONNECTION DEVICE
Type of Gas Propane
Consumption 38 MJ/h
Operating Pressure 2.75kPa
Injector Size 1.8 mm
Heaterspecicationscanbefoundonthedata
label.
d.Theameshouldbevisuallycheckedwhenever
heaterisoperated.Ifamesextendbeyond
surfaceofthechimneyorblackspotis
accumulatingontheburnerorglass,the
heatershouldbeturnedoffimmediately.The
heatershouldnotbeoperatedagainuntilthe
unitisservicedandorrepaired.
e. Any cleaning agent used on the appliance
shouldbeofanon-combustibleandnon-
corrosivenature.
7.Thehoseassemblyshouldbeproperlylocated
outofpathwayswherepeoplemaytripover
it.Thehosemustbeprotectedfromcontact
withhotorsharpsurfacesbothduringuse
andwhileinstorage.Thehoseassembly
shouldbevisuallyinspectedpriortoeachuse
oftheheater.Ifexcessiveabrasionorwearis
evident,orthehoseiscut,itmustbereplaced
prior to operating the heater. The replacement
hoseassemblymaybeobtainedfromthe
manufacturer.
8. DO NOT use any pressure regulator or
hoseassemblyotherthanthosesupplied
withtheappliance.Replacementpressure
regulatorandhoseassemblymustbethose
specied.Replacementpartsmaybeobtained
from the manufacturer or your local sales
representative.
9. Installation and use of this appliance must
conformwithlocalcodesor,intheabsenceof
localcodes,withtheStandardsofStorageand
HandlingofLiqueedPetroleumGases.
10.Thisapplianceisdesignedtooperatewitha
standard9KgpropanecylinderwithApproved
Cylinder Connection.
11.Thevalveoutletmustbemaintainedingood
condition. When the cylinder is not in use,
besuretocoveritwithadustcap.Aleak
testshouldbeperformedwithsoapywater
wheneverconnectinganewcylinder.NEVER
useamatchtotestforleaks.
12.Thepropanecylindermustbeturnedoff
whenevertheheaterisnotinuse.Whenthe
heateristobestoredindoors,thepropane
cylinderandtheheatermustbedisconnected
andthecylinderstoredinaccordancewiththe
StandardforStorageandHandlingofLiqueed
Gases.(i.e.:Notindoors,butinadryandwell
ventilatedarea.)
13.Theheaterhasbeendesignedwithseveral
safetyfeatureswhichincludeatipoverswitch.
Anymodicationtotheheaternotdescribedin
the installation instructions may compromise the
safety of this appliance. Special concern is as
follows:
DO NOTbypassthermocouplesafety;
Clothingorotherammablematerialsshouldnot
behungfromtheheater,orplacedonornearthe
heater.Theareaabovemaybeextremelyhot.
Directcontactwiththesemetalsurfacesshould
beavoidedinordertopreventburnsorclothing
ignition.

4
PARTS LIST
1. Middle Plate
1pc
2. Control Box
1pc
3. Bottom Panel
1pc
4.LowerSupport
Leg 4pcs
80cm Long
RubberFoot
5. Upper Support
Post 4pcs
6. Upper Plate
1pc
7.LowerPlate
1pc
Pre-assembled
in Middle Plate
8.GlassTube
1pc
9. Radiant Head
1pc
Pre-assembled
in Upper Plate
10.Reector
1pc
11. Protection
Guard 4pcs
12. Guard Fixing
Bracket4pcs
13. Side Panel
3pcs
14. Front Panel
1pc
15.Screw
66pcs
Allpre-assembled
inrelativeparts
16.Knob
1pc
17. Chain
1pc
Pre-assembledin
thefrontknob
18. AA Battery
1pc
NOTINCLUDED
19. Wheels
2pcs
Screws&washers
attached

5
ASSEMBLY INSTRUCTIONS
Note:Removeanytransitprotectionmaterial.
Tools required
Phillipsheadscrewdriverand2adjustable
spanners.
STEP 1
Thelowersupportleghasarubberfootatthe
bottom.Removethevescrewsfromeachleg,
usingthemtoattachthebottompanelandmiddle
plate from the inside.
Ensure the magnets on the side of the middle
platearealignedwiththe‘T’shapedholesonthe
sideofthebottompanel.
STEP 2
Removethescrewsfromeachoftheupper
support posts, using them to attach to the middle
plate from the inside.
Removethescrewsfromtheradianthead,using
them to attach it to the upper posts from the
outside.
STEP 3
Laytheframedownandattachthewheelswith
thefastenersremovedfromthem.

6
STEP 4
Attachthecontrolboxtotheundersideofthe
middleplatewiththecontrolsfacingthemagnets,
using4screwsfromunderneath.
Unscrewandremovetheignitercap,inserta‘AA’
batterywiththe+facingoutwards,thenre-attach
the cap.
STEP 5
Carefullyslidetheglasstubeupintotheradiant
head,ensuretherubberringislocatedatthe
bottomofthetubeandloweritintotheholein
the middle plate.

7
STEP 6
Attachthereectortothe
studs on the radiant head
usingthewashersandwing
nuts supplied.
STEP 7
Attachthesideandback
panelsusingthe4screws
supplied per panel.

8
STEP 9
Attachtheknobtotheoutside
topofthedoorpanelwith
the chain on the inside. The
benttabsatthebottomare
positionedintothe‘T’shaped
holesinthebottompaneland
heldatthetopwithmagnets.
STEP 8
Attachtheguardsbyaligning
thehookswiththeslotsin
the upper support posts and
secureatthetopwiththe
bracketandscrewsupplied.

9
OUTDOOR FLAME HEATER - FOR OUTDOOR USE ONLY
Minimum Clearance from Combustible Surfaces*:
*Combustiblematerialsareconsideredtobewood,compressedpaper,plantbres,plasticorother
materialsthatarecapableofbeingignitedandburned.
1800mm 800mm
Hose connection point 700mm
650mm

10
OPERATION
LIGHTING INSTRUCTIONS
Step 1
EnsurethatthecontrolknobisOFF.Slowlyopen
thegascylindervalve.
Step 2
PressandturnthecontrolknobtoLIGHTposition,
pushtheignitertogeneratesparkwhilekeeping
controlknobpressedin.
Step 3
Checkforthepilotamethroughglasstube.
Ifpilotdoesnotlight,turncontrolknobtoOFF
position,waittwominutesminimumandtry
again.Severalattemptsmaybenecessary.
Step 4
Ifthepilotsalight,keepthecontrolknobpressed
for15secondsthenturnthecontrolknobtoLOW.
Step 5
FormaximumheatturncontrolknobtoHIGH.
Step 6
Toturnheateroff,turnthecontrolknobtoOFF.
Step 7
Closethevalveofthegascylinderclockwiseto
OFF after use.
Connect the
hose to the hose
connector on the
underside of the
controlbox.
Inserta‘AA’battery
withthe‘+’facing
outwards.
• Neverusetheheaterwhileitisraining,theglasstubewillbreak.
• Theglasstubewillbeextremelyhotwhenoperating,nevertrytotouchitandkeepchildrenaway
from the heater.
• Alwaysensuretheheaterisseatedrmly,theglasstubemaybreakiftheheaterfalls.
• Neverusetheheateriftheglasstubehasanycrackordamage.
• THEGUARDISFITTEDTOTHISAPPLIANCETOREDUCETHERISKOFFIREORINJURYFROM
 BURNSANDNOPARTOFITSHOULDBEREMOVED.
• ANYGUARDOROTHERPROTECTIVEDEVICEREMOVEDFORSERVICINGTHEAPPLIANCEMUSTBE
 REPLACEDPRIORTOOPERATINGTHEAPPLIANCE.
WARNING

11
TROUBLE SHOOTING
Problem Possible Causes Solution
Mainburner
willnotlight
GasvalvemaybeOFF TurnthegasvalveON
LPG cylinder empty RellLPGcylinder
Oriceblocked Cleanorreplaceorice
Air in supply system Purge air from lines
Loose connection Checkallttings
Pilotwillnot
stay on
Debrisaroundpilot Clean dirty area
Loose connection Checkallttings
Thermocouple faulty Replace thermocouple
Gasleakinline Checkconnections
Lackofgaspressure LPG cylinder is near empty
Gaspressureislow LPG cylinder is near empty
Oriceblocked Remove,cleanandreplace
ControlknobnotON TurnknobtoON
Thermocouple faulty Replace thermocouple
Pilotlightassemblybentornotincorrect
location
Place pilot light in correct position and
retry
Note:Anyrepairstotheheatermustbecarriedoutbyaqualiedperson.

12
SAFE APPLIANCE LOCATIONS
Thisapplianceshallonlybeusedinanabovegroundopen-airsituationwithnaturalventilation,
withoutstagnantareas,wheregasleakageandproductsofcombustionarerapidlydispersedby
windandnaturalconvection.
Any enclosure in which the appliance is used shall comply with one of the following:
 Anenclosurewithwallsonallsides,butatleastonepermanentopeningatgroundleveland
 nooverheadcover(seeExample1).
 Withinapartialenclosurethatincludesanoverheadcoverandnomorethantwo
 walls(seeExample2&3).
Within a partial enclosure that includes an overhead cover and more than two walls, the
following will apply:
atleast25%ofthetotalwallareaiscompletelyopen,and
atleast30%oftheremainingwallareaisopenandunrestricted(seeExample4&5).
Inthecaseofbalconies,atleast20%ofthetotalwallareashallbeandremainopenand
unrestricted.
Thefollowingguresarediagrammaticalrepresentationsofoutdoorareas.Rectangularareashavebeen
usedinthesegures-thesameprinciplesapplytoanyothershapedarea.