Hearth and Home Technologies Simplifyre SFE-35 Installation instructions

1 +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
TM
Model: SFE-35
BUILDER BOX
INSTALLER/CONSUMER SAFETY
INFORMATION
PLEASE READ THIS MANUAL BEFORE
INSTALLING AND USING APPLIANCE.
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
EXACTLY, AN ELECTRICAL SHOCK
OR FIRE MAY RESULT, CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE
OR OTHER FLAMMABLE VAPORS
AND LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER APPLIANCE.
SERVICE MUST BE PERFORMED BY
A QUALIFIED SERVICE AGENCY.
Homeowner’s Installation & Operating Manual
Note: 7KH GHYLFH FRPSOLHV ZLWK 3DUW  RI WKH )&& 5XOHV
2SHUDWLRQLVVXEMHFWWRWKHIROORZLQJWZRFRQGLWLRQV
 7KLVGHYLFHPD\QRWFDXVHKDUPIXOLQWHUIHUHQFHDQG
 7KLVGHYLFHPXVWDFFHSWDQ\LQWHUIHUHQFHUHFHLYHGLQFOXGLQJ
LQWHUIHUHQFHWKDWPD\FDXVHXQGHVLUHGRSHUDWLRQ
ANSI / UL 2021. Fixed or location dedicated electric room heater.
Installer: do not discard this manual -- leave for home owner
TUV Listed as SFE-35
US
C

2 +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
Congratulations!
&RQJUDWXODWLRQVRQVHOHFWLQJD6LPSOLI\UHHOHFWULF¿UHSODFH
7KHXQLW\RXKDYHVHOHFWHGLVGHVLJQHGWRSURYLGHWKHXWPRVW
LQVDIHW\UHOLDELOLW\DQGHI¿FLHQF\
$V WKH RZQHU RI D QHZ ¿UHSODFH \RX¶OO ZDQW WR UHDG DQG
FDUHIXOO\ IROORZ DOO RI WKH LQVWUXFWLRQV FRQWDLQHG LQ WKLV
RZQHU¶V PDQXDO 3D\ VSHFLDO DWWHQWLRQ WR DOO FDXWLRQV DQG
ZDUQLQJV
7KLVRZQHU¶VPDQXDOVKRXOGEHUHWDLQHGIRUIXWXUHUHIHUHQFH
:HVXJJHVW\RXNHHSLWZLWK\RXURWKHULPSRUWDQWGRFXPHQWV
DQGSURGXFWPDQXDOV
TABLE OF CONTENTS
1 Important Instructions 3
$ 8QSDFNLQJWKH8QLW  
% /RFDWLQJ<RXU(OHFWULF)LUHSODFH  
& &OHDUDQFHWR&RPEXVWLEOHV 
' )UDPLQJ 
( (OHFWULFDO6SHFL¿FDWLRQV 
) +DUGZLUH(OHFWULFDO&RQQHFWLRQV 
* :DOO6ZLWFKDQG7KHUPRVWDW&RQQHFWLRQV 
+ )LQLVKLQJ  
2 Fireplace Dimensions 5
3 Operating Instructions 6
$ 5HPRWH&RQWURO 
% 5HPRWH&RQWURO,QLWLDOL]DWLRQ 
& &RQWURO8VDJH 
4 Electrical Wiring 7
5 Service Instructions 7
$ 5HSODFLQJWKH/LJKW%XOE 
% 6FUHHQ&OHDQLQJ 
& 0DLQWHQDQFHRI0RWRUV 
' 5HVHWWLQJWKH7HPSHUDWXUH&XWRXW6ZLWFK 
6 Replacement Parts List 8
7 Warranty 9
3OHDVHUHDGWKHLQVWDOODWLRQRSHUDWLRQLQVWUXFWLRQVEHIRUH
XVLQJWKLVDSSOLDQFH
7KH LQIRUPDWLRQ FRQWDLQHG LQ WKLV RZQHU¶V PDQXDO XQOHVV
QRWHGRWKHUZLVHDSSOLHVWRDOOPRGHOV
<RXUQHZ6LPSOLI\UHHOHFWULF¿UHSODFHZLOOJLYH\RX\HDUVRI
GXUDEOHXVHDQGWURXEOHIUHHHQMR\PHQW
:HOFRPH WR WKH +HDUWK  +RPH 7HFKQRORJLHV IDPLO\ RI
¿UHSODFHSURGXFWV

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
:KHQXVLQJHOHFWULFDOKHDWHUVEDVLFSUHFDXWLRQVVKRXOGDOZD\VEHIROORZHGWRUHGXFHWKHULVNRI¿UHHOHFWULFVKRFNDQG
LQMXU\WRSHUVRQVLQFOXGLQJWKHIROORZLQJ
 7R SUHYHQW D SRVVLEOH ¿UH GR QRW EORFN DLU LQWDNHV RU
H[KDXVWLQDQ\PDQQHU
 $KHDWHUKDVKRWDQGDUFLQJRUVSDUNLQJSDUWVLQVLGH'R
QRWXVHLWLQDUHDVZKHUHJDVROLQHSDLQWRUÀDPPDEOH
OLTXLGVDUHXVHGRUVWRUHG
 8VH WKLV KHDWHU RQO\ DV GHVFULEHG LQ WKLV PDQXDO$Q\
RWKHUXVH QRW UHFRPPHQGHGE\ WKH PDQXIDFWXUHUPD\
FDXVH ¿UHHOHFWULFVKRFNRULQMXU\WRSHUVRQV
 $OZD\V XVH SURSHUO\ JURXQGHG IXVHG DQG SRODUL]HG
RXWOHWV
 $OZD\V XVH JURXQG IDXOW SURWHFWLRQ ZKHUH UHTXLUHG E\
electrical code.
 $OZD\VGLVFRQQHFWSRZHUEHIRUHSHUIRUPLQJDQ\FOHDQLQJ
PDLQWHQDQFHRUUHORFDWLRQRIWKHKHDWHU
 7R SUHYHQW D SRVVLEOH ¿UH GR QRW EXUQ ZRRG RU RWKHU
materials in this heater.
 7RSUHYHQWHOHFWULFVKRFNRU¿UHDOZD\VXVHDFHUWL¿ed
HOHFWULFLDQVKRXOGQHZFLUFXLWVRURXWOHWVEHUHTXLUHG
 :KHQWUDQVSRUWLQJ RU VWRULQJWKH KHDWHUNHHS LQDGU\
SODFH IUHH IURP H[FHVVLYH YLEUDWLRQ DQG VWRUH WR DYRLG
damage.
 $YRLGWKHXVHRIDQH[WHQVLRQFRUGEHFDXVHWKHH[WHQVLRQ
FRUGPD\RYHU KHDW DQG FDXVH D ULVN RI ¿UH+RZHYHU
LI\RXKDYHWRXVHDQH[WHQVLRQFRUGWKHFRUGVKDOOEH
1R$:*PLQLPXPVL]HDQGUDWHGQRWOHVVWKDQ
ZDWWV
 6$9( 7+(6( ,16758&7,216 )25 )8785(
5()(5(1&(
 5HDGDOOLQVWUXFWLRQVEHIRUHXVLQJWKLVKHDWHU
 7KLVKHDWHULVKRWZKHQLQXVH7RDYRLGEXUQVGRQRWOHW
EDUHVNLQ WRXFK KRW VXUIDFHV ,ISURYLGHG XVHKDQGOHV
ZKHQPRYLQJ WKLV KHDWHU .HHS FRPEXVWLEOH PDWHULDOV
VXFKDVIXUQLWXUHSLOORZVEHGGLQJSDSHUVFORWKHVDQG
FXUWDLQVDZD\IURPVLGHVDQGUHDURIKHDWHUDQGDWOHDVW
LQPPIURPWKHIURQW
 ([WUHPHFDXWLRQLVQHFHVVDU\ZKHQDQ\KHDWHULVXVHG
E\RUQHDUFKLOGUHQRULQYDOLGVDQGZKHQHYHUWKHKHDWHU
LVOHIWRSHUDWLQJDQGXQDWWHQGHG
 $OZD\VXQSOXJKHDWHUZKHQQRWLQXVH
 'RQRWRSHUDWHDQ\KHDWHUZLWKDGDPDJHGFRUGRUSOXJ
RU DIWHU WKH KHDWHU PDOIXQFWLRQV KDV EHHQ GURSSHG RU
GDPDJHG LQ DQ\ PDQQHU 5HWXUQ KHDWHU WR DXWKRUL]HG
VHUYLFHIDFLOLW\IRUH[DPLQDWLRQHOHFWULFDORUPHFKDQLFDO
DGMXVWPHQWRUUHSDLU
 'RQRWXVHRXWGRRUV
 7KLV KHDWHU LV LQWHQGHG IRU XVH LQ EDWKURRPV ODXQGU\
DUHDVDQGVLPLODULQGRRUORFDWLRQV1HYHUORFDWHKHDWHU
ZKHUHLWPD\IDOOLQWRDEDWKWXERURWKHUZDWHUFRQWDLQHU
 'RQRWUXQFRUGXQGHUFDUSHWLQJ'RQRWFRYHUFRUGZLWK
WKURZUXJVUXQQHUVRUWKHOLNH$UUDQJHFRUGDZD\IURP
WUDI¿FDUHDVDQGZKHUHLWZLOOQRWEHWULSSHGRYHU'RQRW
coil cord.
 7RGLVFRQQHFWKHDWHUWXUQFRQWUROVWR³2))´WKHQUHPRYH
SOXJIURPRXWOHW
 'R QRW LQVHUW RU DOORZ IRUHLJQ REMHFWV WR HQWHU DQ\
YHQWLODWLRQ RU H[KDXVW RSHQLQJ DV WKLV PD\ FDXVH DQ
HOHFWULFVKRFNRU¿UHRUGDPDJHWKHKHDWHU
1Important Instructions
WARNING! Risk of Fire!
DO NOT:
 LQVWDOORURSHUDWHGDPDJHGKHDWHU
 PRGLI\KHDWHU
 RSHUDWH WKH KHDWHU ZLWKRXW IXOO\ DVVHPEOLQJ DOO
FRPSRQHQWV
7KHIROORZLQJDFWLRQVDUHVWULFWO\SURKLWHG
 ,QVWDOODWLRQRWKHUWKDQDVLQVWUXFWHGE\+HDUWK+RPH
7HFKQRORJLHV,QF
 ,QVWDOODWLRQ DQGRU XVH RI DQ\ FRPSRQHQW SDUW QRW
DSSURYHGE\+HDUWK+RPH7HFKQRORJLHV,QF
+HDUWK+RPH7HFKQRORJLHV,QFGLVFODLPVDQ\UHVSRQVLELOLW\
IRUDQGWKHZDUUDQW\DQGDJHQF\OLVWLQJZLOOEHYRLGHGE\WKH
DERYHDFWLRQV
WARNING! Improper installation, adjustment, altera-
tion, service or maintenance can cause injury or prop-
erty damage. 5HIHUWRWKHRZQHU¶VLQIRUPDWLRQPDQXDO
SURYLGHGZLWKWKLVKHDWHU)RUDVVLVWDQFHRUDGGLWLRQDO
LQIRUPDWLRQFRQVXOWDTXDOL¿HGLQVWDOOHUVHUYLFHDJHQF\RU
\RXUGHDOHU
NOTICE! 7KLV ¿UHSODFHLVQRWLQWHQGHGIRUXVHDVDSULPDU\
KHDWVRXUFHDQGVKRXOGQRWEHIDFWRUHGDVVXFKLQUHVLGHQWLDO
KHDWLQJFDOFXODWLRQV
WARNING! Risk of Electric Shock! 7KLVSURGXFWVKRXOG
QHYHUEHLQVWDOOHGQHDUZDWHU

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
A Unpacking the Unit
&DUHIXOO\UHPRYHSDFNDJLQJIURPWKHXQLW7KHIURQWVFUHHQ
LVKHOGLQSODFHZLWKIRXU3KLOOLSVKHDGVFUHZV7RUHPRYH
WKHVFUHHQH[WUDFWWKHVFUHZV*UDVSWKHVFUHHQIUDPHDQG
SXOORXW
B. Locating Your Electric Fireplace
<RXU QHZ HOHFWULF ¿UHSODFH PD\ EH LQVWDOOHG YLUWXDOO\
DQ\ZKHUHLQ\RXUKRPH+RZHYHUZKHQFKRRVLQJDORFDWLRQ
HQVXUHWKDWWKHJHQHUDOLQVWUXFWLRQVDUHIROORZHG)RUEHVW
UHVXOWVLQVWDOORXWRIGLUHFWVXQOLJKW
3RZHUVXSSO\VHUYLFHPXVWEHHLWKHUFRPSOHWHGRUSODFHG
ZLWKLQWKHKHDWHUSULRUWR¿QLVKLQJWRDYRLGUHFRQVWUXFWLRQ
3URWHFWLYHFRYHUPD\VWD\RQGXULQJIUDPLQJEXWPXVWEH
UHPRYHGEHIRUH¿nal ¿nishing. Once ¿nal ¿QLVKLQJKDVEHHQ
FRPSOHWHGWKHSURWHFWLYHFRYHUFDQEHXVHGWRSURWHFWWKH
KHDWHUXQWLO¿QDOLQVWDOODWLRQLVFRPSOHWH
C. Clearance to Combustibles
 6LGHV  LQPP
 )ORRU LQPP
 7RS LQPP
 %DFN LQPP
D. Framing
 &KRRVH D ILUHSODFH ORFDWLRQ DQG IUDPH DV VKRZQ LQ
)LJXUH
 )UDPHLQWKH¿UHSODFHZLWKDKHDGHUDFURVVWKHWRS
 ,WLVLPSRUWDQWWRDOORZIRU¿QLVKHGIDFHZKHQVHWWLQJWKH
GHSWKRIWKHIUDPH
 ,IDKHDUWKV\VWHPRUUDLVHGKHDUWKLVWREHLQVWDOOHGWKH
XQLW0867EHUDLVHGWRSURYLGHVHUYLFHDFFHVVDQGXVH
RIRSWLRQDOIURQWV
 7KH¿UHSODFHFDQQRZEHSRVLWLRQHGLQWKHRSHQLQJ
 /HYHOLWZLWKVKLPVLIQHFHVVDU\DQGDWWDFKWKHXQLWWRWKH
IUDPHXVLQJWKHQDLOLQJÀDQJHVSURYLGHG
F. Hardwire Electrical Connections
Note: $OO ZLULQJ PXVW EH FRPSOHWHG SULRU WR ¿nishing the
XQLW
)RUVXSSO\FRQQHFWLRQVXVH1R$:*RUODUJHUZLUHV8VH
FRSSHUZLUHRQO\&RQQHFWRQO\WRD$03EUDQFKFLUFXLW
$GHGLFDWHGFLUFXLWLVUHFRPPHQGHGDVRWKHUDSSOLDQFHVRQ
WKH FLUFXLW PD\ FDXVH WKH EUHDNHU WR WULS RU IXVH WR EORZ
ZKHQWKHKHDWHULVRSHUDWLQJ
 5HPRYHWKHVFUHZVVHFXULQJWKHMXQFWLRQEORFNFRYHU
 :LUHWRDSURSHUO\JURXQGHGYROW+]$03
FLUFXLW
 (QVXUHDOOMXQFWLRQEORFNFRQQHFWLRQVDUHWLJKW
 5HSODFHWKHFRYHUDQGUHWDLQLQJVFUHZV
 3OXJLQWKH,(&&SRZHUSOXJWRWKH,(&&
SRZHULQOHWORFDWHGRQWKHXSSHUULJKWVLGHRIWKHXQLW
 $OOFRPSRQHQWVDQGZLULQJPD\EHLQVSHFWHGE\UHPRYLQJ
WKHWRSLQWHUSDQHOWKURXJKWKH¿UHSODFHIURQWRSHQLQJ
G. Wall Switch and Thermostat Connections
7KH2SWLRQDO:DOO6ZLWFKFRQWDLQVWZRVLQJOHSROH
VZLWFKHV/(9,7216HULHVRUHTXDO
7KH2SWLRQDO:DOO7KHUPRVWDWLVDORZYROWDJHPHFKDQLFDO
W\SH&ROXPEXV(OHFWULF5.($$RUHTXDO
0D[LPXP UXQ GLVWDQFH LV  IW  P ZLWK  JDXJH
VROLGFRSSHUORZYROWDJHWKHUPRVWDWZLUH&RQQHFWSHUWKH
HOHFWULFDOZLULQJGLDJUDPRQSDJH
H. Finishing
&RPEXVWLEOHRUQRQFRPEXVWLEOHPDWHULDOVPD\EHXVHGWR
¿QLVKXSWRWKH¿UHSODFHRSHQLQJ
Note: HQVXUHWKDW\RXOHDYHDGHTXDWHURRPWRUHPRYHDQG
UHSODFHWKHIURQWVFUHHQRURSWLRQDOIURQW
WARNING! Do NOT use this appliance if any part has
been under water. ,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFH
WHFKQLFLDQWRLQVSHFWDQGWRUHSODFHDQ\SDUWRIWKHHOHFWUL
FDOV\VWHPLIQHFHVVDU\
E. Electrical Speci¿cations
 9ROWDJH 9$&+]
 7RWDO$PSV$03
 7RWDO:DWWV :DWWV
 +HDWHU5DWLQJ:DWWV%78
WARNING! Electrical wiring must comply with local
building codes and other applicable regulations to
reduce the risk of ¿re, electrical shock and injury.
WARNING! Do NOT connect the optional low voltage
switch and/or thermostat to 120 volt branch circuit.

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
2Fireplace Dimensions
33.75 in.
85.7 cm
1/2 in. (13 mm)
L
48 in.
121.9 cm
34 in.
86.4 cm
Rough
Opening
Height
12.75 in.
32.4 cm
Rough
Opening
Depth
22 in.
55.9 cm
36.5 in.
92.7 cm
Rough Opening Width
30.5 in.
77.5 cm
33.6 in.
85.4 cm
35 in.
88.9 cm
Flush
Nailing Flange
Note: The bottom surface of this
fireplace must be elevated to the
level of the finished surface in
front of the fireplace to allow
access for service and the use
of optional fronts.
12.5 in.
31.8 cm
Unit Front
Unit Top
Note: Nailing flanges may be
hand-bent to accommodate framing
for different styles of optional
decorative fronts. Refer to decora-
tive front installation manuals for
details. If the fireplace will be inset,
add .5 in. (13 mm) to the framing
depth.
Figure 2.1 Fireplace Speci¿cations and Framing Dimensions

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
(QVXUHWKHDSSOLDQFHLVFRQQHFWHGWRDSURSHUO\JURXQGHGHOHFWULFDORXWOHWRQDPLQLPXP$03FLUFXLW,IDQHZRXWOHWLV
UHTXLUHGLWVKRXOGEHLQVWDOOHGE\DTXDOL¿HGHOHFWULFLDQDFFRUGLQJWRDSSOLFDEOHEXLOGLQJFRGHV
A. Remote Control
Note: ,IWKH¿UHSODFHGRHVQRWUHVSRQGWRWKHKDQGKHOGFRQWUROVHH³5HPRWH&RQWURO,QLWLDOL]DWLRQ´EHORZ
7KLVHTXLSPHQWKDVEHHQWHVWHGDQGIRXQGWRFRPSO\ZLWKWKHOLPLWVIRUFODVV%GLJLWDOGHYLFHSXUVXDQWWR3DUWRIWKH)&&
5XOHV7KHVHOLPLWVDUHGHVLJQHGWRSURYLGHUHDVRQDEOHSURWHFWLRQDJDLQVWKDUPIXOLQWHUIHUHQFHLQUHVLGHQWLDOLQVWDOODWLRQ7KLs
HTXLSPHQWJHQHUDWHVDQGXVHVDQGFDQUDGLDWHUDGLRIUHTXHQF\HQHUJ\DQGLIQRWLQVWDOOHGDQGXVHGLQDFFRUGDQFHZLWK
WKHLQVWUXFWLRQVPD\FDXVHKDUPIXOLQWHUIHUHQFHWRUDGLRFRPPXQLFDWLRQV+RZHYHUWKHUHLVQRJXDUDQWHHWKDWLQWHUIHUHQFH
ZLOOQRWRFFXULQDSDUWLFXODULQVWDOODWLRQ,IWKLVHTXLSPHQWGRHVFDXVHKDUPIXOLQWHUIHUHQFHWRUDGLRRUWHOHYLVLRQUHFHSWLRQ
ZKLFKFDQEHGHWHUPLQHGE\WXUQLQJWKHHTXLSPHQWRIIDQGRQWKHXVHULVHQFRXUDJHGWRWU\WRFRUUHFWWKHLQWHUIHUHQFHE\
RQHRUPRUHRIWKHIROORZLQJPHDVXUHV
 5HRULHQWRUUHORFDWHWKHUHFHLYLQJDQWHQQD
 ,QFUHDVHWKHVHSDUDWLRQEHWZHHQWKHHTXLSPHQWDQGUHFHLYHU
 &RQQHFWWKHHTXLSPHQWLQWRDQRXWOHWRQDFLUFXLWGLIIHUHQWIURPWKDWWRZKLFKWKHUHFHLYHULVFRQQHFWHG
 &RQVXOWWKHGHDOHURUDQH[SHULHQFHGUDGLR79WHFKQLFLDQIRUKHOS
B. Remote Control Initialization
7KLVSURFHGXUHLVUHTXLUHGRQO\ZKHQWKHXQLWLVLQVWDOOHGRU
WKHWUDQVPLWWHULVUHSODFHGDQGLVQRWDIIHFWHGE\WKHORVVRI
SRZHU
 (QVXUH WKDW SRZHU LV VXSSOLHG WKURXJK PDLQ VHUYLFH
SDQHO
 3ODFHIUHVKEDWWHULHVLQWKHWUDQVPLWWHU
 $FFHVV WKH /($51 EXWWRQ E\ UHPRYLQJ WKH IURQW
screen.
 3UHVVDQGKROGGRZQ WKH OHDUQ EXWWRQ<RXZLOOKHDU D
EHHS
 3UHVVDEXWWRQRQWKHKDQGKHOGWUDQVPLWWHU
 5HOHDVHWKHOHDUQEXWWRQZKHQ\RXKHDUWKHORQJEHHS
 7KLV FRPSOHWHV WKH UHPRWH FRQWURO UHFHLYHUWUDQVPLWWHU
LQLWLDOL]DWLRQ
C. Control Usage
7KHFRQWUROVRSHUDWHWKH¿UHSODFHPRGHV
 7KHÀDPHHIIHFWDQGEDFNORJHPEHUVDUHWXUQHG212))
E\DOWHUQDWHDFWLRQRIWKH)/$0(EXWWRQRQWKHUHPRWH
transmitter.
 7KHKHDWHUEORZHUDQGIURQWHPEHUVDUHWXUQHG212))
E\DOWHUQDWHDFWLRQRIWKH+($7(5EXWWRQRQWKHUHPRWH
transmitter.
 7KH RSWLRQDO ZDOO )/$0( VZLWFK SURYLGHV PDQXDO
RSHUDWLRQ212))RIWKHÀDPHHIIHFW
 7KHRSWLRQDOZDOO+($7VZLWFKFRQWUROVWKHIURQWHPEHUV
DQGDFWLYDWHVWKHRSWLRQDOUHPRWHZDOOWKHUPRVWDW
 6HWWKHWKHUPRVWDWWRWKHGHVLUHGURRPWHPSHUDWXUH
7KH RSWLRQDO ZDOO VZLWFKHVWKHUPRVWDW DUH LQ SDUDOOHO ZLWK
WKHUHPRWHFRQWUROUHOD\V7KHZDOOVZLWFKHV0867EH2))
IRUWKH5HPRWH7UDQVPLWWHUWRFRQWUROWKH¿UHSODFH
1RWH:KLOHWKHKHDWHULV21WKHHPEHUVLQIURQWZLOOJORZ
(QVXUHWKHKHDWHULV2))ZKHQXQDWWHQGHG
Learn Button
FLAMES
HEATER
3OPERATING INSTRUCTIONS

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
4Electrical Wiring
Projector
Lamp
S7
X1
Motor
Interlock on
Media Cabinet only
Power Supply Module
Hot Line
Ground
Neutral
Branch Circuit
12 VOC
Power
Supply
Heater
Motor
Hi Limit
Heater-Blower Heat Indicator
LED LED LED
LED LED LED
Ember Bed & Back Log
4050-310
Wall Thermostat
4050-309
Wall Switch
Flame
Heat
Terminal Strip ON
RD
WH
WH
RD
Remote Receiver
Flame
Heat
NEMA-5 IEC 320 C13/C14
M
M
P1
1
5
R2
R1
D1
J1
5Service Instructions
A. Replacing the Light Bulb
7KLVDSSOLDQFHXVHVDVLQJOH9ROW:DWW05EXOE
7KHEXOELVORFDWHGEHKLQGWKHVPRNHVKLHOG
$ VSDUH LV SURYLGHG ZLWK WKH XQLW 5HSODFHPHQW EXOEV
3DUW1R  DUHDYDLODEOH WKURXJK \RXU6LPSOLI\UH
dealer.
 7XUQRIISRZHUWRWKHXQLWDWWKHPDLQVHUYLFHSDQHO
 /HWWKH¿UHSODFHFRROLILWKDVEHHQRSHUDWLQJ
 5HOHDVHWKHVSULQJSLQVDQGUHPRYHWKHXSSHUVKLHOG
 5HPRYHWKHWZRVFUHZVRQWKHSURMHFWRUEDVNHW
 5RWDWHWKHKRXVLQJGRZQWRDFFHVVWKHEXOE
 5HPRYHWKHVFUHZVKROGLQJWKHEXOEDQGVRFNHW
 8QSOXJWKHEXOEIURPWKHVRFNHW
 5HSODFHWKHEXOE
 5HDVVHPEOHLQWKHUHYHUVHRUGHU
B. Screen Cleaning
'XULQJ VKLSPHQW LQVWDOODWLRQ KDQGOLQJ HWF WKH VFUHHQ
VXUIDFHPD\FROOHFWGXVWSDUWLFOHVWKHVHFDQEHUHPRYHG
E\OLJKWO\ZLSLQJZLWKDFOHDQGU\FORWK
C. Maintenance of Motors
7KHPRWRUVXVHGRQWKHIDQDQGÀDPHSURMHFWRUDVVHPEO\
DUHSUHOXEULFDWHGIRUH[WHQGHGEHDULQJOLIHDQGUHTXLUHQR
IXUWKHU OXEULFDWLRQ +RZHYHU SHULRGLF FOHDQLQJYDFXXPLQJ
RIWKHIDQKHDWHUXQLWLVUHFRPPHQGHG
D. Resetting the Temperature Cutout Switch
The heater on this ¿UHSODFHLVSURWHFWHGZLWKDVDIHW\GHYLFH
WR SUHYHQW RYHUKHDWLQJ 6KRXOG WKH KHDWHU RYHUKHDW DQ
DXWRPDWLFFXWRXWZLOOWXUQ2))WKHKHDWHUEORZHU7KHVZLWFK
LVUHVHWE\WXUQLQJWKHXQLW2))ZDLWLQJPLQXWHVDQG
VZLWFKLQJWKHXQLWEDFN21
WARNING! Disconnect power at circuit breaker before
attempting any maintenance or cleaning to reduce the
risk of ¿re, electrical shock or personal injury.

  +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
E. Optional Wall Switch / Thermostat Wiring
Connections instructions
7KHRSWLRQDOZDOOVZLWFKDQGWKHUPRVWDWZLULQJLVORZYROWDJH
DQGPXVWEHVHSDUDWHGIURPSRZHUZLULQJ'RQRWFRQQHFW
WKHVZLWFKHVRUWKHUPRVWDWWRKRXVHSRZHU
To control Àames/ember bed with a switch, and
control the heater with a thermostat:
 6ZLWFKWXUQVÀDPHVHPEHUEHG212))
 6ZLWFK   WXUQV IURQW HPEHUV 212)) LQGLFDWLQJ WKH
KHDWHUIDQ LV EHLQJ FRQWUROOHG E\ WKH WKHUPRVWDW 8/
UHTXLUHPHQW
 7KHUPRVWDWWXUQVKHDWHUIDQ212))DVURRPWHPSHUDWXUH
UHTXLUHVLW
 6ZLWFKEHWZHHQWHUPLQDODQG
 6ZLWFKEHWZHHQWHUPLQDODQG
 7KHUPRVWDWEHWZHHQWHUPLQDODQG
To control Àames/ember bed with one switch and
heater/front embers with another switch:
 6ZLWFKWXUQVÀDPHVHPEHUEHG212))
 6ZLWFKWXUQVKHDWHUIURQWHPEHUV212))
 6ZLWFKEHWZHHQWHUPLQDODQG
 6ZLWFKEHWZHHQWHUPLQDODQG
 -XPSHUZLUHEHWZHHQWHUPLQDODQG
To control the ¿replace with a single switch:
ÀDPHVHPEHUEHGDQGKHDWHUIURQWHPEHUVDOORQRUDOORII
 6ZLWFKEHWZHHQWHUPLQDODQG
 -XPSHUZLUHEHWZHHQWHUPLQDODQG
 -XPSHUZLUHEHWZHHQWHUPLQDODQG

 +HDUWK+RPH7HFKQRORJLHV,QF6)(5HY&
7Warranty
:DUUDQW\
+HDUWK  +RPH 7HFKQRORJLHV ,QF ++7 (OHFWULF )LUHSODFHV DUH WHVWHG DQG LQVSHFWHG SULRU WR VKLSPHQW DQG DUH
JXDUDQWHHGIURPGHIHFWWRWKHSXUFKDVHURIHDFKQHZSURGXFW$Q\SDUWZKLFKSURYHVWREHGHIHFWLYHLQPDWHULDORU
ZRUNPDQVKLSXQGHUQRUPDOXVHZLWKLQRQH\HDUZLOOEHUHSDLUHGRUUHSODFHGZLWKRXWFKDUJH7KH&RPSDQ\ZLOOQRW
EH UHVSRQVLEOH IRU DQ\ H[SHQVH LQFXUUHG IRU LQVWDOODWLRQ UHPRYDO IURP VHUYLFH RU WUDQVSRUWDWLRQ FRVWV $Q\ VXFK
GHIHFWVKRXOGEHEURXJKWWRWKHDWWHQWLRQRIWKH'HDOHUZKHUHWKHSURGXFWZDVSXUFKDVHGDQGLVDXWKRUL]HGWRUHSDLU
RUUHSODFHZLWKLQWKHWHUPVRIWKLVZDUUDQW\
7KH &RPSDQ\¶V RQO\ REOLJDWLRQ XQGHU WKLV ZDUUDQW\ ZLOO EH DW LWV VROH RSWLRQ WR UHSDLU RU UHSODFH DQ\ SDUW SURYLQJ
GHIHFWLYHRUWRUHIXQGWKHSXUFKDVHSULFHWKHUHRI
7KHRZQHUXVHUDVVXPHVDOORWKHUULVNVLIDQ\LQFOXGLQJWKHULVNRIDQ\GLUHFWLQGLUHFWRUFRQVHTXHQWLDOORVVRUGDPDJH
DULVLQJRXWRIWKHXVHRIRULQDELOLW\WRXVHWKHSURGXFW
7KHZDUUDQW\ZLOOQRWDSSO\LILQWKHVROHMXGJHPHQWRIWKH&RPSDQ\GDPDJHRUIDLOXUHKDVUHVXOWHGIURPDFFLGHQW
DOWHUDWLRQPLVXVHDEXVHLQFRUUHFWLQVWDOODWLRQRURSHUDWLRQRQDQLQFRUUHFWSRZHUVRXUFH
7KHIRUHJRLQJLVLQOLHXRIDOORWKHUZDUUDQWLHVH[SUHVVHGLPSOLHGRUVWDWXWRU\DQGWKH&RPSDQ\QHLWKHUDVVXPHVQRU
DXWKRUL]HVDQ\SHUVRQWRDVVXPHIRULWDQ\RWKHUREOLJDWLRQRUOLDELOLW\LQFRQQHFWLRQZLWKVDLGSURGXFW
/LJKWEXOEVDUHQRWFRYHUHGLQWKHZDUUDQW\
How to Obtain Service.
7RREWDLQVHUYLFHXQGHUWKLVZDUUDQW\\RXPXVW
 6HQGZULWWHQQRWLFHRIWKHFODLPHGFRQGLWLRQWR+HDWLODWRU7HFKQLFDO6HUYLFH'HSDUWPHQW+HDUWK+RPH7HFKQRORJLHV
,QF:6DXQGHUV6W0W3OHDVDQW,$
 3URYLGHSURRIRISXUFKDVHPRGHOQXPEHUVHULDOQXPEHUDQGPDQXIDFWXULQJGDWHFRGHWR++7
 3URYLGH ++7 UHDVRQDEOH RSSRUWXQLW\ WR LQYHVWLJDWH WKH FODLP LQFOXGLQJ UHDVRQDEOH RSSRUWXQLW\ WR LQVSHFW WKH
DSSOLDQFHSULRUWRDQ\UHSDLURUUHSODFHPHQWZRUNDQGEHIRUHWKH$SSOLDQFHRUDQ\FRPSRQHQWRIWKH$SSOLDQFHKDV
EHHQUHPRYHGIURPWKHSODFHRIRULJLQDOLQVWDOODWLRQ
 2EWDLQ++7¶VFRQVHQWWRDQ\ZDUUDQW\ZRUNEHIRUHWKHZRUNLVGRQH
ADDITIONAL INFORMATION. ,I\RXZRXOGOLNHLQIRUPDWLRQRQFXUUHQW++7SURGXFWVRUZDQWWRORFDWHDGHDOHULQ
\RXUDUHDFDOO
+HDWLODWRULVD5HJLVWHUHG7UDGHPDUNRI+HDUWK+RPH7HFKQRORJLHV,QF
TM