Hoist Fitness CF-3365 User manual

CF-3365
HALF RACK
A00
A00A00
A00
**WARNING!**
TO PREVENT POSSIBLE TIPPING, BOLT THIS UNIT TO THE EXERCISE
FLOOR USING MINIMUM 4-1/2” LENGTH BOLTS. FAILURE TO DO SO
MAY RESULT IN SERIOUS INJURY OR DEATH.

INSTRUCTIONS……………………………..…………………...
FRAME ASSEMBLY……………………..………..………….…
PRE-ASSEMBLY………………………………..……………….
DECAL PLACEMENT……………………….....………………..
DECAL REFERENCE………………...........….………….…….
PART LIST…………………………..……….…….…………..…
ABBREVIATIONS……………………..……….………….……..
BOLT SI ING CHART…………………………………………...
WASHER SI ING CHART…………….….…….……………....
MAINTENANCE SCHEDULE…………..………….………..….
GENERAL MAINTENANCE INFORMATION.............…….…
WEIGHT TRAINING TIPS…………………….……….………..
EXERCISE LOG…………………………………..……………...
LIMITED WARRANTY…………………………..……………….
02
04
21
28
31
33
36
37
38
40
41
42
43
44
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
CONTENTS
PAGE 01 CF-3365 ASSEMBLY

CF-3365 ASSEMBLY PAGE 02
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
INSTRUCTIONS
B for b ginning ass mbly pl as tak th tim to r ad instructions
thoroughly. Pl as us th various lists in this manual to mak sur that
all parts hav b n includ d in your shipm nt. Wh n ord ring, us part
numb r and d scription from th lists. Us only HOIST r plac m nt parts
wh n s rvicing. Failur to do so will void your warranty and could r sult
in p rsonal injury.
HOIST quipm nt is d sign d to provid th smooth st, most ff ctiv
x rcis motion possibl . Aft r ass mbly, you should ch ck all functions to
nsur corr ct op ration. If you xp ri nc probl ms, first r ch ck th
ass mbly instructions to locat any possibl rrors mad during ass mbly.
If you ar unabl to corr ct th probl m, call your authoriz d HOIST d al r.
B sur to hav your s rial numb r and this manual wh n calling. Wh n all
parts hav b n account d for, continu on.
TOOLS REQUIRED
Ratchet Wrench
1/2", 9/16" and 3/4" Sockets
Adjustable Wrench
Rubber Mallet
Tape Measure
Level
SAE Hex Key Wrench Set
Two People

PAGE 03 CF-3365 ASSEMBLY
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
***THIS PAGE WAS INTENTIONALLY LEFT BLANK***

OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
CF-3365 ASSEMBLY PAGE 04

PAGE 05 CF-3365 ASSEMBLY
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
NOTE:
- HAND TIGHTEN HARDWARE.
- SOME PARTS MAY HAVE BEEN REMOVED FOR CLARITY.
NOTE:
ENSURE ORIENTATION OF
FLANGE OFFSET AND
THREADED INSERTS AS
SHOWN BELOW.
THREADED INSERTS
SHOULD FACE TOWARDS
THE BACK OF THE UNIT

CR-3365 ASSEMBLY PAGE 06
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
NOTE:
- HAND TIGHTEN HARDWARE.
- SOME PARTS MAY HAVE BEEN REMOVED FOR CLARITY.
*BE SURE TO ALWAYS SUPPORT UPRIGHTS (11 & 12) THROUGH THE
FOLLOWING STEPS UNTIL ASSEMBLY IS SECURED. FAILURE TO FOLLOW
THESE DIRECTIONS MAY RESULT IN SERIOUS INJURY OR DEATH.*

PAGE 07 CF-3365 ASSEMBLY
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
NOTE:
- HAND TIGHTEN HARDWARE.
- SOME PARTS MAY HAVE BEEN REMOVED FOR CLARITY.
ENSURE MOUNTING TABS ON
ITEM 10 ARE ORIENTED AS
SHOWN (TOWARD V-GROOVE
WHEEL (50)).

CF-3365 ASSEMBLY PAGE 08
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
NOTE:
- HAND TIGHTEN HARDWARE.
- SOME PARTS MAY HAVE BEEN REMOVED FOR CLARITY.
- REPEAT ASSEMBLY FOR OPPOSITE SIDE (10 & 12).

PAGE 09 CF-3365 ASSEMBLY
OWNER’S MANUAL
OWNER’S MANUALOWNER’S MANUAL
OWNER’S MANUAL
FRAME ASSEMBLY
NOTE:.
- SOME PARTS MAY HAVE BEEN REMOVED FOR CLARITY
- SLIDE (13 & 14) DOWN (39), THEN ROTATE (13 & 14) TOWARD (4 ) TO LOCK IN PLACE.