IEI Technology IDS-330-ADL-P Series User manual

IDS-330-ADL-P
Page I
[MODEL NAME]
User Manual
Embedded System with Intel® Core® i5-1235U / i7-1255U,
8GB Memory Pre-installed, Dual 2.5GbE LAN,
Four HDMI, RS-232/422/485,12V DC and RoHS
MODEL:
IDS-330-ADL-P Series
Rev. 1.00 –January 30, 2023

IDS-330-ADL-P
Page II
[MODEL NAME]
Revision
Date
Version
Changes
January 30, 2023
1.00
Initial release

IDS-330-ADL-P
Page III
[MODEL NAME]
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

IDS-330-ADL-P
Page IV
[MODEL NAME]
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

IDS-330-ADL-P
Page V
[MODEL NAME]
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 FEATURE .................................................................................................................... 3
1.3 MODEL VARIATIONS ................................................................................................... 3
1.4 TECHNICAL SPECIFICATIONS ...................................................................................... 3
1.5 FRONT PANEL............................................................................................................. 5
1.6 REAR PANEL............................................................................................................... 5
1.7 LEFT SIDE PANEL ....................................................................................................... 6
1.8 PHYSICAL DIMENSIONS.............................................................................................. 7
2 UNPACKING................................................................................................................. 8
2.1ANTI-STATIC PRECAUTIONS........................................................................................ 9
2.2 UNPACKING PRECAUTIONS......................................................................................... 9
2.3 UNPACKING CHECKLIST........................................................................................... 10
3 INSTALLATION ......................................................................................................... 12
3.1 INSTALLATION PRECAUTIONS................................................................................... 13
3.2 COVER REMOVAL..................................................................................................... 14
3.3 STORAGE INSTALLATION .......................................................................................... 14
3.4 WI-FI MODULE INSTALLATION (OPTIONAL)............................................................. 15
3.5 COVER INSTALLATION.............................................................................................. 17
3.6 SYSTEM FAN INSTALLATION (OPTIONAL)................................................................. 17
3.7 EXTERNAL PERIPHERAL INTERFACE CONNECTORS................................................... 18
3.7.1 HDMI/DP Connector....................................................................................... 19
3.7.2 LAN Connectors............................................................................................... 19
3.7.3 Power Connector............................................................................................. 20
3.7.4 USB 3.2 Gen 2 (10Gb/s) Connectors............................................................... 21
3.7.5 RS-232/422/485 Serial Port Connection ......................................................... 22
3.7.6 ATX/AT Mode Selection ................................................................................... 23
3.8 POWERING ON/OFF THE SYSTEM ............................................................................. 23

IDS-330-ADL-P
Page VI
[MODEL NAME]
3.8.1 Installation Checklist....................................................................................... 23
3.8.2 Power-on Procedure ........................................................................................ 24
3.9 RESET THE SYSTEM.................................................................................................. 25
3.10 MAINTENANCE....................................................................................................... 25
3.10.1 Flash Descriptor Override Setting Jumper.................................................... 26
3.10.2 Clear CMOS Button....................................................................................... 27
3.11AVAILABLE DRIVERS .............................................................................................. 28
3.11.1 Driver Download............................................................................................ 28
4 SYSTEM MOTHERBOARD ..................................................................................... 30
4.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 31
4.1.1 Layout .............................................................................................................. 31
4.2 PERIPHERAL INTERFACE CONNECTORS..................................................................... 32
4.2.1 Battery Connector............................................................................................ 33
4.2.2 Fan Connector................................................................................................. 34
4.2.3 Power Button Connector.................................................................................. 35
4.2.4 EC Debug Connector....................................................................................... 36
4.2.5 EC Flash Connector ........................................................................................ 37
4.2.6 MPS PWM IC Programmer Connector ........................................................... 38
4.2.7 BIOS Programming Connector........................................................................ 39
4.2.8 System 80/81 Port Connector .......................................................................... 40
4.2.9 M.2 B-key Slot.................................................................................................. 41
4.2.10 M.2 M-key Slot............................................................................................... 43
4.2.11 M.2 E-key Slot ................................................................................................ 45
4.2.12 LT86101X IC Programmer Connector .......................................................... 47
4.2.13 SIM Card Slo t ................................................................................................ 48
5 BIOS.............................................................................................................................. 49
5.1 INTRODUCTION......................................................................................................... 50
5.1.1 Starting Setup................................................................................................... 50
5.1.2 Using Setup...................................................................................................... 51
5.1.2.1 Keyboard Navigation................................................................................ 51
5.1.2.2 Touch Navigation...................................................................................... 52
5.1.3 Getting Help..................................................................................................... 53
5.1.4 Unable to Reboot after Configuration Changes.............................................. 53

IDS-330-ADL-P
Page VII
[MODEL NAME]
5.1.5 BIOS Menu Bar................................................................................................ 53
5.2 MAIN........................................................................................................................ 54
5.3ADVANCED............................................................................................................... 57
5.3.1 CPU Configuration .......................................................................................... 58
5.3.2 Trusted Computing........................................................................................... 63
5.3.3 IT55771 Super IO Configuration..................................................................... 64
5.3.3.1 Serial Port 1 Configuration....................................................................... 65
5.3.4 IT5571 H/W Monitor........................................................................................ 66
5.3.4.1 Smart Fan Mode Configuration................................................................ 67
5.3.5 RTC Wake Settings........................................................................................... 68
5.3.6 Serial Port Console Redirection ...................................................................... 70
5.3.6.1 Console Redirection Settings.................................................................... 71
5.3.7 NVMe Configuration........................................................................................ 73
5.4 CHIPSET ................................................................................................................... 74
5.4.1 System Agent (SA) Configuration .................................................................... 75
5.4.1.1 Memory Configuration ............................................................................. 76
5.4.1.2 Graphics Configuration............................................................................. 78
5.4.2 PCH-IO Configuration .................................................................................... 79
5.4.2.1 PCI Express Configuration ....................................................................... 82
5.4.2.2 SATA Configuration.................................................................................. 84
5.4.2.3 HD Audio Configuration........................................................................... 86
5.5 SECURITY................................................................................................................. 87
5.6 BOOT........................................................................................................................ 89
5.6.1 Boot Configuration .......................................................................................... 89
5.6.2 Boot Option Priorities...................................................................................... 90
5.7 SAVE &EXIT............................................................................................................ 91
A REGULATORY COMPLIANCE.............................................................................. 93
B PRODUCT DISPOSAL.............................................................................................. 95
C BIOS OPTIONS.......................................................................................................... 97
D WATCHDOGTIMER .............................................................................................. 100
E ERROR BEEP CODE............................................................................................... 103
E.1 PEI BEEP CODES.................................................................................................... 104
E.2 DXE BEEP CODES ................................................................................................. 104

IDS-330-ADL-P
Page VIII
[MODEL NAME]
F HAZARDOUS MATERIALS DISCLOSURE........................................................ 105
F.1 ROHS II DIRECTIVE (2015/863/EU) ...................................................................... 106
F.2 CHINA ROHS.......................................................................................................... 107

IDS-330-ADL-P
Page IX
[MODEL NAME]
List of Figures
Figure 1-1: IDS-330-ADL-P Series Embedded System................................................................2
Figure 1-2: Front Panel ..................................................................................................................5
Figure 1-3: Top Panel.....................................................................................................................5
Figure 1-4: Left Side Panel ............................................................................................................6
Figure 1-5: Physical Dimensions ..................................................................................................7
Figure 3-1: Remove the Cover.....................................................................................................14
Figure 3-2: Inserting the M.2 Module into the Slot....................................................................15
Figure 3-3: Securing the M.2 Module..........................................................................................15
Figure 3-4: Inserting the WLAN Module.....................................................................................16
Figure 3-5: Securing the WLAN Module.....................................................................................16
Figure 3-6: Connecting RF Cables..............................................................................................16
Figure 3-7: Securing SMA Connector and External Antenna Installation ..............................17
Figure 3-8: Install the cover.........................................................................................................17
Figure 3-9: External Fan Module Installation.............................................................................18
Figure 3-10: HDMI/DP Connection ..............................................................................................19
Figure 3-11: LAN Connection......................................................................................................19
Figure 3-12: RJ-45 Ethernet Connector......................................................................................20
Figure 3-13: Power Connector ....................................................................................................20
Figure 3-14: USB Connection......................................................................................................21
Figure 3-15: DB-9 Serial Port Connector....................................................................................22
Figure 3-16: Serial Device Connection.......................................................................................22
Figure 3-17: ATX/AT Mode Selection..........................................................................................23
Figure 3-18: Power Connector ....................................................................................................24
Figure 3-19: Power Button...........................................................................................................24
Figure 3-20: Reset Button Location............................................................................................25
Figure 3-21: Flash Descriptor Override Setting Jumper Location ..........................................26
Figure 3-22: Clear CMOS Location .............................................................................................27
Figure 3-23: IEI Resource Download Center..............................................................................28
Figure 4-1: System Motherboard ................................................................................................31
Figure 4-2: Battery Connector Location.....................................................................................33

IDS-330-ADL-P
Page X
[MODEL NAME]
Figure 4-3: Fan Connector Location...........................................................................................34
Figure 4-4: Power Button Connector Location..........................................................................35
Figure 4-5: EC Debug Connector Location................................................................................36
Figure 4-6: EC Flash Connector Location..................................................................................37
Figure 4-7: MPS PWM IC Programmer Connector Location ....................................................38
Figure 4-8: BIOS Programming Connector Location................................................................39
Figure 4-9: System 80/81 Port Connector Location..................................................................40
Figure 4-10: M.2 B-key Slot Location..........................................................................................41
Figure 4-11: M.2 M-key Slot Location.........................................................................................43
Figure 4-12: M.2 E-key Slot Location..........................................................................................45
Figure 4-13: LT86101X IC Programmer Connector Location...................................................47
Figure 5-1: BIOS Starting Menu ..................................................................................................50
Figure 5-2: BIOS On-screen Navigation Keys ...........................................................................52

IDS-330-ADL-P
Page XI
[MODEL NAME]
List of Tables
Table 1-1: IDS-330-ADL-P Series Model Variations.....................................................................3
Table 1-2: Technical Specifications..............................................................................................4
Table 2-1: Packing List.................................................................................................................10
Table 2-2: Optional Items.............................................................................................................11
Table 3-1: RJ-45 Ethernet Connector LEDs...............................................................................20
Table 3-2: Power Connector Pinouts..........................................................................................20
Table 3-3: RS-232/422/485 Connector Pinouts ..........................................................................22
Table 3-4: Flash Descriptor Security Override Jumper Pinouts..............................................26
Table 3-5: Clear CMOS Pinouts...................................................................................................27
Table 4-1: Peripheral Interface Connectors...............................................................................32
Table 4-2: CMOS Battery Header Pinouts..................................................................................34
Table 4-3: CPU Fan Connector Pinouts .....................................................................................34
Table 4-4: Power Button Connector Pinouts.............................................................................35
Table 4-5: EC Debug Connector Pinouts ...................................................................................36
Table 4-6: EC Flash Connector Pinouts.....................................................................................37
Table 4-7: MPS PWM IC Programmer Connector Pinouts........................................................38
Table 4-8: BIOS Programming Connector Pinouts ...................................................................39
Table 4-9: System 80/81 Port Connector Pinouts .....................................................................40
Table 4-10: M.2 B-key Slot Pinouts.............................................................................................42
Table 4-11: M.2 M-Key Slot Pinouts............................................................................................44
Table 4-12: M.2 E-Key Slot Pinouts.............................................................................................46
Table 4-13: LT86101X IC Programmer Connector Pinouts.......................................................47
Table 4-14: SIM Card Slot Pinouts ..............................................................................................48
Table 5-1: BIOS Navigation Keys................................................................................................51
Table 5-2: BIOS Options and Configured USB Ports................................................................81

IDS-330-ADL-P
Page XII
[MODEL NAME]
BIOS Menus
BIOS Menu 1: Main (1/2)...............................................................................................................54
BIOS Menu 2: Main (2/2)...............................................................................................................54
BIOS Menu 3: Advanced..............................................................................................................57
BIOS Menu 4: CPU Configuration (1/3).......................................................................................58
BIOS Menu 5: CPU Configuration (2/3).......................................................................................59
BIOS Menu 6: CPU Configuration (3/3).......................................................................................60
BIOS Menu 7: PCH-FW Configuration........................................................................................63
BIOS Menu 8: IT5571 Super IO Configuration ...........................................................................64
BIOS Menu 9: Serial Port 1 Configuration Menu.......................................................................65
BIOS Menu 10: IT5571 H/W Monitor............................................................................................66
BIOS Menu 11: Smart Fan Mode Configuration ........................................................................67
BIOS Menu 12: RTC Wake Settings (1/2)....................................................................................68
BIOS Menu 13: RTC Wake Settings (2/2)....................................................................................69
BIOS Menu 14: Serial Port Console Redirection.......................................................................70
BIOS Menu 15: COM Console Redirection Settings .................................................................71
BIOS Menu 16: NVMe Configuration...........................................................................................73
BIOS Menu 17: Chipset................................................................................................................74
BIOS Menu 18: System Agent (SA) Configuration....................................................................75
BIOS Menu 19: Memory Configuration（1/2）..........................................................................76
BIOS Menu 20: Memory Configuration（2/2）..........................................................................77
BIOS Menu 21: Graphics Configuration.....................................................................................78
BIOS Menu 22: PCH-IO Configuration........................................................................................79
BIOS Menu 23: PCI Express Configuration ...............................................................................82
BIOS Menu 24: SATA Configuration...........................................................................................84
BIOS Menu 25: HD Audio Configuration....................................................................................86
BIOS Menu 26: Security (1/2).......................................................................................................87
BIOS Menu 27: Security (2/2).......................................................................................................88
BIOS Menu 28: Boot.....................................................................................................................89
BIOS Menu 29: Save & Exit..........................................................................................................91

IDS-330-ADL-P
Page 1
Chapter
1
1Introduction

IDS-330-ADL-P
Page 2
1.1 Overview
Figure 1-1: IDS-330-ADL-P Series Embedded System
The IDS-330-ADL-P Series is a fanless embedded system for wide range temperature
environments. It is powered by Intel® Alder Lake processor and on board 8 GB LPDDR4X
memory (up to 16GB). The IDS-330-ADL-P Series includes four HDMI, two 2.5GbE LAN,
one RS-232/422/485, four USB 3.2 Gen 2 ports, audio (line-out and mic-in) and one
external fan connector.

IDS-330-ADL-P
Page 3
1.2 Feature
The IDS-330-ADL-P Series features are listed below:
▪Fanless design
▪Intel® Core® i5-1235U (up to 4.4GHz, 10-core, TDP 15W)
Intel® Core® i7-1255U (up to 4.7GHz, 10-core, TDP 15W)
▪Four HDMI displays up to 4K resolution
▪2 x 2.5GbE LAN for high speed network applications
▪Four USB 3.2 Gen 2 ports
▪One RS-232/422/485 serial port with AFC (DB9)
▪Support audio line-out and mic-in
▪RoHS compliant design
1.3 Model Variations
The model variations of the IDS-330-ADL-P Series are listed in Table 1-1.
Model No.
CPU
IDS-330-ADL-P-i5C-R10
Intel® Alder Lake-P i5-1235U
IDS-330-ADL-P-i7C-R10
Intel® Alder Lake-P i7-1255U
Table 1-1: IDS-330-ADL-P Series Model Variations
1.4 Technical Specifications
The IDS-330-ADL-P Series technical specifications are listed in Table 1-2.
Model Name
IDS-330-ADL-P Series
Chassis
Color
Black
Dimensions (WxDxH) (mm)
176x115.6x55.2
System Fan
Fanless (Fan optional)
Chassis Construction
ABS Plastic + Aluminum
Motherboard
CPU
Intel® Core® i5-1235U (up to
Intel® Core® i7-1255U (up to

IDS-330-ADL-P
Page 4
Model Name
IDS-330-ADL-P Series
4.4GHz, 10-core, 15W TDP)
4.7GHz, 10-core, 15W TDP)
Chipset
SOC
Memory
Onboard LPDDR4X 8GB (up to 16GB)
Storage
Storage
1 x M.2 B key 3042/52/80 with SIM slot (PCIex1 / USB2.0 / SATA)
1 x M.2 M key 2280 (PCIe Gen4 x4)
IO Interfaces
USB
4 x USB 3.2 Gen 2
LAN
2 x 2.5GbE
Display
4 x HDMI 1.4b with CEC (up to 4096 x 2160@30Hz)
COM
1 x RS-232/422/485 with AFC (DB9)
TPM2.0
Support Intel PTT
Others
1 x Power Button, 1 x Reset Button, 1 x AT/ATX switch, 1 x Power LED
(green), 1 x HDD LED (yellow)
Expansions
M.2
1 x M.2 E key 2230 (PCIex1 / USB2.0) Support Vpro
Power
Power Input
DC jack: 12V DC
Power Consumption
[email protected] (Intel i7-1255U with 8GB DDR4 Memory)
Reliability
Mounting
Wall mount, VESA 75/100
Operating Temperature
-10°C ~ 40°C with airflow, 10% ~ 95% non-condensing
Storage Temperature
-20°C ~ 60°C with airflow, 10% ~ 95% non-condensing
Operating Shock
Half-sine wave shock 5G, 11ms, 100 shocks per axis
Operating Vibration
10-500 Hz, 1.04 Grms, random, 1 hr/axis
Weight（Net/Gross）
0.94 / 1.7 kg
Safety/EMC
CE / FCC / CB / BSMI
Watchdog Timer
Programmable 1 ~ 255 sec/min
OS
Supported OS
Microsoft® Windows® 10/11, Linux
Table 1-2: Technical Specifications

IDS-330-ADL-P
Page 5
1.5 Front Panel
The front panel of the IDS-330-ADL-P Series is shown below.
Figure 1-2: Front Panel
1.6 Rear Panel
The rear panel of the IDS-330-ADL-P Series is shown below.
Figure 1-3: Top Panel

IDS-330-ADL-P
Page 6
1.7 Left Side Panel
The left side panel of the IDS-330-ADL-P Series is shown below.
Figure 1-4: Left Side Panel

IDS-330-ADL-P
Page 7
1.8 Physical Dimensions
The physical dimensions are shown in Figure 1-5.
Figure 1-5: Physical Dimensions

IDS-330-ADL-P
Page 8
Chapter
2
2Unpacking