Intermatic AG2403C3 User manual

120/240 VAC Four wire plus Ground
High Leg Delta
Found in Main Disconnect Switches,
Main Distribution panels, Load Centers
Sub panels and equipment locations.
Line
Line
Line
Neutral
Ground
WHITE
BLACK
BLACK
RED
208 v
120 v
240 v
240 v
240 v
120 v
240 VAC Three wire plus Ground
Found at Service Entrances and
Meter Cabinets.
Line
Line
Line
Grounded Neutral
WHITE
BLACK
BLACK
RED
240 v
240 v
240 v
Model AG2403C3
Type 1 or Type 2 Surge Protection Device
INSTALLATION INSTRUCTIONS
120 v
208 v
120 v
Risk of Electric Shock
WARNING
• Thoroughlyreadinstructionsbeforeinstallingunit.
 • InstallationandServicetobeperformedbya 
  qualiedlicensedelectrician.
 • Intendedforindoororoutdooruse.
Type 1 installation:
Atypicalinstallationofatype1SPDwillbeconnectedbetweenthesecondaryoftheservicetransformerandthe
linesideoftheservicepanel.ThisinstallationisintendedtobeinstalledwithoutovercurrentprotectiontotheSPD.
Type 2 installation:
Atypicalinstallationofatype2SPDwillbeconnectedtotheloadsideoftheservicepanelandisintendedtobe
installedwithovercurrentprotectiontotheSPD.
 1. Determininglocation:
  • Ensureconductorlengthsareasshortandstraightaspossibleforbestperformance.Donotcoilexcess
   wire.TheSPDfunctionsbestifallbendsinwiresarerounded,ideallytoa4”radius.Hard90degreebend
   willreduceefciency.Cutallleadstothecorrectlength.Donotcoilexcessleads.
  • Installappropriateweatherproofttingsiftheunitistobemountedoutside.
  • BracketpartnumberAG1BRKTisalsoavailableifneeded.
 2. Connectwiresasshownwithindiagrams.Ifyourapplicationdoesnotmatchoneofthediagramsbelow
  consultyoursupplier.
 3. Ensureallmountingandelectricalconnectionsarecorrectandsecurelyfastened.Onceenergizedthegreen
  indicatorLEDwillbeON.
Maintenance:
¡ACVoltageSPD:
 • PeriodicallycheckSPDtoensuregreenindicatorLEDisON.IfgreenLEDisOFFprotectionhasdiminished
  andtheSPDshouldbereplacedimmediately.
120/240VAC HIGH LEG DELTA 3 PHASE
• Allwiringmustcomplywithallstateandlocal
 electricalcodesincludingtheNationalElectrical
 Codeand/orCanadianElectricalCode.
• Suitableforuseonacircuitcapableofdelivering
 notmorethan50,000rmssymmetricalamperes.
• Thisunitcontainsnoserviceableparts.
• Thisproductdoesnotprotectagainstdirect
 lightningstrikes.
IMPORTANT SAFETY INSTRUCTIONS • SAVE THESE INSTRUCTIONS
http://waterheatertimer.org/How-to-wire-3-phase-electric.html

158--00999
ONE YEAR LIMITED PRODUCT WARRANTY
For
INTERMATIC SURGE PROTECTIVE DEVICES
(1) What is Covered By This Limited Warranty
ReplacementofProduct
IntermaticIncorporated(“Intermatic”)warrantstotheoriginalpurchaseronly,IntermaticAGSeriesSurgeProtectiveDevices(eacha“Prod-
uct”)shallbefreefromdefectsinmaterialorworkmanshipforaperiodofoneyear(12months)fromdateofpurchaseor18monthsfrom
dateofmanufacture.Ifthepurchaserdiscoversadefectinmaterialorworkmanship,thepurchasermustpromptlysubmitawarrantyclaim.
UponadeterminationbyIntermaticthattheProductisdefective,Intermatic,atitssoleoptionshallcorrectanydefectinmaterialorwork-
manshipbyreplacingtheDefectiveProductatIntermatic’sexpense.Theforegoingremedyisthepurchaser’sexclusiveremedyforabreach
ofwarranty.
Theproductmustbeinstalledintheappropriateapplicationincompleteaccordancewiththeinstallationinstructions.Allbuildingwiringand
otherconnectionstotheProductmustconformtoallapplicablenational,state,andlocalelectricalcodes;theProductmustnotbeopened,
modied,exposedtoextremeheatorcold,submergedorsubjectedtoabnormaluseorservice.Allproductsmustbeusedinaccordance
withtheinstructionsprovidedwiththeProductandthepurchasershallbesolelyresponsibleforselectingaProductmodelwithspecications
appropriatefortheequipmenttobeprotected.Intermaticshalldetermine,initssolediscretion,whetheranyProductreturnedbyapurchaser
hasbeenusedinaccordancewithitsinstructions,isanappropriatemodelforthepurchaser’susethereof,andwhethertheProductisdefective.
(2) What is Not Covered By This Warranty
Intermaticdoesnotwarrant(a)defectsintheProductordamagetoanyequipmentcausedbythefailuretoproperlyinstalltheProduct,(b)
damagecausedbyuseoftheProductforpurposesotherthanthoseforwhichitwasdesigned,(c)damagecausedbydisastersuchasre,
oodandwind,(d)damagecausedbyunauthorizedattachmentsormodicationoftheProduct,(e)damagetotheProductoccurringduring
theshipment,(f)electricaldisturbancesexceedingpublishedproductspecications,(g)damagetotheProductcausedbyanyotherabuse
ormisusebythepurchaser,or(h)damageduetodirectorvicinitylightningstrikes.Thiswarrantyappliestoresidentialandcommercialap-
plications.ThisdeviceisnotintendedtoprovideprotectionduringUtilityvoltageswellsorlossofneutralconditionswhicharebydenition
nottransienteventsandarenotcoveredbythiswarranty.
(3) Disclaimer of Warranty
THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER EXPRESSED WARRANTIES. TO THE EXTENT ALLOWED BY LAW,
ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION OF
THIS LIMITED WARRANTY.
(4) Limitation of Remedies
INNOCASESHALLINTERMATICBELIABLEFORANYSPECIAL,INCIDENTAL,ORCONSEQUENTIALDAMAGESBASEDUPON
BREACHOFWARRANTY,BREACHOFCONTRACT,NEGLIGENCE,STRICTTORT,ORANYOTHERLEGALTHEORY.SUCHEXCLUDED
DAMAGESINCLUDE,BUTARENOTLIMITEDTO,DAMAGETOSOFTWARE,LOSSOFDATA,LOSSOFPROFITS,LOSSOFSAVINGS
ORREVENUE,LOSSOFUSEOFTHEPRODUCTORANYASSOCIATEDEQUIPMENT,COSTOFCAPITAL,COSTOFANYSUB-
STITUTEEQUIPMENT,FACILITIESORSERVICES,DOWNTIME,THECLAIMSOFTHIRDPARTIESINCLUDINGCUSTOMERS,DAM-
AGETOPROPERTYANDPERSONALINJURY.SOMESTATESDONOTALLOWLIMITSONWARRANTIESORONREMEDIESFOR
BREACHINCERTAINTRANSACTIONS,INSUCHSTATES,THELIMITSINTHISPARAGRAPHANDINPARAGRAPH(3)MAYNOTAPPLY.
(5) Time Limit for Bringing Suit
Noactionarisingoutofanyclaimedbreachofwarrantymaybebroughtmorethanoneyearafterthecauseofactionhasoccurred.
(6) No Other Warranties
Unlessmodiedinwritingsignedbybothparties,thisagreementisunderstoodtobethecompleteandexclusiveagreementbetweenthe
parties,supersedingallprioragreements,oralorwritten,andallothercommunicationsbetweenthepartiesrelatingtothesubjectmatterof
thisagreement.NoemployeeofIntermaticoranyotherpartyisauthorizedtomakeanywarrantyinadditiontothosemadeinthisagree-
ment.Thiswarrantyismadeby:IntermaticIncorporated/AfterSalesService,7777WinnRd.,SpringGrove,IL.60081-9698/815-675-7000
http://www.intermatic.com
INTERMATIC INCORPORATED
SPRING GROVE, ILLINOIS 60081-9698
http://www.intermatic.com