Invacare Compressor User manual

User: Before using the product, read this manual
and save for future reference.
Dealer: This manual must be given to the end user.
For more information regarding
Invacare products, parts, and services,
please visit www.invacare.com
User Manual
HomeFill® Compressor

WARNING
HomeFill® Compressor 2 Part No 1100873
 WARNING
DO NOT use this product or any available optional
equipment without first completely reading and
understanding these instructions and any additional
instructional material such as owner’s manuals, service
manuals or instruction sheets supplied with this product
or optional equipment. If you are unable to understand
the warnings, cautions or instructions, contact a
healthcare professional, dealer or technical personnel
before attempting to use this equipment - otherwise,
injury or damage may occur.
NOTICE
Theinformationcontainedinthisdocumentissubjectto
changewithoutnotice.
 ACCESSORIES WARNING
Invacare products are specifically designed and
manufactured for use in conjunction with Invacare
accessories. Accessories designed by other manufacturers
have not been tested by Invacare and are not
recommended for use with Invacare products.
NOTE:Updatedversionsofthismanualareavailableon
www.invacare.com.

TABLE OF CONTENTS
Part No 1100873 3 HomeFill® Compressor
SPECIAL NOTES ............................................... 5
TYPICAL PRODUCT PARAMETERS ................... 7
LABEL LOCATION ............................................ 9
DEALER INFORMATION ................................... 9
HOMEFILL INFORMATION .............................. 10
SECTION 1—IMPORTANT SAFETY
INSTRUCTIONS ............................................. 11
Operating Information .....................................................................11
Maintenance........................................................................................13
Double-Insulated Products .............................................................13
Disposal of Equipment and Accessories ......................................14
Radio Frequency Interference........................................................14
SECTION 2—TECHNICAL DESCRIPTION .......... 15
SECTION 3—INITIAL SETUP ............................ 16
Initial Set Up of Compressor..........................................................16
Compressor Initial Setup Checklist..........................................16
Choosing a location......................................................................16
Transporting the Compressor...................................................17
Installing the Power Cord...........................................................17
Connecting the Compressor to the Concentrator..............18
SECTION 4—CHECKLIST AND CYLINDER INSPEC-
TION ............................................................. 20
Compressor Operation Checklist.................................................20
Cylinder Prefill Inspection ...............................................................20
The Hydrostatic Testing Date................................................... 22
External Examination ...................................................................22
SECTION 5—COMPRESSOR OPERATION .......... 23

TABLE OF CONTENTS
HomeFill® Compressor 4 Part No 1100873
Connecting/Disconnecting the Cylinder to/from the
Compressor ..............................................................................................23
Connecting the Cylinder to the Compressor........................23
Disconnecting the Cylinder from the Compressor.............. 26
Turning the Compressor On .........................................................28
SECTION 6—INDICATOR LIGHTS .................... 30
SECTION 7—TROUBLESHOOTING ................... 31
SECTION 8—MAINTENANCE .......................... 33
Cleaning the Compressor Filter .................................................... 33
Cabinet ................................................................................................33
LIMITED WARRANTY .................................... 35

SPECIAL NOTES
Part No 1100873 5 HomeFill® Compressor
SPECIAL NOTES
Checkallpartsforshippingdamage.Incaseofdamage,DO
NOTuse.ContactInvacareforfurtherinstruction.
Signalwordsareusedinthismanualandapplytohazardsor
unsafepracticeswhichcouldresultinpersonalinjuryor
propertydamage.Refertothefollowingtablefordefinitions
ofthesignalwords.
ACCESSORIES
Therearemanydifferenttypesofoxygentubing,cannulas
andmasksthatcanbeusedwiththisdevice.Youshould
contactyourlocalhomecareproviderforrecommendations
onwhichofthesedeviceswillbebestforyou.Theyshould
alsogiveyouadviceontheproperusage,maintenance,and
cleaning.
CAUTION
“Caution:Federallawrestrictsthisdevicetosaleorrentalby
oronorderofaphysician,oranyotherpractitionerlicensed
bythelawoftheStateinwhichhe/shepracticestouseor
ordertheuseofthisdevice.”
SIGNAL WORD MEANING
DANGER Danger indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
WARNING Warning indicates a potentially hazardous
situation which, if not avoided, could result
in death or serious injury.
CAUTION Caution indicates a potentially hazardous
situation which, if not avoided, may result in
property damage or minor injury or both.

SPECIAL NOTES
HomeFill® Compressor 6 Part No 1100873
 DANGER
DO NOT SMOKE while using this device. Keep all
matches, lit cigarettes or other sources of ignition out of
the room in which this product is located and away from
where oxygen is being delivered.
NO SMOKING signs should be prominently displayed.
Textiles and other materials that normally would not
burn are easily ignited and burn with great intensity in
oxygen enriched air. Failure to observe this warning can
result in severe fire, property damage and cause physical
injury or death.

TYPICAL PRODUCT PARAMETERS
Part No 1100873 7 HomeFill® Compressor
TYPICAL PRODUCT PARAMETERS
TYPICAL PRODUCT PARAMETERS
- COMPRESSOR
Standard Listing: Double Insulated Product
ETL Certified as Complying with UL60601-1,
First Edition
ETL Certified Complying with CAN/CSA
C22.2 No. 601-1 M:90 (Canada)
EMC IEC 60601-1-2
Alternating Current
Type BF equipment
Unit running
Unit not running
Attention - Consider Accompanying
Documents
DO NOT smoke
Class II, Double Insulated
Not Protected
Electrical Requirements: 120 VAC ± 10% (108 VAC/132 VAC),
60 Hz
Rated Current Input: 2.0 AMP
Operating Temperature: 50 to 95° F (10 to 35° C) @ 20 to 60%
non-condensing humidity
Storage Temperature: -10 to 150° F (-23 to 65° C) @ 15 to
95% humidity

IPX0

TYPICAL PRODUCT PARAMETERS
HomeFill® Compressor 8 Part No 1100873
Input Pressure Required: 14 - 21 psi
Input Flow Required: 2 L/min
Input O2% Required: >90% O2
Width: 20 ¼ inches
Height: 15 inches
Depth: 16 inches
Weight: 33 lbs
Shipping Weight: 39 lbs
No AP/APG: Not suitable for use in the presence of a
flammable anaesthetic mixture.
Electrical: No extension cords.
Placement: No closer than 7.5 cm (3 in) from any
wall, furniture, draperies, or furniture to
assure sufficient air flow. Avoid deep pile
carpets and heaters, radiators or hot air
registers. Floor location only.
Tubing: 2 m (7 ft) cannula with a maximum 15 m
(50 ft) of Crush-Proof Tubing (DO NOT
pinch).
Time of Operation: Up to 24 hours per day.
Recommended Storage and
Shipping Temperature:
-29°C to 65°C (-20°F to 150°F) at
15-95% relative humidity.
Environment: Smoke and soot-free. No confined
spaces (Example: No closets).
Minimum Operating Time: 30 Minutes

LABEL LOCATION
Part No 1100873 9 HomeFill® Compressor
LABEL LOCATION
DEALER INFORMATION
NOTE:Invacarerecommendsleavingafullcylinderofoxygenwith
thepatientaftersettinguptheHomeFillcompressor.
BeforeleavingaHomeFillCompressorwithauser,the
followingchecklistMUSTbecompleted:
❑Makesurethepressuretestoncylinderhasnotexpired.
❑Instructtheuseronthesafeoperationoftheconcentrator
andreviewallwarnings.
❑InstructtheuseronthesafeoperationoftheHomeFill
compressorandreviewallwarnings.
❑Leaveafullcylinderofoxygenwiththeuser.
❑Leaveacopyofallwarningsandfillinginstructionswith
theuser.
WARNING
Keep all connections free of oil and grease to avoid violent
ignition. See Owner’s Manual before cleaning.
P/N 1075220 Rev C - 10/04
WARNING
DO NOT REMOVE UNIT COVER
This unit contains moving and high pressure
components. Manufacturer Service Only.
P/N 1075221 Rev B- 10/04
WARNING
Keep all connections free of oil and grease.
See Owner’s Manual before cleaning. Never oil or lubricate
coupling.
Cylinders filled on this unit MUST be labeled “Contents of
this cylinder are the product of an oxygen concentrator.”
P/N 1075238 Rev C - 11/17/06

HOMEFILL INFORMATION
HomeFill® Compressor 10 Part No 1100873
HOMEFILL INFORMATION
HomeFillisanaccessorydevicetotheoxygenconcentrator
thatenablesthepatienttorefillcustomportableoxygen
cylindersforpersonaluse.
NOTICE
TheHomeFillcompressorisforusewithspeciallydesigned
InvacarePlatinum™5,10,XLandPerfecto2™HomeFill
compatibleoxygenconcentrators.
Theoxygenconcentratorcanbesettothefollowing
maximumflowrateswhenoperatingwithHomeFill
compressor:
Platinum5,XLandPerfecto2:3L/minorless.
Platinum10:5L/minorless.
TodetermineifyouroxygenconcentratorisHomeFill
compatible,examinethelowerrightcorneroftherearofthe
oxygenconcentratorforanoutletfitting.Refertothe
illustrationbelow.
TOP VIEW
Concentrator
Power Cord
Outlet Fitting

SECTION 1—IMPORTANT SAFETY INSTRUCTIONS
Part No 1100873 11 HomeFill® Compressor
SECTION 1—IMPORTANT SAFETY
INSTRUCTIONS
 WARNING
Thissectioncontainsimportantinformationforthesafe
operationanduseofthisproduct.
 DANGER
Risk of electric shock. DO NOT disassemble. Refer
servicing to qualified service personnel. No user
serviceable parts.
TO REDUCE THE RISK OF BURNS, ELECTROCUTION,
FIRE, OR INJURY TO PERSONS
NEVER use near any type of flame or flammable/explosive
substances, vapors or atmosphere.
Operating Information
DONOTallowoilfromyourhandsorothersourcestocome
intocontactwiththecompressorcouplingorbottlefittings.
Thesesubstancesmaybecomeflammableinthepresenceof
oxygenandcauseinjury.Avoidtouchingthebottlefitting
wheneverpossible.Exampleofitemstoavoidarehand
creamsorlotions,cookingoils,suntanoilsorsunblocksand
similaroilyproducts.Ifyouusethesetypesofproducts,wash
yourhandspriortousingtheHomeFillunit.Ifthebottle
fittingshouldcomeincontactwithsuchsubstancesitshould
becleanedoffwithadampclothpriortoconnectingittothe
compressor.

SECTION 1—IMPORTANT SAFETY INSTRUCTIONS
HomeFill® Compressor 12 Part No 1100873
NEVERoilorlubricatethecompressorcouplerorbottle
fittings.NEVERuseanypenetratingoilorlubricantsuchas
WD‐40®or3‐in‐1oil®.Ifconnectiondifficultyisexperienced
verifythatthebottlefittingisbeinginsertedstraightdown
intothecompressorcoupler.Ifcontinueddifficultyis
experiencedcontactyoursupplierforassistance.
Beforemovingorrepositioningeitherthecompressoror
concentrator,ALWAYSpushthepowerswitchtotheOff(O)
position,disconnecttheACpowercordandtheinterconnect
hosebetweenthecompressorandconcentrator.Failuretodo
somayresultindamagetotheunitorpersonalinjury.
ChildrenshouldALWAYSbesupervisedaroundthe
HomeFillunit.WhenusedwiththeHomeFilltableorsimilar
elevatedsupportsurfaces,achildcouldpulloveranysuch
tablecausingtheunittofall.Failuretoobservethiswarning
mayresultinpersonalinjuryorproductdamage.
Useextremecarewhenhandlingandfillinganoxygen
cylinder.Fulloxygencylindersareunderpressureandcan
becomeaprojectileifdroppedormishandled.
DONOTstorefilledoxygencylindersnearafurnace,hot
watertank,inthetrunkofacarorotherhightemperature
area.Storageinareassuchasthiscanresultinburstingofthe
cylinderorfire.
Theuseofthisdeviceislimitedtotheoxygenpatient.
CylindersMUSTbeusedONLYbytheoxygenpatientandare
nottobedistributedtoanyotherindividualforanypurpose.
DONOTuseoutdoors.
Themaximumpatientflowwhilefillingacylinderwiththe
IOH200is3L/minforPlatinum5,XLandPerfecto2
concentratorsand5L/minforPlatinum10concentrators.
Patientswithahigherprescribedflowshouldnotfilla
cylinderwhilereceivingsupplementaloxygentreatment
fromthePlatinumConcentrator.

SECTION 1—IMPORTANT SAFETY INSTRUCTIONS
Part No 1100873 13 HomeFill® Compressor
NEVERblocktheairopeningsoftheproductorplaceitona
softsurface,suchasabedorcouch,wheretheairopeningmay
beblocked.Keeptheopeningsfreefromlint,hairandthelike.
Ifthecompressorhasadamagedcordorplug,ifitisnot
workingproperly,ifithasbeendroppedordamaged,or
submersedinwater,callaqualifiedtechnicianfor
examinationandrepair.
IfanyleakageoftheoxygencylinderisdetectedDONOT
attempttousethecylinder.Turntheflowselectorknobonthe
regulatortoOff.Ifleakagepersists,placethecylinder
outdoorsandnotifyyourHomeHealthCareProvideror
ServiceRepresentativeofthiscondition.
TheHomeFillisequippedwithahighpressurereliefvalveto
ensuretheuser’ssafety.Whenactivated,thissafetyfeature
willmakeanextremelyloudnoise.Ifthisnoiseoccurs,turn
theunitOffandcontactyourHomeHealthCareProvideror
ServiceRepresentative.
Unplugunitfromoutletwhennotinuseandbeforecleaning.
Maintenance
DONOTdisassemble.Theunitisprovidedwithdouble
insulationandhasnoserviceableparts.Ifanyserviceis
required,contactInvacareTechnicalService.
Double-Insulated Products
Inadouble‐insulatedproduct,twosystemsofinsulationare
providedinsteadofgrounding.Nogroundingmeansis
requiredonadouble‐insulatedproduct,norisameansfor
groundingtobeaddedtotheproduct.Adouble‐insulated
productismarkedwiththewords“DOUBLEINSULATION”
or“DOUBLEINSULATED”orthesymbol().

SECTION 1—IMPORTANT SAFETY INSTRUCTIONS
HomeFill® Compressor 14 Part No 1100873
DONOTunplugthepowercordbypullingonthecord.To
unplug,grasptheplugnotthecord,otherwisedamagemay
occur.
Disposal of Equipment and Accessories
Followlocalgoverningordinanceandrecyclingplans
regardingdisposalofdevicecomponents.
Radio Frequency Interference
Thisequipmenthasbeentestedandfoundtocomplywith
EMClimitsspecifiedbyIEC/EN60601‐1‐2.Theselimitsare
designedtoprovideareasonableprotectionagainst
electromagneticinterferenceinatypicalmedicalinstallation.
Otherdevicesmayexperienceinterferencefromeventhelow
levelsofelectromagneticemissionspermittedbytheabove
standards.TodetermineiftheemissionsfromthePerfecto2is
causingtheinterference,turnthePerfecto2Off.Ifthe
interferencewiththeotherdevice(s)stops,thenthePerfecto2
iscausingtheinterference.Insuchrarecases,interference
maybereducedorcorrectedbyoneofthefollowing
measures:
•Reposition,relocate,orincreasetheseparation
betweentheequipment.
• Connecttheequipmentintoanoutletonacircuit
differentfromthattowhichtheotherdevice(s)is
connected.
Avoidcreationofanysparknearmedicaloxygenequipment.
Thisincludessparksfromstaticelectricitycreatedbyanytype
offriction.
SAVE THESE INSTRUCTIONS

SECTION 2—TECHNICAL DESCRIPTION
Part No 1100873 15 HomeFill® Compressor
SECTION 2—TECHNICAL
DESCRIPTION
TheHomeFillOxygenSystem(IOH200)isan
electro‐mechanicalprescriptionsystemforuseinthehome.
Itsintendedfunctionanduseistosupplypressurizedoxygen
tofillInvacareproprietarygascylindersforambulatoryuse
whilethepatientreceivestherapeuticoxygenfroman
accessoryoxygenconcentrator.TheIOH200gassystemis
designedforusewithanInvacarePlatinumoxygen
concentratorwithanintegralHF2accessoryportthatcan
supplyagasconcentrationgreaterthan90%O2around2
L/min.whilesupplyingapatienttherapyflowrateupto2.5
L/min.forPlatinum5and5L/min.forPlatinum9.
TheHomeFillOxygensystemconsistsofIOH200gas
compressor,connectiontubing,andtheInvacaresupplied
portablegascylinderswiththeintegralflowregulatorand
interlockingfillfitting.
TheIOH200compressorconsistsofamultistagecompressor,
internalreservoir,controlelectronicswithanintegraloxygen
concentrationsensor,interlockingfillfitting,inletfitting,and
drivemotor.Thecompressoroperationiscontrolledbythe
electronicsassembly.Themotor/compressorisallowedtofill
acylinderonlywhentheoxygenconcentrationoftheinletgas
streamisgreaterthan90%.Themotor/compressorfill
operationiscompletedwhenthegasinacylinderreachesthe
maximumfillpressureof2000PSI(13786kPa).
TheIOH200compressorcanfillcylindersforportableuseby
ambulatorypatients.TheInvacaresuppliedportablegas
cylindershaveaninterlockingfillfittingthatmatesonlywith
theInvacareIOH200compressorassembly.Thegascylinder
alsocontainsanintegralflowregulatorwithfixed,selectable
flowsettings.

SECTION 3—INITIAL SETUP
HomeFill® Compressor 16 Part No 1100873
SECTION 3—INITIAL SETUP
NOTE:DealersOnly‐RefertoDealerInformationonpage 9before
performingthisprocedure.
Initial Set Up of Compressor
Compressor Initial Setup Checklist
BeforeoperatingtheHomeFillCompressorforthefirsttime,
completethefollowingchecklist:
❑Choosealocationforthecompressor.
❑Transportthecompressortothedesiredlocation.
❑Connectthepowercordtothecompressor.
❑Connectthecompressortotheconcentrator.
Choosing a location
Thecompressorshouldbeatleastthreeinchesawayfromwalls,
draperiesorfurnituretoensuresufficientairflow.
Avoidplacingthecompressornexttoheaters,radiatorsorhotair
registers.
DONOTuseinacloset.
Thecompressorshouldsitonahardflatstablesurface,suchasa
tableortheReadyRack.
 WARNING
NEVERusenearanytypeofflameorflammable/explosive
substances,vaporsoratmosphere.

SECTION 3—INITIAL SETUP
Part No 1100873 17 HomeFill® Compressor
Transporting the Compressor
 WARNING
NEVERtransportacompressorwithacylinderconnectedtoor
storedonthecompressor,otherwiseinjuryordamagecanoccur.
CAUTION
Whentransportingthecompressor,becarefulnottobumpthe
compressorortheconnectorsintoobstacles.Otherwise,damage
tothecompressormayoccur.
NOTE:Forthisprocedure,refertoFIGURE3.1.
1. Therearetwomethodsto
safelytransportthe
compressor:
•OneHand‐Graspthe
handgripatthe
bottomrearofthe
compressor.
•TwoHands‐Graspthe
handgripsonthesides
ofcompressor. FIGURE 3.1 Transporting the
Compressor
Installing the Power Cord
NOTE:Forthisprocedure,refertoFIGURE3.2onpage 18.
1. Chooseaproperlocation.RefertoChoosingalocationon
page 16.
2. MakesurethepowerswitchisintheOff(O)position
3. Plugthepowercordintotheelectricconnectorinthebackof
thecompressor.
4. Plugtheoppositeendofthepowercordintothewalloutlet.
Hand Grip
Hand Grip
Hand Grip

SECTION 3—INITIAL SETUP
HomeFill® Compressor 18 Part No 1100873
FIGURE 3.2 Installing the Power Cord
Connecting the Compressor to the Concentrator
NOTE:Forthisprocedure,refertoFIGURE3.3onpage 19.
1. Insertoneendoftheinterconnecthoseintotheoutletfitting
onthebackoftheconcentrator(Detail“A ” ) .
2. Inserttheoppositeendoftheinterconnecthoseintotheinlet
fittingonthesideofthecompressor(Detail“B”).
NOTE:Themetaltabsontheconcentratoroutletfittingandthe
compressorinletfittingwillpopoutwithanaudible“click”whenthe
endoftheinterconnecthoseisproperlyinstalled(Detail“C”).
Wall
Outlet
Power
Cord
Compressor
(REAR)
Electrical
Connection
NOTE:Thisproductmaycomewithapolarizedplug(onebladeis
widerthantheother).Asasafetyfeature,thisplugwillfitina
polarizedoutletonlyoneway.Iftheplugdoesnotfitfullyinthe
outlet,reversetheplug.Ifitstilldoesnotfit,contactaqualified
electrician.DONOTattempttodefeatthissafetyfeature.

SECTION 3—INITIAL SETUP
Part No 1100873 19 HomeFill® Compressor
FIGURE 3.3 Connecting the Compressor to the Concentrator
Insert End of
Interconnect Hose into
Inlet/Outlet Fitting
Inlet/Outlet Fitting
Metal
Tab
Interconnect Hose
Compressor
Inlet Fitting
Power Cord
Outlet Fitting
CONCENTRATOR TOP VIEW
DETAIL “A” DETAIL “C”
DETAIL “B”

SECTION 4—CHECKLIST AND CYLINDER INSPECTION
HomeFill® Compressor 20 Part No 1100873
SECTION 4—CHECKLIST AND
CYLINDER INSPECTION
Compressor Operation Checklist
EachtimetheHomeFillCompressorisusedtofillacylinder,
completethefollowingchecklist:
❑EnsuretheconcentratorhasbeenOnforatleastthirty
minutes.RefertotheconcentratorOwner’sManual.
❑Performtheprefillinspectiononthecylinder.
❑Connectthecylindertothecompressor.
❑PushthecompressorpowerswitchtotheOn()position.
❑Examinetheindicatorlightsonthecontrolpanel.
❑Disconnectandremovethefullcylinder.
❑PushthecompressorpowerswitchtotheOff(O)position.
❑Iffillinganothercylinder,repeatthischecklist.
Cylinder Prefill Inspection
 WARNING
ONLYusecylindersthathavetheInvacareHomeFill
connectionandHomeFilllabel.
AllcylindersMUSTbeinspectedbeforeattemptingtofill.
Otherwise,injuryordamagemayoccur.
NOTE:Forthisprocedure,refertoFIGURE4.1onpage 21.