Invacare HomeFill HF2POST6 User manual

Dealer: This manual MUST be given to the end
user.
User: Before using this cylinder, read this
manual and save for future reference.
For more information regarding
Invacare products, parts, and services,
please visit www.invacare.com
Operator’s Manual
HomeFill™
Oxygen Post Valve
Cylinder
HF2POST6
HF2POST9
HF2POSTD
“Caution: Federal law restricts this device to sale or
rental by or on order of a physician, or any other
practitioner licensed by the law of the State in which
he/she practices to use or order the use of this device.”

HomeFill™2 Part No 1148114
 WARNING
DO NOT OPERATE THIS EQUIPMENT WITHOUT
FIRST READING AND UNDERSTANDING THIS
MANUAL. IF YOU ARE UNABLE TO
UNDERSTAND THE WARNINGS, CAUTIONS,
AND INSTRUCTIONS, CONTACT A
HEALTHCARE PROFESSIONAL, DEALER OR A
QUALIFIED TECHNICIAN BEFORE ATTEMPTING
TO USE THIS EQUIPMENT - OTHERWISE INJURY
OR DAMAGE MAY RESULT.
 WARNING
Invacare products are specifically designed and
manufactured for use in conjunction with Invacare
accessories. Accessories designed by other manufacturers
have not been tested by Invacare.
 DANGER
DO NOT SMOKE while using this device. Keep all
matches, lighted cigarettes, candles or other sources of
ignition out of the room in which this product is located
and away from where oxygen is being delivered. Textiles
and other materials that normally would not burn are
easily ignited and burn with great intensity in oxygen
enriched air. Failure to observe this warning can result in
severe fire, property damage and cause physical injury or
death.
NOTICE
The information contained in this document is subject to
change without notice.

TABLE OF CONTENTS
Part No 1148114 3 HomeFill™
TABLE OF CONTENTS
SPECIAL NOTES ............................................... 4
RECEIVING INSPECTION .................................. 4
INTENDED USE ................................................ 4
SECTION 1—GENERAL GUIDELINES .................. 5
SECTION 2—FEATURES .................................... 8
SECTION 3—TYPICAL PRODUCT
PARAMETERS ................................................. 9
SECTION 4—INSPECTION AND COMPRESSOR
INTERFACE ................................................... 10
Cylinder Prefill Inspection ...............................................................10
Filling the Cylinder ............................................................................13
SECTION 5—MAINTENANCE .......................... 19
SECTION 6—CYLINDER FILL TIMES ................. 20
Troubleshooting ................................................................................20
Replacement Parts - Accessories ..................................................20
LIMITED WARRANTY .................................... 22

SPECIAL NOTES
HomeFill™4 Part No 1148114
SPECIAL NOTES
Signal words are used in this manual and apply to hazards or
unsafe practices which could result in personal injury or
property damage. Refer to the following table for definitions
of the signal words.
RECEIVING INSPECTION
Remove product from package and inspect for damage. If
there is any damage, DO NOT use. Contact your dealer/
Home Care equipment provider.
INTENDED USE
To store supplemental oxygen for use with a CGA 870 post
valve compatible conserver or regulator to be used by patients
who may have difficulty extracting oxygen from the air they
breathe.
NOTE: Updated versions of this manual are available on
www.invacare.com.
SIGNAL WORD MEANING
DANGER Danger indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
WARNING Warning indicates a potentially hazardous
situation which, if not avoided, could result
in death or serious injury.
CAUTION Caution indicates a potentially hazardous
situation which, if not avoided, may result in
property damage.

SECTION 1—GENERAL GUIDELINES
Part No 1148114 5 HomeFill™
SECTION 1—GENERAL GUIDELINES
 WARNING
SECTION 1 - IMPORTANT SAFEGUARDS contains
important information for the safe operation and use of
this product. DO NOT use this product or any available
optional equipment without first completely reading and
understanding these instructions and any additional
instructional material such as Owner’s Manuals, Service
Manuals or Instruction Sheets supplied with this product
or optional equipment. If you are unable to understand
the Warnings, Cautions or Instructions, contact a health
care professional, dealer or technical personnel before
attempting to use this equipment - otherwise, injury or
damage may occur.
 DANGER
This product is not intended as a life-sustaining or
life-supporting device.
 WARNING
Only personnel instructed and trained in the use of the
HF2POST6, HF2POST9, and HF2POSTD Cylinder Assembly
should operate this product.
Product contains magnetic, ferrous material that may affect
the results of an MRI.
Be sure all connections are tight and leak free.
DO NOT use a liquid leak detector to test for leaks.
DO NOT autoclave.
DO NOT gas sterilize with ethylene oxide.
DO NOT clean with aromatic hydrocarbons.

SECTION 1—GENERAL GUIDELINES
HomeFill™6 Part No 1148114
 WARNING
DO NOT attempt to repair product.
DO NOT immerse product in any kind of liquid.
Store product in a clean area when not in use.
Only use an Invacare Corporation HF2POST6BAG or
HF2POST9BAG carrying bag.
NEVER smoke in an area where oxygen is being
administered.
ALWAYS confirm prescribed dose before administering to
patient and monitor on a frequent basis.
DO NOT use if dirt or contaminants are present on or around
cylinder, valve, product or connecting devices.
NEVER use near any type of flame or flammable/explosive
substances, vapors or atmosphere.
ALWAYS follow ANSI and CGA standards for Medical Gas
Products and Flowmeters (E-7) and Oxygen Handling (G-4).
The use of this device is limited to the oxygen patient.
Cylinders MUST be used only by the oxygen patient and are
not to be distributed to any other individual for any purpose.
DO NOT allow oil from your hands or other sources to come
into contact with the cylinder fittings. These substances may
become flammable in the presence of oxygen and cause injury.
Avoid touching the cylinder fitting whenever possible.
Example of items to avoid are hand creams or lotions, cooking
oils, suntan oils or sunblocks and similar oily products. If you
use these types of products Invacare suggests you wash your
hands prior to using this product. If the cylinder fitting should
come in contact with such substances it should be cleaned off
with a damp cloth prior to connecting it to the compressor.

SECTION 1—GENERAL GUIDELINES
Part No 1148114 7 HomeFill™
 WARNING
NEVER oil or lubricate the cylinder fittings. NEVER use any
penetrating oil or lubricant such as WD-40 or 3 in One. If
connection difficulty is experienced verify that the cylinder
fitting is being inserted straight down into the compressor
coupler. If continued difficulty is experienced contact your
supplier for assistance.
DO NOT allow cylinders to tip or fall. Secure gas cylinders so
they cannot fall. Ensure cylinder is always in upright position.
DO NOT store cylinders near sources of heat or flame.
DO NOT use while sleeping without consulting your
healthcare provider.
DO NOT place the unit under clothing while in use. When
this product is in use a small amount of oxygen is vented.
Wearing the unit under clothing may saturate fabrics with
oxygen and cause them to burn rapidly if exposed to sparks
or flame. It may take several hours for oxygen levels in fabrics
to return to normal.

SECTION 2—FEATURES
HomeFill™8 Part No 1148114
SECTION 2—FEATURES
FIGURE 2.1 Product Diagram
Cylinder Fill
Port
Toggle Valve

SECTION 3—TYPICAL PRODUCT PARAMETERS
Part No 1148114 9 HomeFill™
SECTION 3—TYPICAL PRODUCT
PARAMETERS
DIMENSIONS:
HF2POST6: Weight 4.0 lbs (1.81 kg)
HF2POST6: Overall Length 11.1 in. (2.8 cm)
HF2POST6: Diameter 4.4 in. (11.1 cm)
HF2POST9: Weight 5.0 lbs (2.27 kg)
HF2POST9: Overall Length 14 in (35.5 cm)
HF2POST9: Diameter 4.4 in (11.1 cm)
HF2POSTD: Weight 6.30 lbs (2.85 kg)
HF2POSTD: Overall Length 20.8 in (52.8 cm)
HF2POSTD: Diameter 4.4 in (11.1 cm)
STORAGE CONDITIONS
TEMPERATURE: -40°F (-40°C) to 140°F (60°C)
MAXIMUM HUMIDITY: 95%

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE
HomeFill™10 Part No 1148114
SECTION 4—INSPECTION AND
COMPRESSOR INTERFACE
NOTE: Refer to the HomeFill ™Compressor Owner’s Manual for
compressor operating instructions.
Cylinder Prefill Inspection
 WARNING
All cylinders MUST be inspected before attempting to fill;
otherwise, injury or damage may occur.
NEVER smoke in an area where oxygen is being
administered.
NEVER use near any type of flame or flammable/explosive
substances, vapors or atmosphere.
NOTE: For this procedure, refer to FIGURE 4.1 on page 12.
The Hydrostatic Testing Date
Aluminum cylinders MUST undergo testing every five years.
 WARNING
DO NOT fill cylinders that have not been tested in the
past five years. Otherwise, serious personal injury may
result. Contact your dealer for replacement.