JVC CS-AW7020 - 10 DVC 2OHM 1000W MAX User manual

ARSEnAL
SUBWOOFER
CRISSON DE GRRVE
CS-AW7020
CS-AW7040
JVC
CS-AW7220
CS-AW7240
For Customer Use:
Enter below the Model No, and Serial
No, which is located either on the rear
or bottom of the speaker unit. Retain
this information for future reference.
Model No.
LVT1743-001A
INSTRUCTION MANUAL L...:s=eri=al N=O.========:=::.J
MANUEL D'INSTRUCTIONS
MANUAL DE INSTRUCCIONES

3. Jump 2. Screw x10
Parts
Thank you for purchasing the ARSENAL Car Stereo Speaker. These Speakers can be
mounted
in the trunk of your vehicle. For the secure installation and perfect operation
of your speakers, please read the following carefully.
1. Grille
~
4. Fuse (10A) x 2 5. Hexagon socket
screw keys
For proper installation and use
1.Before connecting the speakers to the amplifier, confirm that the power has been
turned off. The click noise generated by the connection if the power is
on may
damage the speakers.
2.The amplifier and speakers should be connected between corresponding terminals,
i.e. left to left, and right to right, as well as "+" to "+", and "_" to "_". Connection with
reversed polarity will degrade the quality of stereo reproduction.
3.Do not subject the speakers to excessive input. The power handling capacity of the
CS-AW7020/CS-AW7040/CS-AW7220/CS-AW7240
is 600 watts (R.M.S. MUSIC
POWER). Any excessive input may damage the speakers.
4.The CS-AW7020/CS-AW7040/CS-AW7220/CS-AW7240 has
an impedance of 20
,40,80. Make sure that the output impedance of the amplifier's speaker terminal is
rated at 20,40,80.
5.When cleaning the speakers, use asoft cloth and wipe the surface gently. Do not
apply thinner or solvent.
6.Be sure to carefully follow the instructions for:
Cable Connections
Fuse Replacement
Switching the Impedance Selector
Subwoofer Mounting and Smart Trim Ring Installation
Consult Page 19 of this Instruction Manual for details on these procedures.
- 2 -

Dual 4nApplication Diagrams
SERIES PARALLEL
*JUMPER is Removed
JUMPER
SERIES PARALLEL
( enid Jodwnr •1
~
- ........ -
+ -40n1y.. -
0000
~_r
40
Bi-Amp Configuration 2Mono Amplifiers
1Subwoofer Jumper
is Removed 40 Load
1Mono Amplifier
1Subwoofer
Jumper set
to Parallel
80(40+40) Load
E3~
..... ...... ...
+ - .. Onty.+ -
o0 0 0
SERIES PARALLEL
40 40
*JUMPER is Removed
SERIES PARALLEL
[ • Jumper Plug 1
E3~
lnP"! Bi .......p InfWI
-+ -4OnIJ.+ -
o0 0 0
JUMPER
'+ 402-Chan
Stereo
-+
(!:., ao
Mono
12ch Amplifier
1Subwoofer
Jumper
is Removed
40 Load
1Mono Amplifier
1Subwoofer
Jumper set to Series
80(40+40) Load
JUMPER JUMPER
-- ---.. -- --
SERIES PARALLEL
[ • Jumper Plug 1
E3~
- ....... -
+-40ntJ.+ -
000 0
SERIES PARALLEL
[ • Jumper Plug 1
Mono
(+ __ a.;,;,40;,;.,.;;a~0:..4;,;0~ .. 40 aD 40
40
1Mono Amplifier
2Subwoofers
Jumper set to Series
Subwoofers wired
in Parallel
40 Load
JUMPER JUMPER JUMPER
-------
SERIES PARALLEL
[ • Jumper Plug 1
~
InpuI 1lt-A"'tI IRl>uI
+-40ntJ.+ -
o 000
-- --.. -- --
SERIES PARALLEL
( • Jumper Plug )
E3E3
~ 81· ...... Input
-+ -40rl1y.+ -
o0 0 0
-- -- -- --
SERIES PARALLEL
[ • Jumper Plug)
E3~
Inpul 80.......... In"'"
+-40n1y.+ -
o0 0 0
Mono
1Mono Amplifier
3Subwoofers
Jumper set
to Series
Subwoofers wired
in Parallel
2.60 Load
JUMPER JUMPER JUMPER JUMPER
-------
SERIES PARALLEL
[ • Jumper Plug 1
~
Input III ......... ~
+ - .. Only.. -
0000
--------
SERIES PARALLEL
[ • Jumper Plug 1
~E3
Input 8/..,. ... p IRl>uI
+ _ .. Only.+ _
o0 0 0
------
SERIES PARALLEL
( • Jumper Plug 1
E3E3
Input 80...-.- I<lIl<II
± - .. Only.. -
0000
40 aD 40
-------
SERIES PARALLEL
( • Jumper Plug 1
E3~
Input Bi-Amp Inpul
+ - .. Only.. -
000 0
Mono
CB 20
8
1Mono Amplifier
4Subwoofers
Jumper set to Series
Subwoofers wired in Parallel
20 Load
- 3 -

Dual 2n Application Diagrams
SERIES PARALLEL
( 6nld Jodwnr • )
E3.E3
InpuI 8l~ ......
... -4Onfyt>+ -
o0 0 0
*JUMPER is Removed
JUMPER
10
1Mono Amplifier
1Subwoofer
Jumper set to Parallel
40(20+20) Load
* JUMPER is Removed
20 20
-- -- -- ,--
SERIES PARALLEL
( • Jumper PlUg)
~
..... --- .....
... -<IIONr.-+ -
0000
JUMPER
+
40
Mono
1Mono Amplifier
1Subwoofer
Jumper set to Series
40(20+20) Load
~~
Input 81 .... "'.. 1n",,1
... -.. Only 1>. -
0000
SERIES PARALLEL
~_T
20
Mono
+
Bi-Amp Configuration 2Mono Amplifiers
1Subwoofer Jumper is Removed 20 Load
JUMPER
~~
Input ........ p -.ut
... - .. Only". -
0000
SERIES PARALLEL
JUMPER
+ 202-Chan
Stereo
+
1
2ch Amplifier
1Subwoofer
Jumper
is Removed
20 Load
1Mono Amplifier
2Subwoofers
Jumper set to Series
Subwoofers wired
in Parallel
20 Load SERIES
PARALLEL
( • Jumper Plug)
~~
..... "'- .....
+-40..t,0,,+ -
000 0
-- --. -- ----
JUMPER
SERIES PARALLEL
( • Jumper PlUg)
~
..... --- .....
... -40n1yt>+ -
0000
-- -- -- ---
JUMPER
JUMPER
1Mono Amplifier
3Subwoofers
Jumper set to Series
Subwoofers wired
in Parallel
1.30 Load
+
SERIES PARALLEL
( • Jumper Plug)
~F3
~ 81 ....... ktpuI
+ -.0nIy". -
o0 0 0
--------
JUMPER
SERIES PARALLEL
( • Jumper Plug)
~F3
Input ........... Input
+ -4Onfyt>+ -
o0 0 0
------
JUMPER
SERIES PARALLEL
( • Jumper Plug)
~~
Input 81·......'1n""1
+ -40n1y,,+ -
000 0
------
JUMPER JUMPER
1Mono Amplifier
4Subwoofers
Jumper set to Series
Subwoofers wired
in Parallel
10 Load
(-
SERIES PARALLEL
( • Jumper PlUg)
~
"- .~ .......
+ - .. Onfy". -
0000
-----
SERIES PARALLEL
( • Jumper Plug)
~~
..................
+ -4ewy 1>+ -
0000
--------
SERIES PARALLEL
( • Jumper PlUg)
~E3
InpuI 81"'- InpuI
-+ -.entrl>. -
0000
SERIES PARALLEL
( • Jumper PlUg)
~
Inpul til....... Inpul
... - .. On/J.. -
000 0
- 4 -

~ Top & Bottom Sides (x 2)
Front &Rear Baffle Boards (x 2)
G : Internal Volume
~ Left & Right Sides (x 2)
r;i;.E
l'~~)::uot;og Hoi'
............... :/ Dimension
CS-AW7020 /CS-AW7040 CS-AW7220 /CS-AW7240
A
15-13/32 inch (391.7 mm)
16-13/32 inch (417.1 mm)
B
15-13/32 inch (391.7 mm) 16-13/32 inch (417.1 mm)
C
11-13/32 inch (290.1 mm)
13-29/32 inch (353.6 mm)
D
9-4/32 inch (232 mm) 10-14/32 inch (275.9 mm)
E
9-23/32 inch (247 mm) 11-10/32 inch (295 mm)
F
4/32 inch (3 mm) 4/32 inch (3 mm)
G1.57
ft3 (0.045 m3)2.17
ft3 (0.062 m3)
•To install the sealed enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as recommended in the table below-20 mm (3/4 inch) MDF is also
recommended for the enclosure materials.
"Screw: Dia. 4mm x50mm (x 8) (supplied)
CS-AW7220 /CS-AW7240CS-AW7020 /CS-AW7040
•To install the ported enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as recommended in the table below-20 mm (3/4 inch) MDF is also
recommended
for the enclosure materials.
A
15-13/32 inch (391.7 mm) 15-13/32 inch (391.7 mm)
B
18-13/32 inch (467.9 mm) 18-13/32 inch (467.9 mm)
C
13-13/32 inch (340.9 mm)
15-13/32 inch (391.7 mm)
D
9-23/32 inch (247 mm)
10-14/32 inch (2759 mm)
E
9-23/32 inch (247 mm) 11-10/32 inch (295 mm)
F
4/32 inch (3 mm)
4/32 inch (3 mm)
G 1 inch (25.4 mm) 1inch (25.4 mm)
H
13 inch (330.2 mm)
14 inch (355.6 mm)
-5-
13-6/32 inch (3353 mm)
G
~ :Internal Volume
A Left & Right Sides (x 2)
.pD
r
, Mounting Hole
?Dimension
..............
J 1.85 ft3 <0.052 m3)
I 13-19/32 inch (345.4 mm)
c
"Screw: Dia. 4mm x50mm (x 8) (supplied)
Front &Rear Baffle Boards (x 2)

Parameters CS-AW7020 CS-AW7040 NOTES
parallel series parallel series
Nominal Impedance
(0)
20 + 20 40 +40
SPL (dB,1W/1M) 83.49 dB 83.54 dB
8402 dB 84.12 dB
SPL: Sound pressure level
Displacement (Liter) 0.123
ft3
Hole Cutout Diameter (inch) Dia. 9 - 6/32 inch
(mm)
(233 mm)
Mounting Depth (inch) 6 - 14/32 inch
(mm) (163.5
mm)
Re(O) 0.980
3.830
1.920
7.60 Re: DC voice coil resistance
BL (T.M) 6.85 13.75 8.68 17.21 BL .Product
of Flux density and
Effective Voicecoil-wire length
Vas (Liter)
1708 L 16.98L 18.08 L18.28 L
Vas: Volume of air equal to the driver
compliance
Vas (CuFt) 0.6
ft3 0.599 ft3
0.64 ft3
0.65 ft3
Me (g) 145.99 g147.11 g124.08 g122.44 9Me :Effective mass
D(mm}
Dia. 202 mm D : Effective cone diameter
Fs (Hz) 39.6 Hz 39.5 Hz 41.7
Hz 41.8 Hz Fs :Driver free air resonance
Qms 10.261 10.282
9021 9.169
Qms: Qof driver at Fs considering
only non-electrical resistance
Qes 0.756 0.74 0.83
0824
Qes : Q of driver at Fs considering
only electrical resistance
Qts 0.704 0.691 0.76 0.756 Qts :Total Q
of driver at Fs
Pe [max.] (W)
600W
Pe[max.] :Maximum continuous input
power
Xmax.(mm} 14.95
mm 14.8 mm Xmax. :Maximum effective voicecoil
travel without distortion
Freq.Responce (Hz) 25
-500 Hz
Magnet Mass (oz) 65.4 oz
(g) (1854.1
g)
Voice Coil(Aluminum)Dia.(inch} Dia. 2 - 5/32 inch Dia. 2 - 4/32 inch
(mm)
(54.5 mm) (53.59 mm)
Hvc (mm) 39.9 mm 39.6 mm Hvc :Voice coil Height
Hag (mm) 10 mm
Hag: Gap Height
Parameters CS-AW7220 CS-AW7240 NOTES
parallel series parallel series
Nominal Impedance (O)
20 + 20 40 + 40
SPL (dB,1W/1M) 85.13 dB 85.2 dB 85.87 dB 85.65 dB SPL :Sound pressure level
Displacement (Liter) 0.18
ft3
Hole Cutout Diameter (inch) Dia. 10 -29/32 inch
(mm)
(277 mm)
Mounting Depth (inch) 7 - 6/32 inch
(mm) (182.5
mm)
Re (O)
0.980 3.840 1.940 7.610 Re: DC voice coil resistance
BL (T.M) 6.84 13.72 9.56 19.14 BL :Product
of Flux density and
Effective Voicecoil-wire length
Vas (Liter) 38.7 L38.76 L35.23 L
3505 L
Vas: Volume of air equal to the driver
compliance
Vas (CuFt) 1.37
ft3
1.37ft
31.24
ft3
1.24 ft3
Me (g) 171.85 g172.93 g157.03 g
157.34g Me :Effective mass
D(cm)
Dia. 246 mm D : Effective cone diameter
Fs (Hz) 34.6
Hz 34.5 Hz 37.9 Hz 38 Hz Fs :Driver free air resonance
Qms 10.277
10089 8.931 9.014
Qms : Q of driver at Fs considering
only non-electrical resistance
Qes 0.786 0.765 0.794 0.781 Qes : Q
of driver at Fs considering
only electrical resistance
Qts 0.73 0.711 0.73 0.719 Qts :Total Q
of driver at Fs
Pe [max.] (W)
600W
Pe[max.] :Maximum continuous input
power
Xmax.(mm) 14.95 mm 14.8 mm Xmax. :Maximum effective voicecoil
travel without distortion
Freq.Responce (Hz) 23
-500 Hz
Magnet Mass (oz)
86.2oz
(g)
(2443.7 g)
Voice Coil(Aluminum)Dia.(inch) Dia. 2 - 5/32 inch Dia. 2 - 4/32 inch
(mm)
(54.5 mm) (53.59 mm)
Hvc (mm) 39.9 mm 39.6 mm Hvc :Voice coil Height
Hag (mm) 10 mm
Hag: Gap Height
- 6 -

Dia. 10-14/32 inch 1265 mm J
Dia. 10-26/32 inch 1275 mm JE
E
Dra. 12-12/32 inch 1314 mm J
Dia 12-24/32 inch (324 mm J-
E
E
m
<0
~
-
E-
EE
'"
E
M
"'
~
N
~
~
-5
-
.'=
~
~
~
N
<'">
<D
~
Dia. 9-4/32 inch 1231.96 mm JDia. 10-26/32 inch
1275.94 mm I
CS-AW7020
CS-AW7040
CS-AW7220
CS-AW7240
-17 -

[ Santoprene Surround 1
Air Vented
Aluminum
Cast Basket
Integlated Dual-Layer
Cone construction
Woven Tinsel Lead
(Patent Pending)
Rapid Fire Impedance
Selector Speaker Terminal
( Patent Pending)
[4 (2+2) Layer Voice Coils 1
[ Heat Transfer Silicon 1
Multi Mount Smart
Trim Ring
(Patent Pending)
--=~~~==='7=-rlJ---_J Glass Fiber
Laminated
Hemp Cone
Aluminum Voice
Coil Former
[ Aero Vent Bottom Plate 1
T3 Chassis (Thermal Transfer Technology)
-18 -

-
,/
/
/
--
/
-- --
/
--
/
/~
.......
I ~~-
,
I\
\I
.......
\
~
I
"-
.......
./
\...
.......
I
-?
,/
\
~
/'
/'
\.
/
/'
,/
"/
/'
/,/
/'
"'-
"-
.v
.........
./
--
-
-- --
.-
"
-19 -

TO OUR VALUED CUSTOMER --
THANK YOU FOR PURCHASING THIS JVC PRODUCT.
WE WANT TO HELP YOU ACHIEVE APERFECT EXPERIENCE.
NEED HELP ON HOWTO HOOK UP?
NEED ASSISTANCE ON HOWTO OPERATE?
NEEDTO LOCATE AJVC SERVICE CENTER?
LIKE TO PURCHASE ACCESSORIES?
JVC®IS HERETO HELP!
TOLL FREE: 1(800)252-5722
http://www.jvc.com
Remember to retain your Bill of Sale for Warranty Service.
--- Do not attempt to service the product yourself
Caution
To prevent electrical shock, do not open the cabinet.
There are no user serviceable parts inside.
Please refer to qualified service personnel for repairs.
@ EN, FR, SP
©2007 Victor Company of Japan, Limited Printed
in China