Karma VIP2 Series User manual

Manual Wheelchair Owner's Manual
VIP2 Series
(VIP 2-T/VIP2-TR)

i
GENERAL WARNING
●DO maintain your chair well, in particular check the tire pressure since this
affects the efficiency of the brakes. To know the correct tire pressure, please
see the walls of the tires.
●DO make sure both brakes are applied before getting in or out of the chair.
●DO make sure both brakes are applied when the chair is not being pushed
or used.
●DO take care when climbing kerbs or turning on slopes.
●DO avoid steep or uneven surfaces that may cause the chair to tip over.
●DO avoid soft surfaces because the castors may become bogged down.
●DO travel smoothly in all conditions.
●DO look well ahead to anticipate hazards such as furniture, doors, potholes,
etc.
●DO make sure that both feet are safely on the footrests and that clothing is
safely tucked out of the way so that it cannot get caught in the wheels.
●DO take care when traveling up or down or across inclines.
●DO keep both hands on the push handles to control the chair, if you are the
attendant.
●DO pay attention to keep the wheelchair balanced.
●DO check the frame and components regularly and refer to this user guide
during and after the warranty period.
●DO tie-up the upholstery or replace which with a new one when it becomes
loose.
●DO lubricate bearings regularly.
●DO equip with anti-tippers to avoid falling backwards.
●DO equip with a seat belt designed for disabled people.
●DO equip with "ankle supports" for disabled people.
●DO clean both hands after oiling the wheelchair.
●DO keep far away from flame.
●DO tighten the screws of headrest tubes (if applied).

ii
●DO NOT overload the chair in any circumstance.
●DO NOT hang anything heavy on the back of the chair that could cause the
chair to become unstable, particularly when negotiating inclines.
●DO NOT allow more than one user at a time.
●DO NOT use with an unconscious patient.
●DO NOT use other transport to pull the wheelchair.
●DO NOT do "wheelies", as you my fall or tip over backwards and suffer a
severe injury.
●DO NOT sit in a wheelchair within a moving vehicle unless it has affixed the
labels of hook mark.
●DO NOT go too fast or turn too quickly.
●DO NOT stand on the footplates when getting in or out of the chair.
●DO NOT go down steps forward, whether solo or with an attendant.
●DO NOT attempt to lift the wheelchair by any removable (detachable) parts.
Lifting by means of any removable (detachable) parts of the wheelchair may
result in injury to the user and/or assistant or damage to the wheelchair.
●DO NOT use the wheelchair when the back is folded. This alters the center
of gravity and may cause the wheelchair to tip backwards. The back should
only be folded for storage or transport of the wheelchair.
●DO NOT hang anything on the back joint that could cause the backrest
folding suddenly and may cause injury.
YOU AND YOUR KARMA SERVICE PROVIDER
●No tools are required for assembly. Your wheelchair should be assembled
by your authorized KARMA dealer. Your authorized KARMA dealer is also
your service provider. Unauthorized repairs, upgrades and add-ons will void
your warranty. Anything wheelchair related that requires tools should be
done by your authorized KARMA service provider. Your KARMA service
provider has the necessary service/maintenance manual for your
wheelchair.
●If you have any defective parts or lose any parts, please contact your dealer

iii
for repair and/or replacement. Please only use parts authorized by KARMA.
Use of parts that are not authorized by KARMA will void your warranty.
●Part numbers are listed on our bill of materials (explosion drawings), which
we give to our authorized dealers and service providers. Customers should
order parts through their dealer as well as all repairs and scheduled
maintenance.
●Customers should go to their dealer for all service needs to guarantee their
warranty is not void. Always go to an authorized service provider.
Unauthorized repairs will void your warranty. Procedures other than those
described in this manual must be performed by a qualified technician.
They also have the service manual with a complete list of maintenance
required to keep your KARMA wheelchair in top performance. Please check
the warranty section of this manual to find out what KARMA guarantees and
what maintenance and parts that are not covered by our warranty.
●KARMA does not have an official list of service providers at this time. Please
contact your dealer for service. If you cannot contact your dealer, please
contact another authorized KARMA dealer for service. If all else fails, contact
KARMA directly via our website or give us a call and we can refer you to your
new service provider.
CE MARKING
●This wheelchair complies with the requirements of the Medical Devices
Directive 93/42/EEC.
CAUTION:
●When prescribing wheelchairs for use by full or partial amputees
(above or below knee, single or double) or other conditions that affects
the user's natural center of gravity and might cause the wheelchair to
tip or the person on the wheelchair to fall off, we suggest contacting
your therapist or dealer as well as attaching anti-tippers, pelvic belt, or
other additional safety accessories.
●Anti-tippers MUST be equipped all the times

TABLE OF CONTENTS
1. PREFACE....................................................................................................................1
2. SAFETY.......................................................................................................................1
2.1 Before Using .....................................................................................................1
2.2 While Moving...................................................................................................1
2.3 General................................................................................................................4
2.4 Upholstery.........................................................................................................4
2.5 Anti-Tippers ......................................................................................................4
2.6 Maximum User Weight Limit......................................................................4
2.7 Avoid General Misuse....................................................................................5
2.8 Labeling..............................................................................................................6
3. INTENDED USE & PARTS ....................................................................................7
3.1 Intended Use ....................................................................................................7
3.2 VIP 2 Parts Description..................................................................................8
4. OPERATION ..........................................................................................................11
4.1 Preparing For Use ........................................................................................11
4.2 Recline and Tilt operation.........................................................................14
4.3 Headrest Adjustment .................................................................................15
4.4 Detachable Armrest Adjustment ...........................................................16
4.5 Footplate Height Adjustment .................................................................18
4.6 Footrest............................................................................................................18
4.7 Elevating and Swing-Away Footrest ...................................................19
4.8 Backrest Angle Adjustment (Tilt version only)..................................20
4.9 Pelvic belt........................................................................................................21
4.10 Manual Parking Brake..............................................................................22
4.11 Anti-Tippers.................................................................................................23

4.12 Rear Wheel Disassembly ......................................................................24
4.13 Rear Wheel Assembly ............................................................................24
4.14 Transferring In.............................................................................................25
4.15 Transferring Out.........................................................................................25
4.16 Going Up or Down Steps/Stairs ...........................................................27
4.17 General Use .................................................................................................27
4.18 Storage..........................................................................................................29
4.19 Transportation............................................................................................29
5. INSPECTION AND MAINTENANCE..............................................................32
5.1 Daily Check.....................................................................................................32
5.2 Regular Maintenance Record..................................................................32
6. ACCESSORIES.......................................................................................................35
7. TROUBLESHOOTING.........................................................................................36
9. CLEANING & RECYCLING................................................................................39
9.1 Cleaning...........................................................................................................39
9.2 Recycling .........................................................................................................40
10. WARRANTY ........................................................................................................40
10.1 Serial Number.............................................................................................40
10.2 Warranty Policy...........................................................................................40

1
1. PREFACE
1.1 Please read this owner's manual carefully before using the wheelchair.
Any improper use of the wheelchair may result in harm or injury.
1.2 This owner's manual includes operation, unfolding/ folding instructions
and how to prevent possible accidents for the aspects of the wheelchair.
1.3 This owner's manual is written for KARMA wheelchair: VIP2 Series.
1.4 The symbols used in this manual are explained below. Pay special
attention to the parts marked with these symbols.
WARNING:
Improper use could lead the user to severe injury or death.
CAUTION:
Improper use could lead the user to severe injury and/or
damage to your wheelchair.
SUGGESTION:
Follow these instructions to keep the wheelchair in good
condition.
1.5 This manual includes the repair and maintenance chart as well as the
warranty.
1.6 If someone else uses the wheelchair, make sure that you give him or her
this owner's manual for his or her reference.
1.7 As designs change, some illustrations and pictures in this manual may not
correspond to the wheelchair that you purchased. We reserve the right to
make design modifications without further notice.
2. SAFETY
2.1 Before Using
The user and attendant must be familiar with the operation of the wheelchair
before using. Pedestrian traffic rules apply to the wheelchair. Please be safe.
2.2 While Moving
Please always keep these following safety guidelines in mind.
2.2.1 Doorways
The safest way to operate the wheelchair is on level floors that are free of
obstacles. If possible, always use a ramp to enter or exit a facility. Keeping

2
your hands on the push rims will allow you to maintain the maximum
balance. DON'T try to force yourself over an obstacle and use the sides of
a doorway to pull yourself through a passageway.
2.2.2 Leaning and Standing
DO NOT lean over the side or stand on the wheelchair since such an
action may cause you to lose balance and fall. (See Figures 2.1 and 2.2)
2.2.3 Negotiating Inclines
2.2.3.1. Never turn on a hill due to the danger of tipping over.
2.2.3.2. When an attendant is pushing the wheelchair straight up a slope, if
the user needs to go down midway on the slope, walk backwards
until the user is on level ground. (See Figures 2.3 and 2.4)
Figure 2.1
Figure 2.2
Figure 2.3
Figure 2.4
2.2.3.3. Do not drive on 7 degrees of incline to avoid danger. When
negotiating inclines, don't propel up to 3 degrees of inclines
diagonally.
2.2.3.4. Avoid stopping on an incline, it can potentially cause you to lose
control of the wheelchair.
2.2.3.5 Do not use the brakes to slow down or stop the wheelchair, this
could cause it to stop suddenly and make the user lose control or fall
out of the wheelchair.
2.2.3.6 Whenever possible, utilize help from an assistant/attendant while
negotiating inclines.
CAUTION:
●Although the product has met ISO 7176-1 requirements, we still
recommend you not to drive on any slope (in any direction) greater than
7 degrees.

3
2.2.4 Kerbs
2.2.4.1. Whenever possible, get help from an assistant/attendant. If you have
assistance, make sure that your chair is equipped with push handle.
2.2.4.2. DO avoid huge impacts when descending a kerb. A huge impact
could probably damage the wheelchair.
2.2.4.3. Never try to scale or descend a kerb that exceeds a normal height.
2.2.4.4. Always be careful and never move up or down a kerb in reverse
without an attendant.
WARNING:
●Any improper use of the wheelchair could cause severe injury or death.
●For increasing your safety, please make sure that you have realized those
guidelines as mentioned previously.
●ALWAYS follow The Use of Invalid Carriages on Highways Regulations
outdoors and the guidelines written in this owner's manual.
2.2.5 Streets
2.2.5.1. Always cross streets with great caution.
Reflective tape on the wheelchair and/or your
clothing will make you more visible to drivers.
2.2.5.2. Please comply with traffic safety code.
2.2.5.3. Avoid potholes and rough terrain that might
cause the casters to get stuck.(See Figures 2.5)
Figure 2.5
2.2.6 Stairs
2.2.6.1. Always use two or more assistants. Tilt the wheelchair to its point of
equilibrium. One assistant (at the back) holds the wheelchair up
against the first step, gripping the handles firmly to lift. The second
assistant, holding firmly a fixed part of the front frame, lifts the
wheelchair above the stairs and holds it while the first attendant
places one foot on the following step and repeat the operation.( See
Figures 2.6~2.7)
2.2.6.2. Never go down steps forwards.

4
2.2.6.3. Never use an escalator for transport; use an elevator.
Figure 2.6
Figure 2.7
2.3 General
2.3.1 Always make sure BOTH brakes are applied before getting in or out of
the wheelchair.
2.3.2 Never stand on the footplates when getting in or out of the wheelchair
2.3.3 Never carry more than one passenger. KARMA wheelchairs are limited
to one user.
2.3.4 Use caution to assure your clothing doesn't get tangled with the wheels.
2.4 Upholstery
2.4.1 When cleaning the upholstery, use warm water and a mild soap.
2.4.2 Upholstery cleaner/foam can also be used, but avoid other cleaning
solvents.
2.4.3 Do stay far away from any flame because it might injure the user and
damage the wheelchair
2.5 Anti-Tippers
Always use them to avoid personal injury. The distance between the end of
each anti-tipper and the rear wheel is at least 5 cm; the distance to the
ground is no more than 5 cm.
2.6 Maximum User Weight Limit
2.6.1 The maximum user weight limit for VIP 2 Series is 115 kg. For detail
information, refer to Section 8. SPECIFICATIONS.
2.6.2 Please note that loading exceeding maximum capacity can damage
your wheelchair and cause malfunctions, which leads to a safety hazard.
The warranty does not cover damage caused by improper operation of
the wheelchair.

5
2.7 Avoid General Misuse
Please note that our "Owner's Manual" contains a number of cautions -- any
vehicle can cause injury if misused -- use within our guidelines and with
reasonable care and your safety will be increased. Your wheelchair will give
years of safe use if used sensibly and carefully. Be aware that careless use
endangers your own safety as well as that of others. ALWAYS follow the
Highway Code when outdoors and the guidelines written in this manual.

6
2.8 Labeling
Please carefully read all the labeling on the wheelchair before driving it. Do
not remove them. Protect them for future reference.

7
3. INTENDED USE & PARTS
3.1 Intended Use
3.1.1 The VIP 2 Series is a self-propelled or transit wheelchair. That is, it can
either be propelled by the user (self-propelled) or by an attendant
(transit).
3.1.2 It is designed to be used indoors, and with certain restrictions outdoor.
3.1.3 It is suitable for a single user up to 115 kg in weight. Hand brakes are
provided for both rear wheels.
3.1.4 It is a highly adjustable wheelchair, and the detachable parts are easy to
operate.
3.1.5 Rear wheels with 14”/20" solid tires and ergonomic handrims are
provided with 20”tires. It also has an extremely durable aluminum
alloy frame with tough accessories and does not deteriorate when
exposed to extreme temperature.(neither the user nor the attendant
need to touch any metal part in normal use)
3.1.6 When prescribing wheelchairs for use by full or partial amputees.
(above or below knee, single or double) or other conditions that affects
the user's natural center of gravity, we suggest contacting your
therapist or dealer as well as attaching anti-tippers.
3.1.7 Please contact your dealer for the optional accessories of the VIP 2
series which are planned to be launched shortly.

8
3.2 VIP 2 Parts Description
1. Push Handle
2. Attendant Brake
3. Backrest Upholstery
4. Side Panel
5. Manual Parking Brake
6. Rear Wheel
7. Outside Frame
8. Caster
9. Height-adjustable Armrest
10. Seat Upholstery
11. Swing-Away & Detachable Footrest
12. Cross Bar
13. Heel Loop
14. Footplate
.

9
1. Push Handle
2. Attendant Brake
3. Backrest Upholstery
4. Side Panel
5. Manual Parking Brake
6. Rear Wheel
7. Outside Frame
8. Caster
9. Height-adjustable Armrest
10. Seat Upholstery
11. Elevating Legrest Assembly
12. Cross Bar
13. Calf Pad
14. Footplate
.

10
1. Headrest Pad
2. Headrest Assembly
3. Recline Release Handle
4. Lateral Supporter Joint
5. Tilt Release Handle
6. Anti-tipper
7. Backrest tube joint
.
CAUTION:
●Standard equipments are subject to change without notice.

11
4. OPERATION
4.1 Preparing For Use
4.1.1 Unpacking
4.1.1.1 If any part proves defective or missing, please notify your dealer
immediately.
4.1.1.2 Please consult this owner's manual for complete instructions on the
installation and operation of your VIP 2 .
4.1.2 Assembly of Swing-Away & Detachable Footrests
Please follow the below instructions for the assembly of Swing-Away &
Detachable Footrests.
4.1.2.1 Footrests are packaged in a carton. (See Figure 4.1).
4.1.2.2 The items included are as show in the list below. (See Table 4.1 and
Figure 4.2 )
4.1.2.3 Insert the footplate into the footrest. (See Figure 4.3)
4.1.2.4 Adjust the footplate to the appropriate length, and insert the bolt
and the nut. (See Figure 4.4 and 4.5)
4.1.2.5 Use the #4 Allen Key and wrench provided by KARMA to tighten the
bolt and the nut. (See Figure 4.6)
Figure 4.1
Figure 4.2
Figure 4.3
Figure 4.4
Figure 4.5
Figure 4.6

12
Table 4.1 Swing-Away & Detachable Footrest Assembly Part List
No
Part
Quantity
1
Swing-Away &
Detachable Footrest
2
2
Tube-in-Centre Footplate
2
3
M6 Bolt
2
4
M6 Nut
2
5
Calf Strap
2
4.1.3 Unfolding
While unfolding the VIP 2, follow these instructions as listed below:
4.1.3.1 Stand at the side of the wheelchair as you prefer, hold the armrests
and pull outwards. (See Figure 4.7)
4.1.3.2 Pull the push handles upward and make joint be clamped (See Figure
4.8)
4.1.3.3 Put your hands on side panels and pull them outward (See Figure
4.9)
4.1.3.4 Put your two hands on the seat pan and push down until the seat is
fully lowered, be careful not to get your fingers caught. Make sure
the frame is firmly seated in its holder (See Figure 4.10)
4.1.3.5 Make lateral support bar be fixed by pushing downward. (See Figure
4.11)
4.1.3.6 Install the footrests. (See Figure 4.12)
4.1.3.7 Flip the footplates down. (See Figure 4.13)
4.1.3.8 Place the back and seat cushion on the wheelchair.
4.1.3.9 Ready to use!

13
Figure 4.7
Figure 4.8
Figure 4.9
Figure 4.10
Figure 4.11
Figure 4.12
Figure 4.13
CAUTION:
●While completing step 4.1.3.4, never put your fingers
around the sides or under the wheelchair as they can
be trapped between the seat and the frame. (See the
figure at the right.)
●The calf straps should be adjusted to the length
appropriate for the user's condition.
4.1.4 Folding
While folding the wheelchair, follow these instructions as listed below:
4.1.4.1 Flip up the footplates. (See Figure 4.14)
4.1.4.2 Pull up the seat by holding the front and the back of the seat. (See
Figure 4.15)
4.1.4.3 Make lateral support bar be released by pulling upward. (See Figure