Katadyn MyBottle User manual

Closed
Open
(2) (3) (4) (5)
Preconditioning the System
(When New or After Extended Storage)
1. Prime - Fill the bottle with water to the fill line (indicated on outside of bottle). Insert
cartridge/bottle cap into bottle. Turn bottle cap clockwise until tight. Squeeze bottle
firmly with both hands to start water flow. Repeat until two bottles of water have
been run through the system. While priming, keep bottle as full as possible. Flow
rate will improve once the system is fully primed.
2. Again, fill the bottle with water to the fill line. Insert cartridge/bottle cap into bottle.
Turn bottle cap clockwise until tight. Allow to sit for two hours prior to use.
Normal Operation (After Preconditioning)
1. Fill the bottle with water to the fill line (Figure 4).
Remember, the clearer the water, the longer the Cyst and
Prefilter will last.
2. Insert cartridge/bottle cap into bottle. Turn bottle cap
clockwise until tight.
3. Flip open mouth piece. Note: The mouth piece has two
positions. Pull the mouth piece up to open. Push it down to
close (Figure 5). Do not remove mouth piece.
4. Hold the bottle upright when drinking. Squeeze and sip
using continuous pressure.
Important Notes
1. To be purified, water must pass through the ViruStat® cartridge. The flow rate is
slower than an ordinary sports water bottle to ensure complete purification.
2. New and stored units must be preconditioned. See “Preconditioning the System”
section.
3. Squeeze and sip using continuous pressure. Do not pump. You will notice a 2-4
second pause after squeezing, like using a long straw, before water flows.
4. Always hold bottle upright when drinking. Water will not pass through the cartridge
if bottle is upside down or at an angle.
Product Set-Up (Before First Use)
1. Rinse inside of bottle
2. IMPORTANT! Flush Prefilter
Attach Carbon Prefilter to Bottle Cap. Fill bottle with tap water. Install Bottle Cap on
bottle and tighten. Firmly squeeze bottle with both hands until 1/2 bottle of water has
been run through the system. Remove bottle cap.
3. Assemble the cartridge
Remove the red label from the top of the Virustat® (Figure 2).
Attach the Cyst Filter to the bottom of the ViruStat® and the
Prefilter to the bottom of the Cyst Filter. Gently twist each
component while pushing it on. Make sure ALL O-rings and
components are fully seated and assembled. The cartridge must
be assembled in this way to ensure purification in all water
conditions. Firmly twist and push the cartridge into the bottle cap
(Figure 3).
Figure 3
Figure 2
IMPORTANT!
Remove Safety Seal!
Key Components
Following the U.S. EPA microbiological water purifier test protocols, the MyBottle system’s
long-lasting, replaceable ViruStat® microbial purification cartridge killed or removed:
• 99.9999% of waterborne bacteria such as Klebsiella terrigena
• 99.99% of waterborne viruses* including Poliovirus Type 1* and Type 1 Rotavirus
Strain SA-11*
• 99.9% of waterborne protozoa such as Giardia
• Bad tastes and odors
ViruStat
Cyst Filter
Carbon
Prefilter
Figure 1
Cushioned
mouth piece
Thank you for choosing the Katadyn MyBottle
Personal Water Purification System
This personal water purification system has been proven to render water microbiologically safe for
drinking. Intended only for short-term, limited or emergency use (not intended for long-term use).
Directions For Use
It is a violation of Federal law to use this product in a manner inconsistent with its labeling.
Katadyn MyBottle personal water purification systems eliminate the need to carry or locate safe drink-
ing water, whether you are hiking, traveling or in an emergency situation. Only Katadyn MyBottle
personal water bottle purifiers place the advanced technology of a microbial purification cartridge
into a standard water bottle. The result is a personal hydration system that provides antimicrobial
protection against cysts, bacteria and viruses*.
When To Use
Katadyn MyBottle personal water bottle purifiers are designed for use with untreated fresh water
sources, such as lakes, rivers and streams. They also provide protection against waterborne patho-
gens that may still be present in the tap water of many foreign countries. MyBottle systems are also
effective in emergencies, such as floods, hurricanes and earthquakes, or any time service from a
municipal water treatment plant fails.
Katadyn MyBottle personal water bottle purifiers provide a convenient alternative to pump-style water
purifiers. Because they are designed for personal use, MyBottle systems are not suitable for situations
when large volumes of water must be treated.
How They Work
Katadyn MyBottle personal water purification systems utilize a multi-stage, modular system. At the
heart of the system is the ViruStat® microbial purification cartridge. The ViruStat® uses PentaPure
penta-iodide resin to kill 99.9999% of waterborne bacteria, including Klebsiella terrigena and
99.99% of viruses*, such as Poliovirus Type 1* and Rotavirus Strain SA-11*. The ViruStat® employs
a patented ion-release technology that dramatically reduces residual iodine, and a special layer of
coconut-carbon that further minimizes any residue. The ViruStat® cartridge is preceded by a replace-
able 1-micron filter that removes 99.9% of pathogenic cysts, such as Giardia. A Prefilter is installed
below the Cyst filter to remove sediment and organic contaminants.
Please carefully read the following instructions for maximum performance of your Katadyn MyBottle
personal water purification system. Failure to follow the instructions found in this manual may result
in unsafe drinking water.
Figure 4
Fill Line
Straw
Figure 5
Bottle cap with
integral carry loop
Bottle
8018905_0_January_Approved_Purifier_Manual.indd 1 1/17/2013 12:07:50 PM

(6) (7)
Print No: 8018905/0
Owner’s Manual
Katadyn MyBottle Portable Water
Purification System
Katadyn ViruStat®Replacement Cartridge
(Model # 8011555)
Precautionary Statements
Hazards to Humans & Domestic Animals
CAUTION
This cartridge contains iodide resin. Persons with iodine allergies or thyroid problems and
pregnant women should consult their doctor before using this device because small amounts
of iodine may remain in the treated water.
Limited Warranty
Your Katadyn MyBottle Personal Water Purifier is warranted for one (1) year from the date
of purchase against defects in materials and workmanship. Should your Katadyn MyBottle
Personal Water Purifier prove defective within one year from the date of purchase, return
it to the Katadyn retailer from whom it was purchased. If you do not receive a satisfactory
resolution, contact Katadyn Customer Relations at 1-800-755-6701 for service assistance.
Katadyn, at its discretion, will replace or repair the damaged item. Please retain purchase
receipt as proof of date purchased. To the extent consistent with applicable law, this
warranty gives you specific legal rights.
Contact:
Katadyn Products, Inc.
4830 Azelia Ave N.
Minneapolis, MN 55429
1-800-755-6701
[email protected]
Cleaning
Wash and dry the inside of the MyBottle thoroughly before using and regularly during
heavy periods of use. If using with safe water and without the ViruStat® cartridge, the
bottle must be completely disinfected to prevent contamination from previous contact with
contaminated water. Your MyBottle and the cap are dishwasher safe (without the cartridge).
The rubber mouth piece cover may be removed for cleaning it thoroughly. Do NOT use
soap to clean the ViruStat® cartridge, the Cyst Filter or the Prefilter.
Before storage, remove excess water from the ViruStat® cartridge by disassembling all
three components. Shake out excess water. Allow the components to thoroughly dry.
Wash and dry bottle. Wash well and follow conditioning instructions before resuming
use. Replace a used Cyst Filter when taking the MyBottle system out of prolonged storage.
Do NOT use with carbonated or flavored beverages, as they may damage the ViruStat®
microbial purification cartridge.
IMPORTANT
Refer to the Important Notes and the Product Set-Up before using.
Storage & Disposal
Do not contaminate water, food or feed by storage or disposal.
Pesticide Storage: Store purification components in a cool, dry place or in a
refrigerator (not in the freezer section). Store empty bottle (without the ViruStat®
cartridge, Cyst Filter or Prefilter installed) with the cap on. Container Handling and
Disposal: Used cartridges or filters: Non-refillable containers; do not reuse or refill spent
cartridges or filters; place in trash or offer for recycling if available.
Cartridge Installation
The ViruStat® microbial purification cartridge is for use with the MyBottle personal portable
water purification system as a microbiological water purifier. Each replaceable ViruStat®
microbial purification cartridge will treat up to 26 gallons (100 liters) of water.
Changing the Cyst Filter
When water flow becomes restricted, use the following steps to change the Cyst Filter:
a. Remove the Cartridge/Bottle Cap from the bottle.
b. Remove theCystFilterfromthebottom of the ViruStat®cartridge and the Prefilterfrom the
bottom of the Cyst Filter.
c. Gently twist and push the new Cyst Filter onto the ViruStat® cartridge (see Figure 1).
d. Gently twist and push the Prefilter onto the Cyst Filter.
e. Put Cartridge/Bottle Cap back on bottle.
Changing the ViruStat®Microbial Purification Cartridge
After 26 gallons (100 liters) use the following steps to change the ViruStat® cartridge:
a. Remove the Cartridge/Bottle Cap from the bottle.
b. Remove the ViruStat® microbial purification cartridge with the Cyst Filter and
Prefilter from the cap. Discard cartridge components in trash receptacle.
c. Flush Prefilter (see step 2 of product set-up on page 4).
d. Assemble the Cartridge (see step 3 of product set-up on page 4).
e. Follow the Preconditioning procedure on Page 5.
Keep Out of Reach of Children
CAUTION
See end of manual for additional Precautionary
Statements
EPA Reg. No: 39444-12
EPA Est. 39444-CHE-1
Active Ingredient:
Iodine*..................... 46%
Other Ingredients...... 54%
Total............................. 100%
*Bound to polystyrene divinyl benzene quaternary
ammonium anion exchange resin
8018905_0_January_Approved_Purifier_Manual.indd 2 1/17/2013 12:07:51 PM