Katadyn HFD-PS40 User manual

TROUBLESHOOTING
Close pressure relief valve
SYMPTOM CAUSE REMEDY
No freshwater
Salty product water
No water rejected or produced
Motor/Piston Not Moving Cables not plugged in properly
Intake out of water
Pressure relief valve not sealed
System needs time to stabilize
Solar not providing enough power
Intake filter blocked/too dirty
Air bubble in watermaker
Handheld test read inaccurately
Unplug all cable connections, then plug back in. Check cable ferrules are properly
inserted into DC/DC converter.
Orient solar panels perpendicular to sun rays or switch to another power supply
Place pre-filter back in water or change location of adjustable hose weight
Unscrew old intake filter and screw on provided second filter or clean by spraying water
While running, tilt the watermaker to the left 30° then to the
right 30°. Repeat 4 times.
Sample water regularly for up to 45 minutes
Ensure x10 is not seen in corner of window
HFD-PS40 Land Warfare Universal Watermaker
Quickstart Guide
STORAGE CONFIGURATION
TDS METER
3 PLUMBING BAGS
-FEED HOSE
-DISCHARGE HOSE
-PRODUCT HOSE
-POST-FILTER
ELECTRONIC BAG
-ALLIGATOR CLAMPS
-NATO CABLE
-EXTENSION CABLE
BATTERY CAP CONNECTOR
QUICKSTART GUIDE
2 PRE-FILTER ASSEMBLIES
-MESH CAMOFLAGE BAG

1. CONNECT PLUMBING:
2. CONNECT TO POWER:
3. STARTUP PROCEDURE:
2.1 CHOOSE ONE
POWER SOURCE
ORIENT PERPENDICULAR
TO SUNRAYS
2.2 ATTACH CORRESPONDING CONNECTOR
2.3 CONNECT EXTENSION CORD
2.4 CONFIRM INTAKE IS SUBMERGED,
THEN CONNECT PLUG TO WATERMAKER
1.1 COLOR MATCH HOSE EXTENSIONS
PRODUCT FEED
COOLING
DISCHARGE
OPERATING CONFIGURATION
1.3 ADD PREFILTER TO FEED
1.4. PUT FEED HOSE END IN SOURCE WATER AND
PRODUCT HOSE END IN CONTAINER
1.2 ADD POST-FILTER TO PRODUCT
LINE (IN CASE OR AT END OF LINE)
3.1 IMMEDIATELY OPEN PRESSURE RELIEF VALVE
UPON POWER UP
3.2 WAIT 10 MINUTES FOR CHEMICAL FLUSH,
THEN CLOSE PRESSURE RELIEF VALVE
3.3 BEGIN SAMPLING WATER WITH TDS
METER. STORE WHEN POTABLE.
<1000
2590 2590
PLACE BATTERY WITH CONNECTOR IN FOAM CUTOUT
USE KEY TO OPEN PORT
TOOLS AND INSTRUCTIONS FOR MANUAL POWER UNDER WATERMAKER