Kyocera KYOCERA FS-C8100DN User manual

Page 1 of 12 FS-C8100DN
FS-C8100DN Clearing Paper Jams
If the paper jams in the paper transport system, or no paper sheets were fed at all, thePaper
j am
message appears and the location of the paper jam (the component where the paper jam has
occurred) is also indicated. The printer automatically goes off-line when this message is displayed.
Remove the jammed paper. After removing the jammed paper, the printer will re-start printing.
Possible Paper Jam
Locations
The figure below explains the printer’s paper paths including the options. The locations where pape
r
jams might occur are also shown here, with each location explained in the table below. Paper jam
s
can occur in more than one component on the paper paths.
Mail Box
MT-710
Document Finisher
DF-710/DF-730
Booklet Folder
BF-710
Paper Feeder
PF-710/PF-750
Paper jam message Paper jam
location
Description Referencepage
Paper j am
Cassette 1
A
Paper is jammed at the upper cassette or
inside the printer.
3
Paper j am
Cassette 2
B
Paper is jammed at the lower cassette or
inside the printer.
4
Paper j am
Cassette 3
Paper j am
Cassette 4
C
Paper is jammed at an optional paper
feeder cassette. (PF-710 upper cassette
,
PF-750)
DPaper is jammed at an optional paper
feeder cassette. (PF-710 lower cassette)
5
5
Paper j am
MP Tray
E
Paper is jammed at the MP tray. 6
Paper j am
Feed Uni t
F
Paper is jammed in the feed unit. 6
Paper j am
Left Cover 1
G
Paper is jammed in the left cover section. 9

Page 2 of 12 FS-C8100DN
Paper jam message Paper jam
location
Description Referencepage
Paper j am
Left Cover 2
H
Paper is jammed in a left cover section. 11
Paper j am
Left Cover 3
I
Paper is jammed in the left cover section
of an option unit. (PF-710, PF-750)
11
Paper j am
Top Cover
J
Paper is jammed in a top cover section. 12
Paper j am
Finisher
K
Paper is jammed in the paper stacker
of the optional document finisher.
DF-710 or
DF-730
Operation
Guide
Paper j am
Folding Unit
Paper j am
Mailbox
L
Paper is jammed in the booklet folder. DF-710
Operation
Guide
MPaper is jammed at the mailbox. DF-710
Operation
Guide
General considerations
for clearing
jams
Bear in mind the following considerations when attempting jam removal:
CAUTION:
When pulling the paper, pull it gently so as not to tear it. Torn pieces of paper are difficult
to remove and may be easily overlooked, deterring the jam recovery.
• If paper jams occur frequently, try using a different type of paper, replace the paper with paper
from another ream, flip the paper stackover, or rotatethepaper stack 180 degrees. Selection of
paper is fully discussed in the Handling Paper section in the Advanced Operation Guide. The
printer may have problems if paper jams recur after the paper was replaced.
• Whether or not the jammed pages are reproduced normally after printing is resumed depends
on the location of the paper jam.
Utilizing Online Help Messages
Online help messages are available in the printer’s message display to provide simple instructio
ns
for clearing jams. Press ( ) when the paper jam message has appeared. Then a help message wi
ll
appear to facilitate jam clearing in the location.

Page 3 of 12 FS-C8100DN
Paper Cassette
Paper Cassette 1
Remove the paper if a paper jam occurred in the paper cassette 1. Follow the instructions below.
1
Open the left cover 1.
2
Remove the jammed paper.
3
Open the duplex unit
A1
.
4
Remove the jammed paper.

Page 4 of 12 FS-C8100DN
5
Pull out paper cassette 1.
6
Remove the jammed paper.
7
Slowly close paper cassette 1.
8
Close the duplex unit
A1
and the left cover 1.
IMPORTANT:
Push the indicated position to close left
cover 1 securely.
Paper Cassette 2
Remove the paper if a paper jam occurred in paper cassette 2. Follow the instructions below.
1
Open the left cover 2.
2
Remove the jammed paper.

Page 5 of 12 FS-C8100DN
3
Pull out paper cassette 2.
4
Remove the jammed paper.
5
Slowly close paper cassette 2.
6
Close the left cover 2.
Paper Cassette 3 or 4
(option)
Remove thepaper if a paper jam occurredin the optionalpaper feeder (PF-710/PF-750). Followthe
instructions below.
1
Open the left cover 3.
2
Remove the jammed paper.

Page 6 of 12 FS-C8100DN
3
Pull out the paper cassette being used.
4
Remove the jammed paper.
5
Slowly close the paper cassette.
6
Close the left cover 3.
MP Tray
Remove the paper if a paper jam occurred in the MP tray or feed unit. Follow the instructions below.
1
Open the left cover 1.
2
Remove the jammed paper.

Page 7 of 12 FS-C8100DN
3
Open the duplex unit
A1
.
4
Remove the jammed paper.
5
Open the feed guide
B1
.
6
Remove the jammed paper.
7
Remove all the paper set in the MP tray.

Page 8 of 12 FS-C8100DN
8
Pull out paper cassette 1.
9
Turn the handle B2 counterclockwise 10 times or
more. The jammed paper will bemoved to the inside of
the left cover.
10
Remove the jammed paper. If paper cannot be
removed, perform the steps described below.
11
Pull out the feed unit
B3
.
12
Open the cover
B4
and remove the jammed paper.

Page 9 of 12 FS-C8100DN
13
If paper is torn, pull out the feed unit
B3
completely, and uninstall it with the unit pulled up.
14
Pull out paper cassette 1 completely, and uninstall
it with the cassette pulled up.
15
Remove the jammed paper.
16
Replace paper cassette 1 and feed unit
B3
.
17
Close the feed guide
B1
, the duplex unit
A1
and
the left cover 1.
IMPORTANT:
Push the indicated position to close left
cover 1 securely.
18
Replace the paper in the MP tray.
Left Cover 1
Remove the paper if a paper jam occurred inside the left cover 1. Follow the instructions below.
WARNING:
The printer’s fixing unit is extremely hot. Take sufficient care when working in
this area, as there is a danger of getting burned.

Page 10 of 12 FS-C8100DN
1
Open the left cover 1.
2
Remove the jammed paper.
3
Open the duplex unit
A1
.
4
Remove the jammed paper.
5
Open the fixing unit cover
A2
.