LaCimbali M100 GT Quick start guide

M100
GT - HD - Dosatron- Turbo Milk
MANUALE DEL TECNICO
ENGINEER'S MANUAL
MANUEL DU TECHNICIEN
TECHNIKERHANDBUCH
MANUAL DEL TÉCNICO
MANUAL DO TÉCNICO
(rev. MT-M100TurboMilk P0-1907)

I
M100
1
6
11 8
9a
9
20 13
19
19
19
15
23
Turbomilk
9c
Tsn
12
35
Tsb
Cold Touch (DX)
9b
Cold Touch (SX)
9b

II
LEGEND
1 Main switch
6Pump pressure gauge
8Hot-water outlet
9Steam pipe
9a Turbosteam pipe
9b Turbosteam Cold Touch pipe (*)
9c Turbo Milk pipe (*)
11 Filter holder
12 Hot-water button
13 Turbosteam / Turbomilk selector
15 Tray
19 Coffee boiler (*)
20 Steam supply knob
23 Cup warmer
35 Hot-water“STOP-CONTINUOUS”key
SET Keytoaccessprogrammingmode/menu
TSb Selection touch screen
TSn Touch screen
The components - * - are applied only in some
product congurations
LÉGENDE
1 Interrupteur général
6Manomètre pompe
8Sortie eau chaude
9Buse vapeur
9a Buse Turbosteam
9b Buse Turbosteam Cold Touch (*)
9c Buse Turbo Milk (*)
11 Porte-ltre
12 Bouton eau chaude
13 Sélecteur Turbosteam / Turbomilk
15 Bac d'égouttement
19 Chauffe-eau, café (*)
20 Robinet de débit du vapeur
23 Chauffe-tasses
35 Touche«STOP-CONTINU»eau
chaude
SET Touche programmation/menus
TSb Écran tactile de sélection
TSn Écran tactile
Les composants accompagnés d'un * ne sont
montés que dans certaines congurations de
produit.
LEGENDA
1 Interruttore generale
6Manometro pompa
8Erogatore acqua calda
9Tubo (lancia) vapore
9a Tubo (lancia) Turbosteam
9b Tubo (lancia) Turbosteam ColdTouch (*)
9c Tubo (lancia) Turbo Milk (*)
11 Portaltro
12 Pulsante acqua calda
13 Selettore Turbosteam / Turbomilk
15 Bacinella appoggiatazze
19 Boiler caffè (*)
20 Manopola erogazione vapore
23 Piano appoggiatazze
35 Tasto"STOP-CONTINUO"acquacalda
SET Tastoperentrareinprogrammazione/
menù
TSb Touch screen di selezione
TSn Touch screen
I componenti - * - sono applicati solo in alcune
congurazioni di prodotti.
LEGENDE
1 Hauptschalter
6Manometer Pumpe
8Heißwasserausgabe
9Dampfausgaberohr
9a Dampfausgaberohr Turbosteam
9b Dampfausgaberohr Turbosteam Cold
Touch (*)
9c Milchausgaberohr Turbo Milk (*)
11 Filterhalter
12 Heißwasser-Drucktaste
13 Wahlschalter Turbosteam / Turbomilk
15 Auffangschale
19 Boiler Kaffee (*)
20 Drehknopf Dampfabgabe
23 Tassenerwärmer
35 Taste“STOP-KONTINUIERLICHE“
Heißwasserabgabe
SET Taste zur Programmierung / Menü
TSb Wahl-Touchscreen
TSn Touchscreen
Bauteile - * - sind nur bei einigen Produkt-
Kongurationen angebracht.
LEYENDA
1 Interruptor general
6Manómetro bomba
8Erogador agua caliente
9Tubo (boquilla) vapor
9a Tubo (boquilla) Turbosteam
9b Tubo(boquilla) TurbosteamColdTouch (*)
9c Tubo (boquilla) Turbo Milk (*)
11 Portaltro
12 Botón suministro agua caliente
13 Selector Turbosteam / Turbomilk
15 Bandeja
19 Calentador café (*)
20 Botón giratorio erogación vapor
23 Calientatazas
35 Tecla“STOP-CONTINUO”agua
caliente
SET Tecla para entrar en programación /
menú
TSb Pantalla táctil de selección
TSn Pantalla táctil
Loscomponentes-*-seaplicansóloenalgunas
conguraciones de productos.
LEGENDA
1 Interruptor geral
6Manómetro da bomba
8Distribuidor de água quente
9Tubo do vapor
9a Tubo do vapor Turbosteam
9b Tubo do vapor Turbosteam ColdTouch (*)
9c Tubo Turbo Milk (*)
11 Porta-ltro
12 Botão de distribuição de água quente
13 Selector Turbosteam / Turbomilk
15 Tabuleiro
19 Boiler café (*)
20 Manípulo de distribuição do vapor
23 Grelha para aquecer chávenas
35 Tecla“STOP-CONTÍNUO”água
quente
SET Teclapara entrarna programação/ menu
TSb Touch screen de selecção
TSn Touch screen
Os componentes - * - são aplicados só em
algumas congurações de produtos.
IT FR
EN
DE ES PT

III
M100 GT - M100 HD
M100 Dosatron
Caldaia
Service boiler
Chaudière
Heizkessel
Caldera
Caldeira
133
tipo di macchina
Type of machine
type de machine
Maschinentypen
modelo de la máquina
tipo de la màquina
acqua/vapore
water/steam
eau/vapeur
wasser/Dampf
agua/vapor
água/vapor
2 gruppi
2 groups
2 groupes
2 Einheiten
2 grupos
2 grupos
Tmax
[ °C ]
Pmax
[ bar ]
2
Fluido - Fluid - Fluide
Flüssig - Fluido - Fluido [ L ]
Capacità - Capacity - Capacité
Fassungsvermögen - Capacidad - Capacidade
Scambiatore
Heat exchanger
Échangeur de chaleur
Wärmeaustauscher
Intercambiador de calor
Permutador de calor
acqua
water
eau
Wasser
agua
água
0.22
x 2
133
12
(GT)
15
(HD)
10
3 gruppi
3 groups
3 groupes
3 Einheiten
3 grupos
3 grupos
4 gruppi
4 groups
4 groupes
4 Einheiten
4 grupos
4 grupos
0.22
x 2
10
0.22
x 2
10
Boiler caffè
Coffee boiler
Chauffe-eau, café
Boiler Kaffee
Calentador café
Boiler do cafè
acqua
water
eau
Wasser
agua
água
0.40
x 2
160
12
(GT)
15
(HD)
0.40
x 3 0.40
x 4
Caldaia
Service boiler
Chaudière
Heizkessel
Caldera
Caldeira
133
tipo di macchina
Type of machine
type de machine
Maschinentypen
modelo de la máquina
tipo de la màquina
acqua/vapore
water/steam
eau/vapeur
wasser/dampf
agua/vapor
água/vapor
2 gruppi
2 groups
2 groupes
2 Einheiten
2 grupos
2 grupos
Tmax
[ °C ]
Pmax
[ bar ]
2
Fluido - Fluid - Fluide
Flüssig - Fluido - Fluido [ L ]
Capacità - Capacity - Capacité
Fassungsvermögen - Capacidad - Capacidade
Scambiatore
Heat exchanger
Échangeur de chaleur
Wärmeaustauscher
Intercambiador de calor
Permutador de calor
acqua
water
eau
Wasser
agua
água
0.18 - 0.25
x 2
133
10
3 gruppi
3 groups
3 groupes
3 Einheiten
3 grupos
3 grupos
4 gruppi
4 groups
4 groupes
4 Einheiten
4 grupos
4 grupos
0.18 - 0.25
x 3
15
0.18 - 0.25
x 4
20
12
PED / DESP
PED / DESP

IV
~400 (15.7)
~260 (10.2)
~ø100(3.9)
133(5.2)
75 (3)
602 (23.7)
306 (12)
559 (22)L
L1
133(5.2)
75 (3)
602 (23.7)
306 (12)
559 (22)L
L1
~400 (15.7)
~260 (10.2)
~ø100(3.9)
M100 GT
M100 HD
M100 DT
L
L1 mm
inches
Weight Kg
pounds
DIMENSIONS
2 gr. 3 gr.
mm
inches 817
32.2 1017 40
568
22.4
89
196
768
30.2
105
232
4 gr.
1217
47.9
968
38.1
120
265
L
L1 mm
inches
Weight Kg
pounds
DIMENSIONS
2 gr. 3 gr.
mm
inches 817
32.2 1017 40
568
22.4
87
187
768
30.2
100
221
4 gr.
1217
47.9
968
38.1
123
271

English
1 EN
WARNING: Installation and disassembly must only be performed by qualied and authorized technicians.
Switch off the power to the machine before performing these steps.
Index
Index 1
Description display symbols 2
Boiler shut off 3
Technical programming ow 4
PROGRAMMING - TECHNICAL
1. Programming access 5
2. Service time menu 6
3. Language selection 7
4. INFO menu 7
Counters 7
Sel. Counters 7
(versions with Turbosteam L and Turbosteam R) 8
Water change 8
Coffee 8
Milk (versions with Turbo Milk) 8
Faults 9
Setup 9
Version 9
Serial No. 9
5. Programming measures function 10
Programming measures for
“self-learning” 11
"Clone" Function 13
 Pressureprole(onlyon“HD”machines) 14
 Availableproles 15
 Editproles 15
6. Testing 17
(versions with Turbosteam L and Turbosteam R) 18
(versions with Turbo Milk) 19
7. Washes 20
Coffee 21
Milk 21
Time 21
8. Turbosteam 22
(versions with Turbosteam L and Turbosteam R) 22
Milk (versions with Turbo Milk) 23
9. Cup warmer 24
10. Heating element 24
11. Programming 25
Coffee Boiler 26
Bluetooth connection 27
 OperationsforMachine-Grinder/Dispenser  
Bluetooth communication 28
 BDSactivationandsensorconguration 30
CongurationMagnumBluetooth
grinder/dispenser sensors 31
Setting recipes and connections with
 Grinder/Dispenser 32
Operating logic 33
Grindercontrolparametersconguration 34
 Dosetimevariationrelativetothe  
 MagnumBluetoothGrinder/Dispenser” 37
 Wi-Ficonguration 38
 EnablingFlushkey 39
 Logo 41
 Serviceslogo 42
Coffeegroupdisplaylogo 43
 Time 43
Updating using USB pen drive 44
Recovery 46
Touchscreendisplaytest 47
12. Diagnostics messages 48
DISASSEMBLY AND SETTING
13. Removal of the side panels 52
14. Cup warmer 53
15. Front stainless steel panel 54
16. Rear panel 55
17. Drain for boiler water 56
18. Removing the boiler heating element 57
19. Coffee boiler 58
20. Services display panel 60
21. Turbosteam control and lance 61
22. Junction box 61
23. Safety thermostat 61
24. Peristaltic pump 62
25. CPU Dip-Switches 62
Battery-Fuse 63
26. TurbosteamLside 64
WIRING DIAGRAM 66
CPU Board 68
Servicesboard 70
 WiringDiagramKey 71
Functional Turbo Milk 72
HYDRAULIC CIRCUIT 73
HydraulicDiagramKey 74
Hydrauliccircuit(versionwithTurboMilk) 75
Hydraulicdiagram  
 key(versionwithTurboMilk) 76
Page Page

English
2 EN
Description display symbols
WATER LEVEL
Thissymbolindicatestheboilerwaterlevel.
 Duringtheloadingphase,thebottompartofthe
icon blinks.
Whentheoptimumlevelisreached,thesymbol
looks like this: .
RESISTANCE
This symbol indicates that the resistance is
activatedandfunctioning; athickerluminousow
passingthroughtheresistanceshowstheelectric
heating is on.
Whentheboilerpressurereachesthesetvalue,
the icon looks like this: .
This indicates that the heating resistance has
been disabled.
Note: the customer cannot switch on or switch
off the electric heating.
When the on/off function is programmed, the
electricheatingtakesplaceautomatically.
SEVICE BOILER PRESSURE
Thissymbolindicatestheboilerpressurevalue.
Iftheicon ispressed,thepressuregauge
willbedisplayedanalogically.Thiswillbeshown
onthedisplay:
Press again the icon to return to the
regulardisplaymode.
COLD MACHINE
Thissymbolindicatesthatthemachineisinitsin-
itial warming stage or that the boiler pressure has
decreasedtobelow0.5bar.
It shows the boiler’s warming status and appears if
one or more boilers are still in their initial warming
stage or if their temperature decreases to below
55°C.
Pressing the “STOP/continue coffee” icon
will cause dispensing to occur at the current tem-
perature.
All the other icons are disabled until required
operating pressure is reached.
Whilewaitingforthemachinetobereadyforuse,
attachthelterholderstothegroups.
The machine has reached programmed operating
temperaturewhentheicon nolonger appears
onthedisplay.
CUP-WARMER
These symbols indicate the
power currently selected by
the cup warmer.
WI-FI
This symbol appears on the display when the
Wi-Fi module is in the machine.
BLUETOOTH
ThesesymbolsrefertoBluetoothcommunication:
- theiconindicatesthepresenceoftheBluetooth
module on the machine;
- the blue icon indicates that the machine is
communicating with a Bluetooth grinder-
dispenser.
USB
ThissymbolappearsonthedisplaywhenaUSB
pen drive is connected.
USB
ThissymbolappearsonthedisplaywhenaUSB
pen drive is connected.
BDS
BDSactivation (BaristaDrivingSystem).

English
3 EN
Press the temperature on the boiler
display.
On the boiler display, press the
indication .
Note:Ifnotpressedwithin5seconds,
theboilerreturns tonormal functioning.
Thegroup boiler isdisabled. Press the
displayatanypointtoreturntonormal
functioning.
Switching off the boiler (only on “HD / GT” machines)
Description display symbols
PAYMENT SYSTEMS
This icon indicates that the machine is connected to a
paymentsystemsinterfaceandisconguredtoworkwithit.
Dispensingisthereforepossiblesubjecttoapprovalbythe
paymentsystem.
- therediconindicatesthatthecashsystemhas
denied the transaction;
- theblueiconindicatesthatthecashsystemhas
approved the transaction.
CONTROL OF THE FLOW (ONLY IF IN USE)
When this icon lights up it means that it is necessary
to adjust the grinder-dispenser to tighten or loosen the
grinding,inordertoreturnthecoffeedosetothecorrect
parameters.
The icons that are shown are:
means that the grinding needs to be loosened.
 (owofcoffeeislowerthanthereference).
means that the grinding needs to be tightened.
 (owofcoffeeisgreaterthanthereference).
Note. The number next to the icon (1 or 2) indicates the
grinder-dispenser that must be used.
Theiconappearsonthedisplayinsteadofthelevelsymbol.
1 32



English
4EN
Data ow chart - Technician programming
Milk (versions with Turbo Milk)
Demand
Effectu
Demand
Effectu
Demand
Effectu
0000000
050.00.P0 --/--/-- - 4.6
047.00.P0 --/--/-- - 3.6
061.00.M0 --/--/--
V00. 49.18.19
Testing
(versions with Turbosteam L and Turbosteam R)
































English
5 EN
Accesstheprogrammingmenubypressing:
1)thekey :
2)thekey :
3)typingthepasswordandpressing :
Returntothe previousmenuor exittheprogramming
menubypressingthekey .
1. Programming access
TECHNICIAN PROGRAMMING
(versions with Turbosteam L and Turbosteam R)






English
6 EN
2. Service time menu
Access the service hours menu by
pressing the icon .
Theseparameterscanbecongured:
USE - timed switch-on/switch-off:
YES,NO, Eco (during the switch-off
phase,themachineresistanceisnot
completely disabled and allows the
boilerpressuretoremainat0.2bar).
ON - (switch-on time);
OFF - (switch-off time);
CLOSED-(dayofclosure).
Press the icon to set the time.Theseparameterscanbecongured:
HOUR, MINUTES, STYLE-(24:00or
AM/PM).
Press the icon to set the date.Theseparameterscanbecongured:
DAY, MONTH, YEAR.
Press the icon .




AUTOMATIC SWITCH OFF / SWITCH
ON
Themachinecanbesettoswitchoffand
switch on at programmed times.
During the machine off phase, the
displaylightisdimmed.
Note. When the machine is working in
the automatic on/off function do not
use the general switch (1) to switch
off the machine. If this happens, the
machine will not be able to switch on
again automatically.
FORCED SWITCH ON
Pushanydispensingbuttontoturniton.
Note. Forcing the machine on does
not change the programmed
on/off times.
Note. At this point the machine will
remain on until the next switch
off time is reached.
To immediately return the machine to
“off”asoriginallyprogrammed,switchit
offandonagainusingthegeneralon-off
switch (1).
2a
2b
2c
1

English
7 EN
Press the icon .Press the icon to choose the desired
language.
3. Language selection
4. INFO menu
Counters
Press the icon .
Counters CountersSel.
Water C. Coffee
Malunc. Setup
Version Serial N.
In the Counters menu the listed parameters are:
Coffee Group... - (number of coffee-based beverages);
Water - (number of times that water was dispensed);
Steam - (number of times that steam was dispensed using the Turbosteam
selector on position TS 1);
Steam + Air - (number of times that steam and air were dispensed using the
Turbosteamselector,positionsTS2÷4);
Hot milk - (number of times hot milk was dispensed);
Cold milk - (number of times cold milk was dispensed);
Total Coffee - (total number of coffee-based beverages);
- (time since last start up).
Scrollthroughtheentriesusing the
and arrows..
In the Selection Counters
menu,theparameters relative tothe
individualkeys aretheonesthatare
counted. Example of counter selection of a
coffee group : Example of counter selection of water
doses :
IntheINFOmenu,youcanview:
1 2
3a
3b



English
8 EN
In the Selection Counters
menu,theparameters relative tothe
individualkeys aretheonesthatare
counted.
Water Change
Coffee
Milk (versions with Turbo Milk)

Press the icon  to display the
"Coffee" submenus.


Press the icon  to display the
"Milk" submenus.


Press the icon  to display the
"Water Change" submenus.

1)Theitemsarescrolledbypressingtheicons .
1)Theitemsarescrolledbypressingtheicons .
1)Theitemsarescrolledbypressingtheicons .
Demand
Effectu
Demand
Effectu
Demand
Effectu
2)Pressthekey to clear/reset.
2)Pressthekey to clear/reset.
2)Pressthekey to clear/reset.
ExampleofaTurbosteamkeyselection
counter :
Counters (versions with Turbosteam L and Turbosteam R)
3c
1
1
12
2
2
Turbosteam 2 (SX)
Turbosteam 1 (DX)

English
9 EN
Fault history

Press the icon  to display the
"Malfunctions" submenus.

1)Theitemsarescrolledbypressingtheicons .
2)Pressthekey to clear/reset.
0000000
Version
Setup
Serial number
Press the icon  to display the
"Serial Number" submenus.

Press the icon  to display the
"Setup" submenus.

- :NUMBER OF GROUPS:2,3,4;
- :VersionDT-HD-GT;
- :Turbosteam: TS - TS/2 - NO;
TurboMilk: YES / NO
-: 1 key;5keys;7keys.
NOTE: machines congured with 1
dispensingkeydonotallow"BDS"and
connectiontothepaymentsystem.
Press the icon  to display the
"Version" submenus.
Thesubmenusunder"Version"show
thememoryversions:
-Master047.00.P0;
-Slave050.00.P0;
-Display061.00.M0;
- FirmwareV00.49.18.19;
- Bluetooth;
- WIFI;
- VEBOX;
- TurboMilk / Turbosteam.

Scroll through the entries using the
and arrows.
050.00.P0 --/--/-- - 4.6
047.00.P0 --/--/-- - 3.6
061.00.M0 --/--/--
V00. 49.18.19
12
1
2
1
1
2
2

English
10EN
Press the icon
.
The icons of the programmable keys
areshownontheservicesdisplay;the
numbersrelativetoeachkeyappearon
thegroupdisplay.
The  key makes it possible to
program water doses with the SELF-
LEARNING function (see specific
paragraph).
Press one of the
coffee keys (ex.
Group 3).
By pressing one of the coffee keys
(e.g.key1),therelativewaterdose
isshownontheservicesdisplayand
theiconofthekeyinquestionremains
highlightedonthegroupdisplay.
Bypressingthe key,thedispensingstartsand
thefollowingscreenappearsontheservicesdisplay:
Theparametersdisplayedare:
Dv: Volumetric meter incremental counter
tG: dispensing time
TB: instant coffee boiler temperature
RB: % activation coffee boiler resistance
P: service boiler pressure
Liv: service boiler water level; % level signal
Rc: service boiler resistance
Evc: service boiler load solenoid valve
TV: Turbosteam wand steam temperature
5. Programming measures function
Press the icon .Press the icon. Theseparameterscanbecongured:
SET… - to set the dispensing time;
%- to set the water temperature.
NOTE. - the red borderaroundtheiconindicatesthekeybeingchanged.
- the TESTING phaseforthewaterkeysissimilartothatofthecoffee
keys.
Press the icontoconrmtheinformationentered.
Water dose programming
5
3
2
4
1




2
1

English
11 EN
Water dose programming using the "self-learning" function
Press key to be programmed. When
the desired level is reached in the
containerpressthekeyagain.
Continuewithanyadditionalprogram-
mingofthekeys.
The dispensing time and temperature
of the water added will be displayed
whichcanbecorrectedmanuallyusing
the buttons .
Afterwards, confirm the values by
pressing the icon.
Pressthe icon toexit the SELF-
LEARNING phase.
Place a container suitable for the
amountyouwishtollbeneath thehot-
water outlet and press the icon.
Thebuzzer sound will stopand thered
border at the top left of the icon
will disappear.
The buzzer sound and the red border
around the icon indicate the
SELF-LEARNING STAGE.
4 5
321
6





English
12 EN
Press the key ; a red outline
and the buzzer indicate the SELF-
LEARNING phase.
Hookthelterholderwiththedose
of ground coffee to the group. Press one of the coffee keys (e.g.
Group 3).
Placethecuporcupsunderneath
thelterholdernozzles.
The numbers relative to each
keyappearonthegroupdisplay.
Pushthe buttonto beprogrammed
(e.g.key1):theiconofthekeyin
question remains selected on the
display.
When the desired level is reached
inthecuporcups,pressthekey
again.
Continue to program all the coffee
keys.
By pushing the coffee buttons on the services display, the doses entered
can be viewed, with the values of the impulses of the volumetric dosing
devices.
Thedosesenteredwiththeself-learningfunctioncanbecorrectedmanually
usingthe+/-keys.
Afterwards,conrmthevaluesbypressingthe key.
Programming measures using the “SELF-LEARNING” function
5
3
2
1
6
4




English
13 EN
At the end of the process, all the
groupswillhavethesameparameters.
Clone function
Press the icon toconrm.
Press the icon .
Thisfeatureallowsyoutoreplicatethecoffeeunitsettingsforallothermachinegroups.
Press one of the coffee keys (e.g.
Group 3).
1 2 3
4




English
14EN
Thisfunctionletsyousettheproleforthepressureatwhichthecoffeeisdispensed.
Pressure prole (only on “HD” machines)
Pressure prole: Start/Stop key
1 3
4B
2
A
231






English
15 EN
8presetprolesareavailableandcan
beviewedwhenconsecutivelypressing
the icon .
Theprolescanbecustomizedbymodifyingthedurationandpressureofeachseparatedispensingphase.
Modifying coffee
group and key
Modifying phases
Dispensing phases
Exit menu
Conrm data
Forexample,phase 2 (in yellow) will have a duration of 7 seconds at 9 bars; phase 3 (in blue) will have a duration of
5 seconds at 7 bars.
Phase 1Is tied toinfusion:asshown intheimageabove, it cannotbemodied( ) and has settings (time and
pressure) similar to those of a traditional machine.
Tomodify( ) phase 1,youmustaccesstheProgramming menu and set the Infusion parameter to NO:
Available proles
Edit Proles
2
1
