LDR Alba F250 PD 3200K User manual

01201000
01201100
01202000
01202100
AlbaF250PD3200K
AlbaF250PD5600K
AlbaPC250PD3200K
AlbaPC250PD5600K
230W,100/260V
PhaseDimming+DMX512
+RDM
istruzioniperl'uso
operatinginstructions
Bedienungsanleitung
instruccionesde
manejo
moded'emploi
gebruiksaanwijzing
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredoMN,Italy.tel+390376771777‐email[email protected]

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
1
ENGLISH–TABLEOFCONTENTS

INTRODUCTION
1.Importantsafetynorms…………………………………………………………………………………page02
2.Boxcontents…………………………………………………………………………………………..………page03
3.Weightanddimensions………………………………………………………………………………….page04
4.Importantnoticebeforetheinstallation/installation…………………………………….page04
5.Mechanicaloperation…………………………………………………………………………………….page05
6.Wiring…………………..……………………………………………………………………………………..page05
7.Voltage…………………….…………………………………………………………………………………….page05
8.Frequency…………………..……………………………………………………………………………..…..page05
9.Connecttothepowersupply………………………………………………………………………….page05

CONTROLANDOPERATION
10.Localcontrolpanelandoperation…………………………………………………………………page06
11.Menu………………………………………….……………………………………………………………..…page06
11.1Blocksdiagram.………………………………………………………………………………………….page06
11.2MainMenu..……………………………………………………………………………………………...page07
11.3FunctionMenu……………………………………………………………………………………….….page07
11.4MeasureMenu.……………………………………………………………………………………….…page10
11.5HiddenMenu…………………………………………………..…………………………………….….page11
12SummaryofControlsandFunctions…..............................................................page12

MAINTENANCE
13.Cleaningandmaintenance…………………………………………………………………….…….page13
14.Spareparts………………………………………………………………………………………………….page13
15.Warranty……………………………………………………………………………..………………………page13

DMXCHARTS
16.DMXChart1……………………………………………………………………………………………….page14
16.1DMXChart2……………………….…………………………………………………………………….page14
16.2DMXChart3……………………………………………………………………………………………..page15

LDRConformityCertificate–CertificatodiConformità–Konformitätserklärungpage16
Complaintform–Modulodireclamo–Reklamationsformular………………………….page17
WEEEDirective–DirettivaRAEE–WEEERichtlinie……………………………………………page18




AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
2

ENGLISH
ThankyouforchoosingaqualityproductfromLucidellaRibaltasrl.Wetrustourproductsandservices
meetyourrequirements,butifnotpleasecontactusdirectlyusingtheattachedfeedbackformtohelpus
improveourservicequality.
Thisspotlighthasbeenmanufacturedwithgreatcareandleftourfactoryinperfectcondition,butifithas
beendamagedintransportpleasecontactyourdealerinthefirstinstance.Afeedbackformisappended.
Ourwarrantycoversallmanufacturingandcomponentdefectsforoneyearfromthedateyoureceived
theproduct.
Ourproductsaredesignedfortheuseofprofessionaltechnicians,andtheinstructionsprovidedhere
ensuresafeandcorrectoperationofthisproduct.LucidellaRibaltasrlwillnotacceptanyresponsibility
wheredamagehasbeencausedtotheproductorpersonsthroughimproperuseoftheproductand/or
non‐compliancewiththeregulationsdescribedherein.

IMPORTANT:Readtheseuserinstructionsbeforeusingthislightingunit

Theinstructionsgivenhereensureasafeandcorrectusageofthisproduct.Auser’sfailuretocomply
withtheinstallation,operating,maintenanceandsafetyproceduresmentionedinthismanual,aswellas
thosegenerallyapplicabletothislightingequipment,maycausetheluminairenottoperformas
expected.
LucidellaRibaltaacceptsnoliabilityfordirect,indirect,incidental,special,orconsequentialdamages
resultingfromthecustomer’sfailuretofollowtheinstallation,operating,maintenanceandsafety
proceduresinthismanualorthosegenerallyapplicabletolightingequipment.
Thelimitationextendstodamagesforpersonalinjury,propertydamage,lossofoperations,lossof
profits,lossofproductorlossoftime,whetherincurredinbythecustomer,thecustomer’semployeesor
athirdparty.
Apartfromtheinstructionsgivenonthismanual,allrelevantsafetyandhealthstandardsofthe
appropriateEUDirectivesmustbecompliedwith.

1. IMPORTANTSAFETYNORMS

ThisproductisratedIP20andisthereforedesignedforinterioruseonly.Fordetailsonmaximum
ambienttemperatureandtiltanglepleaserefertowhatindicatedontheproductlabelorscreen‐
printingonthesideofthelens‐tubeortherearoftheLED‐house
Warning,highvoltageignition.Disconnecttheunitfrompowerbeforeservicing
Continuousmainspowerisrequiredforthisspotlightasaninternaldimmercontrolstheintensity
viaDMXorlocalrotaryknob.Useofaphasecontroldimmedmainssupplymaydamagethe
internalelectronics.
Useofaphasecontroldimmedmainssupplymaydamagetheinternalelectronics
Thisproductfeaturesfan‐assistedventilation.Makesureyoudonotcoverthefansorobstructthe
airflowatanyonetime.
Makesurethefansareworkingcorrectly.Shouldyoudetecteventheslightestmalfunction,switch
theluminaireoffandcarryoutthenecessaryservicing.Replacethefanifnecessary.
Repairingandreplacementofanycomponentofthisproductmustbecarriedoutexclusivelyby
professionalpersonnelinconformitywiththerelevantsafetyandhealthstandardsandonlywith
originalLucidellaRibaltasrlcomponents.
Replacementofanypartofthewiringsystemmustbecarriedoutexclusivelybyprofessional
personnelincompliancewiththeoriginalwiringdiagramandwithcomponentsidenticaltoor
compatiblewiththoseoriginallyfitted.

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
3
Installationofthisproductmustbeexclusivelycarriedoutbyprofessionalpersonnelincompliance
withthesafetynormsinforceinthecountrywheretheproductisused.

Thisproductmustbefittedwithasecondaryfixingsystemsuchasasafetychainorbond.Should
thisnotbesuppliedasastandardaccessory,pleasemakesureyoubuyitseparatelyandinstallit
beforeusingtheproduct.



WARNING:DANGEROFELECTRICALSHOCK
DONOTOPERATEONLIVEEQUIPMENT
Disconnectpowerbeforeopeningthisfixturetoaccessitslightsourceorelectronics.
ThereplacementoftheLEDsourceoranyofitselectroniccomponentscanbecarriedout
exclusivelybyprofessionalpersonneluponLDR’swrittenauthorizationandonlywithoriginalLuci
dellaRibaltasrlcomponents.Failuretoobtainthemanufacturer’sauthorizationtocarryoutthe
replacement/repair,willimmediatelyinvalidatetheproduct’swarranty




WARNING:EYEDAMAGEHAZARD
Makesurethisfixtureisinstalledsoastoavoidprolongeddirectstaringatitsoperatinglightsource
(LED)fromadistanceoflessthan7m/23ft.




WARNING:FIREHAZARD
Neverlocatethisfixtureonanyflammablesurface.
Minimumdistanceofanypartofthebodyoftheluminairefromanyflammablesurfaceorobject:
0,5m
Minimumdistancefromlitsurface,pleaserefertoproductlabel
Makesurethemainspowersupplythefixturewillbeconnectedtoisprotectedbyasuitable
thermalmagneticcircuitbreaker

2.BOXCONTENTS
Uponopeningthepackaging,pleasemakesureitcontainsthefollowing:
lightingunitinthechosenmodel
metalcolourframe185x185mm,fitted
160cmmainspowercablewithfittedNeutrikPowerConblueconnector

Shouldoneormoreitemsmiss,wekindlyaskyoutocontactyourdealerimmediately.


AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
4

3.WEIGHTANDDIMENSIONS


 

Albaf250PDLEDAlbapc250PDLED
netweight:9,7kgnetweight:10,1kg
grossweight:11,9kggrossweight:12,3kg
packingdimensions:60x40x45hcmpackingdimensions:60x40x45hcm


4. IMPORTANTNOTICEBEFORETHEINSTALLATION/INSTALLATION
Beforeinstallingthisfixturecheckitsweightontheproductlabelandtheweightofeachaccessoryyou
areaddingandmakesurethestructureyouareinstallingittowithstandsthetotalweight.
Themountingstirruprotatesaroundthebodyoftheluminaireandisdesignedtoallowthespotlightto
besuspendedfromaboveusingaC‐clamporsimilar,orsupportedonastandorbracketfrombelow.

CAUTION
DONOTTURNTHELUMINAIREUPSIDE‐DOWNBUTALWAYSTURNTHESTIRRUP
IFYOUNEEDTOMOUNTITONASTANDORBRACKET

Note:thespotlight’slocationmustprovidesuitableventilationfortheLEDmodule.

Ifnotsuppliedchooseasuitableclampandmakesureitiscorrectlyfixedandstronglytightened
tothestirrupaccordingtotheclamp’smanufacturer’sinstructions
Ifnotsuppliedchooseasuitablesafetycableorbond.Clampittotheeyeletprovidedonthe
upperrearpartoftheluminaire(seepictureherebelow),runittwicearoundthestirrupandthe
structuretheluminaireishungtosoastobondthemtogetherandclosetheloop.



Whentiltingtheunitmakesuretheknobblockingthestirrupisstronglytightenedandthatthe
luminairecanholdthedesiredtiltangle





AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
5
5.MECHANICALOPERATION
Focuscontrol:islocatedontherearendoftheproduct.Turntheknobclockwisetonarrowthebeam
(SPOT).Turntheknobanticlockwisetowidenthebeam(FLOOD).
Thebeamdistribution(peak/flat)isfixed.
Beam‐shaping:a4leafbarndoor(A20100306)canbefittedonthefrontoftheAlbatocontrolandshape
thebeam
Tilt:thestirrupisfittedwithapositivefrictionclampcontrolledbyalargeknob.Turntheknob
anticlockwisetoreleaseit,positiontheluminaireatthedesiredtiltangleandturntheknobclockwiseto
holdthedesiredposition.Makesuretheknobisstronglytightenedatanytimeduringoperation

6.WIRING
Beforebeingconnectedtothemainspower,thisunitmayneedtobewiredwithasuitableplugifnot
alreadyinstalled.Makesuretheplugyouareusingisratedfortheproperpowerloadanditconformsto
therelevantEU/ULelectricalstandards.

MakesuretheplugyouarefittingwithstandstheLEDpowerload.
Thisfixturemustbegrounded
Toperformacorrectwiring,pleasenotethatthecoresinthismainsleadarecolour‐codedas
follows:
Ground:green+yellow–Neutral:blue‐Phase:brown

Incasethecoloursofthewiresdonotcorrespondtothecolouroftheconnectionpointsonyour
plug,pleaseproceedasfollows:
Thegreenorgreenandyellowwiremustbeconnectedtotheconnectionpointmarkedwiththe
letterEorwiththesymbol orcolouredingreenoringreen‐yellow
ThebluewiremustbeconnectedtotheconnectionpointmarkedwiththeletterNorcolouredin
black
ThebrownwiremustbeconnectedtotheconnectionpointmarkedwiththeletterLorcoloured
inred
Beforeyoufinallypositionthisproductforuse,temporarilyconnectittoaproperlyfusedpower
supplytochecktheunitworkscorrectly.


7. VOLTAGE
Beforeoperatingthisunitpleaserefertotheproductlabelmountedoneachsideoftheluminaireto
checkyouareoperatingwiththecorrectvoltage.

TheAlbaF/PCPDcanbeoperatedbetween90Vand260VandtheelectronicDriverinsidethefixturewill
automaticallyswitchtotheavailablevoltage.WARNING:at100Vac(+/‐10%)itisnecessarytoreducethe
currentoutputfrom3,35Ato3A(seechapter9.4forfurtherdetails).
TheAlbaF/PCPDcanalsobepoweredbyaphasecontroldimmer,leading(triac)ortrailing(IGBT)edge.

8. FREQUENCY
FrequencyonthisproductisautomaticallyselectedbytheelectronicDriver(50/60Hz)

9. CONNECTTOTHEPOWERSUPPLY
Connecttheunittoacontinuousmainspowersource
Makesurethepowersupplyisprotectedbyasuitablethermalmagneticcircuitbreaker
Thisfixturemustbegrounde

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
6
10. LOCALCONTROLPANELANDOPERATION
OPERATION:LCDdisplayforDMXaddress,systemsetupandstatusdetails.
POWER:powerLEDstatusindicator,redcolour.ON=power
DMX:DMXLEDstatusindicator,greencolour.LEDOFF=DMXOFFandphasedimmingormanual
controlactivated,LEDON=DMXMODEactivatedwithnoDMXsignal,FLASHINGLED=receiving
DMX
MENU:4pushbuttonstoselectandmodifytheoperatingmodes(seechapter9forfurther
details)
DMXIN:inputDMXsignal(pin1=0,pin2=DATA‐,pin3=DATA+)
DMXOUT:LoopthroughDMXsignaloutput
POWERIN:Mainspowerinput
POWEROUT:Mainspoweroutput


11. MENU
Itispossibletoselectthedevicefunctionsandsettingsthroughthecontrolpanel(FUNCmenu)or
performdevicediagnosticsbyaccessingthemeasurementsoptions(MEASmenu).
Inordertoaccessanydesiredfunction,presstheMENUbuttonfromthemainscreendisplayedand
browsearoundthevariousoptionswiththe+or–keys;oncethedesiredsub‐menuisreached,pressthe
ENTERbuttontoconfirmyourchoice.
TosaveanyspecificsettingpresstheENTERbutton:5blinksofthedisplaywillconfirmasuccessful
saving.
UsetheMENUbuttontomovefromasub‐menutoitsparentmenu(i.e.goingback).

11.1Menu–Blocksdiagram
Dimmer
100%
DMXAddr
001
MENU
Function
MENU
Measure
MENU
Hide
Manual
100%
FUNCTION
Dimmer
MEASURE
TEMPsens
HIDE
Upload
FUNCTION
Display
MEASURE
DmxValue
HIDE
Download
FUNCTION
OutFreq
MEASURE
Dmxrate
HIDE
ResTime
FUNCTION
FanMode
MEASURE
Alarms
HIDE
ResMemo
FUNCTION
Align
MEASURE
OUTvalue
HIDE
FullMenu
FUNCTION MEASUREHIDE

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
7
DefaultFreqval Current
FUNCTION
DmxChan
MEASURE
OUTcurr
FUNCTION
Remoto
MEASURE
Timers
FUNCTION
Mode
MEASURE
Softver


11.2 MainMenu
TheMainmenuisdisplayedwhenthedriveristurnedon:

Dimmer
#%

InPhaseDimmingmode


ItallowstoviewtheoutputpercentagevalueinthePhase
DimmingmodewhentheLEDisactivatedwithanexternal
leadingortrailingedgedimmer.



 
DMXAddr
001

InDMXmode

ItallowstosettheDMXaddressbetween1and512bypressing
the+and–keysandthenconfirmingbyENTER
 


 
Manual
#%

InManualmode

ItallowstoviewtheoutputpercentagevalueinManual
operativemodewhentheLEDisactivatedwiththeexternal
potentiometer
 



11.3 FunctionMenu
TheFUNCTIONmenuallowstochangeandcustomizesomefunctionalsettingsoftheALBAPDe.g.
dimmingcurveorDMXchannels.Fulldetailsherebelow:
MENU
Function
 
 
 
 
  
FUNCTION
Dimmer

DIMMER
Effect

EFFECT
Xeno

ItallowstosimulateaXenonlampdimmingeffect



 

DIMMER
Tungsten

ItallowstosimulateaTungsten‐Halogenlampdimmingeffect
 
 
 
  

DIMMER
Curve

CURVE
Square
ItallowstoselecttheresponsecurveforALBAPDasquadratic
(default).E.g.50%input=25%output.Thissettingcanonlybe
usedonDMXmode.
  
  
  
 
 DIMMER
Linear
ItallowstoselecttheresponsecurvefortheALBAPDaslinear.
E.g.50%input=50%output.Thissettingcanonlybeusedon
DMXmode.
 
 

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
8
 
  
FUNCTION
Display

DISPLAY
On

ItallowstosettheLCDbacklightasalwaysON(default)
 
 
 
  

DISPLAY
Off

ItallowstoturnofftheLCDbacklight,theLEDPOWERandLED
DMXafter1’30”fromthelatestkeyboardoperation
 
 
 
  
FUNCTION
OutFreq

OUTFREQ
####Hz

ItallowstochangethePWMoutputfrequencybetween320Hz
(default)and1200Hz(10Hzsteps).
 
 
 
  

Itallowstosetthefan‐speedaccordingtotheLEDandthedriver
temperatures.Ifeithertemperatureexceedsthemaximum
admittedvalue,thesystemisprotectedbyasecuritypowerde‐
rating.Oncebothtemperaturesfallbackwithintheadmitted
range,theoriginaloutputisautomaticallyrestored
FUNCTION
FanMode

FANMODE
On

 
 
 
 
   

FANMODE
Silent

Itallowstosetalowerfan‐speedtoreducethenoise
 
  
  
  
  
  
  
FUNCTION
Align

ALIGN
SetMin

SETMIN
####
Itallowstocalibratetheminimumoutputlevelbetween0and
9999(default=400).Thissettingisnotrestoredbythe“default
settings”function



  

ALIGN
SetMax

SETMAX
###
Itallowstocalibratethemaximumoutputlevelbetween250and
255(default=255).Thissettingisn’trestoredby“default
settings”function
  
  
  
  
FUNCTION
Default

AreYou
SURE?

Itallowstorestorethedefaultsettings
 
 
 
  
FUNCTION
DmxChan

DMXCHAN
1Chn

Itallowstoselectthe8bit(1DMXchannel)controlmode
(default).FormoredetailspleaserefertotheDMXchartsatthe
endofthismanual
 
 
 
  

DMXCHAN
2Chn

Itallowstoselectthe16bit(2DMXchannels)controlmode.
FormoredetailspleaserefertotheDMXchartsattheendofthis
manual
 
 
 
  

DMXCHAN
3Chn

Itallowstoselectthe16bit+Strobe(3DMXchannels)control
mode.FormoredetailspleaserefertotheDMXchartsattheend
ofthismanual
 
 
 

AlbaF&PC250PD,3200Kand5600KLEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
9
  
FUNCTION
Remoto

REMOTO
###

ItallowstosettheREMOTOaddressbetween1and250to
connecttheALBAPDtothefirmwareupload/downloadaccessory
(part#A20702072:REMOTOcontrolunit.)
 
 
 
  
FUNCTION
Mode

MODE
PhaseDim

Itallowstosetthephase‐cutdimmingcontrol.
 
 
 
  

MODE
Dmx

ItallowstosettheDMXinputcontrol.
 
 
 
         

MODE
Manual

Itallowstochoosethemanualdimmingcontrol,throughthe
externalpotentiometerontherearplateoftheALBAPD
 
 
 
 

