Lionel Extension Searchlight Car User manual

Extension Searchlight Car
Congratulations on your purchase of the Lionel Extension Searchlight Car! The searchlight is powered through track power by a four-foot-long cable. A handy crank stored on the car
winds the cable on and off its reel. The searchlight illuminates when the track is powered up.
The searchlight itself can remain secured to the car with its magnetic base or can be taken off
and placed anywhere along the track.
Reverse angle
showing crank
operation
Searchlight lamp replacement
Figure 1. Extension Searchlight Car
The searchlight is illuminated by one lamp (Lionel part no. 600-0363-300 for non- Command layouts or Lionel part no. 600-1445-300 for Command Control layouts) avail-
able from your Lionel dealer or Lionel Service. To replace the lamp, remove the light housing
by bending apart the metal tabs. Push down on the lamp and turn clockwise to remove it. Slide
the new lamp into the socket and turn it counterclockwise to lock it in place.
The following Lionel marks may be used throughout this instruction manual and are protected under law.
All rights reserved.
Lionel®, TrainMaster®, Odyssey®, RailSounds®, CrewTalk™, TowerCom™, DynaChuff™,
StationSounds™, Pullmor®, ElectroCoupler™, Magne-Traction®, CAB-1®Remote Controller,
PowerMaster®, Lionel ZW®, ZW®, PowerHouse®, TMCC®, Lionelville™, Lockon®, Wireless Tether™
The name FasTrack®is used with permission from Pitsco, Inc.
71-6615-250
5/04

Connecting cable wires
The cable ends are held inside the reel by spring tension and will come out if the cable is com- pletely unwound and pulled.
To reinsert the cable, straighten the tinned wire
ends and insert the wire into the opening on the
spool surface as far as it will go. As illustrated in
Figure 2, use a nail, the crank handle, or another
pointed instrument to press down the end of the reel
axle and push the wire into the spool about one-
quarter inch. When you release the axle, spring ten-
sion will hold the wire in place. Turn the car onto its
other side and repeat with the other wire.
Reel
axle
Cable
wire
end
Limited Warranty/Lionel Service
Figure 2. Wire insertion
This Lionel product, including all mechanical and electrical components, moving parts, motors and
structural components, except for light bulbs, is warranted to
the original consumer-purchaser, for one year against
original defects in materials or workmanship when
purchased through an authorized Lionel merchant.
This warranty does NOT cover normal wear and tear,
light bulbs, defects appearing in the course of commercial
use, or damage resulting from abuse or misuse of the
product by the purchaser. Transfer of this product by the
original consumer-purchaser to another person voids this
warranty. Modification of this product voids this warranty.
Any warranted product which is defective in original
materials or workmanship and is delivered by the original
consumer-purchaser to Lionel L.L.C. or an authorized Lionel
L.L.C. Service Center, together with proof of original purchase
will, at the option of Lionel L.L.C., be repaired or replaced,
without charge for parts or labor. In the event the defective
product cannot be repaired, and a replacement is not
available, a refund of the original purchase price will be
granted. Any products on which warranty service is sought
must be sent freight or postage prepaid, as transportation
and shipping charges are not covered by the warranty.
In no event shall Lionel L.L.C. be liable for
incidental or consequential damages.
Some states do not allow the exclusion or limitation of
incidental or consequential damages, so the above exclusion
may not apply to you.
This limited warranty gives you specific legal rights, and
you may have other rights which vary from state to state.
Instructions for Obtaining Service
If service for this Lionel L.L.C. product is required, bring
the item, along with your dated sales receipt and completed
warranty information to the nearest Authorized Lionel
Service Center. Your nearest Lionel Service Center can be
found by calling 1-800-4-Lionel, or by accessing our Website
at www.lionel.com.
If you prefer to send your product back to Lionel L.L.C.
for repair in Michigan, you must first call
586-949-4100 or FAX [phone], or write to Customer
Service, P.O. Box 748, New Baltimore, MI 48047-0748, stating
what the item is, when it was purchased and what seems to
be the problem. You will be sent a return authorization letter
and label to ensure your merchandise will be properly
handled upon receipt.
Once you have received your return authorization and
label, make sure that the item is packed to prevent damage
during shipping and handling. We suggest that you use the
product’s original packaging. This shipment must be prepaid
and we recommend that it be insured.
Please make sure you have followed all of the above
instructions carefully before returning any merchandise for
service. You may choose to have your product repaired by one
of our Authorized Lionel Service Centers after its warranty
has expired. A reasonable service fee will be charged.
Warranty Information
Please complete the information below and keep it,
along with your dated sales receipt. You must present this
and your dated sales receipt when requesting warranty
service.
Name __________________________________
Address__________________________________
Place of Purchase __________________________
Date of Purchase____________________________
Product Number ____________________________
Product Description __________________________
©2004 LIONEL L.L.C., CHESTERFIELD, MI 48051-2493
UNITED STATES OF AMERICA
PRINTED IN CHINA