Metra Electronics 99-5810 Parts list manual

INSTALLATION INSTRUCTIONS FOR PART 99-5810
99-5810
KIT FEATURES
•DIN Head Unit Provision with Pocket
•ISO DIN Head Unit Provision with Pocket
A) Radio Housing • B) ISO Brackets • C) ISO Trim Plate
KIT COMPONENTS
A
Small Flat Blade Screwdriver/ Panel Removal Tool
•Socket WrenchSet
1-800-221-0932
©COPYRIGHT 2007 METRA ELECTRONICS CORPORATION
www.metraonline.com
TOOLS REQUIRED:
APPLICATIONS
LINCOLN Town Car
2003-2007
C
B

Dash Disassembly
-LINCOLNTownCar2003-2007. ....................................1
Kit Assembly
-DIN Head Unit Provision with Pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
-ISO DIN Head Unit Provision with Pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Final Assembly ..........................................4
TABLE OF CONTENTS
99-5810
*Note:
Refer also to the instructions included with the aftermarket radio.

99-5810 DASH DISASSEMBLY
LINCOLN TOWN CAR 2003-2007
1
10
0
20
30
40
50 60 70
80
90
100
100
60
20
140
180
110
120
P
C
H
RN21
MPH
0.0
MILES
LINCOLN
Disconnect the negative battery ter-
minal to prevent an accidental short
circuit.
1
Remove (2) 7mm bolts facing upward
above instrument cluster/gauges.
(Figure A)
2
Carefully unsnap and remove dash
panel surrounding radio and instru-
ment cluster/gauges. (Figure B)
3
Remove (2) 7mm bolts above clock
panel and remove panel). (Figure C)
4
Remove (4) 7mm bolts securing radio. 5
Continue to kit assembly.
A
C
B

2
99-5810 KIT ASSEMBLY
B
A
DIN HEAD UNIT PROVISION WITH POCKET
Slide the DIN cage into the Radio
Housing and secure by bending
the metal locking tabs down.
(Figure A)
1
Slide the after-market head unit
into the cage and secure. (Figure B)
2
Continue to final assembly.
*Note: Refer also to the instructions included with the aftermarket radio.

3
99-5810 KIT ASSEMBLY
B
A
ISO DIN HEAD UNIT PROVISION WITH POCKET
Mount the ISO Brackets to the head
unit with the screws supplied with
the unit.
(Figure A)
1
Slide the head unit into the radio
opening until the side clips engage.
(Figure B)
2
Snap the Trim plate into the Radio
Housing.
(Figure B)
3
Continue to final assembly.
*Note: Refer also to the instructions included with the aftermarket radio.

99-5810 FINAL ASSEMBLY
FINAL ASSEMBLY
(A) Strip wire ends back 1/2"
B) Twist ends together
C) Solder
D) Tape
A
B
C
D
Locate the factory wiring harness in the dash. Metra recommends using the
proper mating adapter and making connections as shown. (Isolate and individ-
ually tape off the ends of any unused wires to prevent electrical short circuit.)
Re-connect the negative battery terminal and test the unit for proper operation.
Reassemble radio and dash assemblies in reverse order of disassembly.
1
2
3
4
FINAL WIRING CONNECTIONS
Make wiring connections using the EIA color code chart shown below and the instructions included with the
head unit. Metra recommends making connections as shown below; Strip, Splice, Solder, Tape. Isolate and
individually tape off ends of any unused wires to prevent electrical short circuit.
METRA / EIA WIRING CODE
12V Ignition / Acc. . . . . . . . . . Red
12V Batt / Memory. . . . . . . . . Yellow
Ground. . . . . . . . . . . . . . . . . . Black*
Power Antenna. . . . . . . . . . . . Blue
Amp Turn-On . . . . . . . . . . . . . Blue / White
Amp Ground. . . . . . . . . . . . . . Black / White
Illumination . . . . . . . . . . . . . . Orange
Dimmer . . . . . . . . . . . . . . . . . Orange / White
Right Front (+) . . . . . . . . . . . . Gray
Right Front (-). . . . . . . . . . . . . Gray/ Black
Left Front (+) . . . . . . . . . . . . . White
Left Front (-). . . . . . . . . . . . . . White / Black
Right Rear (+) . . . . . . . . . . . . Violet
Right Rear (-) . . . . . . . . . . . . . Violet / Black
Left Rear (+) .............Green
Left Rear (-) . . . . . . . . . . . . . . Green / Black
*NOTE: When a Black wire is not present, ground radio to vehicle chassis.
All colors may not be present on all leads due to manufacturer’s specifications.

99-5810
NOTES
5

99-5810 INSTRUCTIONS
1-800-221-0932
REV. 5/01/07 © COPYRIGHT 2007 METRA ELECTRONICS CORPORATION INST99-5810
www.metraonline.com