PRO20 HYDRAULIC MIXER • OPERATION MANUAL — REV. #0 (04/17/19) — PAGE 7
SAFETY INFORMATION
DANGER
NEVER operate the equipment in an
explosive atmosphere or near combustible
materials. An explosion or fire could result
causing severe bodily harm or even death.
NEVER mix flammable or explosive substances.
WARNING
NEVER place your hands inside the drum
while starting or operating this equipment.
NEVER disconnect any emergency
or safety devices. These devices are
intended for operator safety. Disconnection of these
devices can cause severe injury, bodily harm or even
death. Disconnection of any of these devices will void
all warranties.
Before operating the mixer, ensure that the safety grate
is in position and correctly fitted.
If applicable, NEVER use your hand
to find hydraulic leaks. Use a piece
of wood or cardboard. Hydraulic fluid
injected into the skin must be treated by a
knowledgeable physician immediately or
severe injury or death can occur.
CAUTION
NEVER lubricate components or attempt service on a
running machine.
NOTICE
ALWAYS keep the machine in proper running condition.
ALWAYS ensure the mixer is on level ground before mixing.
Fix damage to the machine and replace any broken
parts immediately.
ALWAYS store equipment properly when it is not being
used. Equipment should be stored in a clean, dry location
out of the reach of children and unauthorized personnel.
ALWAYS deploy stabilizer jack stands prior to use.
DANGER
Engine fuel exhaust gases contain poisonous carbon
monoxide. This gas is colorless and odorless, and can
cause death if inhaled.
The engine of this equipment requires an adequate
free flow of cooling air. NEVER
in any enclosed or narrow
area where free flow of the
air is restricted. If the air
flow is restricted it will cause
injury to people and property
and serious damage to the
equipment or engine.
WARNING
NEVER
place hands or fingers inside the engine
compartment while the engine is running.
NEVER
operate the engine with heat shields or guards
removed.
NEVER
remove the engine oil drain plug while the engine
is hot. Hot oil will gush out of the oil tank and severely
scald any persons in the general area of the mixer.
CAUTION
NEVER touch the hot exhaust manifold,
muffler or cylinder. Allow these parts to cool
before servicing the equipment.
Make certain the operator knows how to and is capable
of turning the engine OFF in case of an emergency.
NOTICE
NEVER
run the engine without an air filter or with a dirty
air filter. Severe engine damage may occur. Service the
air filter frequently to prevent engine malfunction.
NEVER tamper with the factory settings
of the engine or engine governor. Damage
to the engine or equipment can result
if operating in speed ranges above the
maximum allowable.
