Nidec PG-100 User manual

PG-100
1
HANDYMANOMETER
INSTRUCTION MANUALVer.3.1
Nishi-ShinjukuPrimeSquare.,7-5-25
Nishi-ShinjukuShinjuku-kuTokyo160-0023,Japan
https://www.nidec-copal-electronics.com
Formoredetailedinformationpleaseaskforthenearest
distributororthefollowingsalescenter.
Thankyouverymuchforyourpurchaseofourproducts.
Thisinstructionmanualispreparedforyourproperuse
oftheproduct.
（CompliancewithEMCStandards）
CAUTION Thiscautionmarkdescribeswhenthereisapossibilitythatusermaysufferfromdamageorphysical
damagemayoccuriftheproductisusedimproperly.
CAUTION
⑴Theeachattachmentfittingtorquetothepressureportshouldbelessthan1N・m.
⑵Availabiemediatobemeasuredisairornoncorrosivegasonly.
Theanothermedia,i.e.waterorcorrosivegas/liquidmaydamagetheinternalstructureandcausemalfunction.
⑶Appliedpressuremustbelessthanthespecifiedmaximumpressure.
⑷Internalbattery
①ReplacebatterywithToshibaBatteryCo.,Ltd./ERVM3.6V/lithiumbatteryonly.Useofanotherbatterymaypresentariskoffireorexplosion.Ifyou
needreplacebattery,pleaseplaceanorderwithus.
②When“LOBAT”signisdisplayed,thebatteryshouldbereplaced.
③Thebatteryusedinthisdevicemaypresentriskoffireofchemicalburnifmistreated.Donotrecharge,disassemble,heatabove100℃（ 212℉）,or
incinerate.
④Disposeofusedbatterypromptly.Keepawayfromchildren.Donotdisassembleanddonotdisposeofinfire.
⑸TheonlypHneutraldetergentsshouldbeusedtocleanthebody.
Thesolventssuchasthinners,benzine,etc.mustbenotused.
§
1. HANDLINGNOTES
§
2. TRANSPORTATION&STORAGE
⑴Theproduct,whichisaprecisioninstrument,mustbetakenspecialcarenottobedamagedbyimpactnorbybeingdroppedwhenitistrasportedandin
storage.
⑵Theproductmustbeavoidedinstoragewhereisdusty,drippingandvibrated.

2
§
4. PARTNAMESANDFUNCTIONS
⑴Indicationofmodel
ModelName Series
G/V/R；Gauge,A；Absolute
P:kPa,MP:MPa
H:mmHg,B:bar
Nomark:kgf／cm2
（101G:mmH2O）
PG−１００−＊＊＊ ＊ ＊
§
3. SPECIFICATION
Type G/V/R−Gaugepressure,A−Absolutepressure
Display 31/2Digits−1999〜1999max.,LCDDigital
frequency Approximately3Times/sec.
Function AutoPowerOff（3min.）
 ReadingHold
 LowBatterySign
Accuracy ±0.5%F.S.±2digit（at25℃）
 ±1%F.S.±2digit（101RP,only）
TemperatureCharacteristics（DRIFT）
 Zero;±0.05%F.S./℃±2digit
（101G/101GP/101RP/102AP/102AH...±0.1%F.S./℃±2digit）
 Span;±0.05%Reading/℃±2digit
Battery BuiltinLithiumBattery.Life：min.3,000hours
OperatingTemperature&OperatingHumidity
 0〜50℃,35〜85%RH（Nocondensation）
StorageTemperature
 −20〜70℃,（Lessthan65%RH）
Weight Approximately100ｇ
PressurePort M5Femalethread,0.8mmpitch
Attachmentforintakepressure
 Halfunion（for6mmO.D.tube）,1piece
 Barbjoint（for6mmO.D.4mmI.D.tube）,1piece
Outline
BarbJoint
⑵
⑶
⑷
⑸
⑹
⑺
⑻
⑼
⑽
⑾
⑿
⒀
⒁
Pressuredisplay MeasuredpressurevalueisdisplayedinLCD.
PolaritySign Minus（ −）
  MinusSignisdisplayedwhennegativepressureisapplied.Minus（−）
PressurePort Thepressureintake.
PowerButton Toturnonandoffthepower.IfthebuttonispressedwhilethepowerisON,thepowerturnsOFFandviceversa.
Holdbutton Measuredpressurevalueiskeptwhile“Hold”buttonispressed.
ZeroAdjustmentTrimmer Forzeropointadjustment
BatteryMonitor LOBATsignisdisplayedinLCDwhenabatteryisrunningout.
⑴
⑵
⑶
⑷
⑸
⑹
⑺
Attachment
ButteryMonitor PressurePort
ZeroAdjustment
PressureDisplay
polarityindicator
HoldButton
PowerButton
Strap LIDForButtery
HalfUnion
DisplayUnit
PressureRange Max.Pressure Series Res. Unit
101G
101GP
101RP
102G
102GP
102RP
102GH
102VP
102VH
102AP
102AH
103G
103GP
103GMP
103RP
102VB
102GB
103GB
0〜1000
0.00〜10.00
−10.00〜10.00
0〜1.000
00.0〜100.0
−100.0〜100.0
0〜735
00.0〜−100.0
0〜−735
00.0〜100.0
0〜735
0〜10.00
000〜1000
.000〜1.000
−100〜1000
.000〜−1.000
.000〜1.000
0.00〜10.00
2000
20
20
2
200
200
1471
200
1471
200
1471
15
1500
1.5
1500
2
2
15
1
0.01
0.01
0.001
0.1
0.1
1
0.1
1
0.1
1
0.01
1
0.001
1
0.001
0.001
0.01
mmH2O
kPa
kPa
kgf／cm2
kPa
kPa
mmHg
kPa
mmHg
kPaabs
mmHgabs
kgf／cm2
kPa
MPa
kPa
bar
bar
bar
※
※
※
※Measurementcanbemadeupto“−760mmHg”for102VHandupto“760mmHg”for102AH/GH
(Accuracynotguaranteedbeyondtheratedpressure.).

3
Settheattachment（HalfUnionorBarbJoint）intothepressureport.
Turnonthepower.Thedisplaymustbelessthan±5counts.
（Nopressureapplied）
AdjustthezeropointbyZeroAdjustmentTrimmerwithaminusdrivertohave“000”onthePressureDisplay.
！Donotadjustthezeropointof102AP/102AHbecauseitiscalibratedtoavacuum.
Setatubeintotheattachment
Availabletubesizeandmaterialareasfollows；ForHalfUnion;φ6mmO.D.inNylonorUrethane
ForBarbJoint;φ6mmO.D.,φ4mmI.D.inNylon
Applythepressuretobemeasured.ThevalueisdisplayedwhiletheHoldButtonispressed,thevalueiskept.
ThepowercanbeturnedoffbypressingthePowerButtonorbykeepingthepowerONoverthreeminutes.
Thelatterisanadditionalfunction“autopoweroff”
§
5. HOWTOUSE
NidecCopalElectronicswarrantstheproductsfortheperiodofoneyearafterthedateofthecustomerʼsreceipt.Wewillrepairthetroubledproductscausedby
ourimproperdesigningand/orproductioncontrolatourcost.Ourwarrantyislimitedtotheproductsonly,notonanotherdamagethatiscausedbytheproduct
malfunction.
Pleasenotethattherepairingcostresultedfromthefollowingmattersareoutofourresponsibility.
⑴Troubleanddamagecausedbymishandlingorcarelessusageagainstthehandlimgmanual.
⑵Troubleanddamagecausedbyimproperremodeling,adjustmentorrepair.
⑶Troubleanddamagecausedbynaturaldisaster,fireoranyotherirresistibleforce.
⑷Replacementofattachments.（ HalfUnionandBarbJoint）.
§
6. WARRANTY
⑴
⑵
⑶
⑷
⑸