nilan comfort CT150 User manual

Comfort CT150
Version: 10.00, 13-04-2015
Software-version: 2.30
User manual
User manual
CTS 602 by Nilan

Contents
Contents......................................................................................................................................... 2
List of figures .................................................................................................................................. 2
Introduction..................................................................................................................................... 3
Basic panel..................................................................................................................................... 4
Filter change................................................................................................................................... 5
Condensation drain and water trap................................................................................................. 5
System dimensions ........................................................................................................................ 6
Accessories/spare parts ................................................................................................................. 7
List of figures
Figure 1: Basic - Stepwise adjustable control panel...................Fejl! Bogmærke er ikke defineret.
Figure 2: Filter change.................................................................................................................... 5
Figure 3: Condensation drain.......................................................................................................... 5

May be subject to change Page 3 of 7
Introduction

Please check that the following documents have been supplied with the unit:
- Installation instructions
- CTS 602 User manual (this manual)
- Wiring diagram
The purpose of this guide is to indicate on the proper use and maintenance.
IMPORTANT: If the plant gets damage or otherwise becomes damaged –the injury must be
inspected and repaired by a qualified person.
The plant must be started immediately after installation and connection to the canal system. When
a ventilation system is not running the damp air from the rooms will penetrate up into channels and
installations and dispose condensation water. Condensation water can drain out of the valves and
damage furniture or flooring, condensation water in the system may damage the electronics and
the fans.
The factory settings are adapted to most users, if it is not the case, contact your installer for the
second commissioning.

May be subject to change Page 4 of 7
Basic panel
0: OFF
1: Speed 1
2: Speed 2
3: Speed 3
Slow flashing (½Hz) = filter Alarm
Fast flashing (2 Hz) = critical alarm
The alarm is acknowledged by STOP plant (knob to 0)
Figure 1: Basic - Stepwise adjustable control panel

May be subject to change Page 5 of 7
Filter change
Outdoor- and extract air filters are placed behind the front of the system. These filters must be
controlled at least 3 times a year and replaced as required. (See section about accessories).
Before filter change the system is turned off. Screws are loosened and the lid is removed. The
filters can be removed without using tools.
Figure 2: Filter change
Condensation drain and water trap
Check if condensation drain and water trap is clear off filth, if necessary clean drain and water trap
Figure 3: Condensation drain

- Always disconnect the power to the system

May be subject to change Page 6 of 7
System dimensions
1:
Fresh Air
2:
Air Inlet
3:
Air Exhaust
4:
Air Discharge
11:
Condensation drain
Comfort CT150

May be subject to change Page 7 of 7
Accessories/spare parts
Filters HUSK CT150
Type
System type
Qty
Nilan item no.
Pollen filter for fitting
Comfort CT150
1
3927
Filter G4 (1set = 2stk.)
Comfort CT150
1
39170
Spare parts/accessories
Type
Qty
Nilan item no.
Control panel, 3 steps
1
2399002
CTS 602, control PCB
1
239932
CTS 602, control panel, complete
1
2398
CTS 602, white control panel enclosure
1
2398HX
Advance panel
1
2398H02
Heating cable for condensation outlet (frost protection)
System
Type
Nilan item no.
Comfort
Heating cable
2172