Nokia 600 User manual

Nokia 600
RM-701
Service Manual Level 1&2
1
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
SERVICE MANUAL
Level 1&2
Nokia 600
RM-701
Transce iver characteristics
Band
WCDMA 850/900/1700/1900/2100
GSM850/900/1800/1900
D isp lay
3.2” TFT Capacitive touch with 16.7 M colors
640 x 360 pixels
Camera
5 Mpix EDoF camera with LED flash
Operating System
Symbian Belle
Connections:
USB 2.0
3.5mm J ack
Micro USB
Bluetooth
NFC
WL AN
FM RX/TX
GPS
TV Out via IVE3.5
Transceiver with BL-4J battery pack
Ta lk t ime
Standby
GSM:
Up to 15h
WC DMA:
Up to 6,5h
GSM:
Up to 540h
WC DMA:
Up to 600h
Note:
Talk times are dependent on network
parameters
and phone settings

Nokia 600
RM-701
Service Manual Level 1&2
2
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
Table of contents
1. COPYRIGHT..........................................................................................................................................................................4
2. WARNI NGS AND CAUTIONS.............................................................................................................................................5
2.1 WARNI NGS.................................................................................................................................................................5
2.2 CAUTI ONS...................................................................................................................................................................5
3. ESD PROTECTION ...............................................................................................................................................................6
4. CARE AND MAINTENANCE................................................................................................................................................7
5. BATTERY INFORMATION...................................................................................................................................................8
6. EXPLODED VIEW.................................................................................................................................................................9
7. SERVICE DEVICES ................................................................................................................................................................10
8. SOFT WARE UPD ATE ...........................................................................................................................................................11
9. DISASSEMBLY INSTRUCTIONS.........................................................................................................................................12
10. ASS EMBLY HI NTS................................................................................................................................................................18
11. SOLDER COMPONENTS ......................................................................................................................................................20

Nokia 600
RM-701
Service Manual Level 1&2
3
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
CHANGE HISTORY
Status
Version No.
Date
Comments
Approved
1.0
25.08.2011
First approved version
The purpose of this documentis to help NOKIA service levels 1 and 2 workshop technicians to
carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA
service suppliers, and the content of it is confidential. Please note that NOKIA provides also other
guidance documents (e.g. Service Bulletins) for service suppliers, follow these regularly and
comply with the given instructions.
While every endeavor has been made to ensure the accuracy of this document, some errors may
exist. If you find any errors or if you have further suggestions, please notify NOKIA using the
address below:
Nokia Care Academy
[e-mail]
Please keep in mind also that this documentation is continuously being updated and modified,
so watch always out for the newest version.

Nokia 600
RM-701
Service Manual Level 1&2
4
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
1. COPYRIGHT
Copyright © 2011 Nokia. All rights reserved.
Reproduction, transfer, distribution or storage of part or all of the contents in this document in
any form without the prior written permission of Nokia is prohibited.
Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of
Nokia Corporation. Other product and company names mentioned herein may be trademarks or
tradenames of their respective owners.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes
and improvements to any of the products described in this document without prior notice.
Under no circumstances shall Nokia be responsible for any loss of data or income or any special,
incidental, consequential or indirect damages howsoever caused.
The contents of this document are provided “as is”. Except as required by applicable law, no
warranties of any kind, either express or implied, including, but not limited to, the implied
warranties of merchantability and fitness for a particular purpose, are made in rela tion to the
accuracy, reliability or contents of this document. Nokia reserves the right to revise this
document or withdraw it at any time without prior notice.
The availability of particular products may vary by region.
I MPORT ANT
This document is intended for use by qualified service personnel only.

Nokia 600
RM-701
Service Manual Level 1&2
5
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
2. WARNINGS AND CAUTIONS
Please refer to the phone’s user guide for instructions relating to operation, care and
maintenance including important safety information. Note also the following:
2.1 Warnings
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE
MAN AGEMENT SYSTEMS AND ANTI –SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS,
EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE
DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF
ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN
POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS), BLASTING
AREAS ETC.
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY
INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT
A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS.
OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
2.2 Cautions
1. Servicing and alignment must be undertaken by qualified personnel only.
2. Ensure all work is carried out at an anti–s ta tic worksta tion and tha t an anti–static wris t
strap is worn.
3. Use only approved components as specified in the parts list.
4. Ensure all components, modules screws and insulators are correctly re–fitted af ter servicing
and alignment.
5. Ensure all cables and wires are repositioned correctly

Nokia 600
RM-701
Service Manual Level 1&2
6
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
3. ESD PROTECTION
Nokia requires that service points have sufficien t ESD protection (against sta tic
electricity) when servicing the phone.
Any product of which the covers are removed must be handled with ESD
protection. The SIM card can be replaced without ESD protection if the product
is otherwise ready for use.
To replace the covers ESD protection must be applied.
All elec tronic parts of the product are susceptible to ESD. Resis tors, too, can be
damaged by static elec tr icity discharge.
All ESD sensitive parts must be packed in metallized protec tive bags during
shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product
components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD
Protected Area.
For more information and local requirements about ESD protection and ESD
Protected Area, contact your local Nokia After Market Services representative.

Nokia 600
RM-701
Service Manual Level 1&2
7
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
4. CARE AND MAINTENANCE
This product is of superior design and craftsmanship and should be treated with care. The
suggestions below will help you to fulfil any warranty obligations and to enjoy this product for
many years.
•Keep the phone and all its parts and accessories out of the reach of small
children.
•Keep the phone dry. Precipitation, humidity and all types of liquids or
moisture can conta in minerals that will corrode electronic circuits.
•Do not use or store the phone in dusty, dirty areas. Its moving parts can be
damaged.
•Do not store the phone in hot areas. High temperatures can shorten the life
of electronic devices, damage batteries, and warp or melt certain plastics.
•Do not store the phone in cold areas. When it warms up (to its normal
temperature), moisture can form inside, which may damage electronic circuit
boards.
•Do not drop, knock or shake the phone. Rough handling can break internal
circuit boards.
•Do not use harsh chemicals, cleaning solvents, or strong detergents to clean
the phone.
•Do not paint the phone. Paint can clog the moving parts and prevent proper
operation.
•Use only the supplied or an approved replacement antenna. Unauthorised
antennas, modifications or attachments could damage the phone and may
violate regulations governing radio devices.
All of the above suggestions apply equally to the product, battery, charger or any accessory.

Nokia 600
RM-701
Service Manual Level 1&2
8
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
5. BATTERY INFORMATION
Note: A new battery’s full performance is achieved only after two or three complete charge and
discharge cycles! The battery can be charged and discharged hundreds of times but it will
eventually wear out.
When the operating time (talk-time and standby time) is noticeably shorter than normal, it is
time to buy a new battery. Use only batteries approved by the phone manufacturer and
recharge the battery only with the chargers approved by the manufacturer.
Unplug the charger when not in use. Do not leave the battery connected to a charger for longer
than a week, since overcharging may shorten its lifetime.
If left unused a fully charged battery will discharge itself over time Temperature extremes can
affect the ability of your battery to charge.
For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by
leaving the product switched on until it turns itself off (or by using the battery discharge facility
of any approved accessory available for the product).
Do not attemp t to discharge the battery by any other means Use the battery only for its
intended purpose.
Never use any charger or battery which is damaged.
Do not short-circuit the b a ttery. Accidental short-circuiting can occur when a metallic object
(coin, clip or pen) causes direct connection of the + and - terminals o f the battery ( meta l str ips
on the battery) for example when you carry a spare battery in your pocket or purse.
Shortcircuiting the terminals may damage the battery or the connecting object.
Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions,
will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C
and 25°C (59°F and 77°F).
A phone with a hot or cold battery may temporarily not work, even when the battery is fully
charged. Batteries’ performance is particularly limited in temperatures well below freezing.
Do not dispose batteries in a fire! Dispose of batter ies according to local regulations (e.g.
recycling).
Do not dispose as household waste.

Nokia 600
RM-701
Service Manual Level 1&2
9
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
6. EXPLODED VIEW
Ver. 1.0
A2
A1
WINDOW ASSEMBLY
(I0001 - I0004)
A2
LIGHT SWAP PACKAGE
(I0007 - I0010)
A3
C-COVER ASSEMBLY
(I0015 - I0022)
A4
BATTERY COVER ASSEMBLY
(I0027 - I0028)
WINDOW
I0002
EARPIECE
I0003
EARPIECE GASKET
I0004
DOMESHEET
I0008
CAMERA MODULE
I0011 LOCK KEY
I0012
VOLUME KEY
I0013
DC JACK
I0015
AV JACK
I0016
C-COVER
I0019
GPS FLEX
I0021 FM TX ANTENNA
I0020
NFC FLEX
I0028
DISPLAY
I0006
DISPLAY ADHESIVE
I0007
LIGHT SWAP PWB
I0009
TYPE LABEL
I0010
CAMERA KEY
I0014
IHF SPEAKER
I0017
SPEAKER GASKET
I0018
WLAN FMRX FLEX
I0022 ANTENNA FRAME
I0023
END CAP
I0024
SCREW TORX+ SIZE 6
M1.6 X 5
I0025
SCREW TORX+ SIZE 6
M 1.4 X 4
I0026
BATTERY COVER
I0027
KEYMAT
I0005
TOUCH WINDOW
I0001
Only available
as assembly
Not reuseable
after removal
Repair/swap
only in level 3
L3
L3
L3

Nokia 600
RM-701
Service Manual Level 1&2
10
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
7. SERVICE DEVICES
CA-101 Service Cable
AC-8 Trav el C harger BL-4J Battery
Display removal tool SS-250
Camera removal tool SS-88
Nokia Standard Toolkit (v2)
For more information, refer to the
Service Bulletin (SB-011) on Nokia
Online. Supplier or manufacturer
contacts for tool re-order can be
found in “Recommended service
equipment” document on Nokia
Online.

Nokia 600
RM-701
Service Manual Level 1&2
11
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
8. SOFTW ARE UPDATE
Flash concept (Point of Sale)
To use the FLS-5 Flash Dongle, follow the user guide inside the sales package. Please check
always for the latest version of flash software, which is available on Nokia Online.

Nokia 600
RM-701
Service Manual Level 1&2
12
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
9. DISASSEMBLY INSTRUCTIONS
1) Nokia 600 disassembly.
2) You must use the Nokia Standard Toolkit version
2. You will also need a DC plug, an AV plug, the
camera removal tool SS-88 and the display removal
tool SS-250.
3) Protect the TOUCH WI NDOW with protective fil m.
4) Slide open the BATTERY COVER.
5) Remove the BATTERY COVER.
6) Unscrew the six TORX+ size 6 screws in the order
shown.

Nokia 600
RM-701
Service Manual Level 1&2
13
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
7) Slightly open the TOUCH WINDOW and the C-COVER
to remove the LOCK KEY with the tweezers.
8) Lif t up the C -COVER fromthe bottom side and
remove it to direction shown.
9) Use the SS-93 to release the TOUCH WINDOW
connector. Be careful not to damage the connector
or any nearby components.
10) Release the two clips holding the ENGINE BOARD.
11) Lift up and remove the ENGINE BOARD.
12) Protect the DI SPL AY with protective film.

Nokia 600
RM-701
Service Manual Level 1&2
14
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
13) Use the display removal tool SS-250 to detach
and lever up the DI SPLAY from the bottom side. Be
careful not to damage the microphone.
14) Flip the DISPLAY over and disconnect the DISPLAY
connector with the SS-93. Be careful not to damage
the connector.
15) Remove the DISPLAY.
16) Carefully peel off the DISPLAY ADHESIVE
completely with the SS-93. Do not use it again.
Discard it.
17) Remove the CAMERA MODULE with the camera
removal tool SS-88.
18) Peel off the DOMESHEET with the tweezers. Do
not use it again. Discard it.

Nokia 600
RM-701
Service Manual Level 1&2
15
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
19) Protect the other side of the TOUCH WINDOW
with protec tive f ilm.
20) Lever out the EARPI ECE with the dental tool. Be
careful not to injure yourself or any nearby
components with the sharp end of the dental tool.
21) Remove the EARPIECE with the tweezers.
22) Remove the EARPIECE GASKET with the tweezers.
Do not use it again. Discard it.
23) Remove the KEYMAT with the tweezers.
24) Remove the END CAP.

Nokia 600
RM-701
Service Manual Level 1&2
16
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
25) Lever out the DC JACK with a DC plug. Remove it
with the tweezers.
26) Lever out the AV JACK with an AV plug. Remove it
with the tweezers.
27) Remove the CAMERA KEY with the tweezers. Do
not use it again. D iscard it.
28) Remove the VOLUME KEY with the tweezers.
29) Use the SS-93 to release the two clips from both
sides of the ANTENNA FRAME.
30) Remove the ANTENNA FR AME.

Nokia 600
RM-701
Service Manual Level 1&2
17
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
31) Use the dental tool to lever out the I HF SPEAKER.
32) Remove it with the tweezers.
33) Remove the SPEAKER GASKET with the dental
tool. Do not use it again. D iscard it.
34) The Nokia 600 disassembly is now complete.
-END OF DISASSEMBLY-

Nokia 600
RM-701
Service Manual Level 1&2
18
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
10. ASSEMBLY HINTS
1) Star t to assemble the DI SPLAY on the botto m side
of the TOUC H WI NDOW.
2) Use the tweezers to connect the ENGINE BOARD to
the DI SPLAY. Be careful not to damage the connector
or any nearby components.
3) When assembling the CAMERA KEY hold it as
shown and insert the shown pin in its place.
4) Then rotate the CAMERA KEY counterclockwise and
attach the two shown clips.
5) Flip the ENGINE BOARD over on top of the TOUCH
WINDOW and push it down slightly until it snaps.
Then attach the TOUCH WINDOWconnector.
6) Use the tweezers to position the LOCK KEY from
the left side. Slightly push the TOUCH WINDOW and
the C-COVER together to have the LOCK KEY in place.

Nokia 600
RM-701
Service Manual Level 1&2
19
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
7) Tighten the two TORX+ size 6 screws to the torque
of 13 Ncm.
8) Tighten the four TORX+ size 6 screws to the torque
of 17 Ncm.

Nokia 600
RM-701
Service Manual Level 1&2
20
Co nf id e nt ial | C o p yr ig ht © 2011Nokia |A ll rights reserved
V e r s io n 1 .0
11. SOLDER COMPONENTS
X7590
X7591
V2405
V2406
X2072
F3300
X6500
X6501
X6000
F3301
V2407
K2405X6001 S2402
S2404
S2403
G2200
Ver. 1.0
TOP
BOTTOM