Nokia RH-27 Series Guide

CCS Technical Documentation
RH-27 Series Transceivers
Issue 1 11/2003 Confidential ©2003 Nokia Corporation
Assembly

RH-27
Assembly CCS Technical Documentation
Page 2 ©2003 Nokia Corporation Confidential Issue 1 11/2003
Step-by-Step Assembly Instructions
Alway use ESD protection
Assembly Instructions
Step-by-Step Assembly Instructions (Model 6225)
1. Press the Release Key down into its correct position. 2. Put the Release Spring into its place.
3. Put the DC Jack into its place. 4. Put the Vibra into its place.
Note! Avoid touching the spring contacts.

CCS Technical Documentation Assembly
RH-27
Issue 1 11/2003 Confidential ©2003 Nokia Corporation Page 3
5. Put the Volume Key into its place. 6. Put the Power Key into its place.
7. Put the Antenna into its place.
Note! Do not touch the inside of the Antenna plate.
8. Put the UI Board into its place.
9. Place the LCD into the UI frame. Note! Do not press the LCD as it may get damaged.
10. Fit the Display Shield into its place. Make sure the shield is properly locked on both sides to
the frame.
Step-by-Step Assembly Instructions (Model 6225)

RH-27
Assembly CCS Technical Documentation
Page 4 ©2003 Nokia Corporation Confidential Issue 1 11/2003
11. Put the Speaker into the frame so that the guiding
pin goes into its place.
12. Put the Microphone into the frame.
Note! Do not touch the spring contacts.
13. Place the UI Module and the engine together by
closing the Display connector.
14. Put the unit into the C-cover. 15. Tighten the six screws in the order indicated above.
Note! Set 20Ncm/650rpm to your Torque driver before
tightening.
16. Place the B-cover into its place. Make sure the
snaps on both sides are locked to the module.
17. Place the Keymat into its place.
Step-by-Step Assembly Instructions (Model 6225)
1. 3. 5.
2. 4. 6.

CCS Technical Documentation Assembly
RH-27
Issue 1 11/2003 Confidential ©2003 Nokia Corporation Page 5
18. Place the A-cover into its place. 19. Slide the Battery cover into its place until the
Release Key locks it.
Assembly complete!
Step-by-Step Assembly Instructions (Model 6225)

RH-27
Assembly CCS Technical Documentation
Page 6 ©2003 Nokia Corporation Confidential Issue 1 11/2003