Norac UC5 Topcon X30 User manual

Spray Height Controlle
r
ECHO Display Kit
Installation Manual
ECHO-DT1

Printed in Canada
Copyright 2010 by NORAC Systems International Inc.
Reorder P/N: ECHO-DT1-INST Rev B (ECHO Display Kit)
NOTICE: NORAC Systems International Inc. reserves the right to improve products and their specifications without notice and
without the requirement to update products sold previously. Every effort has been made to ensure the accuracy of the information
contained in this manual. The technical information in this manual was reviewed at the time of approval for publication.

1
Contents
1INTRODUCTION .............................................................................................2
1.1List of Parts................................................................................................................................................................. 2
1.2Optional RAM Mount Ordering Information ...................................................................................................... 2
2INSTALLATION ...............................................................................................3
3CABLE DRAWINGS.........................................................................................4
3.1ITEM C01: 43210-01 - CABLE UC5 NETWORK 18 AWG - 1M .................................................................. 4

2
1Introduction
The ECHO™ Display Kit Manual is intended to be used in conjunction with the UC5™ Spray
Height Control Installation Manual. This manual provides instructions to interface the UC5
Control Module to the ECHO Display. For installation of the rest of the UC5 Spray Height
Control System please refer to the sprayer specific manual provided with the kit.
Your input can help make us better! If you find issues or have suggestions regarding the parts
list or the installation procedure, please don’t hesitate to contact us.
1.1 List of Parts
Item Part Number Name Quantity
C01 43210-01 CABLE UC5 NETWORK 18 AWG 1M 2
D01 43700 UC5 ECHO DISPLAY PANEL 1
E20 43764T UC5 NETWORK COUPLER 2-WAY WITH TERMINATOR 2
M01 UC5-BC-MANUAL-ECHO_VT MANUAL UC5 OPERATORS - ECHO/VT 1
M04 ECHO-DT1-INST MANUAL UC5 ECHO TERMINAL DISPLAY KIT 1
If this kit is being installed with an existing system with control module serial
number lower than 3200, the following cable is required:
Item Part Number Name Quantity
C30 43250-17 CABLE UC5 POWER RETROFIT FOR ECHO SWITCH 1
1.2 Optional RAM Mount Ordering Information
This is an optional suction cup mount that may be useful when mounting the ECHO display.
This mount is not supplied with this kit, but can be ordered as per the following information:
To order from NORAC: • Contact us at any of the numbers above.
• Part number - 106332
To order from RAM: • Go to www.ram-mount.com or visit your local RAM dealer.
• Part number - RAM-B-224-1U

3
2Installation
Ensure the ECHO power switch is OFF for the remainder of the installation
(Bottom of switch pressed IN).
1. Install the ECHO™ display in the cab of the sprayer where it will be clearly visible and
within easy reach of the operator.
2. RAM manufactures a suction cup mount that works well for installing the ECHO display.
The suction cup mount is not supplied with this kit, but is available from NORAC or RAM.
See Section 1.2 for ordering information.
3. Connect the cable from the ECHO display (D01) to one of the couplers (E20) and connect
one of the network cables (C01) to the other side of the coupler. Connect the remaining
coupler (E20) between the two network cables (C01).
4. Connect the free end of the second network cable (C01) to the Display Bus connector on
the control module (E01). This is the end of the control module that only has one Deutsch
connector.
Figure 1: ECHO Display Kit Parts

4
3Cable Drawings
3.1 ITEM C01: 43210-01 - CABLE UC5 NETWORK 18 AWG - 1M

Canada
NORAC Systems International Inc.
Phone: [phone]
Toll Free: 1 800 667 3921
Shipping Address:
3702 Kinnear Place
Saskatoon, SK
S7P 0A6
United States
NORAC, Inc.
Phone: [phone]
Toll Free: 1 866 306 6722
Shipping Address:
6667 West Old Shakopee Road, Suite 111
Bloomington, MN
55438
Europe
NORAC Europe
Phone: (+33) (0)4 26 47 04 42
Shipping Address:
Rue de l’hermitage
01090 GUEREINS
France
www.norac.ca