Ozark Trail 30006 User manual

STITCH LINE
Before you begin
Read all instructions thoroughly before beginning set up.
• Select a level site clear of rocks, branches, and other hard or sharp objects, to set up your tent.
WARNING: Keep clear of overhead power lines.
• Do not set up your tent under trees because of potential lightning strikes or falling tree limbs
in inclement weather.
• For best results in windy conditions, position narrow end of tent into the wind.
• Secure with all stakes and guylines provided to prevent property damage or personal injury.
• Two people can easily setup this tent in 60 seconds or less. Scan the QR code to view our
60 second setup video.
Extend Tent Frame
CAUTION: Avoid pinch points when
opening or closing the tent frame.
• Unfold and spread out tent. (Fig. 1)
1
Fig. 1
HUB ASSEMBLY
Setup Instructions:
ROOF POLES
2
Lift Roof Poles
• Lift up on ARM JOINT and ROOF POLE. The tent will partially raise
when ARM JOINT is fully extended. (Fig. 2 & 3)
• Repeat step above for the remaining 3 ROOF POLES.
3
Fig. 4
LOCKING
BUTTON
Extend Telescoping Leg Poles
• Moving to front 2 corners of tent; extend TELESCOPING LEG POLES until the silver LOCKING BUTTONS
“click” into locked position. (Fig. 4)
• Repeat above step for 2 back TELESCOPING
LEG POLES. (Fig. 5)
(continued on other side)
6 PERSON INSTANT CABIN TENT -10 x 9 Item No. CV1009IN
Model No. 30006
Attach Rainfly
• Drape RAINFLY over tent as shown. (Fig. 6)
• Clip HOOK attached to SHOCKCORD of Rainfly onto FABRIC LOOP on tent. (Fig. 7)
• Secure RAINFLY to both LEG POLES with HOOK & LOOP FASTENERS
(located on underside of Rainfly). (Fig. 8)
4
RAINFLY
Fig. 6
ROOF POLES
Fig. 3
ROOF POLES
ROOF POLES
DOOR
ARM JOINT
ARM JOINT Fig. 2
ARM JOINT
ROOF
POLE
NOTE: You can now
easily move your
tent to its final
position
before installing the
Rainfly and securing
with stakes
and guylines. Fig. 5
DOOR
TELESCOPING
LEG POLES
TELESCOPING
LEG POLES
HOOK & LOOP
FASTENER
Fig. 8
DOOR
To Secure Tent:
Stake Tent
• Locate WEBBING LOOPS sewn into the corners at the base of your tent.
• Slide STAKE through WEBBING LOOP at each location; then gently extend out before securing. (Fig. 9)
NOTE: Floor of tent should be taut when staked properly.
Secure Guylines
• Locate GUYLINES attached to the tent and unroll.
• Slide STAKE through loop at each location, extend out and drive in to secure. (Fig. 10)
NOTE: Four corner GUYLINES should extend out at a 45º angle from tent & awning.
• Tighten GUYLINES as needed by adjusting the SLIDER up the cord.
Fig. 9
WEB
LOOP
Fig. 10
SLIDER
Fig. 7
RAINFLY
FABRIC
LOOP
CORD &
HOOK
GUYLINES

STITCH LINE
Take Down & Storage Instructions:
To Take Down Tent
Follow the previous steps and illustrations in the reverse order:
• Remember to push the silver LOCKING BUTTON and telescope the 4 on the LEG
POLES. (Fig. 14)
• Push down on the ARM JOINTS where the legs meet the ROOF POLES starting with
the two middle poles first, then the corner poles. The roof will collapse in and
then pull all the poles inward under the central hub and then fold up the leg poles.
• Lay the tent down on it’s side and roll out the excess air and put back into the bag.
Things You Should Know
• Under certain conditions (cold weather, high humidity, etc.)
condensation will form on the inside of your tent. Conden-
sation is caused by water vapor from your breath, perspira-
tion, or any wet clothing inside the tent. It is NOT LEAKAGE
through the tent fabric. It can be minimized by removing
wet clothing from your tent and by providing good ventila-
tion through the tent.
• Never store tent, even for a short period of time, without
drying it thoroughly and brushing off caked dirt. Do not
pack stakes inside your tent. Use a separate storage bag.
• STAKES SHOULD BE REMOVED BY PULLING ON THE
STAKE ITSELF. NEVER PULL ON THE TENT TO REMOVE
STAKE.
• Do not leave your tent set-up for weeks at a time. Be aware
that exposure to ultraviolet rays from the sun can seriously
damage material and/or cause it to become discolored.
WARNING: Keep all flame and heat sources away from
this tent fabric.
This tent meets the flammability requirements of CPAI-84. The
fabric may burn if left in continuous contact with any flame
source. The application of any foreign substance to the tent
fabric may render the flame-resistant properties ineffective.
Description Part Number
90001 Plastic Clip (16mm)
90002 Plastic Clip (20mm)
90019 Tent Stakes (Large)
90020 48” Replacement Bag with
Compression Straps (Black)
90021 Base of Leg Pole Plastic Connector
(T-shape that goes into the foot)
90029 Center Hub
90030 Corner Roof Pole & Leg Pole (4 Per Tent)
90031 Rainfly
90032 Floor Mat
REPAIR PARTS LIST
Tent Features:
Welcome Mat
• Attach Welcome Mat by
inserting the plastic
toggles through the fabric
loops located below the
doorway along the base
of the tent.
(Fig. 11)
Electrical Cord Access
• Insert electrical cord through
access panel in the lower left
corner of tent. (Fig.12)
NOTE: Use only UL approved cords
rated for outdoor usage.
Fig. 12 ACCESS
PANEL
POWER
CORD
DOOR
WELCOME MAT
Fig. 11
6 Month Limited Warranty
Campvalley (Xiamen) Co., Ltd. Warrants for a period of six months from
the original date of purchase, this product against any defects in materials
or workmanship. At its discretion, Campvalley may provide replacement
parts to original purchaser. Original receipt or proof of purchase is required.
Campvalley will not be responsible for shipping costs incurred outside the
USA. Warranty is valid for the original purchaser from the date of purchase
and is not transferable.
This Warranty Does Not Cover
This 6 Month Limited Warranty does NOT cover normal wear and tear,
abuse or misuse of this product including damage from inclement weather
conditions, including: wind, rain, hail, lightning, tornados. Prolonged
exposure to UV rays will cause any fabric to fade and deteriorate and is NOT
covered by this 6 Month Limited Warranty. This warranty gives you specific
legal rights. You may also have other rights which vary from state to state.
Under no circumstances shall Campvalley (Xiamen) Co., Ltd be liable or
responsible for any incidental or consequential damages.
Our products are designed and manufactured to the most stringent speci-
fications. However, inclement weather including wind and rain may loosen
stakes, invite pooling and cause the frame to weaken. If pooling should occur
it is advisable to adjust the stakes and guylines to avoid damage to the frame
and fabric. In case of inclement weather remove all valuables and persons and
seek appropriate shelter.
This product is designed and intended for Recreational use only.
To Obtain Warranty Service
Call 1-888-774-5840 for repair parts or product questions.
NOTICE: DO NOT RETURN PRODUCT TO RETAIL STORE.
Campvalley (Xiamen) Co., Ltd.
No.18th, West Road 3, Jinyuan, Jimei District, Xiamen, Fujian 361022 (China)
Customer Service: 1-888-774-5840
Made in Bangladesh • Printed in Bangladesh
WARNING: KEEP ALL FLAME AND HEAT SOURCES AWAY FROM THIS
TENT FABRIC
This tent is made of flame-resistant fabric which meets CPAI-84 specifications. IT IS NOT FIRE-PROOF. The
fabric will burn if left in continuous contact with any flame source. The application of any foreign substance
to the product fabric may render the flame-resistant properties ineffective.
DO NOT use fuel burning devices inside or near tent materials.
DO NOT permit children to light matches, operate burning appliances, or handle any flame sources in or near
the tent.
All fuel-burning appliances use air. Lack of fresh air can cause poor combustion and deadly carbon monox-
ide. Never use burning appliances in tent without providing a fresh air opening of at least 40 square inches.
• Never use fuel burning products while sleeping.
• Do not smoke, use matches, candles or open flames of any kind in or near the tent.
• Build campfires several meters downwind from the tent; making sure to fully extinguish campfires before
leaving campsite or retiring for the night.
• Do not refuel lanterns, stoves or heaters inside tent.
• Do not cook inside tent.
• Do not store flammable liquids inside tent.
Fig. 14
LOCKING
BUTTON
Storing the Tent
• Remove guylines and stakes and place in their storage bag.
• All stakes must be placed in their own storage bag before
placing in tent carrying case to prevent damage to the
tent fabric.
• Store in a clean, dry area.
IMPORTANT:
THE ORIGINAL FIRE RETARDENT AND WATER REPELLENT PROTEC-
TIVE COATINGS MAY BE COMPROMISED IF SPRAYS OR OTHER
CHEMICAL TREATMENTS ARE USED ON THE TENT. FABRIC HAS BEEN
FACTORY TREATED. IT IS HIGHLY WATER-REPELLANT; HOWEVER, IT
IS NOT WATERPROOF. ALL TENTS CAN EXPERIENCE SEAM LEAK-
AGE DURING WET WEATHER. IF YOU WANT ADDITIONAL MOISTURE
PROTECTION, TRY A SEAM SEALING COMPOUND ONLY; STRICTLY
FOLLOW THE MANUFACTURER’S DIRECTIONS. IT IS RECOMMENDED
THAT YOU SEAL THE TENT DURING THE INITIAL SETUP AS WELL AS
PRIOR TO EACH CAMPING SEASON. SEAM SEALER COMPOUNDS
CAN BE PURCHASED AT YOUR LOCAL CAMPING PRODUCTS OUTLET.
FOR MISSING PARTS CALL 1-888-774-5840.
PLEASE DO NOT RETURN THIS PRODUCT TO THE RETAIL STORE.
Organizer
• Attach Organizer by inserting the plastic
hooks located at each corner through the
fabric loops located at the back of the tent.
(Fig. 13)
Fig. 13
FABRIC LOOPS
FABRIC LOOPS
ORGANIZER