Ozark Trail WMT-1390S-1 User manual

OWNER’S MANUAL
Model #WMT-1390S-1
13' x 10' Screenhouse

SAFETY CARE
WARNING: KEEP ALL FLAME AND HEAT
SOURCES AWAY FROM THIS TENT FABRIC.
This tent meets the flammability require-
ments of CPAI-84. The fabric may burn if left
in continuous contact with any flame source.
The application of any foreign substance to
the tent fabric may render the flame-resis-
tant properties ineffective.
DO NOT...
1. Do not pitch tent near an open flame.
2. Do not leave campfires unattended.
3. Do not allow CHILDREN or ADULTS
to use lighted candles, matches or
other flame sources in or near tents.
4. Do not use heating, lighting or
cooking equipment with open
flames in or near tents.
5. Do not use fuel burning/oxygen
consuming devices (i.e. heaters,
lanterns, or other flame sources)
inside your tent at any time.
6. Do not use other than recommended
water repellent compounds on your
tent.(See:“Seal the Seams”)
7. Do not spray the tent with insecticide.
8. EXTREME CAUTION: Never use any
fuel burning/oxygen consuming
device, or any device that produces
fumes (including stoves, lanterns,
candles, hibachis, or heaters) in or
around your tent. Inhalation of fumes
may result in carbon monoxide
poisoning, injury and/or death.
DO...
1. Always extinguish campfire before
leaving area.
2. Exercise care when using electricity
and lighting in and near tents.
3. Disassemble and store tent properly
after camping to ensure the tent’s
longevity.
4. Always use a hammer/mallet when
driving stakes into the ground.
This recreational item is not intended for
use as a permanent structure, as fabric
will quickly degrade if exposed to UV
light. No (sun shelter, screenhouse, tent)
can withstand prolonged exposure to
sunlight. UV damage is not covered under
the limited 90 day warranty.
Structural Integrity
Although our tents and screenhouses are
constructed to rigid specifications, periods
of wind or rain soaking the ground may
loosen the stakes and cause the uprights to
sink into the ground.This will weaken the
rigidity of the overall structure.Water pock-
ets may also form in the roof if the unit is
not assembled taut, the weight of which
may cause broken frames and torn fabric.
Storage
Tents/screenhouses must never be rolled
up or packed while damp, as mildew will
form within a few days. Allow tent to dry
completely before rolling and storing.
LIMITED 90 DAY WARRANTY
For 90 days from the date of purchase, Ozark Trail will
replace, at our option, defects in material or workman-
ship that appear in this product, free of charge. Product
must be original factory packaging and unmodified.
You m ust have a copy of your Wal-Mart receipt.
Warranty service is available by calling:
toll free 1-800-775-1965
Mon.–Fri, 7:00 a.m. to 4:00 p.m. (PST-West Coast)
Ozark Trail
3333 Yale Way • Fremont, CA 94538-6169
This warranty gives you specific legal rights.You may
also have other rights which vary from state to state.

RPL2-03 Roof pole “2” 3
RP2B-03 Roof pole “2B” 9
SPL1-03 Side pole “1” 4
MPL5-03 Middle (roof ) pole ”5” with hook 2
MP5B-03 Middle (roof) pole “5B” with hook 2
LPL4-03 Leg pole “4” with holes 4
PL1B-03 Pole “1B” used on side and leg 12
GBLL-03 3 way hub Gable L 2
GBLR-03 3 way hub Gable R 2
GBLT-03 3 way hub Gable T 2
CBAG-03 Carry bag 1
PBAG-03 Pole bag 1
SBAG-03 Stake bag 1
UN-GROPE Guy rope 4
UN-75ABSSTK 7.5" Steel Stake 18
UN-DRING Steel D-ring 8
UN-STSHOOK Steel S-hook 4
PSET-03 Poles/ set of 36 1
SSET-03 Stakes/ set of 18 1
REPLACEMENT PARTS
PART NO. DESCRIPTION QTY. REQ.
1GBLL-03
4
5
1B
1B
1
1B
Model # WMT-1390S-1
HOW TO ORDER REPLACEMENT PARTS
Always mention the Model number in all correspondence regarding your tent and when ordering
replacement parts. To order replacement parts listed below, or for any questions regarding your tent,
call 1-800-775-1965 Mon.–Fri, 8:00 a.m. to 5:00 p.m. (PST-West Coast)
or write to: Ozark Trail • 3333 Yale Way • Fremont, CA 94538-6169
WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION:
1. Model Number 2. Part Number 3. Part Descriptions
GBLL-03
GBLT-03
1
5B
5
1B
GBLR-03
GBLT-03
1B
2B 2B 2B 2
5B
GBLR-03

Step 1 – Lay Out the Screenhouse and Poles
Select a smooth, level site and spread out your
screenhouse.
Sort the poles by number and connect the
sections together. See diagrams below for
numbering.
Step 2 – Install the Poles
Insert the ends of each of the three roof poles
into the 3-way hubs . See Diagram 1.
Insert the four side roof poles into the 3-way
hubs. See Diagram 2.
Insert the leg poles into the hubs to raise the
screenhouse frame. Make sure that the pole
end with the holes in the sides ( ) is pointing
down. See Diagram 3.
Step 3 –Secure the Screenhouse
Drape the screenhouse body over the frames.
Hook the S-Hooks into one of the holes
located at the bottom of the leg poles.
Wrap the velcro tape , located inside the
screenhouse, around the poles to secure them.
When the screenhouse is in its proper location,
stake it down by driving stakes through the
four D-rings located on at the corners.
Step 4 – Install the Guy Lines
Tie the loose end of a guy line through D-ring
Repeat for the other three guy lines.
Make a loop at the end of the guy line with the
slider. Stake the looped end of the line out
about 3' from the base of the pole. Adjust the
slider until the line is taut .
ASSEMBLY INSTRUCTIONS: WMT-1390S-1
2B 2B
2B
2
2B 2B
2B
2
2B 2B
2B
2
1B
1
1
1B
1
T
L
5
5B
1B
R
RL
5B
5
2
2B
2B
2B
T
2B
2B
2B
2
1B
1B
4
1B
1B
4
1B
1B
4
1B
1B
4
2B 2B
2B
2
E
H
B
D
A
G
Diagram 1
Diagram 2
Diagram 3
slider for adjusting
guy line tension
IMPORTANT: WE ADVISE YOU TO ASSEMBLE THE TENT ONCE BEFORE GOING CAMPING TO ASSURE THAT
ALL PARTS ARE PRESENT AND TO BECOME FAMILIAR WITH THE ASSEMBLY OF THE TENT.
To prolong the life of the tent floor, select a level, clean area for the campsite.
C
C
C
T
L
R
T
L
R
hub

Taking Down Your Tent
–Unzip doors and windows and collapse the tent,
removing and disassembling the poles. Place
poles in the pole storage bag and tie shut.
–Removestakes. Do not remove stakes from the
ground by pulling on the stake loops.This may
cause the stake loops to tear out of the seam.
–Spreadtentout flat with all loose fabric and
rainfly (if tent has one) within the edges of the
tent base.Try to flatten tent as much as possible.
–Fold tent in half, thirds or quarters. (Folding
depends on the length of the tent pole sections.)
–Place pole bag on back end of tent (trapped air is
more easily forced out of the open door when
you are rolling up the tent.) The folded tent
should be the width of the pole bag.
–Beginning at the back end, roll your tent tightly
around the pole bag, forcing out excess air as you
roll. Keep tent edges straight and pole bag
centered as you roll.
–When tent is rolled up, tie strap around it and
place into tent carry bag with stake bag, instruc-
tion sheet, and other miscellaneous parts. If tent
won’t fit into bag, unroll and reroll more tightly.
Dimension A should
be close to but not
exceed the length of
the pole bag.
A
Fold tent into a
rectangular shape.
front of tent
(door unzipped)
D
B
G
H
(inside screenhouse)
E

CAMPER’S CHECKLIST AND HELPFUL HINTS
SAFETY AND HEALTH AIDS
•Insectrepellents
•Suntanlotions
•Firstaid kit
•Lifepreservers
CAMP NEEDS
•Axeorhatchet
•Pocketknife
•Sewing kit
•Heavy-duty tape
•Ropeandclothes pins
•Small shovel (to extinguish fires)
•Fishing rod and other sporting gear
•Broom
•Whiskbroom
•Compact tool kit
•Hammer or mallet
CAMPING EQUIPMENT
•Tent
•Sleeping bags
•Ground sheet
•Airmattress and repair kit
•Portable stove
•Cooler
•Water jug
•Pail
•Toilet tissue
•Washbasin
•Mirror
•Foldingtable
•Lounge chairs
•Funnel for fueling appliances
•Camp lantern with extra mantles
•Flashlight
•Small fire extinguisher
•Raincoats
•Waterprooftarpaulins
•Waterproof matches
KITCHEN EQUIPMENT
•Camp stove
•Grill top and charcoal
•Firestarter
•Frypan
•Saucepans
•Coffee pot
•Heavy-duty aluminum foil
•Potholders
•Mixing and serving spoons
•Cookingfork,tongs,spatula
•Kitchenknives
•Can/bottle opener
•Storage containers
•Cooler
•Icepack
•Insulated jug
•Water container
•Tablecloth, napkins, plates
•Mugs,glasses
•Table knives, forks, spoons
•Dish pan
•Detergent
•Potscrubbers
•Plastic garbage bags
•Papertowels
TRAVEL AIDS
•Road maps
•Sunglasses
•Litter bags
•Games
•Binoculars
•Cameraand film
•Waterprooftarpaulins
•Waterproof matches

THANK YOU FOR PURCHASING A SUPERIOR QUALITY OZARK TRAIL TENT. THIS TROUBLESHOOTING GUIDE IS
DESIGNED TO GIVE YOU YEARS OF FUN AND ENJOYMENT FROM YOUR CAMPING EQUIPMENT.
TROUBLESHOOTING GUIDE
PROBLEM SOLUTION
1. CONDENSATION THIS IS CAUSED BY LOWER TEMPERATURES ON THE OUTSIDE OF THE TENT
COMBINED WITH BODY HEAT ON THE INSIDE OF THE TENT. WHEN THIS OCCURS,
AVOID TOUCHING WALLS TO REDUCE CONTACT LEAKAGE. LEAVING THE DOORS
AND WINDOWS OPEN WILL REDUCE CONDENSATION OF MOISTURE .
2. SEAM LEAKAGE TO PROTECT AGAINST SEAM LEAKAGE, APPLY A GENEROUS AMOUNT OF SEAM SEALER
ON ALL INTERIOR SEAMS.
3. MILDEW TO AVOID MILDEW, NEVER PUT YOUR TENT AWAY WET OR DAMP. HOWEVER, IF
MILDEW OCCURS, USE A SOFT BRISTLE BRUSH OR SPONGE WITH MILD DISH
WASHING SOAP OR FELS NAPTHA SOAP TO CLEAN. LET THE TENT DRY IN THE
SUNLIGHT AND APPLY SEAM SEALER COMPOUND ON INSIDE SEAMS.
4. REPAIRING A TEAR FOR SMALL TEARS USE A SELF-ADHESIVE PATCH KIT. WE RECOMMEND A CANVAS
OR AWNING REPAIR SHOP FOR LARGER TEARS.
5. FAULTY ZIPPER ALL OF OUR TENTS ARE MANUFACTURED WITH ZIPPERS WHICH, IF THE ZIPPER
SEPARATES, CAN BE FIXED BY MOVING THE SLIDER TO THE BEGINNING OF THE ZIPPER
TAPE AND REWORKING THE ZIPPER. IF THIS DOESN’T WORK, A REPLACEMENT ZIPPER
MAY BE ORDERED FROM OUR PARTS DEPARTMENT, AND MAY BE INSTALLED BY A LOCAL
CANVAS OR AWNING REPAIR SHOP IN YOUR AREA.
6. FLOOR CONDENSATION A GROUND CLOTH UNDER THE TENT PREVENTS THE FLOOR FROM FEELING DAMP
AND HELPS PROLONG ITS LIFE.THE CLOTH SHOULD BE SMALLER THAN THE TENT
FLOOR TO PREVENT RAIN FROM RUNNING UNDER THE TENT.
7. REMOVING STAKES STAKE SHOULD BE PULLED WITH ANOTHER STAKE, HAMMER OR STAKE PULLER,
BUT NEVER BY PULLING ON THE TENT. AVOID STAKING TENT SO TIGHT THAT IT
STRETCHES THE FABRIC. OVERSTRETCHING MAY CAUSE STAKE LOOPS TO TEAR.
PERHAPS WE’VE MISSED SOMETHING IN OUR TROUBLESHOOTING GUIDE. FEEL FREE TO GIVE US YOUR IDEAS ON
“TRICKS OF CAMPING”, REPAIR PROCEDURES, FEATURES YOU’D LIKE TO SEE, OR JUST YOUR THOUGHTS. SEND THEM TO:
TENT CUSTOMER SERVICE
3333 YALE WAY
FREMONT, CA 94538-6169
To order replacement parts, call toll free
1-800-775-1965 Mon.– Fri, 7:00 a.m. to 4:00 p.m. (PST-West Coast).
Mention complete model numbers.