Panasonic AWLK30 - LENS CONTROLLER User manual

ORDER NO. BSD990934C1
D12
Service
Manual
AW-LK3O
SPECIFICATIONS
Power supply : 12 V DC, 60 mA (supplied from lens)
Lens control: Zoom: Speed, tele/wide
Focus : . Speed, near/far
Iris : Auto/manual, open/close
Connecting cable length : 190 cm
Operating temperature range : —10°C to +45°C (14°F to +113°F)
Humidity : 30% to 90%
Dimensions : 90 (W) x 40 (H) x 70 (D) mm [8-17/82” x 1-9/16” x 2-3/4"]
Weight : 400 g (0.9 lbs.)
Finish : AV ivory paint (close to Munsell 7.9Y6.8/0.8)
Weight and dimensions indicated are approximate.
Specifications are subject to change without notice.
STANDARD ACCESSORY
CHAIN GN in aahteceteyccttedes steered ameauertondauienemeeeinadhootnast: 1 each, right and left
CAMPS COW sixtae scl tssance hin nme se set aeatecdt 1 pc
MOUNTING: SOKEW acer trite ccommets te cesta asia medica 2 pcs
€ 1999 Matsushita Communication Industrial Co., Ltd.
=
Pa
aSOni
All
rights
reserved.
Unauthorized
copying
and
® distribution is a violation of law.

A. WARNING
This
service
information
is
designed
for
experienced
repair
technicians
only
and
is
not
designed
for
use
by
the
general
public.
It
does
not
contain
warnings
or
cautions
to
advise
non-technical
individuals
of
potential
dangers
in
attempting
to
service a
product.
Products
powered
by
electricity
should
be
serviced
or
repaired
only
by
experienced
professional
technicians.
Any
attempt
to
service
or
repair
the
product
or
products
dealt
with
in
this
service
information
by
anyone
else
could
result
in
serious
injury or
death.
This symbol warns the user that uninsulated voltage within
CAUTION the unit may have sufficient magnitude to cause electric
RISK OF ELECTRIC SHOCK shock. Therefore, it is dangerous to make any kind of contact
O
NOT
OPEN
with
any
inside
part
of
this
unit.
CAUTION:
TO REDUCE THE RISK OF ELECTRIC SHOCK,
DO
NOT
REMOVE
COVER
(OR
BACK).
NO
USER
This
symbol
alerts
the
user
that
important
literature
concerning
SERVICEABLE
PARTS
INSIDE.
the
operation
and
maintenance
of
this
has
been
included.
REFER
SERVICING
TO
QUALIFIED
SERVICE
Therefore,
it
should
be
read
carefully
in
order
to
avoid
PERSONNEL.
any
problems.
IMPORTANT SAFETY NOTICE
There
are
special
components
used
in
this
equipment
which
are
important
for
safety.
These
parts
are
indicated
by
the
*AA”
mark on
the
schematic
diagram
and
the replacement
parts
list.
It is essential
that
these
critical
parts
should
be
replaced
with
manufacturer's
specified
parts
to
prevent
X-radiation,
shock,
fire,
or
other
hazards.
Do
not modify
the
original
design
without
permission
of
manufacture.

MAJOR OPERATING CONTROLS AND THEIR FUNCTIONS
(1) Zoom Speed Control [ZOOM SPEED L/H]
To adjust lens zoom control speed. Turning it clockwise
increases speed. |
(2) Zoom Control Tele Switch [ZOOM TELE]
The lens zooms in the telescopic direction while the
switch is kept depressed.
(3) Zoom Control Wide Switch [ZOOM WIDE]
The lens zooms in the wide angle direction while the
switch is kept depressed.
(4) Focus Speed Control [FOCUS SPEED L/H]
To adjust lens focus control speed. Turning it clockwise
increases speed.
(5)Focus Control Near Switch [FOCUS NEAR]
The lens focus draws near while the switch is kept
depressed.
(6) Focus Control Far Switch [FOCUS FAR]
The lens focus moves far while the switch is kept
depressed.
() Iris Auto/Manual Switch [IRIS AUTO/MANU]
At AUTO, the iris is automatically controlled (ALC).
At MANU, the iris can be adjusted with Iris Control ©).
Caution
If your lens has zoom, focus and iris AUTO/MANU
switches, set all the AUTO/MANU switches to AUTO.
Iris Control [IRIS CLOSE/OPEN]
The iris can be adjusted from CLOSE to OPEN or vice
versa when Iris AUTO/MANU switch (@ is at MANU.
Turn it counterclockwise to close the iris, or clockwise to
open it.
(9) Lens Control Connector
Connect the zoom/focus control cable of your lens to it.
Clamper
Use it to clamp the lens controller to the grip of a tripod,
for example.
(1) Clamp Screw
Tighten this screw to fasten the lens controller to the grip
of a tripod, for example.
SCHEMATIC DIAGRAM
MAIN BOARD
$1
IRIS
AUTO/MANUAL
SWITCH
R101
FOCUS
SPEED
CONTROL
$2
FOCUS
CONTROL
FAR SWITCH
$3
FOCUS
CONTROL
NEAR SWITCH
$4
ZOOM
CONTROL
TO ZOOM TELE
TELE SWITCH
CONNECTOR 1fF=—33 $5
| 21¢0 O84 | ZOOM
6
J,
ZOOM WIDE CONTROL
= WIDE SWITCH
CONDUCTOR VIEW
MAIN BOARD
(COMPONENT SIDE VIEW)

EXPLODED VIEW
(.) Numbers show screws, washers, nuts and etc.
INo| Screws |_—Description
4) | XSB3+6FX Binding Head Screws
XSB3+4FN Binding Head Screws
|) | XWGA4FXK
[© | XSB3+6FXK
)
M7
PACKAGING
M8,M9
. M10,M11,M12,
M13
OYO®
FCC Label
for AW-LK30/USA/Canada
a
CE Label for AW-LK30E
REPLACEMENT PARTS LIST
Important Notice
1. Components identified by " A\ " mark have special characteristics important for safety.
When replacing any of these components, use only manufacturer's specified parts.
2. RTL: Retention Time Limited (No longer available after discontinuing product).
ee [ome [awe (wwe | owe | eae
MISCELLANEOUS CCESSORY PARTS / PACKAGING PARTS
A
M8 ZN | 7J1A332A
E1 LK30A1 Lens Control Cord Operating Instructions
M1 1K1A107A Bottom Cover for AW-LK30/USA/Canada
M2 SJ-5003 Rubber Foot 7J1A333A Operating Instructions for AW-LK30E
M3 LAX | 721A058A Main Label for AW-LK30/USA/Canada XZB26X40C05 Polyethylene Bag
7Z1A059A Main Label for AW-LK30E 1B1B452A Mounting Main Bracket
5E1A018A Switch Cusion 1B1B453A Mounting Sub Bracket
1K1A106BA Upper Cover 5G1A103A Rubber Sheet
2R1A015A lris Knob YWT15X20C03 Polyethylene Bag
YWSR5N4 Cord Clamp XZB26X40C05 Polyethylene Bag
for AW-LK30/USA/Canada
PE26X40C05A Polyethylene Bag for AW-LK30E
0C1A062A Packaging Ass'y
V8FA0070A4 Caution Label
PCB1 (RTL) Printed Circuit Board Ass'y YFV8FA0137A4 Packing Label for AW-LK30/USA/Canada
Ri ERDS2TJ361 Carbon 360 ohms 1/4W YWV8FA0140A4 Packing Label for AW-LK30E
R2 ERDS2TJ152 Carbon 1.5K ohms 1/4W
R3 ERDS2TJ361 Carbon 360 ohms 1/4W
R4 ERDS2TJ152 Carbon 1.5K ohms 1/4W
R5,6 ERDS1TJ181 Carbon 180 ohms 1/2W
R7,8 ERDS2TJ101 Carbon 100 ohms 1/4W
R101,102 D2AAA53B0001 Variable Resistor 5K ohms
R103 D2AAA13B0001 Variable Resictor 1K ohms
C1-4 F1E1H104A067 Ceramic 0.1 pF
C5,7 R3S16V470MR Electrolytic 47 uF 20V
C9,11 R3S16V470MR Electrolytic 47 uF 20V
C13-15 F1E1H104A067 Ceramic 0.1 UF
S1 YWSSSF022P9N Switch
S2 15EL1220000 Switch
33
Switch
Switch
12-pin Connector
KOF222A00120
KOF146A00001
K1KA12A00041
CN1
Printed in Japan
S-046® 12,23, 33