Pet Gear PG5927BBR User manual

INSTRUCTION MANUAL
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG
To see our full line of products, visit us online at: www.petgearinc.com
CUSTOMER SERVICE HELP DESK
[email protected]
Toll-Free 877-752-9123 - Eastern Standard Time 8am-3pm, Monday through Friday
For Pets
Only
For The ON-THE-GO Pet™

“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG
2
WARNING!
FOR PETS ONLY.
Not intended to be used as a restraining device for aggressive or dangerous animals that dig,
chew or paw aggressively. Do not leave your pet unattended. PET GEAR is not liable for any damage
caused by aggressive, destructive, immature or untrained animals.
Do not use near an open or exposed
flame. Failure to follow these warnings and the instructions could result in serious injury or death.
Never use plastic shipping bags or other plastic film as pad covers not sold and intended for that
purpose. They can cause suffocation. This product is not intended for commercial use.
AVOIDING SUFFOCATION HAZARDS
THIS PRODUCT REQUIRES ADULT ASSEMBLY.
Be sure the Crate is completely set up before use.
Always follow the instructions in the product instructions to set up the Crate.
Before each use, inspect this product for damaged hardware, loose joints, missing parts, or sharp edges.
Do not use the Crate if any parts are missing or broken.
Call PET GEAR at 1-877-752-9123 for replacement parts. Use only PET GEAR replacement parts.
Visit our website www.petgearinc.com to view or download the product instructions.
Do not substitute parts.
SETTING UP THE CRATE
Remove collar and leashes while using this product. The Crate is for playing or sleeping. When used for
playing, never leave pet unattended and always keep pet in view. When used for sleeping, you must still
provide the supervision necessary for the continued safety of your pet. Always keep the Crate away from
hazards in the area that may injure your pet. DO NOT leave pet in product for prolonged periods of time.
DO NOT ATTEMPT TO MOVE CRATE WHEN YOUR PET IS INSIDE.
USING THE CRATE

“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG 3
PARTS LIST
Check that you have all the parts shown BEFORE assembling your product.
If any parts are missing, call Customer Service. No tools required.
(2) Top Locks
(one on each side).
(1) Matching Bolster Pad
(1) Crate
Wheels
(1) Handle
(1) Carry Bag

CRATE ASSEMBLY
4
Step 1. Remove from carrying case.
Step 2. Place crate on ground as shown, so the PET GEAR
logo on the bottom (black part) is facing toward you. (Figure A.)
Step 3. Lift top up to a ninety degree angle. (Figure B.)
Step 4. Pull the top back so that the side wiring is extended.
(Figure C.)
Step 5. Lift left side up to a ninety degree angle. (Figure D.)
Figure B
Figure C
Figure A
Figure D
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG

5
CRATE ASSEMBLY
Figure E
Base
Figure G
Figure F
Figure I
Figure H
Note: Do not apply excessive force.
Recheck Steps 8 and 9 if lock closes hard.
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG
Step 6. Lift right side up to a ninety degree angle.
(Figure E.)
Step 7. Flip bottom base and sides ninety degrees
toward the top so the crate is on its side. (Figure F.)
Step 8. Align the interlocking panels (top panel)
and (side panel). See Figure G. Repeat this on
the other side panel.
Step 9. Set crate right side up.
Step 10. Install top lock near the handle.
Place lock as shown in Figure H. Put lock
into plastic lock holder and push down.
(Figure I.) Repeat step with opposite side.

6
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG
CRATE ASSEMBLY
Figure J
Figure K
Step 12. Fasten latch on the left back cage as
shown in Figure K. Repeat on right side.
USING BUNGEE CORDS
Note: Do not apply excessive force.
Some of our models now come with bungee cords attached to the bottom of the crate.
These cords help to keep the crate shut when folded.
Step 11. Latch the locks. Extend the lock downward, then lift up to lock the lock in place (Figure J). If
bottom part does not latch repeat steps 8-11. Pull up lightly on the lock to make sure lock is fastened.
Top lock.
Pull cords up from bottom,
around the sides of the crate,
and fasten around the top lock.
Lift cord up from
the bottom center
of the crate and
pull out toward
the sides.

7
RECONNECTING “THE OTHER DOOR®”
These are the necessary steps to reconnect “The Other Door” back onto your steel crate.
Step 1. Place crate with wire side on the floor
(Figure A).
De-clip top and flip down (Figure B).
Step 2. Align door at an angle with screw side
facing the crate, as shown in Figure C. Make sure
plastic knobs on both sides are near tracks so that
when the door is straightened, knobs will click inside
tracks and be re-attached (Figure D).
Step 3. Lay door flat as shown in
Figure E. Make sure door guides are
aligned with their tracks (Figure E)
and slide door into track.
Figure A
Figure B
Figure C
Plastic Knob Figure D
Figure E
Door Guide
Bottom
Top
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG

8
REPLACEMENT PARTS
Please have your model number ready before calling. Use only PET GEAR replacement parts.
“The Other Door®” Steel Crate
PG5927BBR/PG5927BLV/PG5927BOB/PG5927BPK/PG5927BSG
PG5936BBR/PG5936BLV/PG5936BSG
PG5942BBR/PG5942BSG
PO Box 99
West Rutland, VT 05777
877-752-9123
www.petgearinc.com