Polar Electro GC870-A User manual

Model:
GC870-A_GC871-A_CS627-A_CS628-A
Display Cooler
Instruction manual
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 1 2017/8/29 17:50

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
• - Health and Safety at Work Legislation
• - Fire Precautions
• - Wiring Regulations
• - Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Polar recommend that this appliance is PAT tested on an
annual basis to ensure the product remains safe.
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 2 2017/8/29 17:50

3
AUAU
Telephone Helpline: 1300225960
Caution Risk of Fire
• Do not store explosive substances such as aerosol cans
with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
GC870-A - Polar Chilled Display Cabinet - 68Ltr
GC871-A - Polar Chilled Display Cabinet Black- 98Ltr
CS627-A - Polar Chilled Display Cabinet - 68Ltr
CS628-A - Polar Chilled Display Cabinet Black- 98Ltr
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
• POLAR Display cooler
• GC870-A/CS627-A: 3 adjustable shelves
• GC871-A/CS628-A: 4 adjustable shelves
• Instruction manual
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 3 2017/8/29 17:50

4
AU Telephone Helpline: 1300225960
Installation
Note: If the unit has not been
stored or moved in an upright
position, let it stand upright for
approximately 12 hours before
operation. If in doubt allow to
stand.
1. Remove the appliance from the packaging.
Make sure that all protective plastic film and
coatings are thoroughly removed from all
surfaces.
2. Maintain a distance of 20cm (7 inches)
between the unit and walls or other objects for
ventilation. NEVER LOCATE NEXT TO OR
NEAR A HEAT SOURCE.
Note: Before using the appliance
for the first time, clean the
shelves and interior with soapy
water.
Operation
Control Panel
The control panel is located below the door at the
front of the appliance.
Turn On
1. Close the door of the appliance.
2. Connect the appliance to a mains power
supply.
3. Press the Power switch (Green) to the On
position.
Internal Light
The light switch is located at the front of the
appliance next to the power switch.
Set the Operating Temperature
1. Press the SET button. The display will flash.
2. Press the or button to display the
required temperature.
3. Press the SET button to store the temperature.
Manual Defrost
Press and hold the defrost button "aux" for 2
seconds to begin a manual defrost. The defrost
light illuminates.
Cleaning, Care &
Maintenance
Switch off and disconnect
from the power supply before
cleaning.
• The doors can be removed for ease of
cleaning.
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run
through the drain hole into the evaporation
pan.
Replacing the Interior Lamp
Call your dealer or a qualified electrician, the Lamp
Assembly is available to purchase as a spare part.
Cleaning the Condenser
Periodic cleaning of the Condenser can extend
the life of the appliance. POLAR recommend that
a POLAR agent or qualified technician clean the
condenser.
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 4 2017/8/29 17:50

5
AUAU
Telephone Helpline: 1300225960
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline or your POLAR dealer.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance turns on,
but the temperature is
too high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Call POLAR agent or qualified Technician
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a
heat source or air flow to the
condenser is being interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or
blockages to the fan
Appliance is overloaded Reduce the amount of food stored in the
appliance
Factory default parameters
adjusted
Call or qualified technician
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance
(if applicable)
The appliance is
unusually loud
Loose nut/screw Check and tighten all nuts and screws
The appliance has not been
installed in a level or stable
position
Check installation position and change if
necessary
The display lamp does
not illuminate
Lamp needs replacing Call POLAR agent or qualified technician
Light not turned On Ensure Light button has been pressed
properly
Door does not shut Dirt/obstacle in runners Clean runners
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 5 2017/8/29 17:50

6
AU Telephone Helpline: 1300225960
Technical Specifications
Model Voltage Power Range Capacity
(Litres) Refrigerant Dimensions
H x W x D mm
Weight
(kg)
GC870-A 220-240V 50Hz 164W 0 to12°C 68 R134a 100g 970 x 488 x 446 33
GC871-A 220-240V 50Hz 200W 0 to12°C 98 R134a 150g 1195 x 488 x 446 38
CS627-A 220-240V 50Hz 164W 0 to12°C 68 R134a 100g 970 x 488 x 446 33
CS628-A 220-240V 50Hz 200W 0 to12°C 98 R134a 150g 1195 x 488 x 446 38
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
The appliances must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible for
waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 6 2017/8/29 17:50

GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 7 2017/8/29 17:50

GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829
http://www.polar-refrigerator.com/
GC870-A_GC871-A_CS627-A_CS628-A_A5_v2_170829.indb 8 2017/8/29 17:50
This manual suits for next models
3
Table of contents
Other Polar Electro Accessories manuals

Polar Electro
Polar Electro Y6 User manual

Polar Electro
Polar Electro Cadence Sensor W.I.N.D User manual

Polar Electro
Polar Electro GE580 User manual

Polar Electro
Polar Electro Y6 User manual

Polar Electro
Polar Electro G3 User manual

Polar Electro
Polar Electro CoolFlow CFA User manual

Polar Electro
Polar Electro CS Cadence Sensor W.I.N.D. User manual

Polar Electro
Polar Electro GE580 User manual

Polar Electro
Polar Electro W.I.N.D. User manual

Polar Electro
Polar Electro G Series User manual