PowerTech ZM9124 User manual

200W Canvas Blanket
Solar Panel
with Charge Controller
ZM9124
User Manual
More information https://www.caravansplus.com.au

INTRODUCTION
CAUTION / WARNING
BOX CONTENTS
Please ensure that you have read the product manual and instractions in full before
using this product. Failure to do so many result in incorrect operation and potentially
impact the performance of the product.
This product converts natural sunlight into DC electricity. It is designed to charge a
12V battery.
• For optimum performance, protect the solar cell from dust, dirt, and other debris.
• Use and store the product in a dry and vetilated location.
'RQRWXVHLQÁDPPDEOHRUH[SORVLYHDUHDV
• Stop use immediately if any wires become loose or electronic components are
H[SRVHG
• Do not pick panel up directly by the solar cells.
• Use the gap between solar cells to pick up the panel.
• Do not stan or walk on the solar panel.
[:&DQYDV%ODQNHW6RODU3DQHO
[6RODU&KDUJH&RQWUROOHU
[/HDGV
More information https://www.caravansplus.com.au

HOW TO USE
SPECIFICATIONS
• Unfold the solar panel.
• Place the unfolded solar panel in a postion that receives direct sunlight, facing to
the sun. Ensure that no shadows are covering the solar cells.
• Tilt the solar panel at a suitable angle. This can be the same as your loca latttude
(additional support may be necessary, not supplied).
• Connect the solar panel to the solar charge controller before connecting battery
clamp lead to the solar controller.
Solar Panel:
6RODU&HOO7\SH 0RQRFU\VWDOOLQH[PP
3RZHU2XWSXW :
Open Circuit Voltage: 23.7V
Short Circuit Current: 9.8A
:RUNLQJ9ROWDJH 9
:RUNLQJ&XUUHQW $
:HLJKW .*
Dimensons:
 )ROGHG :[+PP
 8QIROGHG :[+PP
Solar Charge Controller
System Voltage: 12/24V Auto
&KDUJH&XUUHQW $
'LVFKDUJH&8UUHQW $
0D[6RODU,QRXW 9
%DWWHU\(TXDOLVDWLRQ
Sealed: 14.4V
 *(/ 9
Flood: 14.6V
Float Charge: 13.7V (Default, Adjustable)
'LVFKDUJH6WRS 9'HIDXOW$GMXVWDEOH
Discharge Reconnect: 12.6V (Default, Adjustable)
86%2XWSXW 9$
6HOI&RQVXPSWLRQ P$
2SHUDWLQJ7HPSHUDWXUH a&
:HLJKW J
More information https://www.caravansplus.com.au

SAFETY INSTRUCTIONS
HOW TO CHARGE A 12V BATTERY
• Ensure battery has enough voltage for the solar charge controller to recognise the
EDWWHU\W\SHEHIRUHÀUVWLQVWDOODWLRQ
%DWWHU\FDEOHVKRXOGEHDVVKRUWDVSRVVLEOHWRPLQLPLVHORVV
7KHUHJXODWRULVVXLWDEOHIRUOHDGDFLGEDWWHULHV)ORRG$*0*(/DQGOLWKLXPLRQ
1RWVXLWDEOHIRUQLFNHOPHWDOK\GULGHRURWKHUEDWWHU\W\SHV
• Charge regulator is only suitable for regulating solar modules. Never connect
another charging source to the charge regulator.
7KHVRODUFKDUJHFRQWUROOHUZLOOEHKRWZKHQZRUNLQJ3OHDVHLQVWDOOLQDÁDWZHOO
ventilated area.
1. Connect the battery to the solar charge controller.
2. Connect load to solar charge controller.
3. Connect solar panel to solar charge controller.
4. Reverse this order when disconnecting.
NOTE+HDY\ORDGVVKRXOGQRWEHFRQQHFWHGWRWKHEDWWHU\
More information https://www.caravansplus.com.au

DISPLAY / SETTINGS
LCD DISPLAY/KEY
0HQX 6ZLWFKEHWZHHQGLIIHUHQWGLVSOD\VRUHQWHUH[LWVHWWLQJVE\ORQJSUHVV
Up: Press to incease value
Down: Press to decrease value
More information https://www.caravansplus.com.au

TROUBLESHOOTING
Issue Probably Cause Solution
Charge icon not on when
sunny
Solar panel closed or reversed Reconnect
/RDGLFRQRII Mode setting wrong Set again
%DWWHU\ORZ Recharge
/RDGLRQVORZÁDVKLQJ Over load Reduce load watts
/RDGLFRQIDVWÁDVKLQJ Short circuit protection Auto reconnect
Power off %DWWHU\WRRORZUHYHUVH
connected
&KHFNEDWWHU\FRQQHFWLRQ
More information https://www.caravansplus.com.au

More information https://www.caravansplus.com.au

Distributed by:
Electus Distribution Pty. Ltd.
320 Victoria Rd, Rydalmere
NSW 2116 Australia
www.electusdistribution.com.au
Made in China
More information https://www.caravansplus.com.au