PROPAIN HUGENE User manual

ASSEMBLY INSTRUCTIONS /USER MANUAL -
READ BEFORE YOUR FIRST RIDE!
INSTRUCTIONS DE MONTAGE /MANUEL D’UTILISATION -
A LIRE AVANT TOUTE SORTIE!
INSTRUCCIONES DE MONTAJE /MANUAL DE INSTRUCCIONES -
LEER ANTES DE LA PRIMERA SALIDA!
HUGENE

//SCOPE OF DELIVERY

1
4
32
5 6
//UNPACKING
Carefully open the top of the bike box ensuring no damage is
caused to internal parts whilst opening the box.
tÐĉďŒÐĴìÐťŘĴðďĊďåĴìÐìĊÌăÐÅīșĴìÐťŘĴðďĊďåĴìÐīÐī
ĴīðĊæăÐĊÌĴìÐťŘĴðďĊďåĴìÐåďīāȘ
ĺīÐåķăăřīÐĉďŒÐĴìÐìĊÌăÐÅīåīďĉðĴĮťŘĴðďĊșĴď
prevent possible damage to the paint.
Carefully remove both wheels.
ĺBe careful to avoid damages.
Carefully remove the bike.
ĺĴÆìĴìÐìĊÌăÐÅīĮșĮķĮĨÐĊĮðďĊåďīāĊÌīÐīÌÐīðăăÐķīȘ
Fix the bike to a work stand for further assembly or place
ðĴďĊĴìÐæīďķĊÌðĊĴìÐīÐīÐĊÌťŘĴðďĊȘ
Remove the box for the small parts and open it.
#ÐĴÆìĴìÐīÐīÌÐīðăăÐķīåīďĉĴìÐīÐīÐĊÌťŘĴðďĊȘ

1
43
2
//MOUNTING THE HANDLEBAR
1. Unscrew the stem clamp bolts.
2. Remove the handlebar clamp and the bolts.
1. Attach the handlebar to the stem.
2. Attach the handlebar clamp and screw in the bolts a few
turns by hand.
1. Screw in the two upper clamping bolts and tighten both
bolts with the torque lasered on the clamp or stem.
2. Screw in the two lower clamping bolts and tighten both
bolts with the torque lasered on the clamp.
1. Center the handlebar and adjust the angle of the handlebar according to your personal preferences.
2. Adjust the brake levers and the shifters to the angle of the handlebar.

5
10 Nm
//MOUNTING THE REAR DERAILLEUR
Mount the derailleur to the derailleur hanger of the frame
using a 5 mm hex key.
ĺThe derailleur stop must be at the lug of the derailleur
hanger.
ĺTighten the derailleur with a torque of 10 Nm.

1 2 3
4 5
//MOUNTING THE FRONT WHEEL
Remove the thru axle from the fork. 1. tÐĉďŒÐĴìÐĴīĊĮĨďīĴĮÐÆķīðĊæÌÐŒðÆÐĴìĴðĮťĴĴÐÌ
between the brake pads.
2. Store the transport securing device for future transport
of your bike.
1. Put the front wheel into the dropouts of the fork. The
brake rotor must be placed between the brake pads.
2. Open the lever of the thru axle and slide the axle through
the non-drive side (left in the direction of travel) fork
dropouts and hub of the wheel.
Rotate the lever clockwise until there is only a small gap left
between lever head and dropout.
1. Close the lever of the thru axle.
2. There must be no gap between lever head and dropout.
ĺClosing the lever should require an increasing amount of hand force until the lever is fully closed.
}ďðĊÆīÐĮÐăÐŒÐīĴÐĊĮðďĊșďĨÐĊĴìÐăÐŒÐīĊÌĴķīĊðĴÆăďÆāœðĮÐȘăďĮÐĴìÐăÐŒÐīĴďīÐÆìÐÆāăÐŒÐīĴÐĊĮðďĊȘ
tÐĨÐĴķĊĴðăĴìÐĴÐĊĮðďĊðĮĮķŨÆðÐĊĴșĴìÐĊÆăďĮÐĴìÐăÐŒÐīȘ
#ÐĨÐĊÌðĊæďĊĴìÐåďīāĉĊķåÆĴķīÐīșĴìÐĴìīķŘăÐĉķĮĴÅÐĨķĮìÐÌåīďĉĴìÐīðæìĴďīăÐåĴĴìīďķæìĴìÐÌīďĨďķĴďåĴìÐåďīāȘ

2
4
1
21
5
3
//MOUNTING THE REAR WHEEL
1. Remove the thru axle from the frame.
2. tÐĉďŒÐĴìÐĴīĊĮĨďīĴĮÐÆķīðĊæÌÐŒðÆÐĴìĴðĮťĴĴÐÌ
between the brake pads.
3. Store the transport securing device for future transport
of your bike.
1. Insert the rear wheel into the dropout of the frame.
ĺThe brake rotor must be placed between the brake
pads.
ĺPut the chain on the smallest sprocket of the
cassette.
2. Slide the thru axle from the brake side (left in the
direction of travel) into the frame dropout and hub of
the wheel.
Screw the thru axle into the dropout using a 6 mm hex key
and tighten the thru axle to a torque of 12 Nm.
Activate the Cage Lock function. Pull the cage of the rear
derailleur forward and press the Cage Lock button with the
symbol .
ĺThe rear derailleur cage remains tilted forward when
the Cage Lock function is activated.
}ìðĮĮðĉĨăðťÐĮĴìÐ
installation of the rear wheel.
Deactivate the Cage Lock function. Pull the cage of the
derailleur slightly forward and carefully return the derailleur
to its original position.

1 1
2
3
R L
//MOUNTING THE PEDALS
One of the pedals has a right- and the other a left-hand thread.
Most pedals have the letter “L” and “R” stamped on the end of
ĴìÐĴìīÐÌȘwďĉÐĨÐÌăĮÆďĉÐœðĴìæīďďŒÐðĊĴìÐŦĊæÐďå
the left pedal.
1. Slightly grease pedal thread.
2. AåœĮìÐīĮœÐīÐĨīďŒðÌÐÌœðĴìĴìÐÆīĊāĮďåřďķīÅðāÐșťĴ
them on the pedal threads.
3. Turn the left pedal counter-clockwise to screw it into the
thread of the left crank arm and tighten the pedal to a
ĴďīĪķÐďåǢǤɁUĉȘ
4. Turn the right pedal clockwise to screw it into the thread
of the right crank arm and tighten the pedal to a torque
ďåǢǤɁUĉȘ
//MOUNTING THE SADDLE
1. Attach the upper clamp to the saddle frame.
2. Adjust the saddle to your personal preferences and
screw in the clamping bolts.
Adjust the seat height:
ķĴðďĊȚìÐĊÌþķĮĴðĊæĴìÐĮÐĴìÐðæìĴșĴìÐÆÅăÐďåĴìÐĮÐĴ
post must be pushed or pulled in or out the frame. Otherwise
the cable may get damaged!
1. Open the saddle clamp.
2. Push the seat post carefully and slowly into the frame
or pull the seat post out of the frame. At the same time
push or pull the cable in or out the frame.
3. Close the saddle clamp.
Unscrew the bolts of the saddle clamp and remove the upper
clamp.

1 2 3
//INFLATING THE TIRE
1. AĊŦĴÐĴìÐĴðīÐĴďÅďķĴǡÅīȘ
2. ìÐÆāĴìÐÆďīīÐÆĴťĴďåĴìÐĴðīÐȘ
ĺThe tire must contact the rim evenly around its
ÐĊĴðīÐÆðīÆķĉåÐīÐĊÆÐȘAåĊďĴșīÐăÐĮÐĴìÐðīșĨīÐĮĮ
the tire into the center of the rim bed and repeat
the procedure.
ĺHave the tire seat checked by a professional if in
any doubt.
3. Slowly rotate and shake the wheel to distribute the
ĮÐăðĊæŦķðÌďŒÐīĴìÐÐĊĴðīÐðĊĊÐīĮķīåÆÐďåĴìÐĴðīÐȘ
4. åĴÐīĴìÐĴðīÐÅÐÌðĮåķăăřĮÐĴÐÌșīÐÌķÆÐĴìÐĨīÐĮĮķīÐĴď
your own requirements.
5. Screw on the valve cap.
6. Carry out a short test ride and check the tire pressure
regularly.
AåřďķìŒÐďīÌÐīÐÌřďķīÅðāÐœðĴìĴķÅÐăÐĮĮĮÐĴķĨșřďķĉķĮĴťăăÅďĴìĴðīÐĮœðĴìĴìÐÐĊÆăďĮÐÌĮÐăðĊæŦķðÌÅÐåďīÐĴìÐťīĮĴīðÌÐȘ
1. Release the air from the tire completely.
2. Unscrew the valve cap.
3. Unscrew the valve insert from the valve using the valve
key supplied.
1. wìāÐĴìÐĨīďŒðÌÐÌĮÐăðĊæŦķðÌåďīÅďķĴďĊÐĉðĊķĴÐȘ
2. 9ðăăĴìÐĮÐăðĊæŦķðÌĴìīďķæìĴìÐŒăŒÐðĊĴďĴìÐĴðīÐȘ
ĨĨīďŘðĉĴÐăřǥǟĉăďåĮÐăðĊæŦķðÌĮìďķăÌÅÐķĮÐÌ
per tire.
3. Screw the valve insert into the valve using the valve key
and tighten it by hand.
AåřďķìŒÐďīÌÐīÐÌřďķīÅðāÐœðĴìďķĴĴķÅÐăÐĮĮĮÐĴķĨșðĊŦĴÐĴìÐĴðīÐĮĴďĨīÐĮĮķīÐďåÅďķĴǡÅīȘ

A B
1
ďķīÅðāÐðĮÌÐăðŒÐīÐÌœðĴìÅĮðÆÌþķĮĴĉÐĊĴďåĴìÐĮķĮĨÐĊĮðďĊÐăÐĉÐĊĴĮȘÐåďīÐĴìÐťīĮĴīðÌÐșĴìÐðīĨīÐĮĮķīÐðĊĴìÐĮķĮĨÐĊĮðďĊÐăÐĉÐĊĴĮĉķĮĴÅÐÌþķĮĴÐÌĴďřďķīÅďÌřœÐðæìĴȘ
//ADJUSTING THE SUSPENSION ELEMENTS
1. Unscrew the valve cap of the shock / fork.
2. Screw on the shock pump and pump the shock / fork up to the required pressure.
ĺObserve the instructions for operating the shock pump.
ĺWe recommend a SAG* of 15% - 20% on the fork and 20% - 30% on the shock.
Please pay attention to the manufacturer's instructions of the suspension elements for the air
pressure. The corresponding manuals are included.
3. Unscrew the shock pump and screw the valve cap onto the valve.
* The air pressure of your suspension elements is adjusted via the so-called
SAG (negative travel). The SAG is the degree by which the shock and the fork
ÆďĉĨīÐĮĮÐĮķĊÌÐīĴìÐœÐðæìĴďåĴìÐīðÌÐīȘ}ďÌþķĮĴĴìÐw:șĮðĴďĊĴìÐÅðāÐœðĴì
ăăřďķīÆřÆăðĊæÐĪķðĨĉÐĊĴȧìÐăĉÐĴșÅÆāĨÆāșĮìďÐĮșÐĴÆȘȨĊÌĴāÐĊďīĉă
riding position. No air can escape when unscrewing the shock pump.

A
B
C
D
D
D
D
1 2
//BEFORE YOUR FIRST RIDE
PROVISIONS FOR USE
Observe the basic provisions for the HUGENE:
INTENDED USE
categories – ranging from the use on paved roads through to
downhill or freeride use.
The HUGENE must only be used in accordance with the
provisions of Category or below.
Details can be found in the user manual of your bike.
PERMISSIBLE TOTAL MASS
The permissible total mass (rider + bicycle + equipment +
luggage) is 120 kg and may not be exceeded!
USER MANUAL
In addition to these instructions, please refer to the user
manual of your bike. All information contained therein must
have been read and understood!
REGULATIONS ACCORDING TO THE GERMAN TRAFFIC REGULATIONS
(STRASSENVERKEHRS-ZULASSUNGSORDNUNG STVZO)
act forwards and backwards. These regulations are for the use on public roads in Germany. If the bicycle is used in another
country, the requirements applicable there must be observed.
Pos. Description Special notes
A front light and white
required by visibility conditions.
be protected against accidental movement under normal operating conditions and must
be permanently operational. The front light must be set so that other road users are not
Brear light and red
C
D

// BEFORE YOUR FIRST RIDE
ÐåďīÐřďķīťīĮĴīðÌÐșÆìÐÆāăăÅĮðÆåķĊÆĴðďĊĮďåřďķīÅðāÐĴďÐĊĮķīÐĴìĴĴìÐīÐīÐĊďĮĮÐĉÅăřÐīīďīĮďīĴīĊĮĨďīĴÌĉæÐĮȘAåĴìÐīÐīÐĊřÌÐåÐÆĴĮďīŦœĮșřďķĮìďķăÌìŒÐřďķīÅðāÐðĊĮĨÐÆĴÐÌĊÌ
īÐĨðīÐÌÅřĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆȘUÐŒÐīīðÌÐœðĴìÌÐåÐÆĴðŒÐÅðāÐȝ
WHEELS / TIRES Lift the wheels one after the other and spin them.
ĺThe wheels must spin smoothly.
ĺ}ìÐœìÐÐăĮĉķĮĴīķĊĴīķÐșœðĴìďķĴĉďŒðĊæķĨĊÌÌďœĊďīåīďĉĮðÌÐĴďĮðÌÐȘ
ĺThe tires must not rub against the frame.
Check the tire pressure.
ĺThe tire pressure should be about 2 bar. The maximum tire pressure of the wheel and of the tire used must not be exceeded.
Check the tightening torque of the thru axles.
ĺ}ìÐăÐŒÐīďåĴìÐĴìīķŘăÐďåĴìÐåīďĊĴœìÐÐăĉķĮĴÅÐÆăďĮÐÌťīĉăřȝ
ĺThe thru axle of the rear wheel must be tightened to 12 Nm!
COMPONENTS ÐīðåřĴìÐĴðæìĴťĴďåĴìÐĮĴÐĉȚwĴĊÌðĊåīďĊĴďåĴìÐÅðāÐœðĴìĴìÐåīďĊĴœìÐÐăÅÐĴœÐÐĊřďķīāĊÐÐĮĊÌĴīřĴďĴķīĊĴìÐìĊÌăÐÅīăÐåĴĊÌīðæìĴȘ
ĺIt should not be possible to turn the handlebar with normal force.
ìÐÆāĴìÐìÐÌĮÐĴåďīĨăřȚwĴĊÌĊÐŘĴĴďřďķīÅðāÐșĨķăăĴìÐåīďĊĴÅīāÐăÐŒÐīĊÌæÐĊĴăřĨķĮìĴìÐÅðāÐÅÆāœīÌĮĊÌåďīœīÌĮȘ
ĺNo bearing play must be detectable.
Make sure that all components are tight.
ĺ}ðæìĴÐĊĴìÐĨīĴĮĴďĴìÐĨīďĨÐīĴďīĪķÐșðåĊÐÐÌÅÐȘAĊÆĮÐďåÌďķÅĴșÆďĊĴÆĴĴìÐqīďĨðĊwÐīŒðÆÐȘ
FRAME Check the frame for damages and deformation.
ĺThere must be no damages.
FORK /
SHOCK
wðĴďĊĴìÐÅðāÐœðĴìăăřďķīÆřÆăðĊæÐĪķðĨĉÐĊĴȧìÐăĉÐĴșÅÆāĨÆāșĮìďÐĮșÐĴÆȘȨĊÌĴāÐĊďīĉăīðÌðĊæĨďĮðĴðďĊȘ
ĺWe recommend a SAG of 15% - 20% on the fork and 20% - 30% on the shock.
ĺAåĊÐÆÐĮĮīřșÆìĊæÐĴìÐðīĨīÐĮĮķīÐďåřďķīĮķĮĨÐĊĮðďĊÐăÐĉÐĊĴĮȘAåřďķìŒÐďīÌÐīÐÌĮìďÆāœðĴìĮĴÐÐăĮĨīðĊæřďķìŒÐăīÐÌřÆìďĮÐĊĮĨīðĊæīĴÐÆďīīÐĮĨďĊÌðĊæĴď
your weight. Details can be found in the user manual of your bike.
BRAKES ìÐÆāÅīāÐÐŨÆðÐĊÆřȚqķăăďĊÐÅīāÐăÐŒÐīåĴÐīĴìÐďĴìÐīœìðăÐĮĴĊÌðĊæĊÌĨķĮìĴìÐÅðāÐÅÆāœīÌĮĊÌåďīœīÌĮȘ
ĺThe front and rear wheel must lock when the brake lever is pulled.
ìÐÆāœìÐĴìÐīĴìÐÅīāÐìďĮÐĮĊÌÆďĊĊÐÆĴðďĊĮīÐăďĮðĊæÅīāÐŦķðÌĊÌÆìÐÆāĴìÐĉåďīÌÐåÐÆĴĮȘ
ĺīāÐŦķðÌĉķĮĴĊďĴÐĮÆĨÐĴĴìÐÆďĊĊÐÆĴðďĊĮȘ
Break in the brake pads. Choose a road away from public roads and brake 20 to 30 times with the front or rear brake from a speed of 30 km/h down to 5 km/h. You should brake as
hard as possible without locking one of the wheels. Repeat the process for the other brake. Only then the brake can show its full braking power.

//SPÉCIFICATIONS TECHNIQUES
Suspension Leverage Ratio
0
3,0
2,8
2,6
2,9
2,7
2,5
2,4
2,3 20 40 60 80 100 120 140
Synthetic silicon
based grease
Synthetic silicon
based grease
Torque: 15Nm
Loctite 243
Torque: 15Nm
Loctite 243
Torque: 15Nm
Loctite 243
Torque: 15Nm
Loctite 243
Torque: 15Nm
Loctite 243
Torque: 15Nm
Loctite 243
7
8910
6
11
18
4
12 13
14
15
16
23
17
5
20
21
22
19
3
2
24
1
Torque: 12Nm
HUGENE - Standards
Shock length 210mm
Shock travel 50mm
Shock mount top 8mm x 30mm
Shock mount bottom 8mm x 30mm
Rear wheel travel 140mm
Bottom bracket BSA 73mm
Brake mount Post mount 180mm
Seat post diameter 31,6mm
Head set (S.H.I.S.) Top: IS42 / Bottom: IS52
Rear wheel axle x12 (148 mm-Boost)
Rear hub width 148mm (Boost)
Chain line 52 mm (boost)
Chain guide mount ISCG 05
Tire size 29" x 2,35
Maxium fork travel 140-150mm
Hanger SRAM UDH

NO Propain Description QTY.
partnumber-version
1 1 001252-AE Front_triangle_Large 1
ǡ ǡǟǟǠǡǥǟȭ tÐīȲĴīðĊæăÐȲ>ķæÐĊÐ9ǡǨ Ǡ
3 3 001044-AB Lever_low 1
4 4 001510-AA Upper_lever 1
5 5 001201 UDH 1
6 6 001261-AA Axle_15dia_46mm_M10x1 1
Ǧ Ǧǟǟǟǥǟǣȭ ăĉĨȲīðĊæȲǠǤĉĉȲŘăÐ ǧ
ǧ ǧǟǟǟǠǦǥȭ ÐīðĊæȲǠǤŘǡǧŘǦȲŦĊæÐ ǥ
Ǩ Ǩǟǟǟǥǟǡȭ #ķĮĴȲÆĨȲĮÐă ǥ
10 10 000600-AB 15mm_Axle_Cap_M10x1 6
ǠǠ ǠǠǟǟǠǡǥǢȭ ŘăÐȲǠǤŘǧǧŘTǠǟȲÆăĉĨȲĴřĨÐ Ǡ
12 12 001262-AA Alloy_Bushing_41mm 1
ǠǢ ǠǢǟǟǟǟǟǥȭ ÐīðĊæȲǠǤŘǡǧŘǦ ǡ
14 14 000605-AB 15mm_clamp_Axle_Cap 2
15 15 000616-AA Axle_15dia_62mm_M10x1 1
Ǡǥ ǠǥǟǟǠǠǠǤȭ  ŘăÐȲǠǤÌðȲǥǨȭǤĉĉȲTǠǟŘǠ Ǡ
ǠǦ ǠǦǟǟǠǟǦǥȭ Aw:ȲǟǤȲīÐĉďŒÅăÐȲÅďďĮĴǠǣǧ Ǡ
Ǡǧ ǠǧǟǟǟǦǢǢȭ ďăĴȲTǤŘǠǢ  ǣ
ǠǨ ǠǨǟǟǟǨǨǠȭ ďăĴȲTǧŘǣǢȲÆķĮĴďĉ ǡ
ǡǟ ǡǟǟǟǟǣǦǣȭ ďăĴȲTǤŘǠǥȲÆďķĊĴÐīĮķĊā ǣ
ǡǠ ǡǠǟǟǟǟǤǦȭ ÅăÐȲæķðÌÐȲǠ Ǡ
ǡǡ ǡǡǟǟǠǣǧǟȭ wwȲĨīďĴÐÆĴďīȲ>ķæÐĊÐȲǡǟǡǠ Ǡ
NO Propain Description QTY.
partnumber-version
23 23 001412-AB CS protector Hugene 2021 1
ǡǣ ǡǣǟǟǠǢǦǤȭ >ķæÐĊÐȭ#}ȭĨīďĴÐÆĴďī  Ǡ

WE BUILD THE BEST BIKE FOR YOU
Congratulations on your new bike & thanks for your trust!
ĊÌĊďœĮĴīðæìĴďĊĴďĴìÐÅðāÐȝ}ìĴȾĮăĉďĮĴīðæìĴșÅÐÆķĮÐðĴÌďÐĮĊȾĴĴāÐăďĊæĴďĮĮÐĉÅăÐřďķīÅðāÐȘUÐŒÐīĴìÐăÐĮĮșĨăÐĮÐĴāÐĴìÐĴðĉÐĴďĮÐĴķĨřďķīÅðāÐÆďīīÐÆĴăřĊÌīÐÌăăĮåÐĴřȭīÐăÐŒĊĴ
information in this user manual. So you are safe on the road and have much more fun with the right setup. With our manuals you will learn step by step how to set up your bike correctly and get all
the information you need. So you will be familiar with your bike in no time at all.
Now your bike has to come out of the box. It is best to have some space around you for the assembly. Our bikes come pre-assembled so that you don't have to have a specialist workshop at home
ďīÅÐĨīďåÐĮĮðďĊăĉÐÆìĊðÆȘďķĮĴðăăÆĊȾĴæÐĴìÐÌȟ}ìÐĊĮðĉĨăřÆďĊĴÆĴďķīÆķĮĴďĉÐīĮÐīŒðÆÐșœìÐĴìÐīŒððĊåďɩĨīďĨðĊȭÅðāÐĮȘÆďĉďīķĊÌÐīɎǣǨȧǟȨǦǤǠǡǟǠǧǟǡǡǡȘ}ďæÐĴìÐīœÐœðăăťĊÌ
ĮďăķĴðďĊȘZĊÐĉďīÐīÐĪķÐĮĴȚÐœĊĴřďķĴďìŒÐåķĊœðĴìřďķīÅðāÐĊÌÅÐĮåÐďĊĴìÐīďÌȘAåřďķīÐķĊĮķīÐÅďķĴĴìÐĮĮÐĉÅăřșÆďĊĴÆĴĨīďåÐĮĮðďĊăȘÐÆĊĊďĴÆÆÐĨĴĊřăðÅðăðĴřðåÆīĮìÐĮ
and injuries occur due to incorrect installation or incorrect use.
Ready? Then we wish you lots of fun with your new bike!
PS: We are happy about your best pictures at #propainbicycles
//USER MANUAL

1. wq'AOAU9ZtT}AZU9Ztqt'U}wș:t#AUwU#wq'tAwZtw
}ìðĮĉĊķăÆďŒÐīĮÅďĴìÌķăĴșĴÐÐĊæÐīĊÌāðÌȾĮÅðāÐĮȘďķīÆìðăÌĉřăīÐÌřÅÐīðÌðĊæÅðāÐðĊĮðšÐĴìĴðĮðĊĴÐĊÌÐÌåďīÌķăĴĮȘăăĨÐīĮďĊĮÐĊĴīķĮĴÐÌœðĴìĴìÐÆīÐďīĮķĨÐīŒðĮðďĊďåĴìÐÆìðăÌĉķĮĴāĊďœș
understand and observe the following points.
DANGER
RISK OF ACCIDENTS DUE TO CARELESSNESS AND LACK OF SENSE OF RESPONSIBILITY OF THE CHILD!
Children are often unable to assess dangers correctly and often do not have the necessary experience and sense of responsibility to use a bike safely!
• qīÐĊĴĮșæķīÌðĊĮďīĮķĨÐīŒðĮďīĮīÐīÐĮĨďĊĮðÅăÐåďīĴìÐĮåÐķĮÐĊÌĨÐīåÐÆĴÆďĊÌðĴðďĊďåĴìÐÆìðăÌȾĮÅðāÐȘ
• The points listed on this page must be observed during every ride.
• AĊÆĮÐďåÌďķÅĴșĴìÐqtZqAUwÐīŒðÆÐďīĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆĉķĮĴÅÐÆďĊĮķăĴÐÌȘ
ĮĨīÐĊĴșæķīÌðĊďīĮķĨÐīŒðĮďīșřďķīÐīÐĮĨďĊĮðÅăÐåďīĴìÐÆĴðŒðĴðÐĮĊÌĮåÐĴřďåĴìÐÆìðăÌȘ
The following points are your responsibility:
• ďķĉķĮĴīÐÌĴìðĮķĮÐīĉĊķăĊÌÌðĮÆķĮĮĴìÐœīĊðĊæĮșåķĊÆĴðďĊĮĊÌķĮÐďåĴìÐÅðāÐœðĴìřďķīÆìðăÌÅÐåďīÐřďķăÐĴìðĉďīìÐīīðÌÐĴìÐÅðāÐȘ
• ďķĉķĮĴťĴĴìÐÅðāÐĨīďĨÐīăřĴďĴìÐÆìðăÌďīìŒÐðĴťĴĴÐÌĨīďĨÐīăřȘ
• You must ensure that the bike is always in perfect condition.
• ďķĊÌĴìÐÆìðăÌĉķĮĴìŒÐăÐīĊÐÌĊÌķĊÌÐīĮĴďďÌĴìÐĮåÐďĨÐīĴðďĊďåĴìÐÅðāÐȘ}ìÐåďÆķĮďåĴìÐťīĮĴīðÌÐĮĮìďķăÌÅÐĴďĴÐÆìĴìÐÆìðăÌĴďÅīāÐĮåÐăřĊÌĴďķĮÐĴìÐÅðāÐĮåÐăřȘ
• ďķĊÌĴìÐÆìðăÌĉķĮĴìŒÐăÐīĊÐÌșķĊÌÐīĮĴďďÌĊÌåďăăďœÐÌĊďĴďĊăřĴìÐĨĨăðÆÅăÐăďÆăăœĮåďīĉďĴďīŒÐìðÆăÐĮșÅðÆřÆăÐĮĊÌĴīŨÆșÅķĴăĮďĴìÐÆďĉĉďĊĮÐĊĮÐīķăÐĮåďīĮåÐĊÌīÐĮĨďĊĮðÅăÐ
cycling.
• ďķĉķĮĴÐĊĮķīÐĴìĴřďķīÆìðăÌăœřĮœÐīĮĊĨĨīďŒÐÌÅðāÐìÐăĉÐĴœìÐĊīðÌðĊæșÅķĴăĮďĴìĴřďķīÆìðăÌķĊÌÐīĮĴĊÌĮĴìĴÅðāÐìÐăĉÐĴðĮďĊăřĮķðĴÅăÐåďīÆřÆăðĊæĊÌĉķĮĴÅÐīÐĉďŒÐÌœìÐĊ
ĊďĴīðÌðĊæȘìÐăĉÐĴĉřĊďĴÅÐœďīĊœìÐĊĨăřðĊæșďĊĨăřæīďķĊÌĮșďĊĨăřæīďķĊÌÐĪķðĨĉÐĊĴșœìÐĊÆăðĉÅðĊæĴīÐÐĮșďīĊÐŒÐīœìÐĊĊďĴīðÌðĊæÅðāÐȘ9ðăķīÐĴďďÅĮÐīŒÐĴìðĮœīĊðĊæĉřīÐĮķăĴðĊ
serious injury or death.
• Parental supervision is required when using a kid's bike.

• The supervising adult must observe at all times whether the child is assessing situations correctly and whether the bike is under control according to the requirements of the environment.
• You must make sure that the bike is the right size for the child. Both feet must touch the ground when the child is sitting on the saddle.
2. GENERAL
This user manual is the most important element to prevent any damages and risks during the use and servicing of your bike. It is provided to give you the most important information on your bike and to
æðŒÐřďķìÐăĨåķăĴðĨĮďŒÐīĴìÐÐĊĴðīÐăðåÐďåřďķīÅðāÐȘAåřďķìŒÐĊřÌďķÅĴĮďīķĊÆÐīĴðĊĴðÐĮīÐæīÌðĊæĴìÐœďīāďĊřďķīÅðāÐșřďķĮìďķăÌăœřĮÆďĊĮķăĴĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆďīĴìÐqtZqAUĮÐīŒðÆÐȘ
qăÐĮÐīÐÌĴìðĮĉĊķăÆīÐåķăăřÅÐåďīÐĴāðĊæĴìÐťīĮĴīðÌÐďĊřďķīĊÐœÅðāÐĊÌĉāÐĮķīÐřďķķĊÌÐīĮĴĊÌÐŒÐīřĴìðĊæȘ'ĊĮķīÐĴìĴĴìðīÌȭĨīĴřķĮÐīĮīÐăĮďðĊåďīĉÐÌÅďķĴĴìÐÆďĊĴÐĊĴĮďåĴìðĮĉĊķă
ĊÌĴìĴĴìÐřķĊÌÐīĮĴĊÌĊÌåďăăďœăăðĊĮĴīķÆĴðďĊĮȘNÐÐĨĴìðĮķĮÐīĉĊķăåďīåķĴķīÐīÐåÐīÐĊÆÐȘAåřďķĮÐăăďīæðŒÐœřřďķīÅðāÐșĨăÐĮÐðĊÆăķÌÐĴìðĮķĮÐīĉĊķăȘ}ìðĮķĮÐīĉĊķăðĮăĮďŒðăÅăÐĴœœœȘ
propain-bikes.com.
2.1 EXPLANATION OF SYMBOLS USED
DANGER
ȜðĊÌðÆĴÐĮìšīÌœðĴììðæìăÐŒÐăďåīðĮāœìðÆìșðåĊďĴŒďðÌÐÌșœðăăīÐĮķăĴðĊÌÐĴìďīĮÐīðďķĮðĊþķīřȘ
CAUTION
.ȘȘðĊÌðÆĴÐĮìšīÌœðĴìăďœăÐŒÐăďåīðĮāœìðÆìșðåĊďĴŒďðÌÐÌșĉřīÐĮķăĴðĊĉðĊďīďīĉďÌÐīĴÐðĊþķīřȘ
NOTE
… indicates a potentially hazardous situation that may result in damage to property.
//USER MANUAL

2.2 TARGET GROUP
}ìðĮĉĊķăðĮðĊĴÐĊÌÐÌåďīřďķșĴìÐďœĊÐīďåĴìÐqtZqAUÅðāÐȘ9ďīāðÌĮÅðāÐĮșĴìÐĴīæÐĴæīďķĨĮďåĴìðĮķĮÐīĉĊķăīÐĨīÐĊĴĮșæķīÌðĊĮďīĴìÐĨÐīĮďĊĮķĨÐīŒðĮðĊæĴìÐĉȧĮÐÐăĮďȴǠȘwĨÐÆðăðĊåďīĉĴðďĊ
åďīĨīÐĊĴĮșæķīÌðĊĮĊÌĮķĨÐīŒðĮďīĮȵȨȘĮĮÐĉÅăřĊÌĉðĊĴÐĊĊÆÐœďīāĮīÐĪķðīÐÅĮðÆāĊďœăÐÌæÐðĊÅðāÐĴÐÆìĊďăďæřȘAåðĊÌďķÅĴșÆďĊĮķăĴĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆȘAĉĨīďĨÐīĮĮÐĉÅăřďīĉðĊĴÐĊĊÆÐ
of your bike may result in serious injury or death!
2.3 REQUIREMENTS TO OPERATE AN E-BIKE
}ìÐīðÌÐīĉķĮĴÅÐĉÐĊĴăăřĊÌĨìřĮðÆăăřÅăÐĴďĮåÐăřďĨÐīĴÐĴìÐÅðāÐďŒÐīăďĊæÐīĨÐīðďÌďåĴðĉÐĊÌăďĊæÐīÌðĮĴĊÆÐĮȘ9ďīÅÐæðĊĊÐīĮĊÌĴìďĮÐæÐĴĴðĊæÅÆāðĊĴďÅðāÐīðÌðĊæșĮĨÐÆðăÅðāÐĮāðăăĮÆďķīĮÐĮ
are recommended.
2.4 OWNER’S MANUALS SUPPLIED BY COMPONENT MANUFACTURERS
}ìðĮķĮÐīĉĊķăÆďĊĴðĊĮăăðĊåďīĉĴðďĊřďķĊÐÐÌåďīĮåÐķĮÐďåřďķīÅðāÐȘAĊÌÌðĴðďĊĴďĴìðĮķĮÐīĉĊķășřďķīÅðāÐĉřÅÐÆÆďĉĨĊðÐÌÅřĮďĉÐĨīďÌķÆĴðĊåďīĉĴðďĊďīķĮÐīĉĊķăĮåīďĉŒīðďķĮ
ÆďĉĨďĊÐĊĴĉĊķåÆĴķīÐīĮȘAåĊÐÐÌÅÐșřďķÆĊķĮÐĴìďĮÐÌďÆķĉÐĊĴĮåďīåķīĴìÐīðĊåďīĉĴðďĊďĊĴìÐīÐĮĨÐÆĴðŒÐĨīďÌķÆĴșðĴĮĮĮÐĉÅăřĊÌĮÐĴķĨȘ}ìÐķĮÐīĉĊķăĮďåĮďĉÐĉĊķåÆĴķīÐīĮĉðæìĴďĊăřÅÐ
ŒðăÅăÐďĊăðĊÐȧăĮďĮÐÐȴǧȘǡ9ķīĴìÐīAĊåďīĉĴðďĊȵȨȘ
2.5 TOOLS
ďīāďĊĴìÐÅðāÐĉřďĊăřÅÐÆīīðÐÌďķĴœðĴìĮķðĴÅăÐĴďďăĮȘwÆīÐœÆďĊĊÐÆĴðďĊĮĉķĮĴÅÐĴðæìĴÐĊÐÌĴďÌÐťĊÐÌĴďīĪķÐķĮðĊæĴďīĪķÐœīÐĊÆìȘĨīďĨÐīðĊĮĴăăĴðďĊĊÌīÐĉďŒăďåÆďĉĨďĊÐĊĴĮÆĊďĊăřÅÐ
guaranteed when using perfectly functioning and undamaged tools.
2.6 THE SPECIAL PROPERTIES OF CARBON
Carbon frames must not be clamped (e.g. into a work stand) or subjected to pressure in any other way. Always tighten carbon parts to the prescribed torque. Damage to carbon components is not necessarily
ðĉĉÐÌðĴÐăřŒðĮðÅăÐȘAåðĊÌďķÅĴșÆďĊĮķăĴĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆȘīÅďĊĨīĴĮìŒÐăðĉðĴÐÌăðåÐĮĨĊȘ>ĊÌăÐÅīĮșĮÐĴĨďĮĴĮșĮĴÐĉĮșÆīĊāĮĊÌœìÐÐăĮĉÌÐåīďĉÆīÅďĊĮìďķăÌÅÐīÐĨăÆÐÌīÐæķăīăř
(e.g. every three years). Intense heat permanently damages the carbon structure. Carbon parts must not be stored close to heat sources or in a vehicle in direct sunlight.

ǡȘǦINSTALLATION OF COMPONENTS AND ACCESSORIES
ðāÐĴīðăÐīĮĉķĮĴďĊăřÅÐťŘÐÌĴďĴìÐīÐīŘăÐďåĴìÐÅðāÐķĮðĊæĮĨÐÆðăìðĴÆìðĊæÌÐŒðÆÐĮȘ}ìÐÆďĊĊÐÆĴðĊæÐăÐĉÐĊĴÅÐĴœÐÐĊĴīðăÐīĊÌÅðāÐåīĉÐĉķĮĴĊďĴĴďķÆìĴìÐÅðāÐåīĉÐȘ Child seats and trailers for
clamp mounting on seat post or frame must not be used. No racks may be attached to the seat post or frame. Please read the manufacturers’ manual before the installation of components and accessories.
TāÐĮķīÐĴďĊďĴÐŘÆÐÐÌĴìÐĉŘðĉķĉĮřĮĴÐĉœÐðæìĴȧĮÐÐȴǡȘǠǟÐðæìĴăðĉðĴȵȨÐŒÐĊœðĴìăăÌÌȭďĊĨīĴĮĊÌÆÆÐĮĮďīðÐĮťĴĴÐÌȝ
ǡȘǧ WEARING PARTS
}ìÐÆďĉĨďĊÐĊĴĮăðĮĴÐÌÅÐăďœĮìďķăÌÅÐÆìÐÆāÐÌīÐæķăīăřĊÌīÐĨăÆÐÌșðåīÐĪķðīÐÌȚ
• Tires and tubes
• Rims
• Brake rotors and brake pads
• ÐīðĊæĮȧìÐÌĮÐĴÅÐīðĊæĮșÅďĴĴďĉÅīÆāÐĴÅÐīðĊæĮșīÐīĴīðĊæăÐÅÐīðĊæĮșìķÅÅÐīðĊæĮȨ
• ìðĊșÆĮĮÐĴĴÐĊÌĮĨīďÆāÐĴ
• >ĊÌăÐÅīĮșĮĴÐĉĊÌæīðĨĮ
• Saddle and seat post
• :īÐĮÐșăķÅīðÆĊĴșìřÌīķăðÆďðăĊÌÅīāÐŦķðÌ
//USER MANUAL

• Shift cables and housings
• Fork and rear shock
• Stickers and paintwork
ǡȘǨ EXCHANGE OF COMPONENTS
}ìðĮķĮÐīĉĊķăðĮŒăðÌåďīĴìÐďīðæðĊăÆďĊÌðĴðďĊďåřďķīÅðāÐȘĊÐŘÆìĊæÐďåÆďĉĨďĊÐĊĴĮðĮăœřĮĴìÐīÐĮĨďĊĮðÅðăðĴřďåĴìÐķĮÐīĊÌĉķĮĴÅÐÆīīðÐÌďķĴðĊÆďĊĮķăĴĴðďĊœðĴìĪķăðťÐÌÅðÆřÆăÐĉÐÆìĊðÆ
or the PROPAIN Service. It is possible that the exchange of components will change the guarantee claims.
2.10 WEIGHT LIMIT
DANGER
UDANGER OF ACCIDENTS DUE TO EXCEEDING THE MAXIMUM SYSTEM WEIGHT!
}ìÐĉŘðĉķĉĮřĮĴÐĉœÐðæìĴðĮĴìÐĮķĉďåīðÌÐīșÅðāÐșÐĪķðĨĉÐĊĴȧìÐăĉÐĴșÅÆāĨÆāșĮìďÐĮșÆăďĴìÐĮȨĊÌăķæææÐȘ'ŘÆÐÐÌðĊæĴìÐĉŘðĉķĉĮřĮĴÐĉœÐðæìĴÆĊœÐāÐĊÆďĉĨďĊÐĊĴĮĊÌăÐÌĴďĮķÌÌÐĊĊÌ
uncontrolled component failure.
THE MAXIMUM SYSTEM WEIGHT OF PROPAIN BICYCLES IS:
• KIDS BIKES WITH 20" WHEEL SIZE: 40 KG.
• NA#wAN'wA}>ǡǣȽZtǡǥȶ>''OwA¢'ȚǧǟN:Ș
• PROPAIN MOUNTAINBIKES: 120 KG.
}ìÐĉŘðĉķĉĮřĮĴÐĉœÐðæìĴĉķĮĴĊďĴÅÐÐŘÆÐÐÌÐÌȝAåÆďĉĨďĊÐĊĴĮīÐÐŘÆìĊæÐÌșĴìÐðīĉŘðĉķĉĮřĮĴÐĉœÐðæìĴĉķĮĴĊďĴÅÐăÐĮĮĴìĊĴìĴďåĴìÐÅðāÐȘ