RKI Instruments 65-2336RK User manual

5.
&DUERQ0RQR[LGH7UDQVPLWWHU
2SHUDWRU¶V0DQXDO
Part Number: 71-0178RK
Revision: B
Released: 7/6/20
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
WARNING
5HDGDQGXQGHUVWDQGWKLVLQVWUXFWLRQPDQXDOEHIRUHRSHUDWLQJGHWHF-
WRU,PSURSHUXVHRIWKHGHWHFWRUFRXOGUHVXOWLQERGLO\KDUPRUGHDWK
3HULRGLFFDOLEUDWLRQDQGPDLQWHQDQFHRIWKHGHWHFWRULVHVVHQWLDOIRU
SURSHURSHUDWLRQDQGFRUUHFWUHDGLQJV3OHDVHFDOLEUDWHDQGPDLQWDLQ
WKLVGHWHFWRUUHJXODUO\)UHTXHQF\RIFDOLEUDWLRQGHSHQGVXSRQWKH
W\SHRIXVH\RXKDYHDQGWKHVHQVRUW\SHV7\SLFDOFDOLEUDWLRQIUHTXHQ-
FLHVIRUPRVWDSSOLFDWLRQVDUHEHWZHHQDQGPRQWKVEXWFDQEH
UHTXLUHGPRUHRIWHQRUOHVVRIWHQEDVHGRQ\RXUXVDJH
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
3URGXFW:DUUDQW\
5.,,QVWUXPHQWV,QFZDUUDQWVJDVDODUPHTXLSPHQWVROGE\XVWREHIUHHIURPGHIHFWVLQ
PDWHULDOVZRUNPDQVKLSDQGSHUIRUPDQFHIRUDSHULRGRIRQH\HDUIURPGDWHRIVKLSPHQWIURP
5.,,QVWUXPHQWV,QF$Q\SDUWVIRXQGGHIHFWLYHZLWKLQWKDWSHULRGZLOOEHUHSDLUHGRU
UHSODFHGDWRXURSWLRQIUHHRIFKDUJH7KLVZDUUDQW\GRHVQRWDSSO\WRWKRVHLWHPVZKLFKE\
WKHLUQDWXUHDUHVXEMHFWWRGHWHULRUDWLRQRUFRQVXPSWLRQLQQRUPDOVHUYLFHDQGZKLFKPXVWEH
FOHDQHGUHSDLUHGRUUHSODFHGRQDURXWLQHEDVLV([DPSOHVRIVXFKLWHPVDUH
:DUUDQW\LVYRLGHGE\DEXVHLQFOXGLQJPHFKDQLFDOGDPDJHDOWHUDWLRQURXJKKDQGOLQJRU
UHSDLUSURFHGXUHVQRWLQDFFRUGDQFHZLWKWKHRSHUDWRU¶VPDQXDO7KLVZDUUDQW\LQGLFDWHVWKH
IXOOH[WHQWRIRXUOLDELOLW\DQGZHDUHQRWUHVSRQVLEOHIRUUHPRYDORUUHSODFHPHQWFRVWVORFDO
UHSDLUFRVWVWUDQVSRUWDWLRQFRVWVRUFRQWLQJHQWH[SHQVHVLQFXUUHGZLWKRXWRXUSULRUDSSURYDO
THIS WARRANTY IS EXPRESSLY IN LIEU OF ANY AND ALL OTHER WARRANTIES
AND REPRESENTATIONS, EXPRESSED OR IMPLIED, AND ALL OTHER
OBLIGATIONS OR LIABILITIES ON THE PART OF RKI INSTRUMENTS, INC.
INCLUDING BUT NOT LIMITED TO, THE WARRANTY OF MERCHANTABILITY OR
FITNESS FOR APARTICULAR PURPOSE. IN NO EVENT SHALL RKI INSTRUMENTS,
INC., BE LIABLE FOR INDIRECT, INCIDENTAL, OR CONSEQUENTIAL LOSS OR
DAMAGE OF ANY KIND CONNECTED WITH THE USE OF ITS PRODUCTS OR
FAILURE OF ITS PRODUCTS TO FUNCTION OR OPERATE PROPERLY.
7KLVZDUUDQW\FRYHUVLQVWUXPHQWVDQGSDUWVVROGWRXVHUVE\DXWKRUL]HGGLVWULEXWRUVGHDOHUV
DQGUHSUHVHQWDWLYHVDVDSSRLQWHGE\5.,,QVWUXPHQWV,QF
:HGRQRWDVVXPHLQGHPQLILFDWLRQIRUDQ\DFFLGHQWRUGDPDJHFDXVHGE\WKHRSHUDWLRQRIWKLV
JDVPRQLWRUDQGRXUZDUUDQW\LVOLPLWHGWRWKHUHSODFHPHQWRISDUWVRURXUFRPSOHWHJRRGV
D$EVRUEHQWFDUWULGJHV G%DWWHULHV
E3XPSGLDSKUDJPVDQGYDOYHV H)LOWHUHOHPHQWV
F)XVHV
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
7DEOHRI&RQWHQWV
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
CO Detector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Amplifier. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Junction Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Mounting the CO Transmitter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Wiring the CO Transmitter to a Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Startup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Introducing Incoming Power. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Setting the Zero Signal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Preventive Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Replacing Components of the CO Transmitter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Calibration Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Preparing for Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Setting the Zero Reading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Setting the Response Reading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Returning to Normal Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
2YHUYLHZ
7KLVLQVWUXFWLRQPDQXDOGHVFULEHVWKH5.FDUERQPRQR[LGH&2WUDQVPLWWHU7KLV
PDQXDODOVRGHVFULEHVKRZWRLQVWDOOVWDUWXSFRQILJXUHPDLQWDLQDQGFDOLEUDWHWKH
WUDQVPLWWHUZKHQXVLQJLWZLWKDJDVPRQLWRULQJFRQWUROOHU$SDUWVOLVWDWWKHHQGRIWKLV
PDQXDOOLVWVUHSODFHPHQWSDUWVDQGDFFHVVRULHVIRUWKH&2WUDQVPLWWHU6HHWKHFRQWUROOHU
RSHUDWRU¶VPDQXDOIRULQIRUPDWLRQVSHFLILFWRWKHFRQWUROOHU
6SHFLILFDWLRQV
WARNING: Do not use this product in a manner not specified in this instruction manual.
7DEOHOLVWVVSHFLILFDWLRQVIRUWKH&2WUDQVPLWWHU
127( 7KHIROORZLQJV\PERORQWKHGHWHFWRUODEHOLVDFDXWLRQWRWKHXVHUWRUHIHUWRWKLV
GRFXPHQWDWLRQIRULQVWDOODWLRQDQGRSHUDWLRQLQVWUXFWLRQV 
WARNING: When using the 65-2336RK, you must follow the instructions and warnings in
this manual to assure proper and safe operation of the 65-2336RK and to
minimize the risk of personal injury. Be sure to maintain and periodically
calibrate the 65-2336RK as described in this manual.
7DEOH6SHFLILFDWLRQV
7DUJHW*DV &DUERQ0RQR[LGH
$UHD&ODVVLILFDWLRQ ([SORVLRQSURRIIRU&ODVV,*URXSV%&DQG'
7HPSHUDWXUH&RGH 7
,QVWDOODWLRQ&DWHJRU\ ,QVWDOODWLRQ&DWHJRU\6LJQDOOHYHOVSHFLDOHTXLSPHQWRU
SDUWVRIHTXLSPHQWWHOHFRPPXQLFDWLRQHOHFWURQLFHWF
ZLWKVPDOOHUWUDQVLHQWRYHUYROWDJHVWKDQ,QVWDOODWLRQ
&DWHJRU\2YHUYROWDJH&DWHJRU\,,UHI,(&
,QSXW9ROWDJH 9'&9'&
6DPSOLQJ0HWKRG 'LIIXVLRQ
6LJQDO2XWSXW WRP$
'HWHFWLRQ5DQJH WR330SDUWVSHUPLOOLRQ
$FFXUDF\ RIUHDGLQJRUSSP&2ZKLFKHYHULVJUHDWHU
&2'HWHFWRU6LJQDO2XWSXW P$DWSSP&2QRPLQDO
P$DWSSP&2QRPLQDO
5HVSRQVH7LPH LQVHFRQGV
2SHUDWLQJ7HPSHUDWXUH )WR)&WR&

www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
'HVFULSWLRQ
7KLVVHFWLRQGHVFULEHVWKHFRPSRQHQWVRIWKH&2WUDQVPLWWHU7KH&2WUDQVPLWWHULVDWR
P$W\SHGHWHFWRUKHDG,WFRQVLVWVRIWKH&2GHWHFWRUDPSOLILHUDQGMXQFWLRQER[
)LJXUH&27UDQVPLWWHU&RPSRQHQW/RFDWLRQ
SIG/PWRTOXIC OXY
Controller Terminal Strip
Amplifier
J-Box
CO Detector
SPAN
ZERO
Zero Pot
Span Pot
Factory Adjust Pot
+ Test Point (Red) Detector Terminal
Strip
- Test Point (Black)
S
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
&2'HWHFWRU
7KH&2GHWHFWRUFRQVLVWVRIWKHGHWHFWRUKRXVLQJERG\GHWHFWRUKRXVLQJFDSFDSJDVNHWSOXJ
LQVHQVRUDQGWKHFKDUFRDOILOWHU
)LJXUH&2'HWHFWRU&RPSRQHQW/RFDWLRQ
Detector Housing Body
7KHGHWHFWRUKRXVLQJERG\SURWHFWVWKHHOHFWURQLFFRPSRQHQWVZLWKLQWKHKRXVLQJ8VHWKH
PRXQWLQJWKUHDGVDWWKHWRSRIWKHKRXVLQJWRVFUHZWKH&2GHWHFWRULQWRWKH´137KXERQ
WKHERWWRPRIWKHMXQFWLRQER[7ZRZLUHVH[WHQGIURPWKHWRSRIWKHGHWHFWRUKRXVLQJERG\
8VHWKHVHZLUHVWRFRQQHFWWKH&2GHWHFWRUWRWKHDPSOLILHU2QHRIWKHZLUHVLVUHGDQGRQHRI
WKHZLUHVLVEODFN
7KHKRXVLQJLQFOXGHVDIRXUVRFNHWSDWWHUQ7KLVVRFNHWSDWWHUQDFFHSWVWKHVHQVRU¶VIRXUSLQV
WRVHFXUHWKHVHQVRUZLWKLQWKHGHWHFWRUKRXVLQJ$SUHDPSOLILHUORFDWHGEHWZHHQWKHVRFNHWV
DQGWZRLQWHUFRQQHFWZLUHVFRQGLWLRQVWKHVHQVRU¶VVLJQDOEHIRUHWKHVLJQDOUHDFKHVWKH
FRQWUROOHU
Housing Cap & Cap Gasket
7KHKRXVLQJFDSVFUHZVRQWRWKHGHWHFWRUKRXVLQJ,WUHWDLQVWKHSOXJLQVHQVRUDQGSURWHFWVLW
IURPGDPDJH7KHKRXVLQJFDSDOVRLQFOXGHVDIODPHDUUHVWRUZKLFKFRQWDLQVDQ\VSDUNVWKDW
PD\RFFXUZLWKLQWKHGHWHFWRUDQGDIODPHDUUHVWRUJXDUGZKLFKSURWHFWVWKHIODPHDUUHVWRU
IURPGDPDJH8QVFUHZWKHGHWHFWRUFDSWRDFFHVVWKHSOXJLQVHQVRUIRUPDLQWHQDQFHRU
UHSODFHPHQW$FDSJDVNHWVHDOVWKHLQWHUIDFHEHWZHHQWKHKRXVLQJDQGFDS
Plug-In CO Sensor
7KHVHQVRULVVHFXUHGZLWKLQWKHGHWHFWRUDVVHPEO\E\WKHKRXVLQJFDS7KURXJKDVHULHVRI
FKHPLFDODQGHOHFWULFDOUHDFWLRQVWKHVHQVRUSURGXFHVDQHOHFWULFDORXWSXWWKDWFRUUHVSRQGVWR
WKHGHWHFWLRQUDQJHRIWKHWUDQVPLWWHU
Plug-In CO Sensor
Rubber Boot With
Charcoal Filter
Detector Housing Cap
Detector Housing Body
Cap Gasket
Flame Arrestor
Guard
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
Charcoal Filter
7KHGLVFVKDSHGFKDUFRDOILOWHULVVHFXUHGWRWKHIDFHRIWKH&2VHQVRUZLWKDUXEEHUERRW7KH
FKDUFRDOILOWHUSUHYHQWVLQWHUIHUHQFHJDVHVK\GURJHQVXOILGH>+6@DQGFHUWDLQK\GURFDUERQV
IURPSURGXFLQJIDOVH&2UHDGLQJV
$PSOLILHU
7KHDPSOLILHUFRQYHUWVWKHHOHFWULFDORXWSXWIURPWKHGHWHFWRUWRDWRP$VLJQDOWKDW
FRUUHVSRQGVWRWKHGHWHFWLRQUDQJHDQGWUDQVPLWVWKHVLJQDOWRDJDVPRQLWRULQJFRQWUROOHU$
IRDPJDVNHWWKDWRULHQWVWKHDPSOLILHUDQGNHHSVLWIURPURWDWLQJLVLQVWDOOHGRQWKHERWWRPRI
WKHDPSOLILHU7KHDPSOLILHULQFOXGHVWKHFRQWUROOHUWHUPLQDOVWULSGHWHFWRUWHUPLQDOVWULS]HUR
SRWVSDQSRWDQGWHVWSRLQWVVHH)LJXUH 
Controller Terminal Strip
7KHFRQWUROOHUWHUPLQDOVWULSLVDWZRSRVLWLRQSOXJLQVW\OHWHUPLQDOVWULSORFDWHGDWWKHWRS
HGJHRIWKHDPSOLILHU8VHWKHFRQWUROOHUWHUPLQDOVWULSWRZLUHWKHDPSOLILHUWRDFRQWUROOHU
Detector Terminal Strip
7KHGHWHFWRUWHUPLQDOVWULSLVDIRXUSRVLWLRQSOXJLQVW\OHWHUPLQDOVWULSORFDWHGEHORZWKH
FRQWUROOHUWHUPLQDOVWULS7ZRRIWKHSRVLWLRQVDUHIRUXVHZLWKDQR[\JHQGHWHFWRUDQGDUHQRW
XVHGLQWKH&2WUDQVPLWWHU8VHWKHWZRGHWHFWRUWHUPLQDOVWULSSRVLWLRQVWKDWDUHODEHOHG
³72;,&´WRFRQQHFWWKHGHWHFWRUWRWKHDPSOLILHU
127( 7KHGHWHFWRULVIDFWRU\ZLUHGWRWKHGHWHFWRUWHUPLQDOVWULS6HH³:LULQJWKH&2
7UDQVPLWWHUWRD&RQWUROOHU´RQSDJH IRUDOOZLULQJSURFHGXUHVUHODWHGWRWKH
WUDQVPLWWHU
Zero Pot
7KH]HURSRWLVORFDWHGLQWKHXSSHUOHIWFRUQHURIWKHDPSOLILHUVHH)LJXUH 8VHDVPDOOIODW
EODGHVFUHZGULYHUWRWXUQWKH]HURSRW¶VDGMXVWPHQWVFUHZDQGDGMXVWWKHDPSOLILHU¶V]HUR&2
IUHHRXWSXWGXULQJWKHVWDUWXSDQGFDOLEUDWLRQSURFHGXUH7XUQWKHDGMXVWPHQWVFUHZ
FORFNZLVHWRLQFUHDVHWKH]HURRXWSXWDQGFRXQWHUFORFNZLVHWRGHFUHDVHWKH]HURRXWSXW
Span Pot
7KHVSDQSRWLVORFDWHGWRWKHULJKWRIWKH]HURSRWVHH)LJXUH 8VHDVPDOOIODWEODGH
VFUHZGULYHUWRWXUQWKHVSDQSRW¶VDGMXVWPHQWVFUHZDQGDGMXVWWKHDPSOLILHU¶VUHVSRQVHRXWSXW
GXULQJWKHVWDUWXSDQGFDOLEUDWLRQSURFHGXUH7XUQWKHDGMXVWPHQWVFUHZFORFNZLVHWRLQFUHDVH
WKHUHVSRQVHRXWSXWDQGFRXQWHUFORFNZLVHWRGHFUHDVHWKHUHVSRQVHRXWSXW
CAUTION: The amplifier includes an additional pot. It is factory-set. Do not adjust it.
Test Points
7KHWHVWSRLQWVDUHRQWKHOHIWVLGHRIWKHDPSOLILHUVHH)LJXUH 7KHWHVWSRLQWVSURGXFHD
P9WRP9RXWSXWWKDWFRUUHVSRQGVWRWKHWUDQVPLWWHU¶VWRP$RXWSXW8VHWKHWHVW
SRLQWVDQGDYROWPHWHUWRPHDVXUHWKHDPSOLILHU¶VRXWSXWGXULQJWKHVWDUWXSDQGFDOLEUDWLRQ
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
SURFHGXUHV7KHEODFNWHVWSRLQWLQWKHORZHUOHIWFRUQHULVWKHQHJDWLYHWHVWSRLQWDQGWKH
UHGWHVWSRLQWEHORZWKH]HURSRWLVWKHSRVLWLYHWHVWSRLQW
-XQFWLRQ%R[
8VHWKHMXQFWLRQER[WRLQVWDOOWKHWUDQVPLWWHUDWDPRXQWLQJVLWHWKDWLVUHPRWHIURPWKH
FRQWUROOHU7KHMXQFWLRQER[SURWHFWVWKHDPSOLILHUDQGZLULQJFRQQHFWLRQVPDGHWRWKH
DPSOLILHU8VHWKHWRS137FRQGXLWKXEWRFRQQHFWZLULQJIURPWKHDPSOLILHUWRWKH
FRQWUROOHU8VHWKHFRYHURQWKHIURQWRIWKHMXQFWLRQER[WRDFFHVVWKHLQWHULRURIWKHMXQFWLRQ
ER[7KHGHWHFWRUDQGDPSOLILHUDUHIDFWRU\LQVWDOOHGLQWKHMXQFWLRQER[7KUHHVSDFHUV
LQVWDOOHGRQWKHEDFNRIWKHMXQFWLRQER[FRQWUROWKHGLVWDQFHRIWKHMXQFWLRQER[IURPD
PRXQWLQJVXUIDFHDQGHQVXUHWKDWWKHUHLVHQRXJKURRPWRLQVWDOODFDOLEUDWLRQFXSRQWKH
GHWHFWRUGXULQJFDOLEUDWLRQ
,QVWDOODWLRQ
7KLVVHFWLRQGHVFULEHVSURFHGXUHVWRPRXQWWKH&2WUDQVPLWWHULQWKHPRQLWRULQJHQYLURQPHQW
DQGZLUHWKHWUDQVPLWWHUWRDFRQWUROOHU
0RXQWLQJWKH&27UDQVPLWWHU
 6HOHFWDPRXQWLQJVLWHWKDWLVUHSUHVHQWDWLYHRIWKHPRQLWRULQJHQYLURQPHQW&RQVLGHUWKH
IROORZLQJZKHQ\RXVHOHFWWKHPRXQWLQJVLWH
 6HOHFWDVLWHZKHUHWKHWUDQVPLWWHULVQRWOLNHO\WREHEXPSHGRUGLVWXUEHG0DNHVXUH
WKHUHLVVXIILFLHQWURRPWRSHUIRUPVWDUWXSPDLQWHQDQFHDQGFDOLEUDWLRQSURFHGXUHV
 6HOHFWDVLWHWKDWLVDWQRUPDOEUHDWKLQJOHYHO
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
)LJXUH0RXQWLQJWKH&27UDQVPLWWHU
 $WWKHPRQLWRULQJVLWH\RXVHOHFWKDQJRUPRXQWWKHMXQFWLRQER[ZLWKWKHGHWHFWRUIDFLQJ
GRZQVHH)LJXUH 
3.10
.38
.75
Rubber
Spacers
3X
J-Box
3/4 NPT
Female
3.65
1 1/2-20 Thread for Calibration Cup
CO Detector
8.45 Max
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
:LULQJWKH&27UDQVPLWWHUWRD&RQWUROOHU
WARNING: If the controller’s construction is not explosion-proof, the controller must be
installed in an ordinary location. Do non install a non-explosion-proof
controller in a classified location.
 7XUQRIIWKHFRQWUROOHU
 7XUQRIISRZHUWRWKHFRQWUROOHU
 5HPRYHWKHMXQFWLRQER[FRYHU
 7KHGHWHFWRUOHDGVDUHIDFWRU\ZLUHG9HULI\WKDWWKHGHWHFWRUOHDGVDUHZLUHGWRWKH
DPSOLILHU¶VGHWHFWRUWHUPLQDOVWULSDVVKRZQLQ)LJXUH 
 7RJDLQDFFHVVWRDSOXJLQWHUPLQDOVWULSIRUZLULQJSXOOLWRXWRILWVVRFNHWE\JUDVSLQJWKH
WHUPLQDOVWULSDQGSXOOLQJ7KHGHWHFWRUWHUPLQDOVWULSLVNH\HGVRWKDWWKHFRQWUROOHUDQG
GHWHFWRUWHUPLQDOVWULSVFDQQRWEHUHYHUVHGLQDGYHUWHQWO\
WARNING: To maintain the explosion proof classification of the CO detector/junction box
combination, a conduit seal must be used within 2 inches of the junction box
conduit hub used for wiring to the controller. Adhere to your local electrical
code when installing the conduit seal.
 *XLGHHLWKHUDWZRFRQGXFWRUVKLHOGHGFDEOHRUWZRZLUHVLQFRQGXLWWKURXJKWKHWRS
FRQGXLWKXERIWKHMXQFWLRQER[
 3XOORXWWKHFRQWUROOHUWHUPLQDOVWULSDQGFRQQHFWWKHWZRZLUHVWRWKHWHUPLQDOVWULSDV
IROORZVVHH)LJXUH 
 &RQQHFWWKHSRVLWLYHZLUHWRWKH6,*3:5³´WHUPLQDO
 &RQQHFWWKHVLJQDOZLUHWRWKH6,*3:5³6´WHUPLQDO
CAUTION: If shielded cable is used, leave the cable shield’s drain wire disconnected and
insulated at the transmitter. You will connect the opposite end of the cable’s
drain wire to the controller’s chassis (earth) ground.
 5HLQVWDOOWKHFRQWUROOHUWHUPLQDOVWULSLQWRLWVVRFNHW
 6HFXUHWKHMXQFWLRQER[FRYHUWRWKHMXQFWLRQER[
 5RXWHWKHFDEOHRUZLUHVOHDGLQJIURPWKH&2WUDQVPLWWHUWKURXJKRQHRIWKHFRQGXLWKXEV
DWWKHFRQWUROOHUKRXVLQJ
CAUTION: Do not route power and transmitter wiring through the same controller conduit
hub. The power cable may disrupt the transmission of the transmitter signal to
the controller.
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
 &RQQHFWWKHZLUHVWRWKHDSSOLFDEOHGHWHFWRUWUDQVPLWWHUWHUPLQDOVWULSDWWKHFRQWUROOHUDV
VKRZQLQ)LJXUH 
)LJXUH:LULQJWKH&27UDQVPLWWHUWRD&RQWUROOHU
 ,IVKLHOGHGFDEOHLVXVHGFRQQHFWWKHFDEOH¶VGUDLQZLUHWRDQDYDLODEOHFKDVVLVHDUWK
JURXQGDWWKHFRQWUROOHU5.,FRQWUROOHUVW\SLFDOO\KDYHDJURXQGVWXGWKDWFDQEHXVHGWR
JURXQGWKHFDEOH¶VGUDLQZLUH
SPAN
TO XIC OX Y S
SI G/PWR
Red
ZERO
Black
S
Controller Detector/Transmitter
Terminals, Typical Designations
Install conduitseal
within 2 inches
CO Detector
Controller Housing
(installed in ordinary location if
device isnon-explosion-proof)
J-Box
Cable Shield
+
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
6WDUW8S
7KLVVHFWLRQGHVFULEHVSURFHGXUHVWRVWDUWXSWKH&2WUDQVPLWWHUDQGSODFHWKHWUDQVPLWWHULQWR
QRUPDORSHUDWLRQ
,QWURGXFLQJ,QFRPLQJ3RZHU
 &RPSOHWHWKHLQVWDOODWLRQSURFHGXUHVGHVFULEHGHDUOLHULQWKLVPDQXDO
 9HULI\WKDWWKHSRZHUZLULQJWRWKHFRQWUROOHULVFRUUHFWDQGVHFXUH5HIHUWRWKHFRQWUROOHU
RSHUDWRU¶VPDQXDO
 7XUQRQSRZHUWRWKHFRQWUROOHU
 7XUQRQWKHFRQWUROOHU
 9HULI\WKDWWKHFRQWUROOHULVRQDQGRSHUDWLQJSURSHUO\5HIHUWRWKHFRQWUROOHURSHUDWRU¶V
PDQXDO
CAUTION: Allow the transmitter to warm up for 5 minutes before you continue with the next
section, “Setting the Zero Signal”.
6HWWLQJWKH=HUR6LJQDO
WARNING: Do not remove the detector housing cap or junction box cover while the
circuits are energized unless the area is determined to be non-hazardous. Keep
the detector housing cap and junction box cover tightly closed during
operation.
127( ,I\RXFDQYHULI\WKDWWKHGHWHFWRULVLQDIUHVKDLUHQYLURQPHQWHQYLURQPHQWNQRZQWR
EHRIQRUPDOR[\JHQFRQWHQWDQGIUHHRIWR[LFDQGFRPEXVWLEOHJDVHVLWLVQRW
QHFHVVDU\WRDSSO\]HURDLUZKHQYHULI\LQJRUVHWWLQJWKHIUHVKDLUUHDGLQJ
7KHSURFHGXUHEHORZGHVFULEHVDSSO\LQJ]HURHPLVVLRQDLUXVXDOO\FDOOHG]HURDLUXVLQJD
FDOLEUDWLRQNLWWKDWLQFOXGHVDFDOLEUDWLRQFXSFDOLEUDWLRQJDVVDPSOHWXELQJDQGDIL[HGIORZ
UHJXODWRUZLWKDQRQRIINQRE5.,,QVWUXPHQWV,QFUHFRPPHQGVXVLQJD/30OLWHUVSHU
PLQXWHIL[HGIORZUHJXODWRU
 8QVFUHZDQGUHPRYHWKHMXQFWLRQER[FRYHUIURPWKHMXQFWLRQER[
 6HWDYROWPHWHUWRPHDVXUHLQWKHPLOOLYROWP9UDQJH
 3OXJWKHYROWPHWHUOHDGVLQWRWKHWHVWSRLQWVRQWKHDPSOLILHU3OXJWKHSRVLWLYHOHDGLQWRWKH
UHGWHVWSRLQWSOXJWKHQHJDWLYHOHDGLQWRWKHEODFNWHVWSRLQW
 6FUHZWKHFDOLEUDWLRQFXSRQWRWKHERWWRPRIWKH&2GHWHFWRU
 6FUHZWKHUHJXODWRULQWRWKH]HURDLUFDOLEUDWLRQF\OLQGHU
 8VHWKHVDPSOHWXELQJWRFRQQHFWWKHUHJXODWRUWRWKHFDOLEUDWLRQFXS
 7XUQWKHUHJXODWRU¶VRQRIINQREFRXQWHUFORFNZLVHWRRSHQLW*DVZLOOEHJLQWRIORZ
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
 $OORZWKHJDVWRIORZIRUWZRPLQXWHV
 9HULI\DYROWPHWHUUHDGLQJRIP9P9
 ,IQHFHVVDU\XVHDVPDOOIODWEODGHVFUHZGULYHUWRDGMXVWWKH]HURSRWXQWLOWKHYROWPHWHU
UHDGLQJLVP9P9
 7XUQWKHUHJXODWRU¶VRQRIINQREFORFNZLVHWRFORVHLW
 8QVFUHZWKHFDOLEUDWLRQFXSIURPWKHGHWHFWRU
 8QVFUHZWKHUHJXODWRUIURPWKH]HURDLUFDOLEUDWLRQF\OLQGHU)RUFRQYHQLHQFHOHDYHWKH
VDPSOHWXELQJFRQQHFWHGWRWKHUHJXODWRUDQGWKHFDOLEUDWLRQFXS
 6WRUHWKHFRPSRQHQWVRIWKHFDOLEUDWLRQNLWLQDVDIHDQGFRQYHQLHQWSODFH
 5HPRYHWKHYROWPHWHUOHDGVIURPWKHWHVWSRLQWV
 6HFXUHWKHMXQFWLRQER[FRYHUWRWKHMXQFWLRQER[
0DLQWHQDQFH
7KLVVHFWLRQGHVFULEHVPDLQWHQDQFHSURFHGXUHV,WLQFOXGHVSUHYHQWLYHPDLQWHQDQFH
WURXEOHVKRRWLQJDQGFRPSRQHQWUHSODFHPHQWSURFHGXUHV
3UHYHQWLYH0DLQWHQDQFH
7KLVVHFWLRQGHVFULEHVDSUHYHQWLYHPDLQWHQDQFHVFKHGXOHWRHQVXUHWKHRSWLPXPSHUIRUPDQFH
RIWKH&2WUDQVPLWWHU,WLQFOXGHVGDLO\DQGTXDUWHUO\SURFHGXUHV
Daily
9HULI\DGLVSOD\UHDGLQJRI330&2DWWKHFRQWUROOHU,QYHVWLJDWHVLJQLILFDQWFKDQJHVLQWKH
GLVSOD\UHDGLQJ
Quarterly
&DOLEUDWHWKH&2WUDQVPLWWHUDVGHVFULEHGLQ³&DOLEUDWLRQ´RQSDJH RIWKLVPDQXDO6HHWKH
FDOLEUDWLRQIUHTXHQF\GLVFXVVLRQLQ³&DOLEUDWLRQ)UHTXHQF\´RQSDJH WRGHWHUPLQHLID
TXDUWHUO\FDOLEUDWLRQVFKHGXOHILWV\RXUQHHGV
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
7URXEOHVKRRWLQJ
7KHWURXEOHVKRRWLQJJXLGHGHVFULEHVV\PSWRPVSUREDEOHFDXVHVDQGUHFRPPHQGHGDFWLRQIRU
SUREOHPV\RXPD\HQFRXQWHUZLWKWKH&2WUDQVPLWWHU
127( 7KLVWURXEOHVKRRWLQJJXLGHGHVFULEHVWUDQVPLWWHUSUREOHPVRQO\6HHWKHFRQWUROOHU
LQVWUXFWLRQPDQXDOIRUSUREOHPV\RXPD\HQFRXQWHUZLWKWKHFRQWUROOHU
7DEOH7URXEOHVKRRWLQJWKH&27UDQVPLWWHU
&RQGLWLRQ 6\PSWRPV 3UREDEOH&DXVHV 5HFRPPHQGHG$FWLRQ
)DLO
&RQGLWLRQ
&RQWUROOHULQGLFDWHVD
IDLOFRQGLWLRQ
 7KHWUDQVPLWWHUZLULQJ
WRWKHFRQWUROOHULV
GLVFRQQHFWHGRU
PLVFRQQHFWHG
 7KHSOXJLQVHQVRULV
QRWSURSHUO\SOXJJHG
LQWRWKHVRFNHWVLQWKH
GHWHFWRUKRXVLQJERG\
 7KHZLULQJIURPWKH
GHWHFWRUWRWKH
DPSOLILHULV
GLVFRQQHFWHGRU
PLVFRQQHFWHG
 7KHWUDQVPLWWHU¶V]HUR
UHDGLQJLVORZHQRXJK
WRFDXVHDIDLO
FRQGLWLRQ
 7KHWUDQVPLWWHULV
PDOIXQFWLRQLQJ
 9HULI\WKDWWKHWUDQVPLWWHUZLULQJWR
WKHFRQWUROOHULVFRUUHFWDQGVHFXUH
 &RQILUPWKDWWKHSOXJLQVHQVRULV
LQVWDOOHGSURSHUO\
 9HULI\WKDWWKHZLULQJIURPWKH
GHWHFWRUWRWKHDPSOLILHULVFRUUHFW
DQGVHFXUH
 3HUIRUPD]HURDGMXVWPHQW$IXOO
FDOLEUDWLRQLVUHFRPPHQGHG
 ,IWKHIDLOFRQGLWLRQFRQWLQXHV
UHSODFHWKHSOXJLQVHQVRUDV
GHVFULEHGODWHULQWKLVVHFWLRQ
 ,IWKHIDLOFRQGLWLRQFRQWLQXHV
FRQWDFW5.,IRUIXUWKHULQVWUXFWLRQ
6ORZRU1R
5HVSRQVH
'LIILFXOWRU
8QDEOHWR
&DOLEUDWH
 8QDEOHWRDFFXUDWHO\
VHWWKH]HURRU
UHVSRQVHUHDGLQJ
GXULQJFDOLEUDWLRQ
 7UDQVPLWWHUUHTXLUHV
IUHTXHQWFDOLEUDWLRQ
Note: Under
“normal”
circumstances, the
transmitter requires
calibration once every
3 months.
Some applications
may require a more
frequent calibration
schedule.
 7KHFDOLEUDWLRQ
F\OLQGHULVORZRXW
GDWHGRUGHIHFWLYH
 7KHIODPHDUUHVWRULQ
WKHGHWHFWRUKRXVLQJ
FDSLVZHWRUFORJJHG
ZLWKGLUWRURWKHU
SDUWLFXODWHV
 7KHFDOLEUDWLRQJDVLV
QRWDQDSSURSULDWH
FRQFHQWUDWLRQ
 7KHWUDQVPLWWHULV
PDOIXQFWLRQLQJ
 9HULI\WKDWWKHFDOLEUDWLRQF\OLQGHU
FRQWDLQVDQDGHTXDWHVXSSO\RID
IUHVKWHVWVDPSOH
 &KHFNWKHGHWHFWRUKRXVLQJFDSWR
GHWHUPLQHLIWKHIODPHDUUHVWRULVZHW
RUGLUW\&OHDQLIQHFHVVDU\
 9HULI\WKDWWKHFDOLEUDWLRQJDV
FRQFHQWUDWLRQLVDSSURSULDWHIRUWKH
WUDQVPLWWHU=HURHPLVVLRQDLU
R[\JHQLVQRUPDOO\XVHGIRUD]HUR
DGMXVWPHQWLIWKHHQYLURQPHQWLV
VXVSHFWDQG330&2LQDLULV
QRUPDOO\XVHGIRUDUHVSRQVH
DGMXVWPHQW
 ,IWKHFDOLEUDWLRQUHVSRQVHGLIILFXOWLHV
FRQWLQXHUHSODFHWKHSOXJLQVHQVRU
DVGHVFULEHGODWHULQWKLVVHFWLRQ
 ,IWKHFDOLEUDWLRQUHVSRQVHGLIILFXOWLHV
FRQWLQXHFRQWDFW5.,IRUIXUWKHU
LQVWUXFWLRQ
8QH[SODLQHG
8SVFDOH
5HDGLQJVRU
$ODUPV
 &RQWUROOHULQGLFDWHV
D&2UHDGLQJWKDW
FDQQRWEHYHULILHG
 &2DODUPVRFFXUDW
WKHFRQWUROOHUWKDW
FDQQRWEHH[SODLQHG
 &KDUFRDOILOWHULV
VDWXUDWHGDQGQR
ORQJHUVFUXEELQJRXW
LQWHUIHULQJJDVHV
 5HSODFHFKDUFRDOILOWHU
 ,IGLIILFXOWLHVFRQWLQXHFRQWDFW5.,
IRUIXUWKHULQVWUXFWLRQV
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
5HSODFLQJ&RPSRQHQWVRIWKH&27UDQVPLWWHU
7KLVVHFWLRQLQFOXGHVDSURFHGXUHWRUHSODFHWKH&2SOXJLQVHQVRUFKDUFRDOILOWHUDQG
DPSOLILHU$SURFHGXUHWRUHSODFHWKHHQWLUHGHWHFWRUDVVHPEO\LVDWWKHHQGRIWKLVVHFWLRQ,Q
PRVWFDVHVLWLVQRWQHFHVVDU\WRUHSODFHWKHHQWLUHGHWHFWRUDVVHPEO\
Replacing the Plug-In CO sensor
CAUTION: The sensor contains electrolyte which is a dilute acid. Do not disassemble the
sensor when replacing it with a new one. If sensor electrolyte comes in contact
with your skin, wash affected area thoroughly with soap and water.
 7XUQRIIWKHFRQWUROOHU
 7XUQRIIRUXQSOXJSRZHUWRWKHFRQWUROOHU
 8QVFUHZWKHGHWHFWRUKRXVLQJFDSIURPWKHGHWHFWRUKRXVLQJERG\0DNHVXUHQRWWRORVH
WKHFDSJDVNHW
 8QSOXJDQGUHPRYHWKH&2VHQVRUZLWKWKHERRWDQGFKDUFRDOILOWHUDWWDFKHG
 5HPRYHWKHUXEEHUERRWDQGFKDUFRDOILOWHUIURPROGVHQVRU
 5HPRYHWKHUHSODFHPHQWVHQVRUIURPLWVSDFNDJLQJDQGUHPRYHWKHZLUHMXPSHU7KLVZLUH
MXPSHULVLQVWDOOHGRQWKHVHQVRUSLQVIRUVKLSPHQWRUVWRUDJHEXWPXVWEHUHPRYHGIRUWKH
VHQVRUWRRSHUDWHSURSHUO\ZKHQLQVWDOOHGLQDGHWHFWRU
WARNING: The CO sensor will not operate properly if the wire jumper is not removed.
 ,QVWDOOWKHUXEEHUERRWZLWKFKDUFRDOILOWHURQWRWKHUHSODFHPHQWVHQVRU¶VIDFH
 &DUHIXOO\SOXJWKHUHSODFHPHQWVHQVRULQWRWKHIRXUVRFNHWSDWWHUQWKDWLVORFDWHGLQWKH
GHWHFWRUKRXVLQJ
 0DNHVXUHWKHFDSJDVNHWLVLQSODFHDQGVFUHZWKHGHWHFWRUKRXVLQJFDSEDFNRQWRWKH
GHWHFWRUKRXVLQJERG\
 7XUQRQRUSOXJLQSRZHUWRWKHFRQWUROOHU
 7XUQRQWKHFRQWUROOHUDQGSODFHLQWRQRUPDORSHUDWLRQ
CAUTION: Allow the replacement sensor to warm up for 5 minutes before you continue with
the next step.
)LJXUH3OXJ,Q6HQVRU-XPSHU5HPRYDO
Remove jumper
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
 &DOLEUDWHWKHWUDQVPLWWHUDVGHVFULEHGLQ³&DOLEUDWLRQ´RQSDJH 
Replacing the Charcoal Filter
 7XUQRIIWKHFRQWUROOHU
 7XUQRIIRUXQSOXJSRZHUWRWKHFRQWUROOHU
 8QVFUHZWKHGHWHFWRUKRXVLQJFDSIURPWKHGHWHFWRUKRXVLQJERG\
 8QSOXJDQGUHPRYHWKH&2VHQVRUZLWKWKHERRWDQGFKDUFRDOILOWHUDWWDFKHG
 5HPRYHWKHUXEEHUERRWWKDWVHFXUHVWKHFKDUFRDOILOWHUWRWKH&2VHQVRU
 5HPRYHWKHFKDUFRDOILOWHUIURPWKHUXEEHUERRW
 3ODFHWKHUHSODFHPHQWILOWHULQWKHUXEEHUERRWLQWKHVDPHSRVLWLRQDVWKHILOWHU\RX
UHPRYHGLQWKHSUHYLRXVVWHS
 5HLQVWDOOWKHUXEEHUERRWZLWKFKDUFRDOILOWHUWRWKH&2VHQVRU
 &DUHIXOO\SOXJWKHUHSODFHPHQWVHQVRULQWRWKHIRXUVRFNHWSDWWHUQWKDWLVORFDWHGLQWKH
GHWHFWRUKRXVLQJ
 0DNHVXUHWKHFDSJDVNHWLVLQSODFHDQGVFUHZWKHGHWHFWRUKRXVLQJFDSEDFNRQWRWKH
GHWHFWRUKRXVLQJERG\
 7XUQRQRUSOXJLQSRZHUWRWKHFRQWUROOHU
 7XUQRQWKHFRQWUROOHUDQGSODFHLQWRQRUPDORSHUDWLRQ
Replacing the CO Detector
127( ,QPRVWFDVHVLWLVRQO\QHFHVVDU\WRUHSODFHWKHSOXJLQ&2VHQVRU
 7XUQRIIWKHFRQWUROOHU
 7XUQRIIRUXQSOXJSRZHUWRWKHFRQWUROOHU
 5HPRYHWKHMXQFWLRQER[FRYHU
 5HPRYHWKHGHWHFWRUWHUPLQDOVWULSIURPLWVVRFNHW
 'LVFRQQHFWWKHGHWHFWRUOHDGVIURPWKHGHWHFWRUWHUPLQDOVWULS1RWHWKHSRVLWLRQRIWKH
FRORUFRGHGOHDGVDV\RXUHPRYHWKHP
 8QVFUHZWKHGHWHFWRUIURPWKHMXQFWLRQER[FRQGXLWKXE
 *XLGHWKHGHWHFWRUOHDGVRIWKHUHSODFHPHQWGHWHFWRUWKURXJKWKHERWWRPFRQGXLWKXERIWKH
MXQFWLRQER[WKHQVFUHZWKHPRXQWLQJWKUHDGVRIWKHGHWHFWRULQWRWKHFRQGXLWKXE,I
QHFHVVDU\IRUHQYLURQPHQWDOFRQGLWLRQVDSSO\WKUHDGVHDODQWRUWHIORQWDSHWRWKHKXEDQG
RUGHWHFWRUWKUHDGVWRVHDOWKHP
 &RQQHFWWKHGHWHFWRUOHDGVWRWKHDSSURSULDWHGHWHFWRUWHUPLQDOVWULSWHUPLQDOV&RQQHFWWKH
UHGZLUHWRWKHWHUPLQDOODEHOHG72;,&DQGWKHEODFNZLUHWRWKHWHUPLQDOODEHOHG
72;,&6HH)LJXUH IRUWKHGHWHFWRUZLULQJFRQQHFWLRQVWRWKHDPSOLILHU
 5HLQVWDOOWKHGHWHFWRUWHUPLQDOVWULSLQWRLWVVRFNHW
 7XUQRQRUSOXJLQSRZHUWRWKHFRQWUROOHU
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
 7XUQRQWKHFRQWUROOHUDQGSODFHLWLQWRQRUPDORSHUDWLRQ
CAUTION: Allow the replacement detector to warm up for 5 minutes before you continue
with the next step.
 &DOLEUDWHWKHUHSODFHPHQWGHWHFWRUDVGHVFULEHGLQ³&DOLEUDWLRQ´RQSDJH 
 6HFXUHWKHMXQFWLRQER[FRYHUWRWKHMXQFWLRQER[
Replacing the Amplifier
 7XUQRIIWKHFRQWUROOHU
 7XUQRIIRUXQSOXJSRZHUWRWKHFRQWUROOHU
 5HPRYHWKHMXQFWLRQER[FRYHU
 8QSOXJWKHGHWHFWRUWHUPLQDOVWULSDQGFRQWUROOHUWHUPLQDOVWULSIURPWKHLUVRFNHWV<RX
PD\OHDYHWKHZLUHVFRQQHFWHGWRWKHWHUPLQDOVWULSV
 8QVFUHZDQGUHPRYHWKHVFUHZZLWKWKHIODWDQGORFNZDVKHUVWKDWVHFXUHVWKHDPSOLILHUWR
WKHMXQFWLRQER[7KHVFUHZLVDWWKHERWWRPULJKWRIWKHDPSOLILHU
 5HPRYHWKHROGDPSOLILHU
 3ODFHWKHQHZDPSOLILHULQWKHVDPHSRVLWLRQDVWKHROGDPSOLILHU$IRDPJDVNHWWKDW
RULHQWVWKHDPSOLILHUDQGNHHSVLWIURPURWDWLQJLVLQVWDOOHGRQWKHERWWRPRIWKHDPSOLILHU
0DNHVXUHWKHDPSOLILHULVVHDWHGIODWLQWKHMXQFWLRQER[
 ,QVWDOOWKHQHZDPSOLILHULQWRWKHMXQFWLRQER[ZLWKWKHVFUHZORFNZDVKHUDQGIODWZDVKHU
\RXUHPRYHGLQ6WHS
 ,QVWDOOWKHGHWHFWRUDQGFRQWUROOHUWHUPLQDOVWULSVLQWRWKHLUVRFNHWVRQWKHQHZDPSOLILHUDV
VKRZQLQ)LJXUH ,IFRQWUROOHUOHDGVRUGHWHFWRUOHDGVZHUHUHPRYHGGXULQJWKLV
SURFHGXUHUHIHUWR)LJXUH IRUWKHGHWHFWRUDQGDPSOLILHUFRQQHFWLRQV
127( :KHQDWUDQVPLWWHULVILUVWSRZHUHGXSZLWKDQHZDPSOLILHUWKHLQLWLDORXWSXWPD\EH
HLWKHUKLJKRUEHORZ]HURGHSHQGLQJRQWKHVHWWLQJRIWKH]HURSRW%HVXUHWRPDNH
DUUDQJHPHQWVVRWKDWWKLVGRHVQRWFDXVHXQZDQWHGDODUPV
 7XUQRQRUSOXJLQSRZHUWRWKHFRQWUROOHU
 7XUQRQWKHFRQWUROOHUDQGSODFHLWLQWRQRUPDORSHUDWLRQ
 $OORZWKHWUDQVPLWWHUWRZDUPXSIRUPLQXWHV
 &DOLEUDWHWKH&2WUDQVPLWWHUDVGHVFULEHGLQ³&DOLEUDWLRQ´RQSDJH 
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
&DOLEUDWLRQ)UHTXHQF\
$OWKRXJKWKHUHLVQRSDUWLFXODUFDOLEUDWLRQIUHTXHQF\WKDWLVFRUUHFWIRUDOODSSOLFDWLRQVD
FDOLEUDWLRQIUHTXHQF\RIHYHU\PRQWKVLVDGHTXDWHIRUPRVW&2WUDQVPLWWHUDSSOLFDWLRQV
8QOHVVH[SHULHQFHLQDSDUWLFXODUDSSOLFDWLRQGLFWDWHVRWKHUZLVH5.,,QVWUXPHQWV,QF
UHFRPPHQGVDFDOLEUDWLRQIUHTXHQF\RIHYHU\PRQWKVIRUWKH&2WUDQVPLWWHU
,IDQDSSOLFDWLRQLVQRWYHU\GHPDQGLQJIRUH[DPSOHGHWHFWLRQLQDFOHDQWHPSHUDWXUH
FRQWUROOHGHQYLURQPHQWDQGFDOLEUDWLRQDGMXVWPHQWVDUHPLQLPDODWFDOLEUDWLRQWKHQD
FDOLEUDWLRQIUHTXHQF\RIHYHU\PRQWKVLVDGHTXDWH
,IDQDSSOLFDWLRQLVYHU\GHPDQGLQJIRUH[DPSOHLIWKHHQYLURQPHQWLVQRWZHOOFRQWUROOHG
WKHQPRUHIUHTXHQWFDOLEUDWLRQWKDQHYHU\PRQWKVPD\EHQHFHVVDU\
&DOLEUDWLRQ
7KLVVHFWLRQGHVFULEHVKRZWRFDOLEUDWHWKH&2WUDQVPLWWHU,WLQFOXGHVSURFHGXUHVWRSUHSDUH
IRUFDOLEUDWLRQVHWWKH]HURUHDGLQJVHWWKHUHVSRQVHUHDGLQJDQGUHWXUQWRQRUPDORSHUDWLRQ
,WGHVFULEHVWKHWHVWXVLQJDFDOLEUDWLRQNLWWKDWLQFOXGHVDFDOLEUDWLRQFXSFDOLEUDWLRQJDV
VDPSOHWXELQJDQGDIL[HGIORZUHJXODWRUZLWKDQRQRIINQRE5.,,QVWUXPHQWV,QF
UHFRPPHQGVXVLQJD/30OLWHUVSHUPLQXWHIL[HGIORZUHJXODWRU
3UHSDULQJIRU&DOLEUDWLRQ
127( &DOLEUDWLQJWKH&2WUDQVPLWWHUPD\FDXVHDODUPV%HVXUHWRSXWWKHFRQWUROOHULQWRLWV
FDOLEUDWLRQSURJUDPRUGLVDEOHH[WHUQDODODUPVEHIRUHFDOLEUDWLQJ
WARNING: Do not remove the detector housing cap or junction box cover while the
circuits are energized unless the area is determined to be non-hazardous. Keep
the detector housing cap and junction box cover tightly closed during
operation.
 8QVFUHZDQGUHPRYHWKHMXQFWLRQER[FRYHU
 6HWDYROWPHWHUWRPHDVXUHLQWKHPLOOLYROWP9UDQJH
 3OXJWKHYROWPHWHUOHDGVLQWRWKHWHVWSRLQWVRQWKHDPSOLILHU3OXJWKHSRVLWLYHOHDGLQWRWKH
UHGWHVWSRLQWSOXJWKHQHJDWLYHOHDGLQWRWKHEODFNWHVWSRLQW
 8VHWKHIROORZLQJIRUPXODWRGHWHUPLQHWKHFRUUHFWWHVWSRLQWVRXWSXWIRUWKHFDOLEUDWLQJ
VDPSOH
Output (mV) = (calibrating sample/fullscale) X 400 + 100
)RUH[DPSOHZLWKDFDOLEUDWLQJVDPSOHRI330&2DQGDIXOOVFDOHVHWWLQJRI
330WKHFRUUHFWRXWSXWLVP9
167 (mV) = (50/300) X 400 +100
 6FUHZWKHFDOLEUDWLRQFXSRQWRWKHGHWHFWRUKRXVLQJ
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]

5.&27UDQVPLWWHU
6HWWLQJWKH=HUR5HDGLQJ
127( ,I\RXFDQYHULI\WKDWWKH&2WUDQVPLWWHULVLQDIUHVKDLUHQYLURQPHQW\RXGRQRWQHHG
WRDSSO\]HURDLUWRWKHGHWHFWRUEHIRUHDGMXVWLQJWKH]HURUHDGLQJ
 6FUHZWKHUHJXODWRULQWRWKH]HURDLUFDOLEUDWLRQF\OLQGHU
 8VHWKHVDPSOHWXELQJWRFRQQHFWWKHUHJXODWRUWRWKHFDOLEUDWLRQFXS
 7XUQWKHUHJXODWRUNQREFRXQWHUFORFNZLVHWRRSHQWKHUHJXODWRU
 $OORZWKHJDVWRIORZIRUWZRPLQXWHVWKHQYHULI\DUHDGLQJRIP9P9,I
QHFHVVDU\XVHWKH]HURSRWRQWKHDPSOLILHUWRDGMXVWWKHUHDGLQJWRP9P9
 8QVFUHZWKHUHJXODWRUIURPWKH]HURDLUFDOLEUDWLRQF\OLQGHU
 /HDYHWKHVDPSOHWXELQJFRQQHFWHGWRWKHUHJXODWRUDQGWKHFDOLEUDWLRQFXS
6HWWLQJWKH5HVSRQVH5HDGLQJ
 6FUHZWKHUHJXODWRULQWRWKHFDOLEUDWLRQF\OLQGHU9HULI\WKDWWKHFDOLEUDWLRQJDVLV
UHSUHVHQWDWLYHRIWKHWUDQVPLWWHU¶VWDUJHWJDV
 7XUQWKHUHJXODWRUNQREFRXQWHUFORFNZLVHWRRSHQWKHUHJXODWRU
 $OORZWKHJDVWRIORZIRUWZRPLQXWHVWKHQYHULI\WKDWWKHUHDGLQJPDWFKHVWKHUHVSRQVH
UHDGLQJP9\RXGHWHUPLQHGHDUOLHU,IQHFHVVDU\XVHWKHVSDQSRWRQWKHDPSOLILHUWR
DGMXVWWKHUHDGLQJWRPDWFKWKHFRUUHFWUHVSRQVHUHDGLQJ
 7XUQWKHUHJXODWRUNQREFORFNZLVHWRFORVHWKHUHJXODWRU
 8QVFUHZWKHUHJXODWRUIURPWKHFDOLEUDWLRQF\OLQGHU
5HWXUQLQJWR1RUPDO2SHUDWLRQ
 5HPRYHWKHYROWPHWHUOHDGVIURPWKHDPSOLILHUWHVWSRLQWV
 8QVFUHZWKHFDOLEUDWLRQFXSIURPWKHGHWHFWRU
127( )RUFRQYHQLHQFHOHDYHWKHFRPSRQHQWVRIWKHFDOLEUDWLRQNLWFRQQHFWHGE\WKHVDPSOH
WXELQJ
 6HFXUHWKHMXQFWLRQER[FRYHUWRWKHMXQFWLRQER[
 :KHQWKHGLVSOD\UHDGLQJIDOOVEHORZWKHDODUPVHWSRLQWVUHWXUQWKHFRQWUROOHUWRQRUPDO
RSHUDWLRQ
 9HULI\WKDWWKHFRQWUROOHUGLVSOD\UHDGLQJGHFUHDVHVDQGVWDELOL]HVDWSSP
 6WRUHWKHFRPSRQHQWVRIWKHFDOLEUDWLRQNLWLQDVDIHDQGFRQYHQLHQWSODFH
www.GlobalTestSupply.com
Find Quality Products Online at: [e-mail]